Ford F-350 Complaints (2005)

331 consumer complaints on file.

#10231103June 16, 2008
STEERING, SUSPENSION:FRONT
FORD F350 STEERING SHAKES TO THE POINT OF LOOSING CONTROL AT ABOUT 60 MPH ON ROUGH UNEVEN FREEWAY OR HITTING POT HOLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10227684May 13, 2008
SUSPENSION:FRONT, STEERING
I HAVE A 2005 FORD F350 SUPER DUTY, WITH DANGEROUS FRONT END PROBLEMS. WHEN GOING AT HIGHWAY SPEEDS (55-70MPH), AND HITTING A BUMP IN THE ROAD(EVEN WORSE WHILE GOING THROUGH A SLIGHT CURVE) THE FRONT END STARTS TO SHAKE VIOLENTLY. THIS OSCILLATION IS SO STRONG, THAT IT ALMOST YANKS THE STEERING WHEEL OUT OF MY HANDS. THE ONLY THING THAT MAKES IT STOP IS TO SLOW DOWN TO ABOUT 20MPH. VERY DANGEROUS TO DO ON THE INTERSTATE!!! AFTER DOING SOME RESEARCH AND READING SOME OF THE ONLINE FORUMS FOR FORD TRUCK OWNERS, I FIND THAT THIS IS A MAJOR PROBLEM AND ALSO A VERY COMMON ONE TO BOOT. THE MOST WORRISOME PART OF THIS PROBLEM, IS THAT IS VERY UNPREDICTABLE. SOMETIMES I CAN GO A MONTH OR SO WITH NO PROBLEMS. HOWEVER, THIS PAST WEEKEND, IT DID THIS THREE TIMES DURING A 10 MILE TRIP HOME FROM A RESTAURANT. THIS IS A MAJOR PROBLEM THAT FORD MOTOR CO. SHOULD BE RESPONSIBLE FOR CORRECTING. IF SOMETHING IS NOT DONE SOON MANY PEOPLE COULD GET HURT, AND GOD FORBID, BE KILLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225370April 22, 2008
FUEL SYSTEM, DIESEL
WHILE DRIVING ON THE HIGHWAY PULLING A TRAILER MY 2005 F -350 DIESEL QUIT RUNNING AND ALMOST GOT RUN OVER BY A SEMI. AFTER PULLING OFF TO THE SIDE OF THE ROAD AND RESTARTED THE TRUCK IT RAN ROUGH. WAS ABLE TO GET IT BACK TO THE SHOP WITH THE HAZARDS ON. TO FIND OUT FROM THE DEALER THAT THE FUEL TANK IS DELAMINATING WHICH CAUSE DEBRIS TO GET INTO THE FUEL PUMP AND INJECTORS CAUSING IT TO STALL. FORD HAS KNOW ABOUT THIS PROBLEM AND THEY CHANGE THERE FUEL TANK DESIGN BUT DID NOT INFORM ANY OWNERS OF THIS SAFETY DEFECT THAT COULD HAVE KILLED ME. NOW I AM ALSO LOOKING AT A $3000. REPAIR BILL THAT FORD WILL NOT BACK ME ON. TO REPLACE THE FUEL TANK WITH A NEW SAFE ONE. I AM ALSO LOOKING AT MY OTHER TWO TRUCKS AND WONDER IF THEY ARE SAFE TO DRIVE. I HOPE THAT NO ONE WILL GET KILLED DUE TO THIS LACK OF PUBLIC INFORMATION BY FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225387April 22, 2008
STEERING
WHILE DRIVING AT HIGHWAY SPEED (65-70 MPH) I HIT A POTHOLE OR BUMP THE WHOLE FRONT END OF THE TRUCK (2005 FORD F-350) STARTED TO SHAKE VIOLENTLY. I HAD TO SLOW DOWN TO 50 MPH WHERE THE SHAKING STOPPED. I WAS ALMOST REAR ENDED BY A SEMI BECAUSE OF MY SUDDEN DECELERATION. THIS HAS HAPPENED 4 TIMES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10220435March 7, 2008
AIR BAGS, STRUCTURE
THIS IS A DESIGN ISSUE. THE 2005 FORD F350 HAS A LARGE PART OF ITS REAR BUMPERS' HORIZONTAL SURFACE REMOVED. THE BUMPER IS THEN COVERED IN A HARD PLASTIC. I STEPPED OFF THE DECK OF MY TRUCK ONTO THE BUMPER AND THE PLASTIC SURFACE GAVE WAY. I ALMOST BROKE MY ANKLE AND LOST MY BALANCE , NOT BECAUSE THE PLASTIC BROKE THROUGH , IT JUST HAD WAY TOO MUCH FLEX IN IT. I'VE TRIED TO DEAL WITH FORD CO REGARDING THIS BUT AS YOU PROBABLY KNOW ,THEY WANT ZERO TO DO WITH THE RETAIL / POST WHOLESALE APPARATUS. I WAS TOLD TO TALK TO THE DEALER. I WOULD HAVE MORE COMPETENCE AND HONEST FEEDBACK FROM MY DOG. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10215739January 23, 2008
