Kia K5 Complaints (2023)

111 consumer complaints on file.

#11667048June 15, 2025
STRUCTURE:BODY
at 2:30 PM i had noticed that my passenger rear trim, right above my trunk was loose. I made note of it. about three hours later, i was driving down the interstate and i noticed it came off and was flying through the air. Thankfully it didn’t hit another vehicle but this isn’t the first time I have had issues with the trim and a lot of other k5 owners have had issues as well.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664652June 3, 2025
FUEL/PROPULSION SYSTEM, POWER TRAIN
My 2023 Kia K5 GT (VIN: [XXX]) is experiencing a dangerous complete power loss at highway speeds. I was driving at the speed limit on [XXX] when the vehicle lost propulsion, entered limp-home mode, and illuminated every warning lamp. This has happened six times since purchase. The car is currently parked, and I am not confident enough to drive the car; I nearly missed a crash pulling into the emergency lane from the leftmost lane to the rightmost lane. After losing power in the engine, that was a traumatizing experience. I tried to explain this to people multiple times at different service centers, but they care less: "We can't fix it unless we can reproduce it," but this happens randomly; I cannot make it happen at the service center. This matches the recall SC250 symptoms exactly, though my VIN is excluded. I have tried with Multiple dealers before, but they cannot fix it. They say, "We cannot fix it unless we can reproduce it." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661975May 19, 2025
FUEL/PROPULSION SYSTEM
On Friday 5/16/25 my check engine light was on when I went to leave for work and when I began driving I felt excessive air flow coming from my back seat. I stopped and noticed that the back seat had popped up. I then noticed my gas gauge was showing empty, but my digital reading was correct.. The car was sluggish and my son's father told me that the gas tank was swollen and to stop driving it. I called Kia on Saturday morning and was told I could bring it in today at 9am. I left the car and was given a loaner, but I do not feel it would be safe to ever drive that car again. They immediately knew what the problem was and said it was a recall, but I was never notified about it. It was extremely scary driving it to Kia this morning because they are over 50 miles away from where I live.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661450May 16, 2025
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, LANE DEPARTURE: BLIND SPOT DETECTION, FORWARD COLLISION AVOIDANCE: WARNINGS
All of my check lights are on. All of my sensors are popping up. It says no power steering. No cruise control. No lane departure and a few other lights are popping on every time I turn my car on and they all stay on. So far it isn’t preventing me from driving it but none of my safety features work
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655970April 21, 2025
STRUCTURE:BODY, UNKNOWN OR OTHER
I was driving with no other cars around, and i heard what sounded to be an explosion, come to find out my sunroof had exploded. I had glass fly all over the back windshield, and onto the road behind me. This could have caused an accident or damage to other vehicles if someone was around me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652524April 3, 2025
FUEL/PROPULSION SYSTEM
While driving, thankfully not with my [XXX] son, the vehicle made a real big bang noise and lost power. Looked back and the whole back seat was lifted. Towed to dealer and tech found that fuel tank had expanded and exploded seat back. Incident happened in November 2024, and to this day, Kia has been the most difficult to deal with. They offered to buy vehicle back, but we have been waiting for a long time for answers and resolution of this issue. Its impossible to get someone on the phone and we keep getting the run around with a loaner/rental while trying to continue to live normal life going to work and dropping kid at school INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651455March 29, 2025
ENGINE, ELECTRICAL SYSTEM, POWER TRAIN
2023 Kia K5 GT1, once at 16k miles and now again at 26k miles, while driving, the dashboard console flickered on me and the car lost complete acceleration and power, fortunately on urban roads or else would have been extremely unsafe and dangerous if high speed, especially since I have a child. Pulled over and turned off vehicle, and turned back on acceleration regained but check engine light remains solid. Took it to dealer at 16k miles and they checked it out and just reset the codes, advised if it happened again to bring it back right away. I am aware of the open recall on this Kia model, but my specific vehicle VIN is not impacted. However, I suspect the sudden power loss issue is the exact same issue. This is an extremely dangerous and unsafe issue with this vehicle, particularly if you have kids or are driving high-speeds on the highway!!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651047March 27, 2025
STRUCTURE:BODY
The back chrome cover around the rear windshield all 3 pieces are coming loose and I had the one on my passenger side fly off while I was going down the highway and the piece almost hit the truck behind me thankfully traffic wasn’t to bad on the highway so he was able to hit his breaks and maneuver out of the way before. I currently have 2 more pieces trying to come off. After doing further research I have seen hundreds of other post from k5 owners years 23&24 all having the exact same issue of the chrome pieces coming off and or flying off while driving. In the pictures you can see the one missing piece and the other 2 you can see where the other 2 pieces are starting to loosen up. If you physically touch it they both will move and feel loose. I believe this should be a recall before one of the pieces fly off and cause a accident by hitting another car like what almost happened in my case or just flying off and hitting a person. I bought my car used but it was a single owner my car was a little over a year old I’ve personally had it for I believe 10-11 months and I keep it in the carport daily so I shouldn’t be having these issues already.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650047March 24, 2025
