Hyundai Kona Complaints (2019)

252 consumer complaints on file.

#11739538May 22, 2026
ENGINE
The contact owns a 2019 Hyundai Kona. The contact observed excessive oil consumption, which has progressively caused the vehicle to stall 2 to 3 times per week. While the engine can be restarted, it idles and runs roughly immediately afterward. Additionally, the contact noted a distinct smell of burning oil exiting from the exhaust system. The contact referenced NHTSA Campaign Number: 21V301000 (ENGINE) however, the VIN was not included in the recall repair. The vehicle was taken to a independent mechanic where it was diagnosed to have excessive oil consumption. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 78,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739344May 21, 2026
ENGINE AND ENGINE COOLING, ENGINE
The contact owns a 2019 HYUNDAI Kona. The contact stated while driving the vehicle at an undisclosed speed, he noticed he had an engine knock, and noticed that the engine was consuming a good amount of oil with no warning lights or oil leaks. The contact pulled over to the side when the knock started and noticed the vehicle was starving of oil although a recent oil change shows it was recent. The vehicle was taken to a dealer where it was diagnosed to have poor service, and engine sludge although dealer stated there was none. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 120,132.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738963May 20, 2026
ENGINE
Vehicle frequently and quietly stalls while driving in active traffic, creating an immediate safety hazard. Vehicle is a 2019 Kona with the 2.0L Nu MPI engine, which is the exact subject of NHTSA Safety Recall 21V301 (Recall 209). Hyundai Motor America (Case #42541672) is actively refusing to honor or inspect the vehicle under the safety recall mandates, claiming a lack of dealership service history overrides a federal safety defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739064May 20, 2026
ENGINE, POWER TRAIN
96,247 mi Engine knock and complete oil loss within 3,000 miles of last oil change Symptoms consistent with NHTSA Recall 21V301 (Hyundai Recall 203) and Warranty Extension TXXM coverage
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736065May 6, 2026
ENGINE
Engine blew a head gasket so had to have the engine rebuilt @ a cost of $13,000. Car only had 22,500 miles on it. I think that should instigate a recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733599April 24, 2026
ENGINE, POWER TRAIN
The vehicle burns oil faster and the vehicle began to stall at highway speeds. Upon further research, a campaign recall for the same vehicle is open but only for specific VIN. Although this vehicle was not part of the recall campaign 21V301000 the vehicle shows issues aligned with the recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731676April 16, 2026
ENGINE
Last week just driving to school, my engine started to knock. So the next day we take it to a local mechanic shop and it exploded while they were test driving it and they diagnosed it with rod bearing failure. So I contact Hyundai and get it towed to the Hyundai dealership for them to inspect it and eventually do an engine swap, but after it got dropped off I was told it’d be $360 to get it diagnosed and filed and they said that I have no warranty. I explained to the rep that the class action lawsuit regarding the Theta 2 GDI engines extends the warranty to 15 years/150,000 miles for all subsequent owners especially since I’ve had the KSDS installed. They’re refusing to cover damages even though my car was affected by a manufacturing issue on their end and was part of major recall campaigns. My car failed at 94,000 miles while up to date on services and the representative was recommending I ask Hyundai for “good-will funding” but I don’t need their “good will” I need them to make the situation right and cover all my expenses related to my blown engine
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729808April 7, 2026
ENGINE
My 2019 Hyundai Kona is equipped with a 2.0L Nu MPI engine covered under Recall 203 (NHTSA Campaign 21V301) for defective piston oil rings. The recall inspection was performed and closed at a Hyundai dealership in September 2023. The engine was passed and not replaced. Following that recall closure, the vehicle has required the same repair four times: replacement of the CVVT Assembly-Exhaust, Camshaft Assembly-Exhaust, and Timing Chain Tensioner. Each repair was performed under warranty. The recurring diagnostic code is P0017 (Crankshaft/Camshaft Position Correlation - Exhaust). Total warranty expenditure on these repeated repairs exceeds $7,800. During one of these visits (January 2025), the technician noted the CVVT had a "slight hold on rotation" and flagged possible exhaust camshaft damage. The vehicle has also experienced stalling while driving, creating a direct safety risk to the driver and others on the road. An independent repair facility has evaluated the vehicle and provided a written assessment concluding that full engine replacement is required, and that an underlying engine defect is causing the repeated component failures. It is my position that the Recall 203 inspection was performed inadequately — the defect was present at the time of inspection and was not identified. The recall remedy did not resolve the condition it was designed to address. Hyundai has since declined to replace the engine despite the documented failure pattern and independent shop recommendation. The vehicle is available for inspection. The problem has been confirmed by both a Hyundai dealer and an independent shop.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726951March 25, 2026
AIR BAGS
I am reporting this for my daughter, [XXX] , while she's recovering on pain meds. She is the owner and driver of the car. no passengers in this 1-car accident. the weather and road conditions were terrible. car skidded of side of road into a ditch. When the airbags deployed, the plastic frame on the drivers side A-pillar broke and exploded out towards the driver. it appears the sharp edge of the broken plastic frame struck driver in left eye, slicing it cornea area of her eye causing a ruptured globe. thankfully, she has no other injuries. the plastic frame on the passenger side A-pillar did not break when it's airbag deployed. reporting by [XXX] . please contact me at [XXX] . [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11726240March 23, 2026
ENGINE
