Ford F-350 Complaints (2006)

272 consumer complaints on file.

#10427593September 27, 2011
TIRES, TIRES:TREAD/BELT
SET OF COOPER TIRES WE PURCHASED FOR OUR VEHICLE (3) HAVE TREAD SEPERATION. (1) EXPLODED CAUSING VEHICLE DAMAGE IN THE AMOUNT OF $4200. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10427175September 26, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING APPROXIMATELY 65 MPH THE CONTACT SMELLED A STRONG ANTI FREEZE ODOR IN THE VEHICLE. THE VEHICLE OVER HEATED AND STALLED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE EXHAUST GAS RECIRCULATION SYSTEM HAD TO BE REPLACED. AFTER THE VEHICLE WAS REPAIRED THE FAILURE CONTINUED. THE FAILURE OCCURRED THREE TIMES. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10427395September 21, 2011
STEERING, SUSPENSION
CPSC#I1190270A. 2006 FORD F350. CONSUMER STATED THE STEERING WHEEL BEGAN TO OSCILLATE BACK AND FORTH VIOLENTLY WHEN HE HIT A SMALL BUMP IN THE ROAD. I WAS UNABLE TO CONTROL THE STEERING WHEEL UNTIL MY SPEED WAS REDUCED TO BELOW 40 MPH. I LEARNED THIS PROBLEM IS VERY COMMONLY REFERRED TO AS THE "DEATH WOBBLE" AND THE FIX IS $ 875. *LN THE CONSUMER VEERED OFF THE PAVEMENT AND WENT DOWN A GRASSY EMBANKMENT. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425750September 16, 2011
FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2006 FORD F-350 DIESEL. THE CONTACT STATED THAT THE FUEL TANK WAS RUSTING DUE TO A FAULTY COATING ON THE INSIDE OF THE TANK. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 61,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10422936September 1, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT THE VEHICLE WOULD STALL AT ANY TIME WITHOUT WARNING. THE DEALER DIAGNOSED THAT THE FUEL TANK WAS RUSTED FROM THE INSIDE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 21,000 AND THE CURRENT MILEAGE WAS 24,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10419833August 17, 2011
ENGINE AND ENGINE COOLING:ENGINE, ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
I HAD A 05 FORD SUPER DUTY 6.0 LITER DIESEL THAT HAD 3 NEW TURBO'S PUT ON DUE TO SKORING. FORD REPLACED ALL 3. WHEN TURBO'S GO OUT YOU LOOSE POWER. I HAVE A 06 SUPER DUTY THAT HAS 26828 MILES. THE WARRANTY JUST WENT OUT 6/16/11. FORD HAD TO PUT ON ANOTHER TURBO BECAUSE IT WAS SKORED. FORD DID PAY $750 AND I HAD TO PAY $1142. I WAS GOING DOWN HIGHWAY AND LOST POWER AND HAD TO LIMP HOME PULLING A 5TH WHEEL CAMPER. I HAVE READ WHERE FORD HAS HAD A LOT OF PROBLEMS WITH THE 6.0 LITER DIESEL ENGINE. I AM UPSET THAT FORD THAT FORD DID NOT COVER THIS PROBLEM FULLY BECAUSE OF ALL PROBLEMS THEY HAVE HAD WITH THE ENGINE. THE PROPERTY DAMAGE BELOW WAS JUST TO THE TURBO ITSELF. I AM WONDERING IF YOU AS AN AGENCY HAVE HAD OTHER COMPLAINTS LIKE THIS AND TO SEE IF THEIR ARE ANY RECALLS OR ARE GOING TO BE ANY RECALLS ON THIS PROBLEM. THE ENGINE ONLY HAD 26828 MILES ON IT AND I DO NOT DRIVE IT EVERY DAY BECAUSE I HAVE A DEPARTMENT VEHICLE. TO DRIVE TO WORK BECAUSE I AM ON CALL 24/7. I VOICED MY CONCERN TO FORD AND NOW I AM VOICING MY CONCERN TO THIS AGENCY. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10419336August 14, 2011
SUSPENSION:FRONT
