Ford F-350 Complaints (2005)

331 consumer complaints on file.

#10172309October 31, 2006
ENGINE AND ENGINE COOLING
DT*: THE CONTACT STATED THE VEHICLE'S ENGINE REVVED UP WHEN STARTING UP, AND WHEN PUT INTO FIRST GEAR, THE ENGINE JERKED PROFUSELY. THE VEHICLE WAS TAKEN TO THE DEALER WHO UPON EXAMINATION COULD NOT DUPLICATE THE PROBLEM. THE MANUFACTURER WAS CONTACTED, AND DETERMINED THAT THERE WAS NO RECALL ON THIS ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10171293October 18, 2006
ENGINE AND ENGINE COOLING:ENGINE
I PARKED MY 05 FORD F-350 IN MY DRIVEWAY. CAME BACK 5 MINUTES LATER AND IT WAS ENGULFED IN FLAMES. *NM
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10167558September 7, 2006
ENGINE AND ENGINE COOLING
DT*: THE CONTACT STATED THE VEHICLE DID NOT START AFTER IT WAS SHUT OFF WHILE FILLING THE GAS TANK, AND ALSO WOULD NOT START AFTER STALLING ON THE ROAD. NO WARNING LIGHTS ILLUMINATED PRIOR TO THE INCIDENT. THE VEHICLE WAS PREVIOUSLY TAKEN TO 2 DIFFERENT SERVICE DEALERS, WHERE THE DEALERS WERE UNABLE TO DETERMINE THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10167019August 30, 2006
SERVICE BRAKES, ELECTRIC
I WAS BACKING LOADED TRAILER DOWN INCLINE TOWARD POND; "TOW COMMAND" TRAILER BRAKE CONTROLLER DID NOT WORK PROPERLY AND THE 2005 F-350 SUPER DUTY TRUCK, WITH WHEELS LOCKED, WAS DRAGGED BACKWARD TOWARD THE EDGE OF THE POND BY WEIGHT OF THE TRAILER AND ITS LOAD; TRAILER AND TRUCK STOPPED BEFORE REACHING EDGE OF POND. THIS HAS OCCURRED AT OTHER TIMES, INDICATING THAT BRAKE CONTROLLER DOES NOT PROVIDE ADEQUATE BRAKING IN REVERSE AT LOW SPEEDS. THE PROBLEM WAS REPORTED TO THE SELLING DEALER, WHO SAID THEIR CHECKS INDICATE THE CONTROLLER IS WORKING ACCORDING TO FORD SPECIFICATIONS AT THE DATE OF MANUFACTURER IN SEPTEMBER, 2004, THOUGH A NEW VERSION OF THE CONTROLLER APPARENTLY HAS BEEN INSTALLED ON LATER MODELS, BEGINNING AROUND MARCH OF 2006. THE DEALER AND FORD CUSTOMER SERVICE REPRESENTATIVES HAVE THUS FAR REFUSED TO REPLACE THE CONTROLLER WITH THE UPDATED VERSION AND MAINTAIN THERE IS NOT ADEQUATE PROOF THAT THE CONTROLLER DOES NOT WORK PROPERLY. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10163704July 20, 2006
TRAILER HITCHES
2005 F-350 TRAILER BECAME UNATTACHED STRIKING THE GUARDRAIL. *TS THE TRAILER TRAVELED OFF THE LEFT SIDE OF THE ROAD AND STRUCK A MEDIAN WALL. THE CONSUMER BELIEVES THE PIN CAME OUT OF THE TRAILER HITCH. THE SAFETY CHAINS WERE ATTACHED BUT ALSO BROKEN OFF. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162459July 15, 2006
ELECTRICAL SYSTEM:WIRING, ENGINE AND ENGINE COOLING:ENGINE:DIESEL
JULY 1, 2006 AT APPROXIMATELY 10:30 AM, I WAS TRAVELING ON I-81 AT 65 MPH TOWING A 9,000 LB. TRAILER AND THE TRUCK STALLED WITHOUT WARNING. NO CHECK ENGINE LIGHT AND NO HESITATION. IT SIMPLY DIED. WITHOUT POWER BRAKES OR STEERING, THE TRUCK WAS COMPLETELY UNCONTROLLABLE. LUCKILY, WE WERE ON A SECTION OF HIGHWAY WITH WIDE SHOULDERS AND LIGHT TRAFFIC. THE TRUCK DIED SO SUDDENLY THAT I COULDN'T EVEN PULL TO THE SHOULDER. THE TRUCK CAME TO A COMPLETE STOP IN THE LEFT LANE AND WOULD NOT RESTART. DRIVERS