Ford Ranger Complaints (2002)

346 consumer complaints on file.

#10042839October 14, 2003
AIR BAGS:FRONTAL
VEHICLE WAS IN A FRONTAL COLLISION WHILE DRIVING AT 30/35 MPH. UPON IMPACT, AIR BAGS DID NOT DEPLOY. DRIVER AND PASSENGER SUSTAINED INJURIES.*AK
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10038368October 12, 2003
ENGINE AND ENGINE COOLING:ENGINE
WHILE DRIVING ENGINE PRODUCES A KNOCKING SOUND.*AK THE CONSUMER STATED THAT THE VEHICLE DOESN'T RUN PROPERLY ON THE 87 OCTANE GAS. THE ENGINE HAD A SPARK-KNOCK CONDITION. THE CONSUMER FEELS THIS TYPE OF PROBLEM IS UNACCEPTABLE FOR A NEW VEHICLE. *PH *NLM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10041570October 9, 2003
WHEELS, TIRES
MY DAUGHTER WAS DRIVING MY 2002 FORD RANGER ON THE FREEWAY. IT WAS RUSH HOUR TRAFFIC, CLEAR SKIES, SUN OUT AND NO RAIN. SHE FELT THE TRUCK VIOLENTLY VEERED TO THE RIGHT, AND THOUGHT THE PASSENGER SIDE FRONT TIRE HAD A BLOWN OUT. BUT THE TRUCK WAS THROWN INTO THE GUARD RAIL, A WITNESS BEHIND HER SAID THE WHEEL FLEW OFF THE TRUCK, THEN IT WENT AIRBORNE AND FLEW BACK TO THE LEFT OVER THREE LANES OF TRAFFIC. FORTUNATELY, MY DAUGHTER HAD ONLY MILD INJURIES AND WAS TRANSPORTED TO THE E.R. VIA AMBULANCE. IN ADDITION, THERE WERE NO OTHER VEHICLES INVOLVED WITH THE TRUCK OR THE FLYING WHEEL. WHEN I SAW THE CAR AT THE WRECKER YARD, I NOTED THE WHOLE WHEEL AND PART OF THE AXLE WERE MISSING. MY DAUGHTER'S BOYFRIEND FOUND THE TIRE ON THE SIDE OF THE ROAD WITH THE AXLE AND PART OF THE BRAKE COMPONENTS STILL ATTACHED. HAS THERE BEEN ANY OTHER REPORTS OF A WHEEL BREAKING OFF OF A FORD RANGER? IN RETROSPECT, THIS TRUCK HAS ONLY 6000 MILES AND THERE HAS BEEN TWO BLOWN OUTS ON THE DRIVER'S SIDE REAR TIRE IN WHICH I HAD TO REPLACE THE TIRE WITHIN THE PAST TWO MONTHS. THE TIRES ARE GOODYEAR. COULD THIS BE RELATED AS WELL OR IS IT A DIFFERENCE PROBLEM? *LA
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10041293October 6, 2003
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
EXHAUST ODOR AFTER ENGINE REACHES NORMAL OPERATING TEMP. THE ODOR IS LIKE ROTTEN EGGS, SULPHUR, PHOSPHORUS. PROBLEM BEGAN WHEN VEHICLE WAS APPROX. 9 MONTHS OLD WITH LESS THAN 10,000 MILES. VEHICLE WAS BOUGHT NEW AND IS A 2002 FORD RANGER WITH 4.0, AUTO, 4X4. VEHICLE NOW HAS 17,405 MILES AND HAS BEEN BACK TO THE DEALER 4 OR 5 TIMES WITHOUT RESOLVE AND IS ABOUT TO GO BACK AGAIN. THE DEALER SAID THEY HAVE DONE EVERYTHING FORD HAS ADVISED THEM TO DO AND THEY DO NOT KNOW WHAT TO TRY NEXT. THE DEALER SAID FORD WILL NOT AUTHORIZE REPLACING THE CATALYTIC CONVERTOR BECAUSE THE PROBLEM WOULD START OVER AGAIN WHEN THE NEW CONVERTOR "BURNS" IN. THE DEALER TOLD ME THE FIRST TIME IT WOULD GO AWAY IN APPROX. 