AIR BAGS
I was involved in a head on collision, all of my safety warning notified me but my airbags NEVER deployed. This is a serious safety hazard especially with many problems being reported with airbag deployment. The adjuster and collision center both stated at the rate of speed from the accident, the airbags should have definitely deployed. My car was deemed a total loss from the damage even without the deployment.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11646614March 5, 2025
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC)
The contact owns a 2023 Kia K5. The contact stated while driving at approximately 70 MPH, the transmission unexpectedly downshifted, shuddered, and there was an abnormal sound coming from the vehicle. The Electronic Stability Control Warning Light was illuminated. The vehicle was taken to a dealer where it was diagnosed that the transmission needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 18,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645398February 27, 2025
STRUCTURE
The contact owns a 2023 Kia K5. The contact stated that the rear passenger's side chrome trim extending to the trunk had separated from the vehicle. The contact related the failure to TSB Number: SA552. The contact was concerned that the failure could cause a road safety hazard. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 13,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644189February 21, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Kia K5. The contact stated that while driving at 65 MPH in hot weather, a loud popping sound came from underneath the vehicle. The vehicle lost motive power. The check engine warning light was illuminated. The contact coasted into a ditch and inspected the vehicle, but no exterior damage was found. The vehicle was restarted and driven to a gas station. The check engine warning light was no longer illuminated. The vehicle was taken to the dealer, but the cause of the failure could not be determined. The failure persisted and the fuel gauge level dropped while driving. The contact pulled over and placed a bag under the vehicle to check for fuel leaks, but found none. The contact stated that the vehicle failed state vehicle inspection due to an unknown emission code. The vehicle was taken back to the dealer, who performed an oil change and updated the computer system. The failure recurred while driving with three minor children in the rear seats. The fuel tank made a loud explosion, and the rear seats propped up, pushing the children forward while the seat belts restrained them in their seats. The child seated in the rear passenger seat received medical attention for injuries to the back of his legs caused by hot fuel fumes from underneath the seat, as well as black specks stuck on his legs. The contact's husband opened the fuel tank, and loud air pressure was released. The fuel tank was bubbling. The vehicle was towed to Classic Kia of Carrollton (2920 N Interstate 35E, Carrollton, TX 75007), who determined that the fuel tank needed to be replaced and requested that the manufacturer send an engineer to inspect the vehicle. The vehicle was towed to the third dealer, Huffines Kia Corinth (6940 S Interstate 35, Corinth, TX 76210), where an engineer determined the vehicle was non-repairable due to the fuel tank expanding in multiple locations and bending the sub-frame. The contact was informed that the fuel tank was manufactured without a pressure release valve. The vehicle was not repaired. Up
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11644070February 21, 2025
FUEL/PROPULSION SYSTEM, ENGINE
Component or System Failed: The fuel tank exploded, causing the vehicle to become undrivable. The explosion was so severe that the back seat was completely blown off. The vehicle is currently not in my possession, as it has been with the dealership for over three months. I have photos and proof of the damage, and I am willing to provide them for inspection. How Safety Was Put at Risk: I have a [XXX] son who sits directly above the fuel tank in the back seat. When the explosion occurred, the back of his seat was completely blown off, and had he been in the car at the time, he could have been seriously injured or killed. This was an extremely dangerous defect, and I am deeply concerned that this could happen to other Kia vehicles, putting more lives at risk. Beyond the immediate danger of the explosion, I have been left without a working vehicle for over three months, and Kia has provided no resolution. Despite confirming that the vehicle is not repairable, they have stalled the process, forcing me to continue making payments on a car I do not even have. Problem Reproduced or Confirmed by a Dealer or Independent Service Center? Yes, the Kia dealership confirmed that the vehicle is not repairable and that the fuel tank failure was severe. However, they have not provided any solution or compensation. Has the Vehicle Been Inspected? Yes, the vehicle was inspected by the Kia dealership, which determined that it was not repairable. I do not know if it has been inspected by any third-party mechanics, insurance representatives, or other authorities. Warning Lamps, Messages, or Symptoms Prior to the Failure? There were no warning lights, messages, or other symptoms prior to the explosion. The vehicle was operating normally before this occurred. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633651January 2, 2025