STEERING, ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
TL*THE CONTACT OWNS A 2005 FORD F-350 SD. WHILE DRIVING 65 MPH, THE CONTACT LOST CONTROL OF THE STEERING AND THE VEHICLE SWERVED ALL OVER THE ROAD. WHEN DRIVING OVER ROUGH PAVEMENT, A BRIDGE EXPANSION, OR A SLIGHT BUMP, THE STEERING WORSENS. HE HAS TAKEN THE VEHICLE TO THE DEALER FOUR TIMES AND WAS INFORMED THAT THE TIRES NEEDED TO BE ROTATED, THE BUSHING NEEDED TO BE CHANGED, AND THE TIRE PRESSURE WAS INCORRECT. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 36,674 AND FAILURE MILEAGE WAS 10,000. THE ENGINE LIGHT ILLUMINATED. UPDATED 02-12-08 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10213392January 2, 2008
ELECTRICAL SYSTEM:WIRING
TL*THE CONTACT OWNS A 2005 FORD F350 SD. WHILE DRIVING 40-60 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT STATED THAT HE WAS UNABLE TO RESTART THE VEHICLE AND HAD IT TOWED TO THE DEALER. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. AS OF JANUARY 2, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THERE IS A RECALL FOR THE ELECTRICAL SYSTEM: WIRING (NHTSA CAMPAIGN ID # 05V270000) HOWEVER, THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 37,000 AND CURRENT MILEAGE WAS 38,757.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10211352December 10, 2007
STEERING
WHEN DRIVING ON UNEVEN PAVEMENT OR DRIVING OVER CHUCK HOLES AND PARTICULARLY WHEN MANEUVERING TURNS, THE FRONT END "HOPS" SEVERELY CAUSING THE DRIVER TO ALMOST LOSE CONTROL AND SKID SIDEWAYS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10211208December 8, 2007
TIRES, STEERING
BOUGHT F-350 WITH 7200 MILES ON IT. VEHICLE HAS A VIOLENT FRONT END SHAKE WHEN YOU HIT A BUMP. IT IS WORSE AT HIGHWAY SPEEDS AND IT IS SO UNCONTROLLABLE THAT YOU FEEL YOU ARE GOING TO LOOSE CONTROL OF THE VEHICLE. THE ONLY WAY TO STOP IT IS TO SLOW DOWN AND AT HIGHWAY SPEEDS THIS IS NOT WISE. I HAVE TAKEN IT TO THE DEALERSHIP SEVERAL TIMES AND THEY TELL ME IT IS TIRE PRESSURE AND OR TIRES. I HAVE BOUGHT NEW TIRES, HAD FRONT END ALIGNED AND CHECK PRESSURE CONSTANTLY AND IT DOES NOT HELP. I WILL NOT LET OTHERS DRIVE THIS VEHICLE AND ALSO ADVISED THE DEALERSHIP THE VEHICLE IS UNSAFE TO DRIVE. I HAVE ONLY 31,000 MILES ON VEHICLE NOW AND OTHER THAN BUYING A NEW VEHICLE DO NOT KNOW WHAT TO DO NEXT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10211058December 6, 2007
SUSPENSION:FRONT
OSCILLATION OF FRONT SUSPENSION. MY 2005 F350 HAVE BEEN IN FOR REPAIRS SEVERAL TIMES BOTH BY THE DEALER UNDER WARRANTY AND SINCE BY OTHER VEHICLE SERVICE AGENCIES. IT CONTINUES TO GIVE ME PROBLEMS AND AT ITS WORSE, CAUSED THE VEHICLE TO MOVE SIDEWAYS SLIGHTLY INTO THE NEXT LANE. BASICALLY I HAVE BEEN TOLD THAT ?THIS IS NORMAL? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10210710December 3, 2007
