Ford Ranger Complaints (2024)

96 consumer complaints on file.

#11653397April 8, 2025
ELECTRICAL SYSTEM, POWER TRAIN
1. The vehicle will sometimes randomly switch between drive modes with no influence from the driver. I believe it could be a faulty drive mode sensor and the vehicle is available to be inspected. 2. Having the vehicle switch drive modes at random could cause an increase in danger while driving. Going from Normal to Baja or other modes while at highway speeds is very concerning, considering it changes from 2-wheel to 4-wheel drive. 3. No. 4. No, the vehicle will be taken to a Ford dealership soon for the current window recall. 5. No prior warnings. The first couple of times, I thought I may have bumped it, but on multiple occasions I have realized it did it by itself with no influence from the operator. 6. For the additional details below: I put in the most recent incident, but it has occurred multiple times over the past year.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652847April 4, 2025
POWER TRAIN
The contact owns a 2024 Ford Ranger. The contact stated that while attempting to leave a parking lot while on an incline, the transmission was shifted into drive(D); however, the vehicle began to slowly reverse. The contact quickly proceeded to depress the brake pedal and shift back to park(P). There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that there was no failure found with the vehicle. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 25V164000 (POWER TRAIN); as a possible cause for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 2,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650060March 24, 2025
UNKNOWN OR OTHER
Approximately 32,000 miles. During that. I've had approximately 10 occasions where I've lost throttle power. It's happened while in turns and inclines. You lose all throttle response for 3 to 5 seconds. Been close to very dangerous a few times because of people behind me when I lost throttle and power. Other issue In both 2024 rangers we own. On curvy roads. The steering wheel starts sticking it will not reset back to center. This is one going into turns to the left and trying to go back to center. You have to use a lot of pressure to get it back to center like it's binding. Again this is happening in both our 2024 rangers starting around 7,000 mi on both. Only one has experienced the loss of power so far. I'm seeing a lot of complaints from other owners of the exact same lost power on forums
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648889March 17, 2025
SERVICE BRAKES
Air vent under steering wheel does not provide proper clearance for brake applications. Foot gets tangled/caught on vent. Had a few close calls during emergency situations. Problem gets worse with thicker sole shoes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648697March 17, 2025
AIR BAGS
There used to be no sufficient clearance between the drivers knee airbag and the brake pedal. I wear steel toe boots for work and my foot just barely fits between the brake pedal and the airbag box. Several times it’s gotten hung up and I had trouble getting to the brake. In a panic situation the could be disastrous. I’ve checked in other model trucks and there is plenty of clearance.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648482March 15, 2025
STEERING, LANE DEPARTURE: ASSIST, ELECTRICAL SYSTEM
I flew down to Anchorage Alaska this brand new 024 FORD RANGER XL on [XXX] sight unseen and no test drive from KENDALL FORD Dealership. After buying the truck I started it, engaged 4 wheel drive and slippery/ icy setting. On the way back to Fairbanks the steering was hard to turn and got progressively harder the faster I drove and the colder it became. About half way home it became exhausting to steer requiring a lot of force to turn the steering wheel that actually resisted with real force being turned. I didn’t know the lane keeping would turn on with the cruise control but it did and resisted me even more. The roads became black ice and it was freezing rain. The phone charge port lost power, the dash blanked out, there was no radio and the rear power port I had switched to lost power and my phone died. I was driving about 30 to 40 mph on the 2 lane undivided snow covered black ice covered highway. In a curve in the road where the highway maintenance snow plows had stopped plowing I believe the truck mistook the snow line for the painted line and unexpectedly and surprisingly actually turned the steering wheel towards the double solid dividing centerline and I turned back into my lane. This slight movement caused the truck to totally slide out of control and cross the double solid dividing centerline and the truck went into opposite highway oncoming lane! Luckily there was no traffic coming the other way or it could have been a horrible accident. I hit the brakes and the truck actually stopped good, and then I got back into my lane and pulled over at the first chance. My phone was dead so I had no flashlight because I flew down I carried nothing but my coat. I tried to inspect the steering but it was all dark and below zero so I continued on towards Fairbanks another hundred miles to the North. The truck also had a bunch of other problems like refusing to start that can leave a person to freeze to death quickly in the Arctic below zero temperatures. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11647966March 12, 2025
STRUCTURE:BODY
[XXX] [XXX] [XXX] [XXX] 3/12/2025 National Highway Traffic Safety Administration 1200 New Jersey Avenue SE Washington, DC 20590 Subject: Complaint Regarding 2024 Ford Ranger Raptor VIN [XXX] Dear NHTSA Team, I am writing to formally report a safety issue with my 2024 Ford Ranger Raptor, VIN [XXX] . After purchasing this vehicle, I encountered a significant problem that I believe poses safety concerns. Recently, I learned that Ford has developed a solution for this issue, as detailed in the following press release: WSAV Press Release. However, Ford is unwilling to cover the necessary repairs under warranty, despite the fact that this solution became available shortly after my purchase. I believe that this situation requires your attention, as it not only impacts my vehicle but may affect other owners of the same model. I urge the NHTSA to investigate this matter to ensure that safety standards are upheld and that consumers are treated fairly. Thank you for your attention to this important issue. I look forward to your response. Link #1: [XXX] #2: [XXX] Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644616February 24, 2025
