GMC Sierra Complaints (2020)

626 consumer complaints on file.

#11658105May 1, 2025
POWER TRAIN
The contact owns a 2020 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11658119May 1, 2025
ENGINE
1) Complete Engine Failure. Vehicle is no longer is in possession for inspection but pictures and video can be provided. 2) My Truck stalled at 70 MPH going down the interstate. I was lucky to be driving in the right lane to glide to a complete stop. This could have been way worse, not just for myself but for others. 3) Shortly after the loss of propulsion on the interstate. The engine started knocking very loud and I brought it into Boucher GMC of Brookfield. After about a week, the conclusion was I needed a new Engine. The Bearings, camshaft, rods and other components within the engine were damaged. The dealership said it was because of Bad Oil. 4) Parts were inspected and Dealership provided pictures. Not sure what they did with the junk parts. 5) I initially brought in the vehicle where it was purchased at Kunes of Stoughton WI for a Check engine light that read a P06DD error code at 56472 miles on the truck. They performed a software update and sent me on way. Since then, I was dealing with a on and off engine light which eventually brought me to a engine replacement at about 70,000 miles. None of this was covered under warranty and I had to pay for all of this out of pocket. In the events of all this. GMC had my truck for about 3 months. I had to purchase another vehicle because it was cheaper then renting one, GMC didn't have a loaner I could use. I could not perform my everyday work tasks besides getting to and from work, because I did not have a truck to carry my everyday work tools. Now understanding the full impact of this faulty engine and that I could have done harm to others or my self, has me worried about driving a GM vehicle. After I received the new engine, approximately 2000 miles later, The new engine, not rebuilt started making a knocking noise, only to find out, it was the same issue after bringing it to the dealership. No engine lights or nothing. People should be scared to drive a vehicle with the L87 engine from GM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657874April 30, 2025
ENGINE
Shut off in traffic twice
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657881April 30, 2025
ENGINE
Engine locked up
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657912April 30, 2025
ENGINE
I have had two engine failures within 2 years of buying a new GMC truck. The first occurred at 24,181 miles whereas i found engine failures is an all to common occurrence with these 5.3 liter engines, failures are wide spread, tons of complaints can be found with a simple internet or youtube search. The second engine failure occurred at 45,517 miles, again with lifer falling apart. Several service bulletins have been issues including reworking vehicles on dealers lots to replace faulty components but in my case i had over 16000 miles so they put the same parts in again and did not touch the other side which then failed two years later at in my case both were attributed collapsed lifter. This is a safety concern, there is no indication this is about to occur. The vehicle loses power, shakes, instrument panel lights up with various different warning lights. If you are passing another vehicle and this occurs it can be frightening as you have no idea what is happening and why you are no longer accelerating if you are passing some vehicles. The value of these vehicles is now also diminished, who wants a GM vehicle with two engine failures with 45k miles? No one, because it more than likely going to keep occurring until the engine is damaged beyond repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657963April 30, 2025
ENGINE
3.0 LM2 Duramax engine failed at 91,000 miles. It needs a new engine and they are available with a 2-3 week wait time. The engine failure has been inspected and confirmed by the dealer. No symptoms or check engine lights were on prior to the failure. Problem first appeared 03/2025.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657509April 29, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2020 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated even though an oil change had been performed within 1,000 miles. The vehicle was taken to the dealer, who diagnosed a failure with the piston O-rings, resulting in damages to the engine. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Action Number: PE25001 (Engine and Engine Cooling). The manufacturer was notified of the failure but provided no assistance. The failure mileage was 79,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657522April 29, 2025
POWER TRAIN
The transmission is jerking and sometimes it will not shift enough to get out of others ways. Severe slippage in the transmission I have taken the truck to the shop 3 times for the same issue. Now they tell me I need a new transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657604April 29, 2025
ENGINE
The contact owns a 2020 GMC Sierra 1500. The contact stated that while attempting to start the vehicle, the vehicle failed to start. There was no warning light illuminated. The contact pushed the vehicle out of the garage. The vehicle was towed to a dealer where it was diagnosed that the spun bearing had failed. The contact was advised that the engine needed to be replaced. The engine was replaced. The contact stated that recently there was an abnormal sound coming from the engine. The vehicle was not diagnosed or repaired after the most recent failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657140April 28, 2025
SERVICE BRAKES
Brake monitor repair keeps illuminating since 2/1/2025! Replaced all brakes and rotors, yesterday 4/27/2025. now don't drive over 43 mph illuminates, emergency brake illuminates says push brake peddle to disengage parking brake yet parking brake has never been engaged
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657179April 28, 2025
ENGINE, POWER TRAIN
1. Vehicle automatic transmission failed during routine highway driving. Significant drivetrain vibration and limited gear availability. Warning lights included: ESC. - Electronic Stability Control TSC - Traction System Control Emergency Brake Fault light Power Steering assist reduced Flashing Yellow Engine Warning light. 2. White exhaust smoke upon arrival at GMC dealership. GMC technician advised full diagnostic would be required to assess extent of transmission failure and cause of white exhaust smoke. Service technician subsequently communicated that the engine was “failed” and would have to be replaced. Vehicle could not be driven and so full extent of transmission failure could not be assessed UNTIL ENGINE IS REPLACED!?!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657259April 28, 2025