Vehicle struggling to accelerate and rolling back when brake is not being used. It stays at a few miles per hour even with full pressure on the gas pedal. A mechanic reviewed and stated the problem was due to low compression in the engine, causing the pistons to misfire. This issue has happened a total of 5 times and has almost caused other vehicles to crash into me due to sudden loss of speed and not being able to accelerate fast enough to properly get to safety
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722955March 9, 2026
ENGINE
The contact owns a 2019 Hyundai Kona. The contact stated that while driving at an undisclosed speed, there was a knocking sound coming from the vehicle with the check engine warning light illuminated. The vehicle was driven to an independent mechanic, where it was diagnosed with engine failure. The contact referenced NHTSA Campaign Number: 21V301000 (ENGINE); however, the VIN was not under recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 94,634.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720849February 27, 2026
UNKNOWN OR OTHER
The rear left passenger will not open. The dealer thinks it is a faulty door latch actuator ($530 parts and labor). They said this is a common problem and they have a special tool to open the door, but they couldn't get it to work on my car. They think they will damage the interior door panel trying to fix this (approximately an additional $1,000). Warranty expired last year. This is a safety issue because in an emergency a passenger could be trapped in the vehicle or at best delayed in their escape. Also, the dealer said it is a common problem and online forums confirm that across several models and years. Also, it seems to be common for multiple doors to fail.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720584February 26, 2026
ENGINE
Engine smoke’s every now and then I go through a quart of oil every 600-1000 miles doubt it’s supposed to do that one time I went the full oil change limit I was completely out of oil the car was ticking and all this other stuff scene then I’m topping off my oil every 1000 miles till I need a oil change and it don’t stop ticking now so that’s a defect I don’t know if it’s apart of the 19-21 recall or not but this is not an okay engine
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720371February 25, 2026
ENGINE
The contact owns a 2019 Hyundai Kona. The contact stated that while his daughter was driving 45 MPH, the check engine warning light illuminated, and the vehicle shut off. The driver pulled over to the side of the road and the vehicle was towed to an independent mechanic to be diagnosed. The mechanic related the failure to NHTSA Campaign Number: 21V301000 (ENGINE); however, the vehicle was towed to a dealer and the dealer declined to honor the recall repair due to sludge in the oil cap. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 100,220.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720399February 25, 2026
ENGINE
The contact owns a 2019 Hyundai Kona. The contact stated that while driving at various speeds, there was an abnormal knocking sound coming from the vehicle with the check engine warning light illuminated. Upon inspection of the vehicle, the contact discovered that the engine oil was low, and the contact added oil to the engine. The contact stated that the failure was intermittent. Upon investigation, the contact discovered NHTSA Campaign Number: 21V301000 (Engine). The contact continued to investigate the failure and discovered that the vehicle was previously repaired before owning the vehicle. The contact reached out to several dealers and the manufacturer about the issue; however, no assistance was provided. The contact continued to speak with the manufacturer, and the manufacturer agreed to have an oil consumption test performed on the vehicle. The vehicle tested by two dealers for the consumption test and the results came back inconclusive. The vehicle was not repaired. The failure mileage was approximately 68,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718156February 15, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
While stopped our 2019 Kona EV at a traffic light with my foot on the brake, the car spontaneously accelerated and crashed into the car also sitting at the light about eight feet in front of us. If there wasn't a car in front of us, we would have gone through a busy intersection at very high speed. The front end of the car was destroyed and both airbags deployed. The car was towed to a collision center and is considered: "Totaled" . We tried to get it inspected for the computer system to confirm what happened, but there was no interest by any party. There was no pre-warning or issues with the vehicle before this happened. The incident happened about ten miles from our house, and we had been driving it for about 15 minutes. The temperature outside was extremely cold at about 5 degrees Fahrenheit.
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#11717113February 10, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2019 Hyundai Kona. The contact stated that while driving at an undisclosed speed, there was a burning odor coming from the vehicle, with the low engine oil warning light illuminated. The contact stated that while checking the dipstick, the contact became aware that the engine oil level was low. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716872February 9, 2026
ENGINE
Vehicle started to stall at low RPMs. While idling at red lights, engine would stall and go into limp mode. All safety features, such as forward collision would stop working. Car would need to be turned off and restarted for a temporary fix. No engine lights would come on. Car inspected by dealership and cannot figure out what the cause is. VIN comes up saying that my car is not part of the recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716639February 9, 2026
ENGINE
Car idles down and dies while driving, unable to restart, no codes showing
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716278February 6, 2026
ENGINE
The contact owns a 2019 Hyundai Kona. The contact stated that while driving at an undisclosed speed, the engine was shutting down while on the way to work, with a knocking sound coming from the engine. The vehicle was towed to the dealer. The contact associated the failure with NHTSA Campaign Number: 21V301000 (ENGINE); however, the dealer refused to perform the recall repair, because there were other failures with the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 100,902.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Kona