Ford F-350 Complaints (2006)

272 consumer complaints on file.

#10778806September 30, 2015
TIRES, TIRES:SIDEWALL
PURCHASED TIRES ON 2/27/2013 . TIRES HAVE 27,441 MILES ON THEM. THEY WERE ORIGINALLY WARRENTED FOR 40 MONTHS OR 50,000 MILES. ALL 4 TIRES HAVE SIDEWALL CRACKING CLOSE TO THE WHEEL RIM. DOT #'S ARE UTOT HWB 4212,UTOT HWB 5012, UTOT HWB 5012, UTOT HWB 5012
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10761713September 4, 2015
SERVICE BRAKES
TL* THE CONTACT OWNS A 2006 FORD F-350 SD. WHILE DRIVING 5 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO STOP THE VEHICLE. THE CONTACT WAS ABLE TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE CONTACT STATED THAT THE BOLTS THAT ATTACHED THE BRAKE BOOSTER AND THE BRAKE MASTER CYLINDER FRACTURED, RESULTING IN TOTAL BRAKE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,738.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10762617September 3, 2015
FUEL SYSTEM, DIESEL
THIS VEHICLES ISSUES BEGAN WITH THE GALVANIZING OF THE INTERIOR OF THE FUEL TANK FLAKING OFF AND GETTING INTO THE FUEL SYSTEM. IT IS A DIESEL. IT HAS BEEN TO THE SHOP TO HAVE THE FUEL TANK REPLACED, INJECTORS REPLACED, HIGH PRESSURE FUEL PUMP REPLACED TO NAME A FEW. ALL AFTER THE FUEL TANK PROBLEM. SINCE THEN THE VEHICLE HAS SHUT DOWN A NUMBER OF TIMES WHILE ON THE HIGHWAY. THIS IS EXTREMELY HAZARDOUS TO LOSE ALL POWER. FORTUNATELY OUR DRIVERS HAVE BEEN ABLE TO MANEUVER IT OFF THE HIGHWAY BEFORE CAUSING AN ACCIDENT. FORD HAS DENIED HAVING A PROBLEM WITH THEIR FUEL TANKS; HOWEVER, WHEN WE CHECKED AROUND WE FOUND IT TO BE QUITE COMMON. IN FACT WE HAD A DIFFICULT TIME SECURING A NEW TANK BECAUSE THERE WERE SO MANY REPLACEMENTS BEING DONE. I BELIEVE FORD SHOULD STEP FORWARD AND ADMIT THERE IS AN ISSUE AND DEAL WITH IT. WE DISCUSSED THIS WITH A ZONE MANAGER AND GOT NOWHERE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10749381August 18, 2015
SERVICE BRAKES
TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING APPROXIMATELY 70 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. THE CONTACT WAS ABLE TO AVOID A CRASH. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR DRIVER AND PASSENGER SIDE BRAKE CALIPERS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT MENTIONED THAT THE REAR BRAKES WERE PREVIOUSLY REPLACED 10,000 MILES PRIOR TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000. MA 10/22/2015 THE CONSUMER STATED HE EXPERIENCED COMPLETE BRAKE FAILURE ALONG WITH THE LOSS OF BRAKE FLUID. ALSO, THE BRAKES BECAME DISABLED ON THE TRAILER, THE CONSUMER WAS TOWING. UPDATED 12/09/15.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10736219July 24, 2015
TIRES:SIDEWALL, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2006 FORD F-350 SD EQUIPPED WITH MICHELIN LTX M/S2 TIRES, SIZE: LT275/70R18 (NA). WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE BEGAN TO VIBRATE VIOLENTLY. THE CONTACT WAS ABLE TO MANEUVER THE VEHICLE TO THE EMERGENCY LANE. THE CONTACT DISCOVERED THAT THE SIDEWALL AND THE STEEL BELT OF THE FRONT DRIVER SIDE TIRE SEPARATED. THE TIRES WERE NOT INSPECTED OR REPLACED. THE TIRES WERE REPLACEMENT EQUIPMENT. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 55,000 AND THE TIRE FAILURE MILEAGE WAS 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10732051July 6, 2015
STEERING
