Hyundai Veloster Complaints (2016)

225 consumer complaints on file.

#11505338February 3, 2023
ENGINE
The engine overheated with no lights on the dash and the engine block cracked
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11503986January 27, 2023
ENGINE
While driving down the highway the engine began to knock loudly. When the engine stalled. The vehicle stalled while traveling on a congested highway at a speed of approximately 70MPH. The vehicle was pulled to the side of the road where I waited for a tow truck via AAA for 5 Hours. The vehicle was towed to an independent service center that diagnosed it with a worn rod bearing, which in turn is causing the knocking. The vehicle has been maintained and oil changed regularly. Vehicle is unusable in current state as it is at risk for complete engine failure and risk of fire. No warning lamps or messages were present at time of incident. Vehicle is available for inspection upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11500762January 9, 2023
ENGINE
The contact owns a 2016 Hyundai Veloster. The contact stated while driving 70 MPH, the vehicle began to stall. The contact stated no warning light was illuminated. The contact was able to park on the side of the road. The vehicle was not drivable. The contact towed the vehicle to her residence. The contact towed the vehicle to the local dealer, where it was diagnosed and determined that the catalytic converter needed to be replaced; and the vehicle was repaired under NHTSA Campaign Number: 20V746000 (Engine). The dealer replaced the catalytic converter but then informed the contact that the VIN was not included in NHTSA Campaign Number: 20V746000 (Engine). The vehicle was not serviced under the recall. The manufacturer had been informed of the failure. The failure mileage was approximately 81,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498872December 26, 2022
ENGINE, UNKNOWN OR OTHER
I was driving my 2016 Hyundai Veloster Turbo when I started to hear a loud knocking sound coming from the engine. At this time I also noticed a decline in power and the check engine light came on. I made an appointment to bring the car to my local Hyundai dealership to have the car looked at. While en route to the dealership, the car suddenly made a loud bang and a profusion of smoke came out of the engine and engulfed the car, inside & out, making it impossible for not only me to see but also limited visibility for the person following me, which was extremely dangerous. I couldn't see or breathe and had to rapidly exit the car on the side of a busy road with no shoulder. The engine completely failed and the car was not drivable. I had the car towed to the Hyundai dealership where they told me the engine had seized and needed to be completely replaced. Although my VIN is not yet included in engine recall 20V746000, my car has the 1.6 liter GDI Gamma engine included in that recall. In addition, the exact chain of events that I experienced have been described by others whose cars are included in the recall which describes connecting rod bearings inside the engine wearing prematurely (creating a knocking sound and reduced engine power), causing engine damage. I am requesting an investigation into this incident as I feel that my car should be included in the recall. It was a very dangerous incident and I don't want others to needlessly experience this same problem, possibly with more harmful consequences.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11495278November 29, 2022
ENGINE
The contact owns a 2016 Hyundai Veloster. The contact stated that an abnormal rumbling noise was coming from the vehicle at start-up. The check engine warning light was illuminated. The contact then received notification of NHTSA Campaign Number: 20V746000 (Engine). The vehicle was taken to a dealer where a software update was performed; however, the failure persisted. The vehicle was then taken to an independent mechanic who diagnosed the vehicle with engine failure. The vehicle was also taken to AutoNation Hyundai Hilton Head (255 Drivers Way Suite B, Hardeeville, SC 29927) where a temporary repair was performed; however, the failure recurred. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 109,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11490761October 25, 2022
ENGINE AND ENGINE COOLING
The contact owns a 2016 Hyundai Veloster. The contact stated that while driving approximately 55 MPH a loud booming sound from the engine compartment had occurred and a knocking noise followed along with white smoke from the exhaust pipes. The vehicle drove off the road before flames were present coming from under the hood. The fire department was called to the scene and extinguished the flames. A police report was taken and the vehicle was towed away. No injuries were reported. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet contacted. The contact indicated that the vehicle had previously been serviced several times for a faulty engine and catalytic converter. The failure mileage was 100,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11484318September 13, 2022
