Freightliner Cascadia Service Bulletins (2010)
763 manufacturer communications on file.
- December 1, 2010•Document ID: 10036724Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:UNIT; EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS; EXTERIOR LIGHTING:BRAKE LIGHTS; EXTERIOR LIGHTING:BACK UP LIGHTS; EXTERIOR LIGHTING:TAIL LIGHTS; EXTERIOR LIGHTING:FOG LIGHTS; EXTERIOR LIGHTING:HEADLIGHTS
- Mfr Comm. #:
- SB-54-258
- Date Added:
- April 11, 2011
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: EXTERIOR LIGHTS BLINKING. TRUCKS BUILT WITH SAM CAB SOFTWARE RELEASE 6.0 (SOFTWARE VERSION 09.31.005 AND ALL TRAILER IF TRAILER FAULT DETECTION IS ACTIVATED) TO LINK MOMENTARILY. BLINKING OF LIGHTS OCCURS APPROXIMATELY 5 SECONDS AFTER IGNITION KEY IS RELEASED FROM CRANK POSITION TO RUN OR OFF. NO MODEL YEARS LISTED. *PE
Associated Products (3)Associated Documents - December 1, 2010•Document ID: 10036671Service Bulletin/Repair InstructionsSTRUCTURE:BODY
- Mfr Comm. #:
- SB-60-146
- Date Added:
- April 9, 2011
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: SIDE EXTENDERS WITHOUT MID SPAN MOUNTING BOSSES; REPLACEMENT AND MID SPAN SUPPORT. SIDE EXTENDERS AND MOUNTING BRACKETS HAVE CHANGED. NEW SIDE EXTENDERS ARE ATTACHED TO THE UPPER AND LOWER MOUNTING BRACKETS WITH ONE SCREW EACH. UNKNOWN MODEL YEARS. *PE
Associated Products (1)Associated Documents - December 1, 2010•Document ID: 10036586Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SB-20-66
- Date Added:
- April 4, 2011
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: GENTECH LOW COOLANT LEVEL SENSOR (PART NO. 06-62384-002) IS ASSEMBLED WITH A TWO PIECE HOUSING HELD TOGETHER WITH TWO LOCKING TABS, ONE ON THE TOP AND THE OTHER ON THE BOTTOM. MODELS CASCADIA, CORONADO, BUSINESS CLASS M2. *PE
Associated Products (2)Associated Documents - November 25, 2010•Document ID: 10037444Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- ICI-10-028
- Date Added:
- May 24, 2011
- Manufacturer:
- FREIGHTLINER
SummaryDAIMLER TRUCKS: REVISIONS TO A PREVIOUS SERVICE CAMPAIGN. *RM
Associated Products (8)Associated Documents - November 1, 2010•Document ID: 10036595Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
- Mfr Comm. #:
- SB-26-49
- Date Added:
- April 4, 2011
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: NEW TRANSMISSION COOLANT LINE CLAMPS. EPA07 VEHICLES EQUIPPED WITH WATER TO OIL TRANSMISSION COOLER IN RADIATOR END TANK, NEW CLAMPS ARE AVAILABLE FOR TRANSMISSION COOLANT LINES. THE NEW CLAMPS REFINES OLDER VERSION TO SUBSTANTIALLY IMPROVE GRIP. NO MODEL YEARS LISTED. *PE
Associated Products (3)Associated Documents - November 1, 2010•Document ID: 10036594Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
- Mfr Comm. #:
- SF-422AB
- Date Added:
- April 4, 2011
- Manufacturer:
- FREIGHTLINER
SummaryDAIMLER TRUCK (FREIGHTLINER): KICK PLATE DOOR HINGES. THE KICK PLATE DOOR HINGE SPRINGS ON SOME TRUCKS MAY BE MISSING OR FRACTURE. A FAILURE OF BOTH SPRINGS MAY RESULT IN KICK PLATE DOOR NOT REMAINING SHUT. KICK PLATE DOOR HINGE SPRINGS WILL BE REPLACED WITH MORE ROBUST SPRINGS. *PE
Associated Products (5)Associated Documents - November 1, 2010•Document ID: 10036593Service Bulletin/Repair InstructionsSTEERING:RACK AND PINION
- Mfr Comm. #:
- SB-46-52
- Date Added:
- April 4, 2011
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: INPUT SHAFT SEAL REPLACEMENT, RACK AND PINION STEERING GEAR. WHEN REPLACING AN INPUT SHAFT SEAL ON A RACK AND PINION STEERING GEAR, IT IS PREFERABLE TO USE REPLACEMENT SEAL KIT THY 607157A. NO MODEL YEARS LISTED. *PE
Associated Products (2)Associated Documents - November 1, 2010•Document ID: 10036592Service Bulletin/Repair InstructionsSTEERING:RACK AND PINION
