Kia Soul Complaints (2016)

825 consumer complaints on file.

#11518441April 22, 2023
ENGINE
Previous NHTSA 11498487 for the same issue reported on 12/22. After 8 months of changing the catalytic converter the Kia Soul 2016 de-accelerated in the highway from 60mph to barely 30Mph with a burning smell the check engine light come up and the code once again for the catalytic converter. The catalytic converter was replaced under the warranty from the repair shop on 1/23. Now on 4/23 the check engine light is on again for the catalytic converter again. The repair shop won't change it again. Instead they suggested to bring it to the dealership. Kia dealership stated that my VIN is not included in the recall and they only did theE PI2002A ECU update the rest is not covered by the manufacturer warranty. I've changed 3 times the catalytic converter and the light is code is asking for another one. It's not normal. Major safety hazard for the vehicle to stall in the highway suddenly. Proper maintenance and oil changes are done on time as suggested by Kia. However it burns oil after a new change before hitting the 3,000 miles driven short distances and engine is less than a quart with no leeks at all. Another safety hazard because there's no warning light of low engine oil that could possibly cause the engine to stop and hazard to driver and others.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517731April 18, 2023
ENGINE
As we were driving on the highway, the check engine light started flashing on my car and it proceeded to go into limp mode. This proved to be a danger to me and everyone driving around me. The car would not accelerate and would shake violently. I had to pull over on the side of the highway. The only light that ever appeared was the CEL, when it was already too late. Upon taking it to a mechanic we were told that the 1st and 3rd cylinders were complete garbage and a whole engine replacement was necessary.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517439April 17, 2023
ENGINE
The contact owns a 2016 Kia Soul. The contact stated while driving approximately 65 MPH, the vehicle stalled and failed to restart. The check engine warning light was illuminated prior to the failure. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the previous owner repaired the vehicle under NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling) and 17V608000 (Steering); however, the failure recurred. The manufacturer was notified of the failure. The failure mileage was approximately 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517189April 15, 2023
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
Car cuts off when idling. I took it to the mechanic several times and they produced the issue once but could not diagnose and would give it back to me at no charge. When it cuts off the RPMs will sometimes stay at 0 even when I start the car again. Sometimes the check engine light will come on along with the traction light. Mechanic said it shows catalytic codes but said nothing is wrong with catalytic converter. They said they can’t find anything wrong to warrant repair. The check engine and traction control lights stay on and then go off randomly. The car cuts off at stop lights and today it cut off when I was turning right at a stop sign. I was already out in the road and someone was behind me. Thankfully no one was coming down the road at full speed. I am afraid to drive the car but no one knows what is wrong with it or how to fix it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517176April 15, 2023
ENGINE
Was idling at a red light, the engine warning light came on, and my engine set on fire. No reason. I jumped out of the car. Thankfully someone came over and threw water on it. Engine to be completely rebuilt (under warranty). Took 3 weeks.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11517102April 14, 2023
ENGINE AND ENGINE COOLING, ENGINE
The contact owns a 2016 Kia Soul. The contact stated that the vehicle was previously included in NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling) regarding the heat shield for the catalytic converter, which, was replaced under the recall. The contact stated that the vehicle began to malfunction after the repair. The vehicle would jump and shift into gear roughly while driving at various speeds. The RPM was revving abnormally. The contact stated that it seemed as if the vacuum seal had detached underneath the vehicle, and the vehicle was making a whistling sound while accelerating. The check engine warning light was illuminated. The vehicle was taken to the dealer who informed the contact that the catalytic converter replaced since the recall was closed. The manufacturer was made aware of the failure. The approximate failure mileage was 99,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516862April 13, 2023
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
The contact owns a 2016 Kia Soul. The contact stated while starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer for a diagnostic test and the dealer stated that the catalytic convertor needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but provided no assistance. The failure mileage was 88,520.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516262April 10, 2023
FIRERELATED