5,000 MILES. THE SMELL REMAINS AND, IF ANYTHING, IS GETTING WORSE. THE FRUSTRATION BEGAN WHEN I TOOK THE TRUCK IN THE FIRST TIME FOR THE EXHAUST ODOR AND A SEVERE JERK WHEN PUTTING THE TRANS. INTO REVERSE. THE SERVICE MANAGER SAID THE "JERK" WAS BECAUSE THE VEHICLE (10,008 MILES) WAS GETTING "BROKE IN" BUT THE SMELL WAS DUE TO THE CONVERTOR JUST "BURNING IN" BECAUSE IT WAS NEW! I'VE HAD 5 RANGERS SINCE 1996 AND PURCHASE 3 OTHER VEHICLES SINCE 1990 AND HAVE NEVER HAD THIS ODOR IN ANY OF THEM. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10042276October 3, 2003
PARKING BRAKE
THE VEHICLE WAS PARKED OVERNIGHT. THE NEXT MORNING THE CONSUMER NOTICED THAT THE VEHICLE HAD ROLLED BACKWARDS AND ACROSS THE STREET. THE CONSUMER CHECKED THE VEHICLE AND NOTICED THAT THE PARKING BRAKE HAD RELEASE WHILE THE GEAR SHIFTER WAS STILL IN THE PARK POSITION. THE VEHICLE WILL BE TAKEN TO THE DEALER TO BE CHECKED. *NLM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10039764October 1, 2003
AIR BAGS:FRONTAL
WHILE DRIVING 40 MPH THE CONSUMER'S VEHICLE REAR ENDED ANOTHER VEHICLE. UPON IMPACT BOTH FRONT AIR BAGS DID NOT DEPLOY. THE CONSUMER CONTACTED THE DEALERSHIP.*AK *NLM *JB
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10037901October 1, 2003
AIR BAGS, VISIBILITY:WINDSHIELD WIPER/WASHER
AIR BAG SENSOR LIGHT REMAINED ON. THE DEALER INSPECTED VEHICLE, BUT COULD NOT SOLVE THE PROBLEM, THE AIR BAG SENSOR LIGHT CONTINUED TO STAY ON. *AK THE DEALER INSTALLED NEW WIPER BLADES. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10040811September 26, 2003
STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
WHILE DRIVING 25 MPH THE FIBER GLASS CAP THAT COVERS THE PICK UP BED FLIPPED UP IN THE FRONT, CAUSING THE HYDRAULIC PISTONS TO BREAK FREE AND FLING INTO THE ROAD. THIS INCIDENT CAUSED THE COVER TO SPLIT STRAIGHT DOWN THE MIDDLE. DEALER AND THE MANUFACTURER HAD BEEN NOTIFIED OF THE PROBLEM. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10041851September 16, 2003
TIRES
PROBLEMS WITH TIRE EQUIPMENT ON 2002 FORD RANGER.*MR TRANSFERRED TO OVSC. *CB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10037432September 8, 2003
POWER TRAIN:AUTOMATIC TRANSMISSION
REPLACEMENT OF TRANSMISSION IN A 2002 FORD EDGE RANGER. THIS TRANSMISSION WENT BAD WITH NO INDICATION OF A PROBLEM UNTIL THE DAY OF FAILURE. THE VEHICLE HAD 51000 MILES ON IT AT THE TIME OF FAILURE AND THE TRUCK WAS MAINTAINED ACCORDING TO MANUFACTURERS SUGGESTED MAINTENANCE. ACCORDING TO THE DEALER WHERE THE REPAIR/ REPLACEMENT WAS MADE, THE TORQUE CONVERTER HAD BEEN SEIZING FOR SOME TIME THROWING SHRAPNEL INTO THE TRANSMISSION AND THE ENTIRE UNIT NEEDED REPLACING.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10037173September 3, 2003
