Ford Ranger Complaints (2002)

346 consumer complaints on file.

#10285937October 1, 2009
ENGINE AND ENGINE COOLING:ENGINE
THE VEHICLES ENGINE SHUTS OFF AS IT IS BEING ACCELERATED, OR AT CRUISING SPEED. THE ENGINE IS THE ONLY SYSTEM AFFECTED BUT CAUSES VEHICLE TO BE UNDRIVABLE FOR AROUND 5-10 SECONDS UNTIL VEHICLE PUTS ITSELF BACK IN GEAR AFTER SHUTTING OFF. THIS OCCURS RANDOMLY SOMETIMES RIGHT AWAY AFTER VEHICLE IS STARTED AND MOVED OR OTHER TIMES AFTER LONGER PERIODS OF DRIVING. IT HAS OCCURRED REPEATEDLY, WHEN THE VEHICLE ENGINE COMES BACK AND IT DOES PUT ITSELF BACK INTO GEAR AND YOU START TO ACCELERATE AGAIN IT WILL CUT OFF. IT HAS CAUSED OPERATOR NOT TO BE ABLE TO ACCELERATE TO MERGE ONTO HIGHWAYS, PULL OUT ONTO ROADS, OR TO MAINTAIN CRUISING SPEEDS IN ROADS OR HIGHWAYS. IT HAS BEEN TAKEN TO FORD DEALERSHIP FOR REPAIRS 3 TIMES. EACH TIME THE ENGINE CONTROL RELAY DIODE HAS BEEN CHANGED AND BLAMED FOR PROBLEM. THE VEHICLE HAS BEEN CONNECTED TO COMPUTER AND DRIVEN(FIRST TIME AT FORD REPAIR SHOP), THE ENGINE HAS CUT OUT CAUSING VEHICLE TO STOP ACCELERATING AND THE COMPUTER SHOWS THAT NOTHING IS HAPPENING. IT CONTINUES TO READ THAT THE VEHICLE IS RUNNING FINE.I HAVE PERSONALLY REPLACED COIL PACK, AND THROTTLE POSITION SENSOR. THE FIRST TIME DIODE WAS REPLACED THE VEHICLE RAN FOR ALMOST 8 MONTHS THEN PROBLEM RECURRED. IT WAS TAKEN TO FORD AND DIODE REPLACED AGAIN, THIS TIME LASTING ONLY 2-3 MONTHS. IT WAS TAKEN TO FORD THE 3RD TIME FOR DIODE TO BE REPLACED, THIS TIME LASTING ONLY 2 WEEKS. I CALLED THE FORD SHOP AND SPOKE TO MANAGER AND WAS TOLD THAT THE ENTIRE WIRING HARNESS WOULD HAVE TO BE REPLACED BECAUSE THEY COULD NOT FIGURE OUT WHY THE ENGINE WAS CUTTING OUT. I WAS ALSO INFORMED THAT THE WIRING HARNESS WAS NOT AVAILABLE FOR THEM TO GET AND THAT THERE WAS NOTHING THEY COULD DO TO FIX MY VEHICLE, SO I WAS TO CONTINUE TO DRIVE IT EVEN THOUGH THE ENGINE SHUTS OFF WHILE DRIVING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10283878September 14, 2009
TIRES
TL*THE CONTACT OWNS A 2002 FORD RANGER WITH TWO FRONT FIRESTONE DESTINATION LE P245/75R16 TIRES. WHILE DRIVING 60 MPH, THE VEHICLE STARTED VIBRATING. THE CONTACT DECREASED THE SPEED EXPECTING THE VIBRATION TO STOP; HOWEVER, WHILE DRIVING 55 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE IMPACT CAUSED THE LEFT FRONT FENDER TO EXTEND OUTWARD APPROXIMATELY ONE INCH. A LOCAL REPAIR FACILITY MECHANIC STATED THAT THE BLOW OUT WAS CAUSED BY ROAD HAZARD MATERIALS. THE CONTACT WAS CONCERNED THAT THE VIBRATION CAUSED THE TIRE BLOW OUT. THE MANUFACTURER STATED THAT THEY INSPECTED THE TIRES AND SINCE THEY WERE UNABLE TO DETERMINE HOW LONG THE TIRES WERE ON THE VEHICLE THEY WERE UNABLE TO REPLACE THEM FREE OF CHARGE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 45,000. UPDATED 10/06/09 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10273550June 11, 2009