ENGINE AND ENGINE COOLING, ENGINE AND ENGINE COOLING:ENGINE:DIESEL
TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 65 MPH, THE VEHICLE SHUT OFF AND THE INSTRUMENT PANEL LIGHTS ILLUMINATED. THE CONTACT PULLED THE VEHICLE OVER AND IT WAS TOWED TO THE DEALER. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT COULD NOT WAIT FOR THE WORK TO BE PERFORMED ON THE VEHICLE AND TRADED IT IN FOR A 2008 MODEL. THE CURRENT AND FAILURE MILEAGES WERE 20,392. UPDATED 12/18/07 *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10210555November 28, 2007
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
2005 FORD F-350 WITH FAULTY INTEGRATED BRAKE CONTROLLER. CONSUMER STATES THAT NO MATTER HOW HARD THE BRAKE PEDAL IS PRESSED SOMETIMES IT DOES NOT SEND A SIGNAL TO THE TRAILER TELLING THE TRAILER TO STOP. *KB THE CONSUMER STATED THE INTEGRATED BRAKE CONTROLLER HAS BEEN REPLACED 3 TIMES. THE BRAKE SWITCH WAS REPLACED, HOWEVER THE PROBLEM REMAINED THE SAME. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10207387October 30, 2007
STEERING, STEERING:LINKAGES, TIRES, SUSPENSION:FRONT:STABILIZER BAR
FRONT END SHIMMY ON FORD F350 4X4 CREW CAB DULLY, PRODUCTION YEAR 2005. AT ABOUT 40 MPH WHEN THE VEHICLE HITS A BUMP THE FRONT END STARTS TO SHAKE. THE FEED BACK THROUGH THE STEERING WHEEL TRIES TO SHAKE THE STEERING WHEEL OUT OF THE DRIVERS HANDS. THIS VEHICLE HAS HAD THE FRONT STABILIZER SHOCK CHANGED, THE LEFT SIDE DRAG LINK CHANGED AND THE FRONT END RE-ALIGNED. THIS PROBLEM HAS BEEN CONTINUING SINCE THE VEHICLE AS HAD APPROX 40,000 MILES. CURRENTLY THE VEHICLE HAS 90K. I HAVE BEEN TOLD THAT THE SHIMMY IS CAUSED BY THE TIRE PRESSURE, TIRES WORN, FRONT END WEAR, ECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10205832October 16, 2007
ELECTRICAL SYSTEM:WIRING, ENGINE AND ENGINE COOLING:ENGINE:DIESEL
I HAVE 2005 FORD F350 6.0L DIESEL. TRUCK STALLS ON THE ROAD AND WILL NOT RESTART. I HAD TRUCK TOWED TO FEDUKE FORD 3 TIMES. WILL NOT FIX BECAUSE THEY CAN'T DUPLICATE PROBLEM. ALMOST HAD SERIOUS CRASH WHEN STALLED, TRACTOR TRAILER ALMOST TOOK ME AND FAMILY OUT. FORD HAD RECALL FOR THIS DEFECT. RECALL#-05S34.NHTSA#-05V270000 I CALLED FORD AND THEY TOLD ME MY VIN# WAS NOT INCLUDED IN RECALL,I TOLD THEM MY TRUCK HAS SAME ISSUE AS RECALL. I NEED HELP. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10205764October 15, 2007
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
I HAVE A 2005 FORD 350 SUPERDUTY 6.0 DIESEL TRUCK. I PULL A LARGE 5TH WHEEL UNIT. IT IS WITHIN THE WEIGHT RANGE INDICATED BY FORD. I HAVE INSTALLED A THERMOCOUPLE GAUGE TO MONITOR THE ENGINE EXHAUST TEMPERATURE. I WAS TOLD BY FORD DEALER THAT THE NORMAL EXHAUST GAS TEMPERATURE (EGT) SHOULD BE BETWEEN 750 AND 900 WHILE PULLING THE UNIT. UNDER A NOMINAL HILL CLIMB, I NOTED THE EGT NEVER GOT BELOW 1000, EVEN WHEN THE TRANSMISSION SHIFTED TO A LOWER GEAR. IT WAS HARD KEEPING THE EGT UNDER 1400. I HAD TO TRAVEL AT 55 MPH AND IN 4TH GEAR TO MAINTAIN THE 1000 DEGREE TEMPERATURE BOOST WAS BETWEEN 24 AND 28 PSI. NEAR THE TOP OF A CLIMB, THE