ENGINE
The contact owns a 2016 Hyundai Veloster. The contact stated that while driving 70 MPH, the engine misfired and the vehicle stalled. The check engine warning light illuminated. The vehicle was towed to the dealer where it was diagnosed that the engine failed and needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 20V746000 (Engine). The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 98,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11483139September 6, 2022
ENGINE, AIR BAGS
Oil pressure light began coming on around 7/1/2022. By 7/5/2022 car would accelerate past 40mph unless put into manual drive. Dealership pulled camshaft codes but said they couldn't find the code in manual for car. Now estimated $800 for repairs with airbag light also on
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11482399September 1, 2022
ENGINE
2016 HYUNDAY VELOSTER. CONSUMER WRITES IN REGARD TO ENGINE FAILURE. THE CONSUMER STATED THE VEHICLE WAS TAKEN TO BE DIAGNOSED FOR A RECALL REPAIR. THE VEHICLE WAS FOUND TO NEED THE REPAIR, BUT THE CONSUMER WAS ON A TIME CONSTRAINT. IT WAS ADVISED THE VEHICLE WAS UNSAFE TO DRIVE AND SHOULD AWAIT THE RECALL REPAIR. THE VEHICLE HAD NOT EXPERIENCED ANY FAILURES. THE CONSUMER WAS DUE TO MOVE TO A NEW STATE SOONER THAN THE VEHICLE COULD BE REPAIRED. AFTER THE RECALL REPAIR, THE VEHICLE BEGAN MALFUNCTIONING. THE CONSUMER STATED THE VEHICLE WAS SLOW TO ACCELERATE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11481668August 28, 2022
ENGINE, POWER TRAIN
Unknown Vehicle stalls and misfires
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11481283August 25, 2022
POWER TRAIN:MANUAL TRANSMISSION
The contact owns a 2016 Hyundai Veloster. The contact stated while driving approximately 55 MPH and shifting to a higher gear, he attempted to depress the clutch pedal; however, the pedal was flat against the floorboard. The contact had to lift the clutch pedal with his foot several times to get the pedal back to position to respond to shifting gear. The contact stated no warning light was illuminated. Additionally, the vehicle was slow to respond to the accelerator when the contact attempted to accelerate. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that there was no issue with the clutch pedal. The vehicle had not been repaired. The contact stated that the failure of the clutch pedal was intermittent. The manufacturer had not been informed of the failure. The failure mileage was approximately 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477988August 7, 2022
POWER TRAIN, UNKNOWN OR OTHER, AIR BAGS
When I first bought my car it seemed to have some sort of transmission problem because it's a dual clutch I was told they do have problems sometimes when I'm trying to pick up speed it seems like it won't switch gears so it won't pick up speed which is extremely dangerous especially when I'm on the beltway or highway and I've already had Hyundai replace the first transmission because it was faulty now my second transmission is already acting up and it's only been 2 years
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477628August 4, 2022
ENGINE
The contact owns a 2016 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound coming from the vehicle. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact added an additional 4 quarts of oil. The contact stated that the connecting rod bearing had failed. There were no warning lights illuminated. The vehicle was towed to the local dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The contact stated the failure was related to NHTSA Campaign Number: 20V746000 (Engine). The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 185,613.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477486August 3, 2022
ELECTRICAL SYSTEM, ENGINE
Me and my who is currently pregnant was driving at a highway running 40mph when my car suddenly stalled. The engine died and my car is like on neutral. Thank god i was able to maneuver it to the sidelane and no one was injured. There were no warning lights whatsoever. I had to call a tow truck to bring it to my house. And since im very scared to use it again. And up to now the car is still not working, i wonder if its the engine or the alternator that caused the engine to die.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476044July 27, 2022
ENGINE, FUEL/PROPULSION SYSTEM
