Kia Soul Complaints (2019)

142 consumer complaints on file.

#11683721August 28, 2025
ENGINE
For some reason my 2019 Kia Soul is not included in the previous engine recall. My vehicle is experiencing severe oil burn which has caused the failure of a second catalytic converter. The first was replaced on 11/25/2024 and it is being replaced again on 8/28/2005. This failure is due to improperly heat-treated piston oil rings that lose their ability to seal, leading to cylinder wall damage, increased oil consumption, and potentially engine failure or fire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679647August 10, 2025
ENGINE, UNKNOWN OR OTHER
Hello, my oil rings in my engine failed, which there is a recall of 2021 and newer but same issues, causing my oil to burn and get trapped in the catalytic converter, then burning it out the exhaust, also I kept loosing oil. Under further diagnosis from a mechanic, I had to get a full rebuild of my engine at a cost of $5,000, and also I had to get a new catalytic converter with a cost of 500.00. PLEASE look into this and let me know what I can do further. Thank you!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679458August 8, 2025
ENGINE
Engine burns oil at a rapid rate. Has been inspected & confirmed by dealer. Was informed it may be a piston issue that has been located on similar Kia vehicles, but is not on the recall list. No warning lights appear. No warning light indicating low oil either, which means I must check the level daily & add oil as needed (about one quart per week).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672843July 11, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Kia Soul. The contact stated that while the vehicle was at an independent mechanic receiving an undercoating, the independent mechanic performed an inspection of the vehicle. The contact stated that during the inspection, the independent mechanic identified that there was severe corrosion on the fuel tank straps. The contact was informed that the fuel tank straps needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure but provided no assistance. The vehicle was scheduled for inspection. The manufacturer was made aware of the failure and a case was filed. The contact referenced an unknown recall however, the VIN was not included in the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was 46,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672373July 9, 2025
ENGINE
I tired to let the KIa dealer in Evans Ga know my Kia was consuming oil about a quart a week. They did an oil consumption test and stated it was within normal range. That’s 4 quarts of oil a month. This was done before the warranty ran out. Now they are saying it’s 14000 to replace the engine. I looked up the 2019 Kia Souls and there are recalls on this model and year but not by the VIN. It is now using 5 plus quarts of oil a month with no visible oil leak.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668529June 23, 2025
ENGINE
Burning oil have to put a quart in every 500 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666014June 10, 2025
ENGINE AND ENGINE COOLING
The contact owned a 2019 Kia Soul. The contact stated that while his daughter was driving at 50 MPH, the brakes failed to operate upon depression as heavy, black smoke began to emit from the under the hood of the vehicle. The contact's daughter managed to pull off to the shoulder of the highway as all occupants quickly exited the vehicle. The vehicle quickly became engulfed in flames as police arrived immediately on the scene. The fire department also arrived on the scene and extinguished the fire. No injuries were reported. A police report was filed but when the contact called for a copy, he was informed that the report was not yet produced. The vehicle was towed to an independent tow yard were the vehicle was deemed a total loss. The contact went to view the vehicle and linked the failure the engine's connecting rod which he saw hanging from what remained of the engine. The manufacturer was notified of the failure but offered no assistance. The vehicle was destroyed. The failure mileage was approximately 65,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11661764May 19, 2025
ENGINE
Excessive oil consumption
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661126May 15, 2025
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
My 2019 Kia Soul had an engine misfire, breaking down and requiring new spark plugs. My car has been consuming oil excessively for the past 8 months, causing me to change the oil myself once a week. The engine light has been on, leading me to fix both catalytic converters. The engine light came back on right after this and pulled up two codes related to the camshaft position. I asked Kia for an oil consumption test and was told they do not perform that. The oil continues to burn excessively and requires constant changing. Other mechanics have informed me that this could lead to a serious fire hazard and engine issue, posing a high safety concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661316May 15, 2025
ENGINE
My 2019 Kia Soul has had excessive oil consumption issues since we bought it in 2022 or 2023. This week, the check engine light came on, and the mechanic says it is the catalytic converter. This could be a potential fire hazard if we don't take care of it, and the cost to do this is almost as much as the car is worth.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659550May 7, 2025
ENGINE
The contact owns a 2019 Kia Soul. The contact stated that while driving at various speeds, the vehicle stalled on several occasions. After restarting the vehicle, the vehicle operated normally; however, the failure persisted. The vehicle was taken to the local mechanic who diagnosed the vehicle and determined that cylinder #3 was faulty. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not contacted. The failure mileage was 67,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656542April 24, 2025
ENGINE
The contact owns a 2019 Kia Soul. The contact stated while driving at various speeds, the check engine and oil warning lights became illuminated. The vehicle was taken to an independent mechanic however, the mechanic was unable to retrieve a fault code. The contact stated that an abnormal clanking sound was coming from the engine while driving at various speeds. The contact checked under the hood and discovered that the engine oil level was extremely low. The contact topped off the engine oil; however, the oil level was extremely low two days later. The vehicle was taken back to the independent mechanic where the vehicle was diagnosed with engine failure. The vehicle was not repaired. The dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 106,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651594March 30, 2025
