Ford Ranger Complaints (2003)

243 consumer complaints on file.

#10182044February 8, 2007
ENGINE AND ENGINE COOLING:ENGINE
TRUCK BUCKS/JERKS DURING DRIVE CYCLE WHEN IN 3RD OR 4TH GEAR, RPM ~2500. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10178400January 11, 2007
AIR BAGS:FRONTAL
I HAVE A 2003 FORD RANGER IN WHICH THE AIR BAG WARNING LIGHT WAS MALFUNCTIONING. AT DIFFERENT TIMES IT WOULD COME ON, STAY ON FOR A LONG TIME, WEEKS, THEN WOULD GO OFF AGAIN. I TOOK IT TO THE DEALER WHO FOUND A SERVICE BULLETIN THAT DIRECTED THEM TO CLEAN WIRES, WRAP WIRES AND RE-ROUTE WIRES UNDER THE SEAT. IT HAD TO DO WITH THE SAFETY BELT RETENTIONER. I DO NOT KNOW IF THIS WAS ACTUALLY A SAFETY ISSUE OR NOT. NO ONE WOULD TELL ME HOW MANY FORD RANGERS HAD THIS PROBLEM, IF THIS WOULD CAUSE ANY FAILURE IN THE SEAT BELT OR THE AIR BAG. EVEN THOUGH I FELT THIS WAS A FAILURE OF THE AIR BAG AND SAFETY BELT SYSTEM WAS CHARGED FOR THIS REPAIR. (I WAS STILL UNDER FORD'S 50000 SAFETY SYSTEM WARRANTY.) I AM CONCERNED ABOUT THE COST, BUT I AM ALSO CONCERNED THAT THE PRETENTIONER WAS NOT REPLACED AND WHETHER THIS WILL OCCUR AGAIN. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10173328November 13, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
DT*: THE CONTACT STATED WHILE APPLYING THE BRAKE PEDAL, A SOUND OF METAL ON METAL WAS HEARD. THE VEHICLE WAS PULLED OVER AND THE CONTACT NOTICED THE PAD SEPARATED FROM THE CALIPER HOLDER ON THE FRONT PASSENGER SIDE. AN INDEPENDENT REPAIR SHOP REPLACED THE PASSENGER FRONT BRAKE PAD. UPDATED 12/12/2006 - *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168695September 19, 2006
ENGINE AND ENGINE COOLING:ENGINE
A FAILED ROLLER ROCKER DESTROYED A CAM AND LIFTER AFTER ONLY 66,000 MILES. 3,000 MILES PREVIOUS I HAD TAKEN IT TO THE DEALER WHO SAID THEY COULDN'T HEAR THE NOISE. BY THE TIME THEY COULD HEAR IT, THE DAMAGE HAD MORE THAN TRIPLED. THE FAILURE WAS DEFINITELY CAUSED BY THE DEFECTIVE ROLLER ROCKER(THE PART IS AVAILABLE FOR INSPECTION). *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168440September 16, 2006
POWER TRAIN:AUTOMATIC TRANSMISSION, STRUCTURE
SEVERE WATER LEAK IN ROOF AND REAR WINDOW EXACT LOCATION NOT DETERMINED YET. OWNER NOTICED WATER DRIPPING ON DRIVERS SEAT. UNDER HEAVY RAIN CONDITIONS THE CAB WILL FILL UP WITH WATER -ALL OVER THE FLOOR, CARPETS, MATS, ETC. WATER HAS CAUSED DAMAGE TO INTERIOR AND UPHOLSTERY. I TOOK THE TRUCK TO FORD''S SERVICE DEPARTMENT AND THEY REFUSED TO LOOK AT THE VEHICLE AS WELL AS REPAIR THE LEAK AND DAMAGE TO INTERIOR. THEY TOLD ME LEAKS ARE COMMON AND THEY WILL DO NOTHING ABOUT IT. SECOND DEFECT: AUTOMATIC TRANSMISSIONS DOES NOT SHIFT CORRECTLY WILL EVEN GET HUNG UP IN A GEAR; CAUSES HEAVY VIBRATION UPON BRAKING. SOME STEERING AND SUSPENSION COMPONENTS HAVE BEEN RECENTLY REPLACED BY OWNERS EXPENSE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10154102July 3, 2006
VEHICLE SPEED CONTROL
