GMC Sierra Complaints (2002)

591 consumer complaints on file.

#10397355April 25, 2011
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
TL* THE CONTACT OWNS A 2002 GMC SIERRA 2500 HD. THE CONTACT STATED THAT THE ABS ACTIVATED INDEPENDENTLY AT REDUCED SPEEDS WHEN COMING TO A COMPLETE STOP. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BUT THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC: ANTILOCK). THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 89,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 88,000. UPDATED 06/01/11*LJ UPDATED 06/02/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10397194April 23, 2011
SERVICE BRAKES, HYDRAULIC, EQUIPMENT
I APPLIED MY BRAKES ON MY GMC TRUCK AND THEY FAILED . THE BRAKE TUBING RUSTED THRU AT THE ABS UNIT. UPON FURTHER INSPECTION IT WAS DETERMINED THAT ALL THE BRAKE LINES WERE RUSTED SEVERELY. I TRIED TO FIND PRE BENT LINES AND THEY ARE NOT AVAIL. FROM GM AND NOT AVAIL FROM AFTERMARKET FOR A 2002 GMC 2500HD 2WD OR ANY GMC FROM DEALER.FRME AND UNDERCARRIAGE IS RUSTED WORSE THE MY 1983 AND BRAKE ROTORS RUSTED AND FLAKED AWAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10394129April 4, 2011
STEERING
TL* THE CONTACT OWNS A 2002 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 5 MPH THE CONTACT HEARD A CLANKING NOISE AND FELT A VIBRATION IN THE STEERING COLUMN. THE CONTACT STATED THAT THE VIBRATION AND THE SOUND WOULD OCCUR CONSTANTLY WHEN DRIVING AT LOW SPEEDS AND BECAME MORE NOTICEABLE WHEN DRIVING AT HIGHWAY SPEEDS. THE MANUFACTURER AND DEALER WERE CONTACTED AND STATED THAT THERE WAS NOT A RECALL FOR THE FAILURE AND THEY COULD NOT PROVIDE ANY FURTHER ASSISTANCE. THE FAILURE WAS NEITHER DIAGNOSED NOR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10392965March 26, 2011
SERVICE BRAKES, HYDRAULIC
BRAKE FAILURE DUE TO RUSTED BRAKE LINE, TRUCK LOST ALL BRAKE FLUID! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10386343March 3, 2011
SERVICE BRAKES, HYDRAULIC
2002 GMC SIERRA 1500 BRAKELINE FAILURE DUE TO SEVERE CORROSION OF HARD LINES UNDER DRIVERS SIDE . I WAS BACKING OUT OF A PARKING LOT WHEN BRAKE PEDAL WENT TO FLOOR AND HAD SEVERE LOSS OF BRAKING POWER. UNDER FURTHER INVESTIGATION ONE LINE WAS RUSTED THROUGH AND OTHERS SEVERELY CORRODED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10378880January 26, 2011
FUEL SYSTEM, GASOLINE
I HAVE A 2001 CHEVROLET TRUCK WITH A 4.3 LITER V6 ENGINE AND A 2002 GMC SIERRA 1500 HD WITH A 6.0 LITER V8 ENGINE AND BOTH OF THEM HAVE FUEL GAUGE PROBLEMS. THE FUEL GAUGE IS VERY ERRATIC AND HARDLY EVER ACCURATE. I WAS GOING ABOUT 70 MPH AND SHOWED 1/2 TANK OF GAS AND ALL OF A SUDDEN RAN OUT OF GAS IN THE 2002 MODEL. THE 2001 MODEL IS NEVER ACCURATE. I HAVE TO CARRY SPARE GAS WITH ME EVERYWHERE. ON THE INTERNET, THERE ARE THOUSAND AND THOUSANDS OF OTHER PEOPLE COMPLAINING ABOUT THE SAME PROBLEMS IN NUMEROUS CHAT LOGS. GM SHOULD RECALL THESE VEHICLES AND DO SOMETHING ABOUT THIS MAJOR DEFECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10378349January 23, 2011
SERVICE BRAKES, HYDRAULIC
THREE BRAKE LINES RUPTURED SIMULTANEOUSLY CAUSING AN INABILITY TO STOP THE VEHICLE. THE CAUSE OF FAILURE WAS RELATED TO AN EXTENSIVE AMOUNT OF CORROSION ON ALL OF THE BRAKE LINES ON THE VEHICLE. COMPLETE REPLACE IS NECESSARY. THERE IS A REGIONAL RECALL ON THIS EXACT ISSUE BUT DOES NOT INCLUDE MY STATE. THERE ARE CONSIDERABLE REPORTS OF THIS FAILURE ACROSS THE COUNTRY BUT GM AND EVEN WORSE NHTSA FAILS TO FORCE A NATIONWIDE RECALL OF THIS POTENTIALITY DEADLY FAILURE. A SIMPLE SEARCH OF THE INTERNET WILL PROVE THIS DEFECT IS NOT CONSTRAINED TO ONLY THE RUST BELT STATES. MY '66 CHEVY STILL HAS THE ORIGINAL BRAKE LINES WITH NO SIGNS OF DEGRADATION HOWEVER MY '02 GMC REQUIRES THE REPLACEMENT OF ALL METAL LINES ON THE VEHICLE. THE EXISTENCE OF A CURRENT REGIONAL RECALL PROVES THAT GM ADMITS TO THE PROBLEM! THIS FAILURE NEEDS TO BE CORRECTED NATIONWIDE. *LN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10378955January 20, 2011