I took my car to a dealer called Lee Johns in Everett WA for 2 recalls, but they told me I had problems with my catalytic converter and they replaced it under warranty at no cost to me. After 2 days they gave me the car and it did not work more than 2 hours and the engine light started blinking and from one moment to another it reduced the speed to 20 miles per hour. I called the dealer and they told me to take them, but to this day they only replied that the car warranty would only cover 55% for the replacement of the damaged engine. They gave me the defective car after they changed the catalyst and I gave them a working car that now doesn't work and they only tell me that I have to pay 4000usd so that they can repair it and they haven't given me any report of the engine revision because It failed, after they changed the catalyst, only telling me that I should pay and then make a claim or sue the manufacturer. I delivered my car to them on June 27 and to date they have it in their possession, leaving me unable to move and me having to assume the costs of renting and paying friends to pass their cars to me. I hope they can see my case since they wrecked my car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11471177June 27, 2022
ENGINE
The contact owns a 2016 Hyundai Veloster. The contact stated while driving 40 MPH, she heard an abnormal loud knocking sound coming from the engine. There were no warning lights illuminated. The contact veered to the side of the road. The vehicle was towed to the local dealer where it was diagnosed that the rod bearing had failed and the engine needed to be replaced. The contact became aware of NHTSA Campaign Number: 20V746000 (Engine) however, the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 106,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468748June 11, 2022
ENGINE
The dealership refuse to do the recall on my vehicle just because my vehicle needs a new battery and want me to get a new battery to get the recall done. They don’t want to use a battery from their shop and then put my old battery back.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456928March 16, 2022
ENGINE
The contact owns a 2016 Hyundai Veloster. The contact stated that she had initially received a recall notification for NHTSA Campaign Number: 20V746000 (Engine). The contact took the vehicle to a dealer where they inspected the vehicle and found no damage related to the recall, the recall was then removed and the vehicle returned to the contact. Recently, the contact stated that on two separate occasions, once while driving at 70 MPH, the vehicle stalled with the check engine warning light illuminated. The dealer was notified and provided a diagnostic fee for an inspection. The contact then took the vehicle to Hyundai of Yakima (3204 Fruitvale Blvd, Yakima, WA 98902) where they confirmed that the connecting rod bearing was defective which was linked to the recall. The manufacturer was notified by the dealer and the manufacturer denied the claim submitted to have the vehicle serviced under the prior recall. The vehicle remained in the possession of the dealer and was not repaired. The failure mileage was approximately 117,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455257March 4, 2022
ENGINE, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
The contact owns a 2016 Hyundai Veloster. The contact stated his daughter was driving and was at a stoplight. The driver was making a right turn when the vehicle lost motive power and the vehicle stalled lost power. The driver was able to restart the vehicle and slowly pulled the vehicle into a parking lot and parked. There were no warning lights illuminated. The contact had to pick up the vehicle the next day and have it towed to their residence and then towed to an independent mechanic to inspect the vehicle and failure was related to an internal issue with the engine making abnormal noise. The contact had the vehicle towed to a local dealer who diagnosed the failure as related to the catalytic converter and damage to the engine where it would need to be replaced. The dealer also inform the contact the failure could be related to an NHTSA Campaign Number: 20V746000 (engine), however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 59,270.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11451884February 14, 2022
POWER TRAIN, ENGINE
Cruising on freeway ~70 mph when car starts slowing due to lack of power- for unknown reason car went into "limp mode", with turbo boost pressure and power cut off, barely enough power to keep car at 60 mph in order to make it to freeway exit to pull off. This could have caused serious collision. Turned off car, let it sit 1 min, turned it back on, and problem seemed to go away. No Check Engine Light, no OBD2 codes. Limp mode sometimes occur during harsh shifts but releasing throttle and reengaging usually fixes it but this time needed to shut off the car. Has been reported to dealer but they can't reproduce consistently and no CEL/codes so they won't try to find a fix. But losing power for no apparent reason on freeway definitely dangerous situation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Veloster