CONSUMER REQUESTING INFORMATION ON 2003 RANGER DEFECTS. *TS A FRIEND OF THE CONSUMER'S DOWNLOADED COMPLAINTS THAT WERE SIMILAR TO THE PROBLEMS THE CONSUMER EXPERIENCED WITH HIS VEHICLE. *NM WHILE DRIVING 55 MPH WITH THE CRUISE CONTROL ON THE TRUCK BEGAN TO ACCELERATE. THE VEHICLE SPED UP TO APPROXIMATELY 80 MPH BEFORE THE CONSUMER COULD GET IT TO STOP. THREE MONTHS LATER WHILE STOPPED AT A TRAFFIC LIGHT THE VEHICLE ACCELERATED SUDDENLY AND STRUCK SEVERAL VEHICLES. THIS ACCIDENT CAUSED SERIOUS INJURIES TO FOUR PEOPLE. THE CONSUMER WAS UNABLE TO PROVE THAT THE VEHICLE CAUSED THE ACCIDENT THEREFORE HE WAS SENTENCED TO 70 MONTHS IN JAIL. *NM
Crash:
Yes
Fire:
No
Injuries:
4
Deaths:
0
#10158884June 2, 2006
STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
MY SON-IN-LAW WAS HELPING UNLOAD A BOX FROM THE BED OF MY 2003 FORD RANGER PICKUP AND WAS STANDING ON THE TAILGATE. THE COMBINED TOTAL WEIGHT WAS LESS THAN 200 LBS. WHILE HE WAS STANDING ON THE TAILGATE, BOTH CABLES SECURING THE TAILGATE SNAPPED WITHOUT WARNING, CAUSING HIM TO FALL OFF THE TRUCK TAILGATE. HE WAS NOT INJURED. SOME SCRATCHING OF THE TAILGATE OCCURRED AS IT STRUCK THE BUMPER. I TOOK THE TRUCK TO THE DEALER, BUT SINCE IT IS A FEW MONTHS PAST WARRANTY (ALTHOUGH WITH ONLY 21,000 MILES). THEY WOULD NOT COVER THE CABLE REPLACEMENT. I CALLED THE FORD CONSUMER LINE, AND WAS TOLD THEY WERE NOT INTERESTED IN REPAIRING THE DEFECT EITHER. THERE WAS NO EXISTING DAMAGE TO THE CABLES, AND THE TRUCK IS NOT USED COMMERCIALLY, NOR HAS IT BEEN IN AN ACCIDENT. THE PARTS HAVE NOT YET BEEN REPLACED. THE OLD PARTS ARE AVAILABLE FOR INSPECTION AT ANY TIME. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10149370February 3, 2006
EXTERIOR LIGHTING:FOG LIGHTS
FOG LAMP LENSES ON 2003 FORD RANGER PICK-UP TRUCK KEEP CRACKING. DEALER CLAIMS ROADSIDE DEBRIS IS THE CAUSE. HOWEVER, BOTH LENSES HAVE CRACKED TWICE AT THE SAME TIME. COMPLAINTS HAVE BEEN MADE TWICE TO FORD MOTOR CO. WHICH HAS NO RECALL RECORD FOR THIS TYPE OF INCIDENT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146171December 27, 2005
STEERING:HYDRAULIC POWER ASSIST SYSTEM
DT: THE CONTACT WAS TRAVELING AT 45 MPH WHEN THE VEHICLE HIT A PATCH OF ICE ON THE ROAD. HE LOST CONTROL OF THE VEHICLE AND HIT A DITCH. THE VEHICLE THEN ROLLED AND HIT AN EMBANKMENT. THE VEHICLE T BUSTED IN TO FLAMES. THE OCCUPANTS WERE ABLE TO GET OUT OF THE VEHICLE BEFORE IT EXPLODED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. INJURIES WERE SUSTAINED. THE VEHICLE HAS NOT BEEN INSPECTED AT THIS TIME TO DETERMINE WHAT CAUSED THE VEHICLE TO EXPLODE. THE VEHICLE WAS TOTALED.*AK
Crash:
Yes
Fire:
Yes
Injuries:
2
Deaths:
0
#10143915November 29, 2005
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR, SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
DT: THE CONTACT TOOK VEHICLE TO THE DEALERSHIP TO HAVE THE BRAKE PADS CHANGED. THE MECHANIC DETERMINED THAT THE FRONT BRAKE ROTORS WHERE CORRODED AND PITTED. THE ROTORS HAD TO BE REPLACED. *AK UPDATED 01/04/06. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144242November 15, 2005
VEHICLE SPEED CONTROL
CONSUMER COMPLAINT REGARDING 2003 RANGER SUDDENLY GOING AT FULL SPEED AND CAUSED AN ACCIDENT. *TS THE FIRST TIME THIS OCCURRED THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM, THEREFORE NOTHING WAS FIXED. COMPLAINANT WRITING ON BEHALF OF CONSUMER. *NM