POWER TRAIN
When stopped or turning from a stop I will lose acceleration for 3-4 seconds at such time I will almost over accelerate when it does catch which I almost will lose control especially in icy weather. I have no codes have taken to dealership for repairs 4 times they can't find any issues. The issues appeared day 1 asked them to look at it they said it was fine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644040February 21, 2025
STRUCTURE:BODY, UNKNOWN OR OTHER
Not sure if this is the correct channel, but here goes my concern. The safety incident has not yet occurred, but the manufacturer has stated it could/may occur if a certain fix is not performed, but are unwilling to issue a recall for said fix, or even produce the parts they say are necessary to implement the fix. I own a 2024 Ford Ranger Raptor that Ford has demonstrated has a design flaw in their bed (for vehicles produced before mid Sept, 2024) in that it cannot carry more than 88 lbs on the bed rails without the potential for failure. I need to install a topper to protect and secure cargo in the bed which will exceed the 88 lb failure number they state. The fix they say must be implemented is to install 2 Ford supplied load box reinforcement brackets (called J-braces), yet I've been trying to order/obtain said braces for almost 5 months now without success. Ford seems to have given up on producing them as they've been "out of stock" since I purchased my vehicle, and Ford has cancelled my order for them twice now, when I try to submit an order. If the bed fails due to weight above 88 lbs put on the rails while driving, depending on what a failure looks like, it could cause collisions with the affected vehicle, or with other traffic in the vicinity. Ford has been completely unresponsive in issuing a recall so far regarding this known design flaw, yet they redesigned the suspect area mid year to fix the issue on vehicles produced after mid-Sept and going forward. Yet they are leaving purchasers of vehicles prior to this time, in a precarious position as they have potential safety concerns that Ford is unwilling to address, or even provide a solution for.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632810December 28, 2024
STRUCTURE:BODY, SUSPENSION
I purchased a new 2024 Ford Ranger yesterday. As I was researching camper shells and truck racks I found that these common items cannot be installed without first installing a load bed reinforcement bracket kit to reinforce the truck bed to the bed side rails. Apparently, nothing can be attached to the side rail which weights more that 88 lbs or the truck bed could separate from the side rails. This is an design/engineering shortcoming from Ford as these are common after market add-ons for mid-sized trucks. Also, Ford is asking customers to pay for the reinforcement bracket and installation - which was quoted today at $1,600, and the Ford part is not currently available from the corporate US Ford website, and has not been available for several months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629933December 10, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I was in an area that had received snow and cold temperatures. I started my car to warm it up and began cleaning off the snow. The heat from the rear defroster caused my read window to shatter leaving glass mostly on the exterior of the truck bed but also in the back seat. This is a known problem with Ford model trucks and they refuse to repair the issue or replace my window.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627625November 26, 2024
SEATS
The rear seats in the 2024/2025 Ford Raptor Ranger are connected to the rear of the cab via a single latch. The single latch does not always latch. I noticed it had failed to properly latch the next day when I was installing my car seats. I figured it was user error, but than I re-tested it and struggled to properly latch it. The danger is the rear portion of the seat could suddenly fold forward during a hard break or accident, resulting in serious injury to rear passengers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621817October 24, 2024
STEERING
Vehicle displays “Steering Assist fault-Service required”. Failure of power steering while driving could result in loss of control of the vehicle. The earliest available appointment for the dealer to check the problem is 11/20/24.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617130September 29, 2024
STRUCTURE:BODY
2024 Ford Ranger Trucks made in Michigan between January 4, 2024 to July 15, 2024 do not include the load box reinforcement bracket. Without this bracket installed, if the owner were to place more than 88lbs onto one or both bed side rails the bed could crack, warp, bend, or break. If operators of this vehicle are not aware and do load the bed side rails over 88lbs, this could pose a safety issue to the driver or other drivers on the road around the vehicle. Ford has not notified all owners of affected vehicles, and in my case I found out my vehicle was affected out of sheer curiosity and reading forums with posts of other owners whose vehicles are also affected. Ford is currently not willing to address the issue without additional cost burden on the vehicle owner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617035September 28, 2024
UNKNOWN OR OTHER
I bought this ford ranger and got it last week and went to put a topper on it and you cant - the box rails only hold 80 pounds . You have to install new brackets Ford nose about this but makers buyer pay for it . please make ford do a recall on this before someone gets hurt . thank you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11615090September 17, 2024
WHEELS
The contact owns a 2024 Ford Ranger. The contact stated while driving 50 MPH, the brake pedal was depressed and the front driver’s side wheel locked up, causing the vehicle to pull to the left. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that there was a part missing from the wheel. The contact was informed that the wheel needed to be replaced. The manufacturer was notified of the failure and a case was opened. The failure mileage was 6,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ranger