BEHIND ME SWERVED TO THE SHOULD TO AVOID A COLLISION. THE DEALER DID NOT FIND A PROBLEM AND DID NOTHING TO PREVENT THIS SITUATION FROM OCCURRING AGAIN. AFTER THE TRUCK SAT AT THE DEALER FOR 2 DAYS (OVER THE WEEKEND), IT STARTED FOR THE TECHNICIAN ON THE FOLLOWING MONDAY. THE DEALER INFORMED ME THAT NHTSA #05V270000 DOES NOT APPLY TO MY TRUCK, ALTHOUGH THIS CAMPAIGN NUMBER DESCRIBES THE EXACT SITUATION THAT OCCURRED WITH MY TRUCK. THE TRUCK AND TRAILER COMBINED WEIGH APPROXIMATELY 19,000 LBS. 19,000 LBS TRAVELING AT 65 MPH AND SUDDENLY LOOSING BRAKES AND STEERING IS A DEATH WAITING TO HAPPEN. PLEASE HELP BEFORE AN INNOCENT MOTORIST(S) GET KILLED BY THIS TRUCK. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162639July 10, 2006
STEERING, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM, ENGINE AND ENGINE COOLING:ENGINE:DIESEL, ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER, ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
2005 FORD F350 CREWCAB VIBRATION WHILE PULLING A LOAD, TURBO UNIT HAS BEEN REPLACED TWICE, DASH CLUSTER ONCE, EXHAUST LEAK. *KB ***NAR*** THE TEMPERATURE GAUGE WAS ACTING ERRATIC. THERE WAS A STEERING NOISE WHEN MAKING TURNS. THE CONSUMER WAS TOLD THE VIBRATION THAT HE WAS EXPERIENCING WAS BEING INVESTIGATED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161380July 4, 2006
SUSPENSION:REAR:SPRINGS, SUSPENSION:REAR
REAR AXLE SUSPENSION FAILURE ON 2005 FORD F-350 SUPER DUTY TRUCK CAUSING A CRASH WITH PROPERTY DAMAGE. *JB
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10159300June 8, 2006
ENGINE AND ENGINE COOLING, SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP, SUSPENSION
DT*: THE CONTACT STATED THE ENGINE STALLED SUDDENLY WITHOUT WARNING A TOTAL OF FOUR TIMES. THE VEHICLE WAS TOWED ON EACH INCIDENT. THE DEALERSHIP REPLACED A MODULE ON THE WIRING HARNESS AND VARIOUS OTHER UNKNOWN PARTS, BUT THE PROBLEM STILL PERSISTS. ON ONE OCCASION WHILE ATTEMPTING TO DEPRESS THE BRAKE, THE PEDAL WOULD NOT DEPRESS. AFTER PLACING THE VEHICLE IN NEUTRAL, THE BRAKES WORKED PROPERLY. TWO MONTHS AGO THE SHOCK ON THE PASSENGER SIDE FRACTURED. A WELDING SHOP DETERMINED THE PROBLEM WAS A BAD WELD JOINT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10158759June 1, 2006
STRUCTURE:BODY:TAILGATE
THE VEHICLE IN QUESTION, A FORD F-350 PICK UP, IS NORMALLY USED TO PULL A GOOSENECK TRAILER. TO CONNECT THE TRAILER, THE TAIL GATE OF THE TRUCK MUST BE OPENED, THE TRUCK BACKED UP PART WAY, THE TAIL ATE THEN CLOSED, AND THE TRAILER CONNECTED. THE TAIL GATE IS NOT OPENED AGAIN UNTIL THE TRAILER IS BEING DISCONNECTED. I FOLLOWED THIS PROCEDURE, HAULED THE TRAILER ABOUT 40 MILES ON INTERSTATE HIGHWAY TO ITS DESTINATION AND UNLOADED THE TRAILER. I THEN WAS PROCEEDING TO PARK THE TRAILER BEFORE UNLOADING THE BED OF THE TRUCK. DURING A LOW SPEED U TURN OVER SLIGHTLY ROUGH GROUND, THE TAIL GATE OF THE FORD F-350 (WHICH WAS STILL TOWING THE GOOSE NECK TRAILER) POPPED OPEN AND FELL AGAINST THE TRAILER. BEFORE I COULD GET THE VEHICLE STOPPED, THE TAIL GATE WAS BENT BY THE TRAILER. DAMAGE TO THE TAILGATE AND TRUCK IS COSTING $1750 TO REPAIR. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10158562May 30, 2006