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10138566October 4, 2005
ENGINE AND ENGINE COOLING:ENGINE
DT: THE CONSUMER STATED THAT HIS 2003 FORD RANGER CAUGHT ON FIRE ON 9-30-05. THE VEHICLE STARTED SMOKING WHILE IN MOTION. THE VEHICLE WAS PULLED OVER. THE FIRE WAS VIEWED COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED. THE TRUCK WAS DECLARED A TOTAL LOSS. THE CONSUMER FELT THAT THE FIRE DEPARTMENT WAS UNABLE TO DETERMINE THE CAUSE OF THE FIRE. THE CONSUMER EXPERIENCED NO PRIOR PROBLEMS WITH THE VEHICLE. THE DEALER WAS MADE AWARE OF THE PROBLEM. THE CONSUMER CONTACTED HIS INSURANCE COMPANY. THE TRUCK WAS TOWED TO A JUNK YARD IN ILLINOIS. PICTURES WERE TAKEN OF THE ENGINE AND THE VEHICLE ITSELF. THE CONSUMER PLANNED TO NOTIFY THE MANUFACTURER ABOUT THE FIRE. *AK (11/22/05) A POPPING NOISE WAS COMING FROM THE ENGINE AND IT BEGUN TO LOSE POWER. THE CONSUMER POPPED THE HOOD AND SAW FIRE COMING OUT OF THE ENGINE. BY THE TIME THE FIRE DEPARTMENT ARRIVED, THE ENGINE WAS ENGULFED IN FLAMES. *SC
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10135679September 7, 2005
VEHICLE SPEED CONTROL
THE IDLE CONTROL VALVE FAILED IN OPEN POSITION. THIS CAUSED THE VEHICLE TO IDLE AT 4000 RPM. DRIVING ABILITY WAS SEVERELY IMPAIRED AT THIS HIGH IDLE. SPEED CONTROL WHILE APPLYING THE BRAKE WAS DIFFICULT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10133876August 23, 2005
ENGINE AND ENGINE COOLING:ENGINE
DT: THE CONTACT OWNS A 2003 FORD RANGER. WHILE DRIVING VEHICLE STALLED. THE DEALERSHIP HAD THE VEHICLE 6 TIMES, BUT COULD NOT FIND ANYTHING WRONG WITH IT. THE CONTACT STATED THE VEHICLE STARTED JERKING THEN IT DIED, AND AFTER WAITING APPROXIMATELY 1 HOUR THE VEHICLE STARTED BACK UP. THE DEALERSHIP WANTED TO TRADE THE VEHICLE WITH THE CONTACT. BUT THE MANUFACTURER WANTED THE DEALERSHIP TO FIND THE CAUSE OF THE PROBLEM BEFORE THEY WOULD AUTHORIZE THE TRANSACTION. THE CONSUMER CONTACTED THE MANUFACTURER. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10133387August 18, 2005
VEHICLE SPEED CONTROL:CRUISE CONTROL
CRUISE CONTROL ON MY 2003 FORD RANGER 4X4 APPEARED TO DISENGAGE WHEN I SHIFTED THE TRUCK INTO NEUTRAL GOING DOWN A STEEP HILL. WHEN MY VEHICLE SLOWED, I SHIFTED FROM NEUTRAL BACK INTO DRIVE AND THE ENGINE RACED TO REDLINE(REV LIMITER) AS THE CRUISE WAS TRYING TO IMMEDIATELY INCREASE THE SPEED WITHOUT WAITING FOR THE TRANSMISSION TO ENGAGE FULLY. I SHIFTED BACK INTO NEUTRAL AND THEN I NOTICED THAT I HAD THE CRUISE CONTROL ON. I CUT CRUISE CONTROL OFF, THEN SHIFTED BACK INTO DRIVE AND EVERYTHING WORKED CORRECTLY. IF CRUISE CONTROL IS SUPPOSED TO DISENGAGE WHEN SHIFTED TO NEUTRAL, IT REALLY SHOULD DISENGAGE NOT RACE TO REDLINE WHEN SHIFTED BACK INTO DRIVE. I DON'T KNOW WHAT THE AFFECT WOULD BE IF AN ENGINE AT 6000 RPMS SUDDENLY ENGAGES THE TRANSMISSION AT 65 MPH. I'D RATHER HAVE THE ENGINE RACE WHEN I FIRST PUT THE SHIFTER IN NEUTRAL THAN WHEN I SHIFTED BACK INTO DRIVE! *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130122July 26, 2005
FUEL SYSTEM, OTHER:DELIVERY