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP, ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT WAS INFORMED BY HIS NEIGHBOR THAT HIS VEHICLE WAS SMOKING IN THE DRIVEWAY. THE CONTACT NOTICED BLACK SMOKE COMING FROM THE VEHICLE. THE FIRE DEPARTMENT DISCONNECTED THE BATTERY AND STATED THAT THERE WAS ELECTRICAL FAILURE. THERE WERE NO FLAMES PRESENT, BUT A FIRE REPORT WAS FILED. A CASE WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT THE ANTI-LOCK BRAKING SYSTEM CAUSED THE FAILURE. NO REPAIRS WERE MADE TO THE VEHICLE. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 99,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10266741April 26, 2009
TIRES, TIRES:SIDEWALL
DRIVING ON FREEWAY AT APPROX 65 MPH FELT SEVERE VIBRATION AND MANAGED TO PULL OVER ACROSS THREE LANES TO GORE POINT AT AN ON RAMP FRONT RIGHT TIRE HAD SIDEWALL COMPLETELY SEPARATE FROM TREAD VEHICLE 2002 FORD RANGER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10258367February 11, 2009
TIRES
THE TIRES STARTED TO WEAR IN AN ODD CUPPING SHAPE AFTER CHECKING TIRE PRESSURE CONSTANTLY TO VERIFY THIS WAS NOT THE CAUSE OF THE WEAR. ADDITIONALLY MULTIPLE ALIGNMENTS HAD BEEN PERFORMED TO ALSO VERIFY THIS WAS NOT THE CAUSE OF THE WEAR. AFTER DRIVING FOR WEEKS LATER, THE TIRE FAILED AT 35 MPH IN A BUSY SUBURBAN STATE ROUTE INTERSECTION. AFTER PULLING ASIDE AND REPLACING THE TIRE, I DISCOVERED A DELAMINATION OF THE TREAD. I HAD INSPECTED THE TIRES AND HAD SEEN ANOTHER STARTING TO SHOW SIGNS OF DELAMINATION. I IMMEDIATELY STARTED TO PRICE TIRES. I CONTACTED FIRESTONE ABOUT THE ISSUE AND WAS TOLD THE TIRE IS NOT ON THE RECALL. THREE DAYS LATER, AND THE OTHER TIRE IS CLEARLY DELAMINATED. I FEEL BECAUSE OF THE LOW MILES ON THE TIRES, THE CONSTANT AND PROPER PREVENTABLE MAINTENANCE PERFORMED, THE TIRES SHOULD BE REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10257339February 3, 2009
ENGINE AND ENGINE COOLING
HAVING ISSUES WITH MY TRUCK I THOUGHT MIGHT BE TRANSMISSION NOW THE DEALER SAYS IT IS A CAM SENSOR. THE TRUCK SPUTTERS AND STOPS CAUSING SEVERAL NEAR MISSES THIS HAS BEEN AN ISSUE FOR SEVERAL YEARS BUT THE DEALER WAS NOT BALE TO FIND THE PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10255872January 21, 2009
POWER TRAIN:AUTOMATIC TRANSMISSION