FUEL SYSTEM, DIESEL
DT*: THE CONTACT STATED WHILE TRAVELING AT VARIOUS SPEEDS, THE VEHICLE LOSSES POWER. THE VEHICLE WAS TOWED TO THE DEALERSHIP AND THE INJECTOR WAS REPLACED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10158110May 23, 2006
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
DT*: THE CONTACT STATED WHILE DRIVING ON THE INTERSTATE AT 65 MPH AND PULLING A TRAILER THE VEHICLE STALLED AND WOULD NOT RESTART. THE VEHICLE WAS MANEUVERED OFF THE INTERSTATE WITHOUT INCIDENT. THE VEHICLE WAS TOWED TO THE DEALERSHIP, WHO DETERMINED THE HIGH PRESSURE OIL PUMP FAILED AND WAS REPLACED. SINCE THE REPLACEMENT OF THE HIGH PRESSURE OIL PUMP THERE HAVE BEEN NO ADDITIONAL PROBLEMS. UPDATEDN 06/09/2006. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10157735May 17, 2006
SERVICE BRAKES, ELECTRIC
TRAILER BRAKE CONTROLLER ONLY ALLOWS MINIMAL ELECTRIC CURRENT TO TRAILER UNDER 15 MPH. I AM TOLD, DOT KNOWS OF THIS PROBLEM IN FORD F 350 TRUCKS MFRD. PRIOR TO 03/05. COVERED BY FORD BULLETIN. FORD REFUSES TO UPDATE OR REPAIR. NOT ENOUGH BRAKES UNDER 15 MPH TO STOP TRAILER OR TO TEST FOR TRAILER BRAKES. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10157750May 17, 2006
FUEL SYSTEM, DIESEL
VEHICLE HAD JUST RETURNED HOME AFTER BEING DRIVEN A CONSIDERABLE DISTANCE. VEHICLE SHUT OFF FOR A FEW MINUTES WHEN FIRE STARTED UNDER THE HOOD AND MOVED INTO CAB. INSURANCE COMPANY HIRED A FIRE ORIGIN AND CAUSE ANALYST AND IT WAS DETERMINED THAT FIRE WAS CAUSED WHEN FUEL LEAKED FROM THE BANJO FITTING ON THE FUEL FILTER ONTO THE HOT SURFACE OF THE ENGINE. THE BANJO FITTING ON THE LOWER PORTION OF THE FUEL FILTER WAS COVERED WITH A HEAVY LAYER OF FUEL VARNISH. THE BOLT IN THE BANJO FITTING WAS CHECKED AND FOUND TO BE EXTREMELY LOOSE. THIS OCCURRED ON 6.0L DIESEL ENGINE. THERE LOOKS TO HAVE BEEN SIMILAR PROBLEM ON GASOLINE ENGINES WHICH HAD A RECALL DATE OF 6/7/05 AND NHTSA ID NUMBER OF 05V266000. WOULD LIKE TO KNOW IF FORD HAS SEEN PROBLEM ON DIESEL ENGINES?*JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10155420April 16, 2006
STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
MAKING A LEFT HAND TURN THE STEERING FAILED CAUSING THE TRUCK TO RUN INTO A POLE. THE TRUCK IS BEING REPAIRED USING A MUCH STRONGER STEERING BOX BY MY FORD DEALER. THIS IS BEING PAID FOR BY MY INSURANCE CO. EVEN THOW THE TRUCK HAS ONLY 26000 MILES ON IT AND IS UNDER FACTORY WARRENTY. I WILL GET THE UNDERSIZE BROKEN STEERING BOX. THE TRUCK HAS THE ORIGINAL SUSPENSION,WHEELS,AND TIRES IT CAME WITH. THANKS FORD. *NM
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10154404April 3, 2006
SUSPENSION:FRONT
DT*: THE CONTACT STATED WHILE THE VEHICLE HITS A BUMP, TRAVELING AT LEAST 65 MPH, THE FRONT END VIBRATES. THE DEALERSHIP DETERMINED THIS WAS NORMAL OPERATING CONDITIONS DUE TO THE SIZE OF THE VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10153741March 26, 2006
FUEL SYSTEM, DIESEL