TURBO HOSE BLEW. THE DEALER SAID IT WAS A DIRTY GATE VALVE OR DIRT IN THE VANES OF THE TURBO. DURING THE VACATION THEY REPLACED THE GATE VALVE AND THE TURBO. AFTER VACATION AND WITHOUT THE 5TH WHEEL ATTACHED, I NOTED THE EGT, UNDER NORMAL STREET DRIVING, RUNS AT 800 TO 1000 DEGREES. IF THIS IS AN INDICATION OF THE ENGINE/TURBO DESIGN, THIS ENGINE IS DOOMED TO FAIL. I BELIEVE FORD SHOULD HAVE KNOWN THESE ISSUES BEFORE THEY SOLD THESE TRUCKS. I KNOW THE TURBO WILL FAIL AGAIN. IF THERE IS RECOURSE, I WOULD LIKE TO KNOW. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10204015September 24, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. THE CONTACT STATED THAT THE VEHICLE LOSES POWER INTERMITTENTLY AND WITHOUT WARNING. THE VEHICLE STALLS WHILE ACCELERATING AND DECELERATING. ONCE IT LOSES POWER, THE VEHICLE IS ABLE TO BE RESTARTED. THE FAILURE OCCURS AT SPEEDS BETWEEN 30 AND 60 MPH. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY CANNOT FIND ANYTHING WRONG. THE CONTACT STATED THAT THE FAILURE OCCURS APPROXIMATELY 20-30 TIMES PER DAY AND IS PROGRESSIVELY GETTING WORSE. THE CURRENT MILEAGE WAS 127,058 AND THE FAILURE MILEAGE WAS UNAVAILABLE. UPDATED 01-14-08. *KB UPDATED12/12/07. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10203396September 19, 2007
STEERING, TIRES, SUSPENSION:FRONT
I PURCHASED A NEW 2005 F-350 . SINCE DAY ONE IT HAS HAD A VIOLENT FRONT END SHAKE. IT DOESN'T MATTER IF YOU HIT A BUMP OR NOT. I WILL NOT DRIVE IT ANY MORE. I HAVE TAKEN IT TO THE DEALERSHIP 15 TIMES AND THE HAVE REPLACED THE STEERING BOX, FRONT COIL SPRINGS, DAMPER, SHOCKS AND ADJUSTED THE TIRE PRESSURE. NOTHING SEEMS TO FIX THE PROBLEM. THEN I TOOK IT TO AN OFF ROAD SPECIALTY STORE AND SPENT $6200.00 ON A 4INCH SUSPENSION LIFT, NEW 35" TIRES ,DUAL STABILIZING BARS AND NEW COIL SPRINGS. THE TRUCK STILL SHAKES , BOUNCES , SHIMMIES AND HOPS. I AM FORCED TO BUY ANOTHER VEHICLE (NEVER FORD AGAIN). I AM VERY CONCERNED FOR THE SAFETY OF EVERYONE ON THE ROAD IF FORD DOES NOT FIX THE PROBLEM IMMEDIATELY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10200815August 26, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
FIRST TIME TRUCK QUIT ON NORTH I-25, WE WERE DRIVING AND THE TRUCK JUST QUIT, WOULD NOT RECRANK, STRANDED ON THE SIDE OF THE ROAD FOR 8 HOURS, FINALLY A TOW TRUCK TOWED US 80 MILES TO THE NEAREST FORD DEALERSHIP, WE PAID A TOWING BILL OF $250 ALSO 2 DAYS IN THE HOTEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10200817August 26, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
2ND TIME WAS WHITE SMOKE COMING OUT EXHAUST, THEN IT OVERHEATED AND OIL WAS MIXED WITH ANTIFREEZE, STRANDED FOR 5 HOURS, TOWED 18 MILES TO NEAREST FORD DEALERSHIP, COST US 4 DAYS IN A HOTEL. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10200820August 26, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
3RD TIME IN LESS THAN A MONTH....WOULD NOT START????? STRANDED FOR 12 HOURS, TOWED 30 MILES TO DEALERSHIP AND PAYING AGAIN FOR A HOTEL AND CAR RENTAL.... *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-350