AIR BAGS:FRONTAL
MY SON WAS INVOLVED IN A SINGLE VEHICLE ACCIDENT WHEN HE DROVE INTO A SANDY DITCH WHILE AVOIDING ANOTHER VEHICLE. HE HIT A SAND HILL HEAD ON, AT APPROX 25 MPH. THE RANGER/EDGE WAS TOTALLED, NO ONE WAS INJURED, BUT THE AIR BAGS NEVER DEPOLYED. THE BODY SHOP LOOKED AT THE VEHICLE AND DETERMINED THERE ARE NO AIR BAG SENSORS, OR AIR BAG HARNESSES FOR THE SENDORS LOCATED IN THE FRONT PORTION OF THE TRUCK. THE SHOP CALLED FORD AND REQUESTED A DIAGRAM OF WHERE THE SENSORS AND WIRING SHOULD BE. USING THE FORD DIAGRAM IT IS OBVIOUS THERE WERE NO SENSORS OR WIRING. I AM WONDERING HOW MANY OTHER FORD RANGERS / EDGES ARE OUT THERE WITH NO SENSORS AT THE FRONT BUMPER. CONTACTED KEN GRODY FORD AND TALKED WITH THE SERVICE MANAGER WHO DID NOT APPEAR CONCERNED. HE DIRECTED ME TO THE FORD COMPLAINT DEPARTMENT. *AK
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10033233August 21, 2003
TIRES:TREAD/BELT
2002 FORD RANGER PICKUP TRAVELING ON THE HIGHWAY WHEN THE LEFT REAR TIRE BEGAN TO BOUNCE AND THEN THE TREAD BEAGN TO SEPARATE. DRIVER LOST CONTROL OF THE VEHICLE, RESULTING IN LOSS OF CONTROL THEN OVERTURNING.*AK
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
1
#10032636August 12, 2003
ELECTRICAL SYSTEM
I NEED HELP. I WAS DRIVING FROM MY CHILDS SCHOOL THE OTHER DAY, WHILE ACCELERATING DOWN THE HILL THE CAR SUDDENLY SHUT OFF. I LOST COMPLETE CONTROL OF THE CAR AND IF IT WASNT FOR THE PARKING LOT TO THE RIGHT I WOULD HAVE COME UPON A RED LIGHT MAY HAVE BEEN IN A MAJOR CAR ACCIDENT. ON AUGUST 11, 2003 I WAS DRIVING TO A SCOUT MEETING, WHILE COMING UPON A STOP SIGN I PROCEEDED TO TERN ON MY HEAD LIGHTS AND THE SAME THING BEGAN TO OCCUR. ALL OF THE INSTRUMENTS WENT OFF AND SUDDENLY CAME BACK ON. BUT BECAUSE WE BOUGHT THIS CAR FROM A USED CAR DEALER I DONT KNOW IF IT IS STILL COVERED UNDER WARRANTY. BUT AFTER READING A LOT OF THE HORROR STORIES ON THIS SITE ABOUT PEOPLE HAVING PROBLEMS WITH THERE RANGERS ALSO I AM CONSIDERING GETTING RID OF THE TRUCK. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10031176August 9, 2003
EQUIPMENT, ELECTRICAL SYSTEM:IGNITION