THIS HAS HAPPENED SEVERAL TIMES WHEN THE TRUCK IS TRAVELING ALONG A ROAD OR HIGHWAY. YOUR DRIVE TURNS INTO A DEATH WOBBLE. THE TRUCK IS UNCONTROLLABLE AND JUMPS LANES AND IS ALL OVER THE ROAD. THIS IS A DANGER THAT HAS BEEN PRESENTED TO FORD BY MANY AND IT IS JUST BEING IGNORED. THIS IS A TRUE DANGER AND MAY NOT ONLY KILL THE DRIVER AND PASSENGERS BUT ANYONE DRIVING DOWN THE ROAD. IT'S ALL OVER THE INTERNET AND HAPPENING ALL OVER THE COUNTRY. THIS IS BEING SWEPT UNDER THE CARPET, JUST AS THE PINTO WAS, WITH MANY DEATHS. YOU AS THE SAFETY BOARD NEED TO STEP UP AND DO SOMETHING SO CONSUMERS CAN DRIVE THE VEHICLES THAT THEY HAVE PURCHASED, FOR MANY OVER $55,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10412372July 14, 2011
STEERING, SUSPENSION
2006 FORD F350 EXPERIENCE EXTREMELY VIOLENT SHAKING WHEN DRIVING 45 PLUS MPH AND HIT ANY TYPE BUMP. SHAKING IS SO VIOLENT STEERING IS NOT CAPABLE AND BRAKING ONLY MAKES SHAKING WORSE. I'VE CONTACTED DEALER AND THEY SAID THEY REPLACED A BUSHING BUT PROBLEM PERSISTED. THEY HAVE NOT CORRECTED THE PROBLEM. VEHICLE IS BASICALLY OUT OF CONTROL WHEN THIS HAPPENS. LAST DATE OF OCCURRENCE IS JULY 14,2011 AND THIS PROBLEM HAS PERSISTED SINCE TRUCK WAS PURCHASED NEW FROM DEALER. TRUCK HAS NO LIFT AND IS STOCK MODEL. PLEASE HELP! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10408608June 23, 2011
FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2006 FORD F350. THE CONTACT STATED THAT THE VEHICLE SUDDENLY LOST POWER AND WOULD NOT ACCELERATE OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE FUEL TANK LINER, CAUSING THE FILTER AND FUEL LINES TO BECOME CLOGGED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 38,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10406018June 12, 2011
FUEL SYSTEM, DIESEL
THE CONTACT OWNS A 2006 FORD F-350 DIESEL. THE VEHICLE AT IDLE OR DRIVING DOWN THE ROAD WILL WITHOUT NOTICE BEGIN TO BUCK, AND SUDDENLY INCREASE RPM'S AND ACCELERATE,OR WILL STALL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPLACED THE ERG VALVE. THAT CORRECTED IT FOR ABOUT 30 DAYS AND THEN IT STARTED IT AGAIN. I TOOK IT BACK AND THEY TOLD ME I WOULD HAVE TO REPLACE THE MANIFOLD NEXT, BECAUSE THE CARBON THAT HAD BUILT UP IN THE MANIFOLD. AFTER A LENGTHY DISCUSSION THEY ADMITTED THAT THIS IS A SERIOUS PROBLEM WITH THIS ENGINE. THE FORD ENGINEERS TOLD THEM THAT THIS ENGINE WAS DESIGNED BY INTERNATIONAL FOR THE EUROPEAN MARKET AND THEIR DIESEL FUEL IS MORE REFINED THAN OURS, STATING THAT IS WHAT IS CAUSING THE PROBLEM. FORD REFUSES TO STAND BEHIND THE PROBLEM. JUST LOOK AT THE INTERNET ABOUT THE 6.0 DIESEL ENGINE AND THERE IS PAGE AFTER PAGE STATING THE SAME PROBLEMS. AT THIS POINT I HAVE NOT CORRECTED THE PROBLEM, I AM STILL TRYING TO DECIDE HOW I SHALL PROCEED. THE VEHICLE HAS 96,000 MILES. I HAVE ONLY USED EXXON OR SHELL FUEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10402808May 26, 2011
STEERING
TL*THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH THE VEHICLE BEGAN TO SHAKE VIOLENTLY ON THE FRONT END. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 134,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10402237May 20, 2011
FUEL SYSTEM, DIESEL