MY FORD 2002 RANGER EDGE PICK UPS AUTOMATIC TRANSMISSION FAILS TO SHIFT GEARS UNDER ACCELERATION SUCH AS TAKING OFF FROM A LIGHT OR MERGING ON INTO TRAFFIC. THE TRANSMISSION WILL SHIFT FROM ONE GEAR THAN NOT GO INTO GEAR LEAVING VEHICLE ON OF GEAR AND WITHOUT FORWARD MOTION. I HAVE HAD PROBLEMS GETTING ACROSS INTERCEPTIONS AND ONTO THE HIGHWAY. HAVE TO REMOVE FOOT FROM ACCELERATOR FOR SEVERAL SECONDS FOR TRANSMISSION TO FIND A GEAR TO SHIFT INTO. FORD MOTOR COMPANY HAS SOME SERVICE BULLETINS REGARDING SHIFTING ISSUES BUT FALL WAY SHORT OF CORRECTING THIS SAFETY ISSUE. THIS HAS AND IS AN ON GOING ISSUE SINCE THE VEHICLE WAS NEW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10250839December 5, 2008
POWER TRAIN:AUTOMATIC TRANSMISSION
I HAVE A 2002 FORD RANGER, SHORTLY AFTER I PURCHASED IT THE AIR BAG LIGHT STARTED FLASHING AND THEN THE O/D LIGHT STARTED FLASHING AND THE TRANSMISSION STARTED SHIFTING REALLY HARD INTO SECOND GEAR. I TOOK IT TO THE DEALERSHIP AND THEY SAID THE TRANSMISSION NEEDED REPLACED AND THE AIRBAG SWITCH WAS BAD.. FROM WHAT I HAVE READ THIS HAS BEEN AN ONGOING PROBLEM WITH THIS TYPE OF TRANSMISSION SINCE IT CAME OUT. IT IS A SEALED TRANSMISSION, IN THAT,THE FLUID CANT BE CHECKED. IT'S VERY POORLY DESIGNED AND FORD DOESN'T WANT TO DO A RECALL EVEN THEY ARE AWARE OF THE PROBLEM.... *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10250354December 1, 2008
POWER TRAIN:DRIVELINE
THE RIGHT REAR AXLE FLANGE SEPARATED FROM THE AXLE, NEARLY CAUSING AN ACCIDENT, STARTING A GREASE FIRE IN THE AXLE HOUSING, AND DAMAGED THE REAR BODY PANEL ON THE RIGHT SIDE. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10248820November 14, 2008
POWER TRAIN:DRIVELINE
AT APPROX. 26,500 MILES VEHICLE MADE POPPING/CLUNK SOUND ACCOMPANIED BY A JERKING MOVEMENT WHEN TURNING. ESPECIALLY SLOW TURNS AFTER MAKING A STOP. SOUND CAME FROM REAR END. 1 OR BOTH REAR TIRES WOULD BIND IN SLOW CORNERS AND SKID. FORD DEALER CONFIRMED BROKEN GEARS IN DIFFERENTIAL. 2002 RANGER EXT. CAB WITH MANUAL TRANS, 4 CYL, 2WD. $1,650 TO REPAIR. FORD WILL NOT ASSIST IN PAYING FOR ANY PART OF THIS. EVIDENTLY FORD IS SATISFIED WITH THEIR BREAD AND BUTTER TRUCKS FAILING SO QUICKLY. THIS IS HOW THEY LOSE A CUSTOMER FOR LIFE, BY NOT STANDING BEHIND THEIR VEHICLES. TOO MANY REPORTS OF THIS FAILURE FOR IT NOT TO BE TAKEN CARE OF BY FORD. VERY ANGRY, FORD, YOUR HUGE LOSSES ARE WELL DESERVED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10241246September 7, 2008
VEHICLE SPEED CONTROL
VEHICLES CRUISE/SPEED CONTROL MALFUNCTIONS DISENGAGES AND ENGAGE ON IT'S OWN. STOPS WORKING WITH OUT NOTICE CAUSES VEHICLE TO DECELERATE RAPIDLY WITHOUT NOTICE. WILL NOT ENGAGE AGAIN AFTER SHUTTING IT OFF FOR LONG PERIODS OF TIME. SOMETIMES VEHICLE IN SPEED CONTROL MODE WILL START SURGING AND THEN CONTROL STOPS WORKING ALL TOGETHER. VEHICLE HAS 49,499 MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10238597August 17, 2008