ENGINE AND ENGINE COOLING
THE ENGINE SHUTS OFF AFTER IT WARMS UP. THIS CAN HAPPEN AT ANY TIME AND ANY SPEED. AFTER WAITING APPROX. 2 MINUTES IT WILL START AGAIN AND RUN FINE FOR THE REST OF THE DAY. NO CHECK ENGINE LIGHTS OR DIAGNOSTIC CODES ARE AVAILABLE. THERE IS A RECALL FOR THE 2001 MODELS (CAMPAIGN ID # 07V521000). THIS PROBLEM ALSO EXTENDS INTO NEWER MODEL YEARS. MINE WAS MANUFACTURED IN 1/02
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10377169January 19, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2002 GMC SIERRA 3500. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SMOKE AND LOSE POWER ABNORMALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE FUEL FILTER WAS REPLACED. THE FAILURE RECURRED IN LESS THAN ONE YEAR. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THE CONTACT WAS ADVISED THAT THERE WERE THREE DEFECTIVE FUEL INJECTORS THAT WOULD NEED REPLACING. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 06E043000 (FUEL SYSTEM, GASOLINE) YET THE REPAIR DID NOT REMEDY THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 82,828.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10376513January 13, 2011
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2002 GMC SIERRA. WHILE TRYING TO PARK THE VEHICLE THE BRAKE PEDAL EXTENDED TO THE FLOOR. THIS WAS THE FIRST TIME THE CONTACT HAD A PROBLEM WITH THE BRAKES ON THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT ALL OF THE BRAKE LINES NEEDED TO BE REPLACED. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 55,445. UPDATED 3/1/11 *CN THE CONSUMER HAS SINCE SOLD THE VEHICLE. UPDATE 03/03/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10376422January 12, 2011
ENGINE AND ENGINE COOLING
I HAVE A GMC 2500HD 4X4 WITH THE 8.1 LITER ENGINE IN THE PAST YEAR IT HAS STALLED AND THEN RESTARTED ITSELF 5 OR 6 TIMES ONE TIME I HAD TO SIT FOR ABOUT 6 MINUTES BEFORE IT WOULD RESTART. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10373751January 2, 2011
SERVICE BRAKES, HYDRAULIC
BRAKE LINE TUBING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10373399December 30, 2010
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
EXHAUST MANIFOLD BOLTS BREAK CAUSING EMISSION FAILURE AND EXHAUST LEAK. THE REPAIR BILL IS UP TO $1000. OR MORE. YOU HAVE TO HAVE A GARAGE DRILL OUT OLD BOLTS AND REPLACE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10372168December 22, 2010
TIRES, TIRES:SIDEWALL
MY HERCULES TERRA TRAC A/T 245 70 16 ARE SHREDDING NEAR THE SIDEWALL. THE 17 INCH VERSION OF MY TIRES WERE RECALLED BUT THE 16 INCH WAS NEVER RECALLED. HERCULES DEALER REFUSED TO REPLACE TIRE SAYING THAT I POSSIBLY HIT A CURB. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10371265December 20, 2010
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2002 GMC SIERRA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH AND ENTERING A CAR PORT AT HER RESIDENCE WHEN THE BRAKES FAILED AND SHE CRASHED INTO THE FRONT CORNER OF HER HOUSE. NO ONE WAS INJURED. THE CONTACT STATED THAT NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL PRIOR OR AFTER THE FAILURE. THE POLICE WERE NOT CALLED TO THE SCENE. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR HAD IT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000. THE VIN WAS UNAVAILABLE.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10363466November 1, 2010
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