The contact was an administrator of a probate trust who was filing a complaint on behalf of the deceased owner of a 2016 Kia Soul. The contact stated that while a relative of the deceased was driving at an undisclosed speed, the vehicle was shaking. No warning lights were illuminated. The deceased relative pulled over into a parking lot and noticed there was smoke coming from the engine compartment before the vehicle caught fire. The fire department arrived on the scene and extinguished the fire. No injury was sustained. Police and fire department reports were filed. The vehicle was towed to a tow lot. The vehicle did not have insurance coverage. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11515830April 6, 2023
ENGINE, ENGINE AND ENGINE COOLING
The contact owns a 2016 Kia Soul. The contact stated while her daughter was driving approximately 35 MPH and ascending a slight grade in the road, the vehicle stalled. The check engine and oil pressure warning lights were illuminated. The contact stated that her daughter was able to restart the vehicle. The contact stated that the oil pressure warning light had been illuminated intermittently even after routine oil changes. The vehicle was taken to the local dealer, where it was diagnosed that the gas cap needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The manufacturer was not notified of the failure. The failure mileage was approximately 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515364April 4, 2023
ENGINE
The contact owns a 2016 Kia Soul. The contact stated that while driving approximately 70 MPH, the engine seized without warning. The vehicle was towed to the local dealer where it was diagnosed that the rod bearing had failed. The vehicle was not repaired. The manufacturer was contacted but provided no additional assistance due to the vehicle not meeting the Warranty Extension requirements. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515427April 4, 2023
STEERING
Driving around curves my car slows dramatically and traction control light comes on. I have no ability to steer at this point until the car “breaks free” and allows acceleration again. It’s as if the ABS system kicks on all on its own. The sound it makes is as though the brakes are kicking in to slow the vehicle. It almost comes to a stop on curves. Steering intermittently loosens on its own while driving and I lose controlled steering as there is a lot of play in the steering wheel. Then it will tighten up again as if it’s a brand new car. There is an occasional pop noise but it’s not constant and doesn’t make the sound when driving at speeds greater than 40mph. No other sounds are present. I contacted Kia as they placed a set screw in the steering for a pinion plug recall repair to keep a nut from backing out and this was not properly documented by the previous service department per the new management. There were no images of the repair that was done and no notes in the repair log according to the young lady I spoke with. No evidence of a repair other than being marked in the system.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515294April 3, 2023
ENGINE, UNKNOWN OR OTHER
2/17/23 Car was disabled on highway lost speed in the middle of traffic and could not go over 20MPH at dealership- it was confirmed that catalytic convertor went out. 2/23/23 Car CC was replaced picked it up and noticed weird sound from engine 2/24/23 Car returned to dealership 3/3/23 Dealership stated the engine was bad 3/13/23 We were informed that KIA would not cover the repairs and we had to pay $5700 4/3/23 Dealership called and said car was ready to be picked up Car has 78,000 miles on it and has been well maintained - we have all of the service records We understand there is a class action lawsuit where high exhaust gas temperatures may damage the catalytic convertor, resulting in abnormal engine combustion damaging the engine. We have been told that our engine did not qualify under the VIN number that we had. KIA has had known engine problems for over 12 years and we feel that the CC damaged the engine and this is what caused the failure. There were no warning signs, no smoke out of the exhaust etc We just keep getting the run around saying that our VIN was not part of the recall even though our engine had only 78,000 miles and it was very well maintained. Please let us know if we can get any help in paying for this huge expense
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514812March 31, 2023
ENGINE
Catalytic converter issues. I've had to get it replaced several times already and still issues. car burns oil like crazy as well and I have had to add oil throughout the week. it's been this way since I bought it in 2018. 2016 Kia Soul +
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514375March 29, 2023
ENGINE
Horne Kia in Gilbert Arizona tore down our engine and found it damaged beyond repair. We were told by the aforementioned dealership that the engine would need to be replaced. Kia has given our engine a 15 year / 150,000 mile warranty due to this nation wide Kia / Hyundai engine defect situation. Our vehicle has around 79,000 miles and is a 2016 model. Still Kia refuses to replace the engine. The safety problem that comes into play is that Kia is telling us to continue driving our vehicle until the engine completely freezes up. Kia is sending ours and many others vehicles back out on the road in this condition. These vehicles can break down at any time and create a possible incident that could be detrimental to the safety of the driver and others in the area.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11512129March 16, 2023