ON 2 OCASSIONS IN JULY 2002; FORD RANGER JUST STOPPED RUNNING...ALL SYSTEMS NON FUNCTIONING; RIGHT IN THE MIDDLE OF THE ROAD, WITH MILEAGE< 15,000. THERE WAS NO TIME TO PULL OFF ROAD AS NO WARNING LIGHTS CAME ON; ALL SYSTEMS SIMPLY FAILED. FIRST TIME IT WAS REPAIRED UNDER WARRANTY, IT HAPPENED AGAIN A WEEK LATER. I MIGHT ADD THEIR ROADSIDE SERVICE COULD NOT BE PROVIDED AS THEY HAD NO ONE AVAILABLE. I SAT FOR 2 HOURS UNTIL POLICE CAME BY & OBTAINED A TOW FOR ME. VICTORY FORD IN STOUGHTON MA. DID FIRST REPAIR & TRUCK WAS NOT RUNNING RIGHT. WHEN I BROUGHT IT BACK THE NEXT DAY; THEY STATED IT WAS ROAD TESTED. HOW CAN THEY ROAD TEST WHEN IN MILEAGE WAS THE SAME AS OUT MILEAGE? SECOND TIME REPAIR WAS DONE AT A DIFFERENT FORD DEALERSHIP, WHICH I HAVE NO PROBLEM WITH EXCEPT IT TOOK OVER A WEEK BEFORE THEY COULD GET TO IT. THE REPAIR WAS COMPLETED AND I WAS TOLD IT WAS THE MAIN COMPUTER CHIP. BUT IN CASE IT HAPPENED AGAIN THEY GAVE ME AN EXTRA CHIP AND SHOWED ME HOW TO INSTALL IT !!! REAL CONFIDENCE BUILDER!! TRUCK CONTINUED TO RUN ROUGH BUT I WAS TOLD THIS WAS TYPICAL OF FORD BY THE MECHANIC. SECOND COMPLAINT...ENGINE LIGHT CAME ON, AND WHEN I WENT TO FORD GARAGE THEY TOLD ME THEY COULDN'T GET TO IT FOR DAYS, BUT THAT IT WAS PROBABLY ALRIGHT TO DRIVE, BUT THAT I SHOULD HAVE IT CHECKED OUT. HOW DO I GET IT CHECKED OUT WHEN NO LOCAL FORD GARAGES COULD DO IT. TOOK MY CHANCES AND WENT ON VACATION. WHEN I ARRIVED AT MY DESTINATION; A MALE RELATIVE CALLED A FORD GARAGE IN N.H. THE PROBLEM..A DPFE SENSOR & IT WAS PROMPTLY REPAIRED. THIS GARAGE IN CONWAY N.H. (MACDONALD MOTORS) TREATED ME THE WAY I FELT ALL CUSTOMERS SHOULD BE TREATED. MUST I GO OUT OF STATE NOW TO GET TRUCK FIXED WHICH IS STILL UNDER WARRENTY AND <18,000 MILES ON IT. THANK YOU FOR HEARING ME OUT & ALLOWING ME TO VENT. I HAVE BEEN A FORD OWNER FOR MANY YEARS & TRADE VEHICLES EVERY 2 YEARS. GUESS IT'S TIME TO SEEK ANOTHER AUTO MAKER.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10031102August 8, 2003
AIR BAGS:ON-OFF SWITCH ASSEMBLY
LABOR DAY 2002 MY 2002 FORD RANGER 2.3 LET ME DOWN. APPROX. 4000 MILE ON IT LEAVING SEQUIM WASHINGTON ON HWY 101 GOING TO PORT ANGELES WASHINGTON, I WAS TRAVELING 55 MILES HOUR. ALL A SUDDEN I SMELT GAS, THEN MY RANGER STARTED TO SPEW OUT LOTS OF BLACK SMOKE. THE MOTOR QUIT AND I PULLED OFF THI HWY. IT WON'T STATR UP. CALLED THE DEALER, THEY WERE JUST CLOSING UP TIME 4:30 PM LABOR DAY I SOPKE TO A SALEMAN, SERVIDE DEPT NOT WORKING, NO ONE TO HELP ME. I TOLD THE SALESMAN I WOULD GO BACK AND TRY TO START IT, IF I GOT IT STSRTID I WOULD TAKE IT HOME. NO HELP THE RANGER WAS INSURED. I WENT BACK, AFTER A FEW TIMES I GOT IT STARTED. BLACK SMOKE WAW COMING OUT OF THE TAIL PIPE. I REVERED THE ENGINE UP AND WAS ABLE TO DRIVE IT HOME IN SECOND AND THIRD GEAR MAINTANING 35 TO 40 MILES AN HOUR. GOPT UP THE NEX MORNING THE