2006 FORD F-350 SUPER DUTY DIESEL DUMP TRUCK. THIS TRUCK HAS BEEN TO CROWLEY FORD IN PLAINVILLE CT. OVER 50 TIMES , YES THAT'S RIGHT I SAID 50. THE TRUCK HAS BEEN TOWED IN NO LESS THAN 6 TIMES IN 4 YEARS. MANY TIMES LEAVING A CREW OF 5 STRANDED ON THE SIDE OF A HIGHWAY. FORD TECHNICIANS HAVE NOT BEEN ABLE TO DETERMINE WHAT IS WRONG WITH THE VEHICLE. TRUCK WILL SUDDENLY LOOSE POWER OR JUST SHUT OFF. FORD HAS DENIED THAT THERE IS ANYTHING WRONG WITH THIS PARTICULAR TRUCK AND MOTOR BUT THERE ARE MANY CONTRACTORS IN OUR AREA THAT ARE HAVING THE SAME PROBLEM. RECENTLY THE TRUCK SAT AT CROWLEY FORD FROM MARCH 1 THROUGH THE END OF MARCH, THEIR TECH'S NOR FORDS TECH'S COULD FIGURE OUT WHAT WAS WRONG WITH IT. THEY ARE STILL DENYING THAT THE GAS TANK DELAMINATION HAS ANY BEARING ON THE SITUATION. COMPLETELY DISGUSTED WITH FORD AND THEIR LACK OF ATTENTION. I ASSUME ITS GOING TO TAKE A FATALITY OR TWO BEFORE THE PRESS PICKS UP ON THIS STORY AND FINALLY HOLDS FORD ACCOUNTABLE. IN THE MEAN TIME SMALL CONTRACTORS AND TRUCK OWNERS ARE TAKING IT IN THE WALLET BECAUSE FORD WILL NOT ACKNOWLEDGE THIS PROBLEM. PLEASE HELP US OUT HERE!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10401393May 18, 2011
VEHICLE SPEED CONTROL, ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2006 FORD F-350 SD. THE CONTACT STATED WHILE THE VEHICLE WAS IDLE WITH PRESSURE APPLIED TO THE BRAKE PEDAL THE IT LUNGED FORWARD WITH A SUDDEN INCREASE IN THE RPMS. IN ADDITION, AN UNEXPECTED ACCELERATION OCCURRED WHEN THE VEHICLE WAS IN MOTION. THE FAILURE OCCURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS FOR THE SIMILAR FAILURES. THE TECHNICIAN STATED THE FAILURE WAS CONTRIBUTED TO THE DIESEL FUEL CONSUMED IN THE VEHICLE. THEY ALSO RECOMMENDED THE MANIFOLD AND ERG VALVE BE REPLACED. AFTER THE ERG VALVE WAS REPLACED THE FAILURE CONTINUED TO OCCUR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ACCELERATION DEFECT. THERE WERE NO ADDITIONAL REPAIRS PERFORMED ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 96,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10403449May 12, 2011
FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING
TRAILER BREAK CONTROLLER FAULTY, REPLACE EGR AND INJECTORS. 3/31/09~ REPLACE EGR COOLER, GASKET, FUEL FILTERS. 6/8/10~ ICP SENSOR & CONNECTOR FAULTY, CAC HOSE LEAKING, INJECTORS FAULTY, EGR VALVES CHANGED. 6/25/10~ 17 DAYS LATER BACK AGAIN IN SHOP FOR SAME ISSUE. TRUCK RUNS THEN WHEN YOU STOP THE TRUCK IN HOT WEATHER, IT WILL NOT RESTART FOR ABOUT 1 HOUR. TRUCK NEEDS TO COOL DOWN BEFORE RESTARTING. AND NO ONE CAN FIGURE OUT WHAT PROBLEM IS AND FIX IT CORRECTLY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10399315May 6, 2011
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2006 FORD F-350 SUPERDUTY. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START WHEN HE ATTEMPTED TO TURN IT ON. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE THE CONTACT WAS TOLD THAT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. HE TOOK THE VEHICLE TO ANOTHER REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE SENSOR COULD BE THE CAUSE OF FAILURE. THE VEHICLE ALSO STALLED WHILE HE WAS DRIVING APPROXIMATELY 65 MPH. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO STATED THAT A HIGH PRESSURE OIL LEAK, A DEFECTIVE SENSOR, AND DEFECTIVE O-RINGS WERE THE CAUSE; THE VEHICLE WAS REPAIRED. THE FAILURE OCCURRED AGAIN. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY WOULD LOOK INTO THE PROBLEM. THE CURRENT MILEAGE WAS APPROXIMATELY 92,000. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10396672April 18, 2011
FUEL SYSTEM, DIESEL