THE DEATH WOBBLE THAT YOU SAY HAD ONLY 76 COMPLANTS IS [XXX] ! OVER THE LAST 3 YEARS IT HAS HAPPENED OVER 18 TIMES WITH NEW CORRECT SIZE TIRES @ CORRECT PRESSURE ! I HAVE HAD TO MAKE RAPID LANE CHANGES SLAMMING ON THE BRAKES TO GET TO THE SIDE OF THE ROAD SO IT WILL STOP ! IF YOU THINK THIS IS NOT A PROBLEM MAYBE YOU SHOULD GO TO WORK FOR FORD ,ON SECOND THOUGHT ITS APPARENT YOU ALREADY DO ! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10730174June 24, 2015
POWER TRAIN, SUSPENSION
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE INDEPENDENTLY SWAYED SIDE TO SIDE WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE DRIVE SHAFT, CASE SHIFTER, TRANSMISSION, LIFT PUMP, TRANSFER CASE, LEFT CALIBER, FUEL LINE AND REAR SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 131,000. MA 08/13/15 UPDATED 09/01/2015*LJ UPDATED 10/14/2015*JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10714112May 1, 2015
AIR BAGS
I WAS DRIVING ON NORTHBOUND FM 920 BETWEEN PEASTER AND POOLVILLE, TEXAS IN THE RAIN. BECAUSE OF THE RAIN, I WAS NOT DRIVING THE SPEED LIMIT OF 60 MPH, ONLY DRIVING APPROXIMATELY 50 MPH. THERE WERE TWO VEHICLES APPROACHING ME SOUTHBOUND ON FM 920. ONE OF THEM WAS PASSING A VEHICLE AND WAS DRIVING HEAD ON TO ME WHILE PASSING THE OTHER VEHICLE IN THE RAIN. I DID NOT WANT HER TO HIT ME SO I SWERVED TO MISS HER AND ENDED UP IN A DITCH AND HIT A TREE HEAD ON. THE AIRBAGS DID NOT DEPLOY. MY PICKUP WAS TOTALED. BOTH OF THE OTHER VEHICLES LEFT THE SCENE OF THE ACCIDENT. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10706022April 16, 2015
SERVICE BRAKES
THE VEHICLE SHOOK AT 65 MPH AND SHIMMIED WHEN THE BRAKES WERE APPLIED. WE FIRST HAD TIRE ROTATED AND BALANCED AND A FRONT END ALIGNMENT WITH THE REPLACEMENT OF RIGHT SIDE BALL JOINTS. IT DID NOT CORRECT THE PROBLEM. WHEN WE RETURNED THE VEHICLE TO THE DEALER FOR FURTHER REPAIR, THE DEALER TOOK US BACK TO LOOK AT THE REAR BRAKES. THE BACKING PLATES HAD FAILED DUE TO RUST AND THE PINS FOR THE PARKING BRAKE SHOES HAD PULLED THROUGH. THE DEALER REPLACED BOTH ROTORS, BOTH BRAKE SHOES, THE BACKING PLATES AND THE PADS FOR THE DISK BRAKES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10703474April 3, 2015
STEERING, ENGINE, FUEL/PROPULSION SYSTEM
PURCHASED THIS VEHICLE LESS THAN A YEAR AGO AND WAS ORIGINALLY VERY PLEASED. SUDDENLY WE ARE NOW EXPERIENCING THE DEATH WOBBLE AS OTHER HAVE DESCRIBED. THE VIOLENT SHAKING OF THE FRONT END. THIS USUALLY OCCURS WHEN YOU ARE APPROACHING THE SPEED OF 60MPH. WE DO NOT HAVE TO HIT A BUMP FOR IT TO HAPPEN. THE OTHER COMPLAINT, IS THAT WE BOUGHT THIS TRUCK WITH VERY LOW MILEAGE FOR THE YEAR, RAN GREAT, LOOKED GREAT, VERY PLEASED UNTIL THIS LAST MONTH WHEN THE CHECK ENGINE LIGHT CAME ON AND IT SEEMS TO SPUTTER. PUT SOME HIGH QUALITY FUEL INJECTOR CLEANER IN THE TRUCK, THINKING IT MAY BE A INJECTOR STICKING. NOPE, DIDN'T FIX THE PROBLEM. LIGHT NEVER WENT OFF. TOOK IT TO A DEALERSHIP, THEY TESTED IT AND CAME BACK WITH YOUR FUEL TANK IS DETERIORATING PUTTING LITTLE METAL SHARDS IN YOUR ENGINE. YOU ARE LOOKING AT A POTENTIAL FULL ENGINE REBUILD COSTING A MINIMUM OF $6000. THIS IS UNACCEPTABLE FOR ANY VEHICLE MANUFACTURER TO NOT RECALL A VEHICLE THAT HAS A SERIOUS KNOWN PROBLEM. WE ARE STUCK WITH THIS TRUCK THAT IS NOT WORTH THE [XXX] PAPER THE TITLE IS WRITTEN ON. IT IS TIRING OF READING ALL THESE SIMILAR COMPLAINTS AND NO ONE IS DEFENDING THE CONSUMERS. AT WHAT POINT, DOES THE MANUFACTURER NEED TO BE HELD RESPONSIBLE TO OWN UP TO THE FAULTY EQUIPMENT AND FIX THE PROBLEMS? WHEN MY CHILD IS KILLED BECAUSE OF THE INABILITY TO CONTROL THE VEHICLE DUE TO THE STEERING PROBLEMS IN THE FRONT END OR THAT IT STOPS RUNNING IN THE MIDDLE OF THE HIGHWAY OR DOWNTOWN TRAFFIC BECAUSE THE FUEL TANK DETERIORATED FOR NO REASON AND DESTROYED THE ENGINE. *TR INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10690881February 26, 2015