THE FAILURE OF DIESEL FUEL INJECTORS IN THE '05 FORD F-350 SUPER DUTY TRUCKS WITH THE POWER STROKE 6.0L DIESEL ENGINE. VEHICLE HAD APPROX. 14,800 MILES ON IT AT THE TIME OF THE INCIDENT. DID NOT LEAD TO AN ACCIDENT, I FEEL THAT IT COULD IN ANOTHER CASE. THERE WERE NO WARNINGS THAT THIS WAS GOING TO HAPPEN AND OCCURRED SUDDENLY WITHOUT WARNING. I WAS DRIVING INTO TOWN(ABOUT 17 MILES). ON THE INTERSTATE HIGHWAY TRAVELING AT APPROXIMATELY 75 MPH. MY VEHICLE LOST MOST OF IT'S POWER AND BEGAN TO JERK AND SPUTTER AS I PULLED TO THE SIDE OF THE ROAD. SHUT VEHICLE OFF, DID A BASIC CHECK OF THE VEHICLES COMPONENTS AND THEN RESTARTED . STARTED AND RAN FINE. I BEGAN TO MERGE INTO TRAFFIC ONLY TO LOOSE SIGNIFICANT POWER AND WAS FORCED TO RETURN TO THE SIDE OF THE ROAD. I WAS SERIOUSLY SLOWING THE ONCOMING TRAFFIC. I BEGAN TO LIMP MY TRUCK TO THE NEAREST EXIT RAMP. EXITED THE INTERSTATE, MY TRUCK DIED AND LEFT ME STRANDED, NOT ABLE TO RESTART. VEHICLE TOWED TO THE DEALERSHIP FOR REPAIR. AT THE REPAIR SHOP, THE #1 CYLINDER INJECTOR WAS DETERMINED TO HAVE FAILED AND WAS REPLACED WITH A NEW OR REBUILT PART. (THIS IS NOT SPECIFIED BY FORD.) I DID/DO NOT HAVE ACCESS TO THE FAILED PART(S). APPROX. 3 WEEKS AFTER THIS INCIDENT, MY TRUCK EXPERIENCED THE SAME FAILURE (AN INJECTOR ON CYLINDER #7) WITH SIMILAR RESULTS. FORD IS WELL AWARE OF THIS PROBLEM AND CONSIDERS IT AN "ACCEPTABLE" DESIGN FLAW AND PUTS THE BLAME ON POOR FUEL (ALL OTHER DIESEL ENGINES WILL RUN ON FUEL STATION GRADE FUEL, WHICH IS ONLY TO BE EXPECTED.). I KNOW THAT MANY OTHERS HAVE EXPERIENCED THIS PROBLEM IN THE 2003 TO THE 2006 POWERSTROKE 6.0L ENGINES. IT IS A VERY COMMON PROBLEM. IN THE CASE OF TWO INJECTORS FAILING AT ONCE, THE VEHICLE WOULD BE INOPERABLE WITH FAILED BRAKING, STEERING AND POWER LOSS. IF ONE INJECTOR FAILS, THE VEHICLE COULD HAVE ERRATIC POWER SURGES AND PARTIAL OR FULL LOSS OF POWER WITH FAILED OR REDUCED BRAKING AND STEERING. AT HIGHWAY SPEED, AND WITH NO WARNING THIS COULD SPELL DISASTER. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10152229March 8, 2006
EQUIPMENT
DT*: THE CONTACT STATED THE VEHICLE DID NOT COME EQUIPPED WITH A SPARE TIRE, JACK AND LUG WRENCH. THE CONTACT FEELS THIS IS A SAFETY ISSUE, IF THE VEHICLE HAS A BLOW OUT WHILE DRIVING THERE WOULD BE NO SPARE TO USE. THE MANUFACTURER WAS ALERTED AND STATED IT IS STANDARD FOR THIS EQUIPMENT NOT TO BE PROVIDED ON THE VEHICLE WHEN SOLD. UPDATED 4/6/2006 - *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10150234February 14, 2006
TIRES
DT*: THE CONTACT STATED WHILE DRIVING ON THE HIGHWAY AT VARIOUS SPEEDS IN SNOW, THE VEHICLE SLIDES SIDE TO SIDE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. UPON INSPECTION, THE DEALERSHIP COULD NO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS NOTIFIED HOWEVER, NO REPAIRS HAVE BEEN MADE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148398January 23, 2006
TIRES
DT*: THE CONTACT STATED WHILE DRIVING ON THE HIGHWAY AT 40 MPH IN SNOW, THE VEHICLE SLIDES SIDE TO SIDE WHEN 4-WHEEL DRIVE IS IN USE. THE TIRES SEEM TO BE THE WRONG SIZE FOR THE VEHICLE. THE VEHICLE IS REGULARLY SERVICED AT THE DEALERSHIP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-350