- Mfr Comm. #:
- SB-46-49
- Date Added:
- April 4, 2011
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: RACK AND PINION STEERING GEAR SERVICE PROCEDURES. UNTIL FURTHER NOTICE, RACK AND PINION REPLACEMENT ASSEMBLIES A14-17666-000 AND A14-17666-001 ARE NO LONGER AVAILABLE FROM THE DTNA PARTS DISTRIBUTION CENTERS. TIME FRAME FOR AVAILABLE STOCK HAS NOT YET BEEN DETERMINED. DTNA IS WORKING ON RESOLVING SHORTAGE. NO MODEL YEARS LISTED. *PE
Associated Products (2)Associated Documents - October 1, 2010•Document ID: 10036648Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- SB-49-27
- Date Added:
- April 6, 2011
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: EXHAUST STACK CLAMP FAILURE; EPA07 VERTICAL ATD. A DUAL BAND EXHAUST STACK CLAMP, FAILS ON AN EPA07 VEHICLE WITH A VERTICAL ATD, REPLACE IT WITH SINGLE BAND CLAMP. *PE
Associated Products (3)Associated Documents - October 1, 2010•Document ID: 10036624Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- SB-83-136
- Date Added:
- April 6, 2011
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: PARKSMART AUXILIARY HVAC SYSTEM INFORMATION. A BATTERY POWERED A/C SYSTEM, A FUEL OPERATED HEATER, AND AUXILIARY CONTROL UNIT (ACU) THAT REPLACES THE STANDARD AUXILIARY HVAC UNIT. *PE
Associated Products (1)Associated Documents - October 1, 2010•Document ID: 10036591Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
- Mfr Comm. #:
- SB-20-64
- Date Added:
- April 4, 2011
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: FAN CLUTCH NUTS. ALWAYS USE NEW NYLOC NUTS WHEN INSTALLING THE ENGINE COOLING FAN ON A BORG WARNER (KYSOR) FAN CLUTCH. FAILURE MAY LEAD TO A LOOSE OR LOST FAN, AND DAMAGE TO THE FAN CLUTCH OR TRUCK. *PE
Associated Products (4)Associated Documents - September 1, 2010•Document ID: 10037124Service Bulletin/Repair InstructionsSTEERING:COLUMN
- Mfr Comm. #:
- SB-46-50
- Date Added:
- May 9, 2011
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: THE PROCEDURE FOR REPLACING A FAILED THRUST BEARING IN A STEERING COLUMN. *RM
Associated Products (3)Associated Documents - September 1, 2010•Document ID: 10037110Service Bulletin/Repair InstructionsSUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM:SPRINGS/BAGS
- Mfr Comm. #:
- SB-32-40
- Date Added:
- May 6, 2011
- Manufacturer:
- FREIGHTLINER
SummaryDAIMLER TRUCKS: TROUBLESHOOTING FOR A MISALIGNMENT OF THE SUSPENSION AIR SPRINGS. *RM
Associated Products (5)Associated Documents - January 1, 2010•Document ID: 10033171Service Bulletin/Repair InstructionsSTEERING:GEAR BOX (OTHER THAN RACK AND PINION)
- Mfr Comm. #:
- SB-46-48
- Date Added:
- July 21, 2010
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: TRW TAS85 STEERING GEAR INTERNAL LEAKAGE TEST. SOME TRW TAS85 STEERING GEARS HAVE BEEN EQUIPPED WITH AN INTERNAL RELIEF VALVE. THESE STEERING GEARS ARE TYPICALLY INSTALLED WITH POWER STEERING PUMPS THAT HAVE A PRESSURE RELIEF RATING GREATER THAN 2175 PSI (150 BAR). THE INTERNAL RELIEF VALVE LIMITS MAXIMUM SUPPLY PRESSURE TO PROTECT THE STEERING GEAR. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, COLUMBIA, CORONADO, BUSINESS CLASS M2 AND CASCADIA. NO MODEL YEARS LISTED. *PE
Associated Products (21)2011 Freightliner Cascadia2011 Freightliner Columbia2011 Freightliner Coronado2010 Freightliner Cascadia2010 Freightliner Columbia2010 Freightliner Coronado2009 Freightliner Cascadia2009 Freightliner Columbia2009 Freightliner Coronado2008 Freightliner Cascadia2008 Freightliner Columbia2008 Freightliner Coronado2007 Freightliner Cascadia2007 Freightliner Columbia2007 Freightliner Coronado2006 Freightliner Cascadia2006 Freightliner Columbia2006 Freightliner Coronado2005 Freightliner Cascadia2005 Freightliner Columbia+ 1 moreAssociated Documents - December 1, 2009•Document ID: 10033168Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:12V/24V/48V BATTERY