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT STATED THAT EXHAUST FUMES WERE EMITTING FROM THE EXHAUST MANIFOLD IN FRONT OF THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THERE WERE EXHAUST FUMES IN THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10652785November 5, 2014
AIR BAGS
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT CRASHED INTO A DEER AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,018. THE VIN WAS UNAVAILABLE.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10651475October 30, 2014
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THE ENGINE OVERHEATED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE EGR COOLER WAS FAULTY AND NEEDED TO BE REPLACED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE FAILURE WAS REPAIRED BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. PAM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10651012October 29, 2014
STEERING
STEERING WOBBLE AND SHAKES. THIS HAS BEEN GETTING WORSE AS TIME GOES ON. ANYTIME I HIT A BUMP ON THE FREEWAY MY TRUCK STARTS TO VIOLENTLY SHAKE AND WOBBLE. IT IS EVEN WORSE ON A ROAD CURVE. IT IS VERY DANGEROUS TO DRIVING ON THE FREEWAY IN THE MOUNTAINS. I FEW TIMES I ALMOST LOST CONTROL. THE SHAKE DOES NOT GO AWAY UNTIL I SLOW DOWN BELOW 40MPH WHICH CAUSES ANOTHER DANGEROUS SITUATION WHILE ON THE FREEWAY. I HAVE CHANGED TIRES, CHECKED PRESSURE AND ROTATED TIRES. ALSO, I REPLACED STEERING DAMPENER. NOTHING HAS WORKED TO DIMINISH THE SHAKE. I ALSO HAD THE 4 WHEEL ALIGNMENT CHECKED AND THE SHOP SHOWED ME THAT IT WAS CORRECT. THEY CHECKED EVERYTHING AND COULD NOT FIND ANYTHING THAT WAS WORN OUT AND NEEDED CHANGING. I WAS TOLD NO REPAIRS NEEDED. THIS IS A VERY DANGEROUS SITUATION AND NEEDS TO BE CORRECTED BEFORE BODIES START PILING UP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10649413October 23, 2014
ENGINE
2003-2006 FORD F350 DIESEL WITH 6.0 HAVE A CHAIN OF ISSUES, BUT THEY REFUSE TO FIX IT. THE OIL COOLER FAILS, THEN THE EGR SYSTEM FAILS, FINALLY HEAD GASKETS FAIL. AND TO FIX IT, THE CAB HAS T COME OFF AND IT COSTS THOUSANDS OF DOLLARS TO FIX. FORD FIX YOUR ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10649276October 22, 2014
WHEELS
WHILE PARKED, A CRACK IN THE CIRCUMFERENCE OF THE DRIVERS SIDE ALUMINUM WHEEL WAS NOTICED. THE CRACK EXTENDS FROM SPOKE TO SPOKE ON THE 20" FACTORY FORD RIM. AFTER SOME RESEARCH ON THE INTERNET, I AM NOT THO ONLY ONE EXPERIENCING THIS SITUATION. IN MOST CASES SUCH AS MINE THE RIMS ARE CRACKING IN THE SAME PLACE AND IN MOST CASES THERE WAS NO DAMAGE NOTED TO THE WHEEL FROM POTHOLES OR IMPACTS, THE RIM IS DEFECTIVE AND CRACKING. I HAVE CONTACTED FORD AND THERE IS NO RECALL AT THIS POINT AND THE TRUCK IS NOT UNDER WARRANTY. HOWEVER THIS APPEARS TO BIG A HUGE SAFETY ISSUE, AS IF THE WHEEL WOULD CONTINUE TO CRACK, IT WOULD NOT HOLD AIR AN THE TIRE COULD GO FLAT IMMEDIATELY. I WOULD LIKE TO SEND A PICTURE OF THIS TO SHOW THE ISSUE. THERE ARE SEVERAL PICTURES ON THE INTERNET OF THE SAME WHEEL (5 SPOKE 20" ALUMINUM WHEEL 2006 F-350 TRUCKS). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10649047October 21, 2014
ENGINE, FUEL/PROPULSION SYSTEM