POWER TRAIN, ENGINE
Merging onto highway, lost engine power. Cylinder lifter failed, damaged cam shaft, caused damage to coolant system via metal debris, and engine needs to be replaced. 76,000 miles on vehicle, regularly serviced at dealership. I inspected the parts, and was shown the cylinder lifter that had failed and fragmented as well as the galled cam shaft. There were no prior indications of impending failure (no hard shifts, jumping, warning lights, etc). Warning lamps turned on after failure. I asked the mechanic at the GMC Dealership what caused the failure, and wasn't given a definitive answer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656231April 23, 2025
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
I was about 45 miles or so from home on [XXX]. As I left a business my truck went about 100 feet and the engine stopped working . No warning. Truck was towed to a GM dealer in Wilmington Il. It was determined the cause was due to the wiring from the engine ECM that was run over the top of a very sharp plastic mounting bracket for the ECM. The wire had been cut because of the way this was done at the factory. In addition the fuel pump also needed to be replaced . At the time of this, the truck had 39,140 miles on it. I had no warning this was about to happen. No check engine light went on , etc. Most of my route home is on the highway . Had this not happened on a side street , I would have been involved in an accident. I ended up paying $865.42 plus towing for this repair I should not be paying for. The people at the GM dealer told me this has been happening on numerous GM pick up trucks. This is NOT a maintenance issue or an isolated case. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656277April 23, 2025
ELECTRONIC STABILITY CONTROL (ESC), ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
The contact owns a 2020 GMC Sierra 1500. The contact stated while driving 40 MPH, the vehicle failed to properly respond. There were no warning lights illuminated; however, the message ESC was displayed. The contact stated that the brakes, steering, and a message to check the trailer brakes was also displayed. The contact pulled over to the side of the road and the brake pedal was depressed several times however, the brakes failed to respond, and the vehicle was difficult to control. The vehicle was towed by AAA and then towed to a dealer however, the vehicle was not yet diagnosed. The contact stated that the brakes were inoperable, and the control center was destabilized. The vehicle was not yet repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 125,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656171April 22, 2025
STRUCTURE:BODY
Had water leaking into cab of truck. First incident they stated it was a rear window seal and it was "repaired" under warranty. Second incident I was advised it was body panel separation where the cab roof and side body seam was leaking. It was repaired by sealing with "body seam sealer." I later read these repairs should have been welded. This was after the warranty expired and I had to pay for it. I then read on the Silverado/Sierra forum this repair should have been a weld not just "glued" is this a safety issue?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655565April 19, 2025
ENGINE
2020 GMC Sierra "Denali" 6.2L engine with only 64,000 all original well maintained at miles -- NO prior issues no unusual sounds or indications of any issues. Vehicle has had timely maintenance regularly. engine lost power and began shuddering severely. Immediately taken to GM certified dealership upon which charged almost $1600.00 for engine analysis. Diagnosis is cylinder # 5 had lifter collapse which in turn ruined the camshaft. Will have to wait 4 weeks for parts and since GM power train warranty (conveniently) only covers first 60,000 miles the total engine rebuild is out of my pocket. Total price $9,741.11. THIS IS RIDICULOUS AND GM NEEDS TO REPAIR OR REIMBURSE EVERY SINGLE OWNER THAT EXPERIENCES THIS ISSUE IN FULL. I think GM knew about this issues and hopes it will go away but this really pisses me and SHOULD everyone else too.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655399April 18, 2025
ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL, POWER TRAIN
The contact owns a 2020 GMC Sierra 2500. The contact stated that the vehicle was under NHTSA Campaign Number: 24V797000 (Power Train) and the vehicle was repaired. The contact stated that after the recall repair, the transmission started shifting hard. The vehicle was taken to the dealer, and the contact was informed that the transmission module would reprogram and adjust independently. The contact stated that a week later, while driving approximately 45 MPH, the vehicle started to run rough, and the message engine power reduced was displayed. The transmission fault, parking brake system alert, service parking brake, and the check engine warning light illuminated. The vehicle was towed to the dealer, who diagnosed the vehicle and determined that the fuel injector was open, causing high resistance in the connector for cylinder #4. The transmission could not be diagnosed until the injector was repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was 125,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655482April 18, 2025
ENGINE
Second engine failure in 8 months. 1st with 97k miles and last after 15k on a brand new 6.2L engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654874April 15, 2025
POWER TRAIN
Valve body failed while pulling my camper down the interstate. Transmission began to have issues and locked up on us while driving. Luckily i was able to avoid any accidents. Had truck towed to a private Transmission shop to have the transmission repaired. Shop advised the failure was due to the faulty valve body.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654538April 14, 2025
POWER TRAIN
The contact owns a 2020 GMC Sierra 1500. The contact stated while driving 65 MPH, the vehicle briefly started to shimmy. Upon decelerating, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V797000 (Power Train), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to GMC Sierra