ENGINE AND ENGINE COOLING
A RATTLE IN THE ENGINE COMPARTMENT OF A 2002 FORD RANGER (64,000 MILES) ATTRIBUTED TO THE TIMING CHAIN. NO DAMAGE YET, BUT I HAVE ASKED AROUND AND FOUND THIS TO BE A WIDESPREAD PROBLEM AND IN SOME CASES, LEADING TO ENGINE FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10233877July 11, 2008
SUSPENSION:FRONT
TL*THE CONTACT OWNS A 2002 FORD RANGER. WHILE DRIVING 65 MPH, THE CONTACT HEARD A RUMBLING SOUND COMING FROM THE FRONT PASSENGER SIDE TIRE. HE EXAMINED THE VEHICLE AND NOTICED THAT THE PASSENGER SIDE FRONT WHEEL BEARING WAS VERY LOOSE. THE CONTACT DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE BEFOREHAND AND THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE VEHICLE HAS BEEN REPAIRED BY THE CONTACT. THE CURRENT AND FAILURE MILEAGES WERE 94,000. UPDATED 08/04/08 *BF THE SEALED FRONT WHEEL BEARING ABS FAILED. UPDATED 08/07/08.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10232063June 23, 2008
STRUCTURE:FRAME AND MEMBERS
MY SON WAS TRAVELING ON A 4 LANE STATE HWY AT ABOUT 65 MPH IN THE OUTSIDE LANE WHEN THE DRIVER'S SIDE BACK TIRE FLEW OFF. HE SAID ALL HE REMEMBERS WAS THAT THE TRUCKS REAR DROPPED ON THAT SIDE, SPINNING THE TRUCK TO FACE THE OPPOSITE DIRECTION, AND CAUSING IT TO ROLLOVER NUMEROUS TIMES UNTIL IT LANDED IN THE DITCH ON THE OPPOSITE SIDE OF THE HWY. NOT TO MENTION IT HAD TO GO UP AND EMBANKMENT TO GET THERE. HE COULD HAVE BEEN KILLED OR SERIOUSLY INJURED. DPS , WRECKER DRIVER, MY HUSBAND AND MY SON COULD NOT FIND THE TIRE, WHICH STILL HAS THE BRAKE DRUM ON IT. UPON INSPECTION IT WAS NOTED THAT LEFT REAR AXLE BROKE BEHIND THE FLANGE WHERE THE LUG NUTS GO. I AM TOLD THIS MUST BE A DEFECT BECAUSE YOU RARELY HEAR THIS HAPPENING. DPS AND WRECKER DRIVER STATED THAT VEHICLE HAD GOOD TIRES AND LOOKED AS THOUGH IT HAD BEEN WELL TAKEN CARE OF. IT IS A 2002 FORD RANGER EDGE. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10230507June 10, 2008
TIRES, TIRES:TREAD/BELT
WHILE TRAVELING FROM WORK ON THE INTERSTATE, I HEARD THE TREAD COME OFF OF MY REAR PASSENGER TIRE. THIS SENT ME INTO THE GUARD RAIL AND PRECEDED TO FLIP MY TRUCK OVER SEVERAL TIMES. THE TIRES SHOULD NO SIGNS OF UNUSUAL WEAR, TEAR OR DEFECT AT THIS POINT. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10228966May 27, 2008
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED. THE MECHANIC REPLACED THE THERMOSTAT UNIT HOWEVER, AFTER THE REPAIR THE VEHICLE CONTINUED TO LEAK COOLANT. UPON FURTHER INSPECTION, THE MECHANIC FOUND A SMALL HOLE IN THE ENGINE BLOCK. IN ADDITION, HE FOUND THAT THE ENGINE BLOCK RUSTED. THE CURRENT AND FAILURE MILEAGES WERE 62,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10228712May 22, 2008