2006 FORD F-350 6.0 DIESEL CAB AND CHASIS -- EGR VALVE 1ST TIME FIXED BY FORD DEALER NO COST, EGR VALVE 2ND TIME FIXED AT COST, EGR VALVE 3RD TIME BY-PASSED, 16 FUEL INJECTORS REPLACED. DELAMINATING GAS TANK, OVER A DOZEN FUEL FILTERS AT $60,00 A POP, NEW FUEL PUMP, NEW GAS TANK, 8 MORE NEW FUEL INJECTORS. POSSIBLE TURBO ISSUES AND I MAY BE FORGETTING SOMETHING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10633288September 15, 2014
TIRES
TOYO OPEN COUNTRY XTREME A/T II LT285/75R/17E BOTH INSIDE DUALS SIDEWALL BUBBLES. IT HAS BEEN REPORTED TO THE TIRE DEALER AND TOYO TIRES USA. TIRES PURCHASED IN MAY 2013. TIRES HAVE 5,130 MILES ON THEM. DOT SERIAL # M431013 SAME FOR BOTH TIRES. THE TRUCK HAS A TRUCK CAMPER MOUNTED IN THE PICK UP BED. TIRES WERE MAINTAINED AT 75 PSI ON ALL 7 TIRES. TRUCK HAS A 12 PACK REAR LEAF SPRING SYSTEM INSTEAD OF THE OEM 5 PACK AND 1 OVERLOAD SPRING THAT FORD CALLED IT'S CAMPER PACKAGE. I HAVE PHOTOS OF THE TIRES IF NEEDED. THANK YOU *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610472July 14, 2014
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS, SERVICE BRAKES, STEERING
TL* THE CONTACT OWNS A 2006 FORD F-350 SD. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE DECELERATED AND FAILED TO RESPOND WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. IN SOME INSTANCES, THE VEHICLE STALLED AND THE POWER STEERING AND BRAKES MALFUNCTIONED. THE DEALER STATED THAT THE FUEL INJECTORS WERE FAULTY. THE FUEL INJECTORS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 102,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10588902May 16, 2014
POWER TRAIN, ENGINE
THIS YEAR ALONG WITH OTHER YEARS HAVE A PROBLEM WITH THE EGR VALVE AND TURBO. I UNDERSTAND THAT THERE WAS A DEAL WHERE FORD HAD TO REPAIR EMERGENCY VEHICLES WITH THIS SAME PROBLEM BUT NOT A NORMAL EVERYDAY CONSUMER. THERE ARE MANY COMPLAINTS REGARDING THIS ENGINE BLOWING HEAD GASKETS AND EGR VALVE ISSUES WHICH MAKES THE TRUCK SUDDENLY HAVE LOSE OF POWER WHEN DRIVING ALONG WITH OTHER ISSUES AS SMOKING AND ENGINE LIGHTS GOING ON. AS YOU CAN READ ON LINE EVERYONE THAT HAS HAD THIS PROBLEM IS REALLY FRUSTRATED AND FORD WILL NOT STAND BEHIND THIS ENGINE. THE DIESEL TRUCK SHOULD NOT HAVE THIS PROBLEM AT 79000 MILES. THIS IS WHY WE HAVE PURCHASED THIS VEHICLE. I WOULD THINK A DECISION HAD BEEN MADE TO PUT THIS ENGINE IN TRUCKS KNOWING THAT THERE WAS AN ISSUE WOULD STAND BEHIND IT. I GUESS NOT ENOUGH PEOPLE HAVE BEEN KILLED YET OR SERIOUSLY HURT. JUST BECAUSE FORD WILL NOT BE REIMBURSED FOR THE REPAIRS THEY WILL NOT STAND BEHIND THIS PROBLEM AFTER THE WARRANTY RUNS OUT. WHICH IT HAS WITH US. I FEEL THAT SOMETHING SHOULD BE DONE. WE HAVE PULLED A 15,000 LBS BOAT BEHIND THIS TRUCK AND IT COULD SUDDENLY LOST POWER AND COULD HAVE KILLED SOMEONE. HAS MY HUSBAND WAS DRIVING IT ON A BUSY HIGHWAY IT SUDDENLY LOST POWER AND STARTING SMOKING. SOMEONE COULD HAVE BEEN SERIOUSLY HURT BUT I GUESS BECAUSE NO ONE WAS AND NO ONE HAS BEEN KILLED BECAUSE OF THIS PROBLEM NO ONE WILL PAY TO REPAIR. IT IS SAD THAT OUR TAX DOLLARS HELP DIG THIS CAR MAKERS OUT OF DEBT BUT THEY WON'T STAND BEHIND THEIR WORKMANSHIP. WHY DOESN'T THE SAFETY BOARD MAKE FORD REPAIR THIS ISSUE. MANY PEOPLE ARE REALLY FRUSTRATED AND WOULD LIKE FORD TO REPAIR. IT IS NOT THE CONSUMERS FAULT THERE WAS A BAD ENGINE. 2006 IS NOT THE ONLY YEAR. THIS IS A LARGE SAFETY ISSUE WHEN YOU ARE DRIVING AND SUDDENLY LOSE POWER ON YOUR VEHICLE AT LEAST I WOULD THINK SO. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-350