TL*THE CONTACT OWNS A 2002 GMC SIERRA DENALI. WHILE DRIVING 25 MPH AND ATTEMPTING TO STOP, THE CONTACT NOTICED THAT THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD. THE CONTACT PULLED OVER AND ALSO NOTICED THAT BRAKE FLUID WAS LEAKING ON THE DRIVER SIDE. THE CONTACT LATER INSPECTED THE VEHICLE AND DISCOVERED THAT THE BRAKE LINES WERE CORRODED. THE DEALER AND THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10362149October 24, 2010
SERVICE BRAKES, HYDRAULIC
* 3-MAY-06: VEHICLE TAKEN IN TO DEALER AT 29 K MI FOR RECALL TO INSPECT BOTH FRONT WHEEL ABS SPEED SENSORS. TOTAL INSPECTION TIME APPROX 10 MIN, NO REPAIRS MADE. ONE POSSIBLE BRAKING INCIDENT OCCURRED 3.5 YRS EARLIER. * 24-SEP-08, 38 K MI: FRONT BRAKE PADS REPLACED, NORMAL WEAR PATTERNS. BOTH REAR INNER DISK BRAKE PADS WORN TO METAL AND JAMMED, BOTH REAR OUTER PADS LITTLE WEAR, BOTH REAR DISKS HEAVILY SCORED AND REPLACED. VEHICLE HAS BEEN USED LITTLE FOR TOWING. REAR CALIPER NUTS REQUIRED AN ESTIMATED 350+ LBS TORQUE TO LOOSEN. * 31-JUL-09, 39 K MI: NEAR ACCIDENT ON HWY AT LOW SPEED AFTER VERY LONG STOP AT SLOW SPEED, THEN 3 MI LATER CRASH INTO CONCRETE ABUTMENT OCCURRED WHILE PARKING AT IDLE SPEED. LOUD GROANING HEARD FR ENGINE COMPARTMENT. SCAN TOOL INFO BY GM DEALER INDICATED BOTH FRONT ABS SPEED SENSORS WERE NOT SENDING A SIGNAL. BODY REPAIR TO FRONT $800 USING USED PARTS AND EXCLUDING ABS SENSOR REPLACEMENT. * NEAR TOTAL, REPRODUCIBLE BRAKE LOSS OCCURS BETWEEN APPROX 3 AND 7 MPH. PRESSING HARDER ON THE BRAKE PEDAL SEEMS TO LENGTHEN THE STOPPING DISTANCE. HEADLAMPS DIM WHEN TRYING TO STOP AT SLOW SPEED WHILE THE ABS PUMP IS GROANING. * PROBLEM HAS YET TO BE CORRECTED. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10362160October 24, 2010
LATCHES/LOCKS/LINKAGES
NEITHER THE LEFT NOR RIGHT CARGO GATE LATCH BOLTS FAILED TO ENGAGE WHEN THE GATE WAS IN THE FULL UPRIGHT POSITION AND WHERE IT SHOULD HAVE LATCHED. THIS ALLOWED THE GATE TO FALL OPEN WHEN ACCELERATING. LUBRICATION WITH A SILICONE WAX SPRAY DID NOT SEEM TO FREE THE BOLTS. REPEATED LIFTING OF THE CENTER HANDLE ON THE GATE FOLLOWED BY QUICK RELEASE DID NOT RESULT IN THE LATCH BOLTS ENGAGING AND THE HANDLE SUBSEQUENTLY BROKE WITH MINIMAL EFFORT. ONCE THE HANDLE WAS REMOVED, CONTACT POINTS ON THE REMAINING HANDLE HARDWARE AND LATCH BOLTS THEN ALLOWED FREE MOVEMENT OF THE LATCH BOLTS. THE HANDLE HAS NOT BEEN REPLACED BUT THE LATCHES ON THE GATE ARE EASILY OPENED BY PULLING BOTH CABLES TOWARDS THE MIDDLE. CONTACT SURFACES SHOW LITTLE OR NO CORROSION OR DEBRIS. THE GATE WAS ALWAYS TESTED FOR CLOSURE AND IT IS SUSPECTED THAT THE LATCH BOLTS WERE ONLY PARTIALLY CLOSING AT THE TIME OF THE INCIDENT. THE GATE HAD BEEN FOUND OPEN AND ITEMS LOST IN THE PAST BUT IT HAD BEEN THOUGHT THE GATE HAD JUST BEEN LEFT OPEN RATHER HAVING BEEN CLOSED FOLLOWED BY FALLING OPEN AFTER LATCH FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10360733October 16, 2010
SERVICE BRAKES, HYDRAULIC, EQUIPMENT:ELECTRICAL
I HAVE HAD TO REPLACE FRONT WHEEL ABS SPEED SENSORS AND RELATED PARTS TWICE ON MY 2002 GMC SIERRA 1500. THE FIRST TIME WAS IN 2006, THE SECOND JUST THIS WEEK. THE TRUCK HAS JUST OVER 86000 MILES. THE ABS ENGAGED BELOW 10 MPH. I ALMOST HIT OTHER CARS OR OBJECTS SEVERAL TIMES WHEN THIS OCCURRED. SPEED SENSORS WERE CORRODED. HUB BEARINGS WERE ALSO REPLACED DUE TO SPEED RING FAULTS. IT HAS COST ME OVER $1500 BOTH TIMES TO HAVE THIS WORK DONE TO MAKE MY TRUCK SAFE TO DRIVE. MY REQUEST FOR WARRANTY COVERAGE WAS DENIED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10360378October 13, 2010
SERVICE BRAKES, HYDRAULIC
THE ANTI-LOCK BRAKES SYSTEM FAILED. WHILE BRAKING AT APPROXIMATELY 2-10 MPH, THE BRAKES LOCK UP. THIS LOCK-UP OCCURS AT ALL STOP SITUATIONS. THE LOCK-UP CAUSES SKIDDING, AND LONGER STOPPING DISTANCE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to GMC Sierra