UNKNOWN OR OTHER
My car is burning oil fast. 3 times a month I have to add oil. Sometimes it doesn't even register on my dipstick. When I take my car to kia of muncie for a oil change, they keep saying its my oil pan gasket that needs resealed. I park my car in my garage, I have no oil spots in my garage. When I take my car to midas for a pill change, they don't say anything about the oil pan gasket. I don't understand why my car keeps burning oil so fast.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650756March 26, 2025
ENGINE
I am experiencing excessive oil consumption and potential engine failure in my 2019 Kia Soul. Despite regular maintenance, my vehicle has suffered from multiple major repairs, including a top-end engine rebuild and catalytic converter replacement in 2024. The excessive oil consumption issue persisted, ultimately requiring a full engine replacement in 2025. Kia has delayed repairs and provided minimal support, leaving me without a vehicle for extended periods. Service History & Progression of the Issue: March 11, 2024: Took my vehicle to Planet Kia dealership after noticing excessive oil consumption and performance issues. Kia initiated an oil consumption test but did not approve immediate repairs. May 2024: Kia performed a top-end engine rebuild instead of replacing the engine, even though significant oil loss continued. December 2024: The catalytic converter was replaced, likely due to prolonged oil burning and engine inefficiencies. January 22, 2025: Returned the vehicle to Kia as the excessive oil consumption issue worsened, and the engine was struggling to function properly. March 2025: Kia finally approved a full engine replacement, but my vehicle has now been in service for over 137 days, and the repair process has been delayed due to missing parts. March 26, 2025: Planet Kia has not provided clear updates on beginning or completion of engine replacement despite having all parts in-house. Safety Concerns: Risk of Engine Failure: If the engine runs low on oil, it can seize while driving, creating a dangerous situation. Potential Fire Hazard: Excessive oil consumption could lead to overheating and increased fire risks, as seen in similar Kia engine-related recalls. Manufacturer Delays & Accountability: Kia has known about oil consumption issues for years but continues to delay solutions for affect
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650873March 26, 2025
ENGINE
The contact owns a 2019 Kia Soul. The contact stated while driving 75 MPH, the RPM revved extremely high, and the vehicle lost motive power. The contact stated that the vehicle failed to accelerate above 65 MPH. Additionally, the check engine warning light flashed on the instrument panel. The vehicle was steered to the side of the road where the contact saw smoke coming from the engine compartment. The vehicle then stalled. The vehicle was towed to the residence. The vehicle was taken to an independent mechanic, where it was diagnosed that either cylinder #1 or the entire engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 115,932.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648755March 17, 2025
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
The contact owns a 2019 Kia Soul. The contact stated that while driving approximately 75 MPH and attempting to overtake a Commercial Semi-Truck, the vehicle suddenly lost automotive power and started to decelerate. The vehicle coasted to the side of the road and stalled. The vehicle was later towed to a nearby dealer who diagnosed that the fuel injectors had failed and were stuck in the fully opened position. The fuel injectors were replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 37,754.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648478March 15, 2025
ENGINE
Owner was driving vehicle coming off of a highway onto sideroad when vehicle suddenly made a loud banging and grinding engine sound and engine quit immediately. Luckily able to drift over to shoulder and call tow truck. Vehicle towed to dealership. Dealership claimed vehicle was made in Mexico and therefore not covered by any recall. No forewarning by any dashboard lights. Owner needed a vehicle immediately for work and bought a brand new seltos the next day, then dealership refused to take soul as a trade in and so it remains unrepaired in the yard. It is able to be seen. I believe it should have been repaired or bought back by dealership. I feel like I was taken advantage of and lied to by the dealership
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647846March 12, 2025
ENGINE
The contact owns a 2019 Kia Soul. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. In addition, the contact stated that the oil needed to be added to the engine every 3,000 miles. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that an oil consumption test was performed. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. Additionally, the contact stated that the vehicle was taken to the dealer every three months, however the failure was not duplicated. The manufacturer was made aware of the failure. The failure mileage was approximately 50,045.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646461March 5, 2025
ENGINE
I have a 2019 Kia Soul and the engine has had issues over the past year regarding it stalling and losing power. These engines are prone to have oil circulation issues which can cause catastrophic engine failure due to lack of adequate lubrication inside the cylinder(s). My engine has cut off and lost power while driving on several occasions recently. If this happens, it can cause someone to smash into us on the interstate causing a possible fatal accident. I am terrified to drive my vehicle because of this issue. The VIN for my vehicle is: [XXX] . I purchased this vehicle new in 2020 our Kia dealer in Goose Creek, SC. I have heard of many of these engines being replaced by Kia and feel that this issue directly affects my vehicle. Please help us get this issue resolved. Thank You INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646144March 4, 2025
ENGINE, WHEELS
Engine died on the highway. All of the warning light lit up before the car stalled and eventually died.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Soul