- Mfr Comm. #:
- SB-54-242
- Date Added:
- July 21, 2010
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: CASCADIA BATTERY BOX COVER. IN SOME CLIMATES, IT IS HELPFUL TO HAVE THE BATTERIES COVERED TO PREVENT ICE AND SNOW BUILD UP WHEN THE CASCADIA IS EQUIPPED WITH CHASSIS SIDE FAIRINGS. IF DESIRED, A BATTERY BOX INSTALLATION KIT IS AVAILABLE FROM FREIGHTLINER FOR THIS PURPOSE. NO MODEL YEARS LISTED. *PE
Associated Products (7)Associated Documents - October 1, 2009•Document ID: 10031824Service Bulletin/Repair InstructionsSTEERING:LINKAGES:TIE ROD ASSEMBLY; STEERING:RACK AND PINION
- Mfr Comm. #:
- SB-46-47
- Date Added:
- January 13, 2010
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER TRUCK: INNER TIE ROD INSPECTION AND REPAIR, RACK AND PINION GEAR. INCREASED LENGTH OF THE DRIVER SIDE INNER TIE ROD (IF THE INNER TIE ROD UNTHREADS FROM THE RACK) MAY CAUSE ABNORMAL STEER TIRE WEAR DUE TO HIGH TOE IN OR AN INABILITY TO MAINTAIN CORRECT TOE IN ADJUSTMENT. NO MODEL YEARS LISTED. *PE
Associated Products (17)2010 Freightliner Cascadia2010 Freightliner Columbia2009 Freightliner Cascadia2009 Freightliner Columbia2008 Freightliner Cascadia2008 Freightliner Columbia2007 Freightliner Columbia2006 Freightliner Columbia2005 Freightliner Columbia2004 Freightliner Columbia2003 Freightliner Columbia2002 Freightliner Columbia2001 Freightliner Columbia2000 Freightliner Columbia1999 Freightliner Columbia1998 Freightliner Columbia1997 Freightliner ColumbiaAssociated Documents - October 1, 2009•Document ID: 10031804Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:DIESEL
- Mfr Comm. #:
- SB-01-96
- Date Added:
- January 13, 2010
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER TRUCK: VEHICLES EQUIPPED WITH A CUMMINS ISX ENGINE MAY HAVE THE AFTERTREATMENT DEVICE (ATD) PRESSURE SENSOR IN THE SAME CIRCUIT AS THE ACCELERATOR, CAUSING FAULT CODE 1993. AN OVERLAY HARNESS SHOULD BE INSTALLED TO CORRECT THIS PROBLEM. NO MODEL YEARS LISTED. *PE
Associated Products (3)Associated Documents - September 1, 2009•Document ID: 10030460Service Bulletin/Repair InstructionsSUSPENSION:MULTIPLE AXLE
- Mfr Comm. #:
- SB-31-25
- Date Added:
- October 7, 2009
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: AIRLINER SUSPENSION SIX PIECE BOLTED SERVICE CROSSMEMBER. THE SIX PIECE BOLTED SERVICE CROSSMEMBERS ARE AN IMPROVED, MORE DURABLE SERVICE REPLACEMENT FOR FIVE PIECE WELDED CROSSMEMBERS, OR BOLTED FIVE PIECE SERVICE CROSSMEMBERS, USED WITH STEEL FRAME RAILS. NO MODEL YEARS LISTED. *PE UPDATED 1/13/10. *PE
Associated Products (3)Associated Documents - July 1, 2009•Document ID: 10030870Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- SB-60-133
- Date Added:
- December 16, 2009
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: FLEX EXTENDER INSTALLATION ON DELIVERED VEHICLES. TRUCKS FROM ORIGINAL EQUIPMENT MANUFACTURER ARE TRANSPORTED WITH THE RUBBER FLEX EXTENDERS (IF SO EQUIPPED) REMOVED FROM THE TRAILING EDGE OF THE CAB SIDE EXTENDERS. TRANSPORTING THE TRUCK BACKWARDS AT HIGH SPEEDS COULD CAUSE INSTALLED FLEX EXTENDERS TO COME LOOSE AND FALL OFF. NO MODEL YEARS LISTED. *PE
Associated Products (6)Associated Documents - July 1, 2009•Document ID: 10029384Service Bulletin/Repair InstructionsSTRUCTURE:BODY:HOOD
- Mfr Comm. #:
- TSB-88-37
- Date Added:
- July 8, 2009
- Manufacturer:
- FREIGHTLINER
SummaryFREIGHTLINER: HOOD TILT ASSIST STRUT OIL LEAKS CAN BE PREVENTED BY FLIPPING THE STRUT ORIENTATION TO KEEP OIL IN THE CYLINDER, WHICH CONTRIBUTES TO LONG STRUT LIFE. MODEL YEARS UNKNOWN. *PE
Associated Products (5)Associated Documents