FUEL/PROPULSION SYSTEM
Heard and felt extremely loud BANG under the car while driving then check engine light came on. Vehicle had low power and the gas was decreasing severely fast. The backseat had moved with our 2yr daughter in her car seat above it. Took it to dealership and they said the gas tank expanded and couldn't be fixed. They offered bottom dollar to buy it back
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633201December 30, 2024
FUEL/PROPULSION SYSTEM
Engine came on and off twice, car was smelling like gas and driving rough. Tried to put gas in car and it would not take the gas, it wasted all over car. I checked my back seat and felt it was hard and sitting right so I looked under and the seat was lifted. After doing research, I learned I have an expanded fuel tank. Not only that but there has been a recall on it that I was unaware of, I took the car immediately to the nearest dealership and they acknowledged there’s a recall and I can’t drive the car because the backseat can explode anytime now.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628798December 4, 2024
FUEL SYSTEM, GASOLINE
The contact owned a 2023 Kia K5. The contact stated that while her son and daughter-in-law were driving, three loud bangs were heard coming from underneath the vehicle. The vehicle was pulled over to the side of the road and inspected; however, no cause for the banging sounds were found. The vehicle was then taken to a gas station to be inspected, but no cause for the sounds were found. The contact’s son then added fuel to the vehicle, but the fuel spilled from the filler neck. The vehicle was taken to the residence. The vehicle was then taken to a dealer where it was determined that the gas tank had expanded and damaged a part underneath of the vehicle. The vehicle was taken to be inspected after being deemed a total loss. The manufacturer was notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11624408November 10, 2024
VISIBILITY:SUN/MOON ROOF ASSEMBLY
I was driving down the road and I heard a loud boom noise and it was my sunroof burst it pieces. It was raining and it was not hot. Nothing fell on it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622080October 26, 2024
VEHICLE SPEED CONTROL
I submitted a previous report NHTSA ID: 11488746 and have not heard anything. I continue to have this problem and am afraid it could cause a severe accident. When I come to a stop with the "Auto Hold" engaged the acceleration increases to 4 rpms or a little higher so I hold the brake down hard with my foot in fear that the Auto Hold will not work. I proceed to shift it in Park then as i take my foot off the brake the acceleration returns to normal. This is very alarming and has occurred to me at least 20 times since I've had the car. I have had the car in the dealership but they do not see anything wrong with it and does not register any Error codes. The car has less than 10k miles on it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613925September 11, 2024
ENGINE, POWER TRAIN
One day I was driving and my car began to shake really bad. It doesn’t transition smoothly when switching gears in transmission. Sometimes it doesn’t accelerate and I’d have to floor the gas to get it going. Rough acceleration. Car would even shake in idle sometimes. It has been doing this ever since. One day it’ll shake, the next day it might not. It doesn’t matter if I drive slower or faster, the car still shakes, has rough to no acceleration, and shifts gears roughly. Engine light is on and is reading misfire of cylinder 3.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11612816September 5, 2024
FUEL/PROPULSION SYSTEM
Ive a 2023 Kia K5 GT-Line AWD with 73000 mileage. I was having a trip from New Jersey to Massachusetts for a wedding. I had 208 miles to go and 223 miles range. Than suddenly it went down to 93 miles. I stop by a gas station. I could not pump gas. It was kicking the nozzle. I atop by another gas station miles later. I couldnt pump gas either. It kickes the nozzle and my gas tank looks full. Than i start the car and check engine light and P045100 code came on. Than i checked the closest KIA but it was Saturday. They couldn’t service i was at Rhode Island. I called one of the KIA and they said as long as CEL is on i can drive. If its keep flashing i shouldnt drive. I said it smells gasoline and i cant fill up my tank and i asked if they have a suggestion and they said idk and closed the phone. Than i heard a clicking noise and it smelled a lot more gasoline. I saw that my rear seats popped up. I saw that one of the gas tank or whatever it is was up and my tank was expanding. I had to leave my car to another dealer nearby airport at Rhode Island. They will check my car at Monday. I rent a car from airport enterprise. I guess ill need to wait and see. I knew that there is a recall. But i went for an oil change at 60000 mileage and my local dealer told me that there was a recall and they checked and thats why it took long and im good to go. So they checked the recall and it was fine and now its not fine. I had the recall done but it still happened. My car stayed at dealer from 10 days. They couldnt fix it and someone from Kia Tech came to check, while they are checking the gas tank had a mini explosion as they said. Kia is going to buy my car back and they confirm that i can either get a replacement or buyback. They confirmed that there is no permanent fix for it. They do not know how to fix it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia K5