WE OWN A FORD F-350 DIESEL PICKUP. IT IS A 2006, PURCHASED NEW. IT HAS HAD REPEATED POWER FAILURE IN THE LAST TWO AND HALF YEARS, WITH OTHER SIMILAR PROBLEMS BEFORE THAT. MOST RECENTLY WE HAD IT TOWED TO OUR DEALERSHIP TO THE TUNE OF $2500.00 REPAIR FOR FUEL INJECTORS AND FUEL INJECTOR MODULES. THE PROBLEM, IS SAFETY FOR OUR LIVES AND POSSIBLY OTHERS IN OUR PATH. THE VEHICLE HAS RECURRING ENGINE FAILURE CAUSING IT TO DIE WHILE DRIVING. THIS HAS HAPPENED NOT ONLY AT A STOP LIGHT, BUT THROUGH INTERSECTIONS, AND ON STRAIGHT ROADS. WE MOST RECENTLY HAD IT DIE TWICE WHILE PULLING 2 HORSES IN A TRAILER. QUICKLY SHIFTING INTO NEUTRAL TO RESTART TO AVOID AN ACCIDENT. IT HAD TO BE TOWED TO OUR HOME JUST LAST THURSDAY APRIL 14TH DUE TO NOT RESTARTING. TODAY, APRIL 18TH, WE TOOK THIS TRUCK TO OUR LOCAL FORD DEALERSHIP AS WAS RECOMMENDED BY FORD MOTOR CO. APPARENTLY THERE IS AN ISSUE WITH THESE TRUCKS HAVING ENGINE/POWER FAILURE AND OTHER THINGS ASSOCIATED WITH THE INTERNATIONAL PARTS THAT WERE USED FOR THIS YEAR TRUCK. WE ARE RETIRED, TRYING TO RUN A BUSINESS WHICH DEPENDS ON THIS PICKUP. WE ARE FEARFUL OF THIS HAPPENING WHILE DRIVING ON A HIGHWAY, THROUGH AN INTERSECTIONS, OR COMING TO A STOP AND LOSING POSER. OUR LIVES ARE AT STACK AND THOSE AROUND US. OUR WARRANTY IS UP ON THE TRUCK. THE LAST TIME IS WAS JUST OUT OF WARRANTY ONE MONTH. NO ONE FROM FORD EVER MENTIONED RENEWING OUR WARRANTY AT ANY TIME EITHER. WE WOULD LIKE TO SEE THIS ADDRESSED AS THERE ARE THOUSANDS OUT THERE HAVING SIMILAR ISSUES. IT IS NOT JUST A "LEMON", IT IS AN ERROR MADE THAT SHOULD BE RECALLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10394247April 4, 2011
STEERING, SUSPENSION
FORD F350 DEATH SHAKE HAS HAPPENED MULTIPLE TIMES TRUCK HITS BUMP OR POT HOLE REGARDLESS OF SPEED (BUT SHAKE IS WORSE OVER 40 MPH)AND STARTS A VERY DANGEROUS SHAKE THAT GETS WORSE UNTIL THE WHOLE TRUCK IS OUT OF CONTROL. BRAKING HARD TO STOP WILL STOP IT BUT ACCIDENT SEEMS TO BE AROUND THE CORNER. I HAVE TAKEN TO DEALER AND TIRE SHOP THEY SAY NOTHING WRONG. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10379945February 2, 2011
STEERING
TL*THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT THE STEERING WHEEL SHOOK WHILE DRIVING AT ANY SPEED. THE SHAKING WOULD WORSEN WHEN DRIVING OVER BUMPS AND AROUND TURNS. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 103,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10380530February 1, 2011
SUSPENSION
THIS IS A COMPANY VEHICLE DRIVEN BY SEVERAL DIFFERENT EMPLOYEES. MANY OF THESE DRIVERS HAVE COMPLAINED OF A SUDDEN VIOLENT SHAKING OF THE VEHICLE WHILE AT HIGHWAY SPEEDS, USUALLY AFTER HITTING A BUMP IN THE ROAD, EXPANSION JOINT, ETC. THIS SHAKING WILL ONLY STOP BY LOWERING SPEED SOMETIMES TO AS LOW AS 10 MPH. WE HAVE TAKEN THE VEHICLE TO A LOCAL FORD DEALERSHIP MULTIPLE TIMES WITH NO SUCCESS IN SOLVING THE PROBLEM. THEY EVEN ADVISED US TO INSTALL AIRBAGS TO THE REAR SUSPENSION TO DISTRIBUTE WEIGHT TO THE FRONT OF THE VEHICLE WHEN LOADED. WE ARE CURRENTLY ON OUR FOURTH SET OF QUALITY E-RATED TIRES (RECOMMENDED TIRE PRESSURE IS MAINTAINED) BUT ARE STILL EXPERIENCING THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10379301January 27, 2011
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2006 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, HE NOTICED SMOKE BEING EMITTED FROM THE TAILPIPE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE HEAD GASKET HAD BLOWN AND THE GASKET, EGR, AND OIL COOLANT NEEDED TO BE REPLACED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 69,338.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-350