VEHICLE SPEED CONTROL
I HAVE HAD MULTIPLE ISSUES WITH MY VEHICLE SPEED CONTROL SINCE I BOUGHT THE RANGER EDGE PICKUP SINCE 2002. THE DEALERSHIP HAS CHANGED HANDS SINCE IS NOW LANDERS BUT WAS CALLED CRAIN FORD LINCOLN MERCURY. WHAT IS HAPPENING IS THE SPEED CONTROL IS DISENGAGING WHEN ACTIVATED AND NOT ACTIVATING WHEN TURNED ON AND THEN WORKING SOME TIME AFTER IT HAS BEEN DRIVEN A WHILE. I HAVE 105,000 MILES ESTIMATED BUT WHEN ENGAGED I HAVE HAD IT DISENGAGE NUMEROUS TIMES WHILE DRIVING. THIS WAS CHECKED BY FORD DEALERSHIP OVER 7 TIMES SINCE 2002 AND THEY STATED COULD NOT FIND ANY PROBLEMS AT ALL AND STATED EVERYTHING IS OK BUT THE PROBLEMS STILL PERSIST AND IT SEEMS ONCE THE TRUCK GETS WARM IT STARTS WORKING BUT STOPS WORKING AS WELL. EVEN SOMETIMES WHEN THE TRUCK HASN'T BEEN RUNNING VERY LONG THE SPEED SYSTEM WANT ENGAGE AT ALL WHILE DRIVING THE VEHICLE. IT IS VERY SCARY THOUGH WHEN IT DISENGAGES AND YOU ARE AWARE THAT IT IS NOT WORKING WHILE DRIVING ON THE INTERSTATE AND COULD CAUSE SOMEONE TO RUN INTO ME IF I DON'T NOTICE IT DUE TO THE CHANGE OF LOSS OF SPEED. ALSO THERE HAVE BEEN MANY OCCASIONS WHEN TRYING TO ACTIVATE THE SPEED CONTROL AND IT WILL NOT ENGAGE WHILE ON THE INTERSTATE FOR LONG DRIVE TIMES. WHAT CAN BE DONE???? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10226961May 7, 2008
POWER TRAIN:AUTOMATIC TRANSMISSION
TRANSMISSION SHIFT PROBLEMS ON 2002 FORD RANGER. DELAYED SHIFTS; ROUGH SHIFTS; OVERDRIVE LIGHT BLINKS INDICATING TRANSMISSION FAULT; SERVO COVER BLOWN OFF ALLOWING TRANSMISSION FLUID LOSS - INOPERATIVE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10222065March 23, 2008
ENGINE AND ENGINE COOLING:COOLING SYSTEM
A PLASTIC WATER HEATER CONTROL VALVE IN THE VEHICLE COOLING SYSTEM DENATURED AND CRUMBLED, LEAKING COOLANT OUT OF THE VEHICLE WHICH COULD HAVE CAUSED AN ENGINE SEIZURE HAD I NOT BEEN AWARE OF THE SITUATION. THIS IS THE SECOND PLASTIC PART FAILURE (FIRST WAS THE THERMOSTAT/TEMP SENSOR HOUSING) WHICH FAILED AND LEAKED COOLANT DURING THE WARRANTY INTERVAL. COOLING SYSTEMS ARE NO PLACE FOR PLASTIC PARTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10219646February 29, 2008
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
VEHICLE WAS HIT IN DRIVER SIDE IN APRIL 2005. AIRBAG DID NOT DEPLOYED THEN. TOOK TRUCK FOR INSPECTION IN JAN 08 AND WAS REJECTED FOR AIR BAG LIGHT ON. COULD BE AIR BAG MODULE DEFECTED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ranger