RANGER WOULD NOT START TILL I TRIED IT SEVERAL TIMES. IT DID START AND RAN PRETTY GOOG BUT WITH IGNITION TROUBLES. TRAVELING, MOTOR RUNNING 1800 TO 2800 RPM IN 5TH GEAR RANGER FELT LIKE IT WOULD SHIFT UP AND DOUN. TIMING WAS CHANING. SOME TIME ENGINE WOUL SHUT DOWN THEN COME BACK ON. FORD DEALER CAN'T FINED ANY THING WRONG. APPROX 16000 MILES LATER I TOOK RANGER TO A GARAGE. THERE COMPUTER SHOWED THE ENGINE WOUD DROP TWO CLYNDERS NOW AND THEN. SHUT DOWN AND RIGHT BACK ON. TOOK IGNITION PRINT OUT TO FORD DEALER, THEY STILL SAY THERE IS NOTHING WRONG.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10032383August 7, 2003
TIRES:TREAD/BELT
WHILE TRAVELING ABOUT 35MPH WITHOUT PRIOR WARNING THE DRIVER AND PASSENGER SIDE TREAD SEPARATED FROM THE WHEEL. THE TIRE WAS A BRIDGESTONE FIRERSTONE P22570R15. PLEASE FILL IN ADDITIONAL INFORMATION. DEALER WAS MADE AWARE OF THE PROBLEM. *PH
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10032386August 7, 2003
WHEELS, TIRES:TREAD/BELT
THE CONSUMER HAD A BLOW OUT ON THE DRIVER SIDE DUE TO TREAD SEPARATION. THE WHEEL WOULD NOT COME OFF. PLEASE FILL IN ADDITIONAL INFORMATION. DEALER IS AWARE OF THE PROBLEM. *PH
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10024370August 1, 2003
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:SHOES/LININGS, TIRES:TEMPORARY/EMERGENCY SPARE TIRE, UNKNOWN OR OTHER, VEHICLE SPEED CONTROL, TIRES, EQUIPMENT:MECHANICAL:ACCESSORY SCISSOR/SCREW/BOTTLE JACK/LIFT
THE JACK BROKE WHEN THE CONSUMER WAS CHANGING A TIRE. THE SPARE TIRE WAS A DIFFERENT SIZE FROM THE REGULAR TIRES WHICH CAUSED REAR END NOISE. THE BRAKES LOCKED UP WHEN THE CONSUMER ATTEMPTED TO STOP WHICH CAUSED AN ACCIDENT. THE DEALER REPLACED THE BRAKE SHOES. THE REAR DOOR AND SPEAKERS VIBRATED WHEN THE RADIO WAS IN USE. THE DEALER REPOSITIONED THE LOOSE INSULATION. WHEN THE CRUISE CONTROL WAS ACTIVATED THE VEHICLE MADE NOISE AND THE ACCELERATOR PEDAL VIBRATED. THE DEALER REPLACED THE ACCELERATOR CABLE AND PEDAL. WHEN ACCELERATING THE VEHICLE MADE A LOUD NOISE. *AK *CB *NLM
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10031397July 29, 2003
SUSPENSION:FRONT
CONSUMER STATES TIRES ARE WEARING PREMATURELY DUE TO FRONT END SUSPENSION. DEALER NOTIFIED.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10030148July 25, 2003
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
CONSUMER STATES THAT DRIVER'S FRONT SAFETY BELT LATCH PLATE DOES NOT LOCK INTO THE BUCKLE WHEN ATTEMPTING TO SECURE. CONSUMER DOES NOT HAVE THE PROTECTION OF SAFETY BELT WHEN DRIVING.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ranger