STEERING:STEERING WHEEL /HANDLE BAR:YAW/ANGLE SENSOR
The contact owns a 2016 Kia soul. The contact stated while driving 80 MPH with the cruise control feature engaged, the feature independently deactivated and the vehicle decelerated to 60 MPH. The contact stated that after the cruise control feature was disengaged the vehicle was veered to the side of the road. The contact then drove the vehicle 40 MPH back to the residence. The vehicle was then towed to a dealer where it was diagnosed that the steering angle sensor needed to be recalibrated. The vehicle was repaired but the failure reoccurred. The contact stated that the failure persisted, and the check engine warning light was illuminated. The vehicle was taken to another dealer; Hyman Bros Kia (11901 Midlothian Turnpike, Midlothian, VA 23113) where it was diagnosed that the vehicle was consuming an excessive amount of engine oil. The vehicle was not repaired. The contact stated that a quart of oil had to be added every other week. The manufacturer was notified of the failure. The failure mileage was approximately 57,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11510608March 7, 2023
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
The vehicle contains a defect related to motor vehicle safety or does not comply with an applicable federal motor vehicle safety standard ENGINE REPLACED THRESHOLD REPLACED CATALITIC CONVERTER BLEW ECU COMPLETED AIRBAG WARNING DOES NOT CLEAR INACCURATELY REPORTED/ COMPLETED VEHICAL MALFUNCTIONING LOSS OF POWER
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509616February 28, 2023
UNKNOWN OR OTHER
I have been having issues with oil consumption since early fall 2022. I am the sole owner of my Kia Soul Plus and have had multiple oil consumption tests performed. I found out I had an oil consumption problem when my car shut off WITHOUT WARNING on the highway. Luckily this happened around midnight when there wasn't a lot of traffic. I contacted the dealer and they did an oil consumption test, which it "passed" because the dipstick indicated there was still oil in the engine. After the first one, I started to monitor my car and it seems like a little past the 1k mark does the dipstick indicate there's no oil. I've done like 3 tests with the dealer, and I think the last one that was performed I think they put too much oil in it. I say this because when I checked the oil -- when the car sat for awhile to cool off-- there was oil past the fill line on the dipstick. When I asked about it, they made it seem like I invalidated the test because I simply checked the oil. I was also told to not check the oil when the car has been sitting. So now, I check it at different times; when it has and has not been sitting (when I get gas). What ended up happening was the guy just read the dipstick right there in front of me, said it was fine, topped of the oil and said I was good to go. I think they did this the second time as well but didn't think to check the oil level then. I also noticed oil stains/residue on my engine cover and asked the dealer about it, but received no answer. It seems like the oil stains are getting worse -- more prominent. My car currently has 92k miles on it and have been trying to figure out the issue as this is a HUGE safety issue to me and my family. On multiple occasions I have found that my car has had low oil in it and carry oil in the back of my car just in case. After doing research, I'm glad to see I'm not alone but also that this is a known issue but I feel like the dealer is waiting for my warranty to expire before anything gets taken seriously.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509337February 27, 2023
ENGINE AND ENGINE COOLING
The contact owns a 2016 Kia Soul. The contact stated while driving 30 MPH, the vehicle started to stall. The vehicle was taken to the dealer for diagnostic test, and the dealer stated that the catalytic converter needed to be replaced, and that the vehicle was not included in NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 124,030.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509360February 27, 2023
ENGINE
I purchased my 2016 Kia Soul 11/25/22 and on 12/15/22 my check engine light came on getting off freeway. While driving the accelerator wasn’t catching speed could’ve go pass 20mph making loud noises like transmission was slipping. The dealer towed my car from my Job. Dealership gave me an tuneup oil change and replaced engine coils. 2/7/23 check engine light came again and my car couldn’t do 15mph again and service department stated a need a new engine and it’s covered under warranty but every Kia dealership states they can’t Maintence my car until months advance and they can’t give me a loaner if they can replace the engine so I been missing work due to my Kia running bad and I only had it since 11/22.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509072February 25, 2023
ENGINE
Engine knocking noise on acceleration
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Soul