I HAVE A 2003 FORD RANGER REGULAR CAB 2 WHEEL DRIVE TRUCK. ON 5 OCCASIONS THE EMERGENCY FUEL SHUTOFF SWITCH LOCATED INSIDE THE CAB ON THE PASSENGER SIDE FIRE WALL HAS BEEN DISLODGE BY THE PASSENGER GETTING THERE FOOT ON THE CONNECTOR AND DISCONNECTING THE POWER PLUG FROM THE SWITCH THIS CAUSES THE TRUCK TO STALL IMMEDIATELY. I HAVE ONLY OWNED THIS TRUCK FOR APPROX 90 DAYS. IF THIS HAPPENS AT THE WRONG TIME THIS COULD GET SOMEONE HURT OR KILLED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10126294July 25, 2005
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
DT: CONSUMER'S VEHICLE WAS INVOLVED IN A COLLISION ON JUNE 9, 2005. . THE AIRBAGS DEPLOYED BEFORE THE IMPACT. THE CONSUMER SAW SOMETHING FLASH IN HER FACE, WHICH WAS THE CENTER OF THE STEERING WHEEL, AND THE AIRBAGS DEPLOYED. THE CONSUMER TOOK THE VEHICLE TO THE DEALER, AND THEY SAID THAT THERE WAS SOMETHING WRONG WITH THE SRS, AND THEY FOUND A FAULTY SENSOR # 450047 IN THE FRONT OF THE VEHICLE. IT HAS BEEN FIXED SINCE THIS ACCIDENT. *AK *JB
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10129801July 23, 2005
TIRES, TIRES:SIDEWALL
IN MAY 2005, I FOUND THAT I HAD A NAIL IN ON OF MY WRANGLER GOODYEAR TIRES AND I TOOK THE TRUCK TO GOODYEAR. WHEN THEY REMOVED THE TIRE THEY FOUND A CRACK NEAR THE BEAD. THE TIRE ONLY HAD 20,000 MILES ON IT. THEY CLAIMED THIS WAS THE FAULT OF FORD MOTOR COMPANY FOR IMPROPER MOUNTING OF TIRE. THEY CLAIMED THIS WAS COMMON. MY TIRE WAS REPLACED IMMEDIATELY WITH AN ADJUSTED FOR WEAR. I CONTACTED GOODYEAR AND FORD AND BOTH BLAMED THIS PROBLEM ON THE OTHER. BOTH COMPANIES SHOULD BE ASHAMED OF THEIR DECEPTIVE PRACTICES. IT IS GOOD THAT I HAD A NAIL IN MY TIRE OR I COULD HAVE BEEN INJURED WITH A BLOWOUT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10128355July 11, 2005
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
I HAVE HAD TO TAKE THIS VEHICLE INTO THE DEALERSHIP FOR BRAKING PROBLEMS 7 TIMES NOW. THERE HAS BEEN A CONSTANT VIBRATION UPON BRAKING. THE VIBRATION HAS BECOME SO BAD AT TIMES, IT IS DIFFICULT TO HOLD THE STEERING WHEEL. THE VIBRATION IS BEING CAUSED BY WARPED ROTORS. THE ROTORS HAVE BEEN TURNED AND REPLACED AT LEAST 2 TIMES EACH. I AM NOW ON MY THIRD SET OF ROTORS. THE LAST TIME I BROUGHT THE TRUCK BACK FROM DEALERSHIP, IT WAS OBVIOUS THE CALIPER WAS STICKING. FORD EVEN HAD AN ENGINEER LOOK AT THE TRUCK. THE ENGINEER LOOKED AT THE TRUCK 100 MILES BEFORE THE CALIPER WAS STICKING. HE COULDN'T COME UP WITH ANY REASON FOR THE WARPAGE. ON TAKING MY TRUCK BACK TO THE DEALERSHIP THIS PAST TIME, THE BRAKE PEDAL STARTED GOING TO THE FLOOR AND WAS MAKING A WHOOSHING SOUND UPON DEPRESSING THE PEDAL. I WAS AFRAID IT WOULDN'T STOP. I AM NOW AFRAID OF DRIVING THIS TRUCK BECAUSE I DON'T KNOW WHAT WILL HAPPEN WITH THE BRAKES NEXT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10127746July 7, 2005
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
ON NUMEROUS OCCASIONS, WHILE STOPPED IN TRAFFIC, THE VEHICLE HAS ACCELERATED OUT OF CONTROL, ALMOST CAUSING AN ACCIDENT. THIS HAS HAPPENED WITH AT LEAST 4 DIFFERENT DRIVERS. HAVE HAD THE TRUCK LOOKED AT BY 2 DIFFERENT DEALERSHIPS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ranger