Ford Escape Complaints (2004)

499 consumer complaints on file.

#10655170November 15, 2014
VEHICLE SPEED CONTROL
ON THREE PREVIOUS OCCASIONS THROTTLE STUCK ON HIGH WHEN STOPPED OR IN PARK WHILE PARKING VEHICLE. AFTER GOOGLING INFORMATION ON POSSIBLE CAUSES I FOUND A COMPLAINTS ALREADY FILED WITH THIS ISSUE. FORD ACKNOWLEDGED RECALL NUMBER 12S37. WHEN I CONTACTED MY LOCAL FORD DEALER SATURDAY MORNING 11/15/2014 WITH THIS NUMBER THEY WHERE UNAWARE,AND FOUND NO REFERENCE THIS ISSUE. PLEASE ASSIST. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10655207November 15, 2014
SUSPENSION, STRUCTURE:BODY
DRIVING AND SOUNDS LIKE A SQUARE BOWLING BALL IS ROLLING AROUND IN BACK. LOOK TO FIND A RUSTY MESS FROM SHOCK MOUNT GOING THROUGH WHEEL WELL. ASKED AROUND AND SEEMS TO BE COMMON PROBLEM. THANK GOODNESS I WASN'T FAR FROM HOME. VERY DANGEROUS, WHY IS THIS NOT RECALLED YET! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10655221November 15, 2014
SUSPENSION, WHEELS
A FEW WEEKS AGO I WAS DRIVING SLOWLY DOWN A DIRT ROAD AND I STARTED TO HEAR A BUMPING NOISE TOWARDS THE BACK OF MY CAR, ONLY WHEN I WHEN OVER BUMPS. I FIGURED IT WAS JUST GEAR IN MY TRUNK MAKING THE NOISE AND I WAS GOING TO TAKE A LOOK AT IT LATER, BUT IT DIDN'T SEEM LIKE ANYTHING TO BE CONCERNED ABOUT. YESTERDAY I FINALLY GOT ALL MY IGNITION COILS FIXED AFTER SOME TROUBLE WITH THE MECHANICS DOING IT WRONG ORIGINALLY. WHEN I LEFT HE TOLD ME I MAY HAVE A SUSPENSION PROBLEM, BUT THAT IT IS NOT LIKELY TO BE A PROBLEM ASIDE FROM THE ANNOYINGNESS OF IT. WHEN I GOT HOME I DECIDED TO HAVE A LOOK AROUND MY CAR AND AFTER DISCOVERING THAT IT DID NOT HAVE TO DO WITH MY TRUNK I LOOKED UNDER THE WHEEL WELL AND SAW THAT THE SUSPENSION MOUNT HAD COMPLETELY RUSTED OFF AND HAD BOUNCING AROUND AS I DROVE. IT WAS COMPLETELY DETACHED, AND AFTER GOODLING THIS I SAW THAT MANY OTHER PEOPLE HAVE THIS SAME EXACT PROBLEM AND THAT IT IS VERY UNSAFE, AND MOST LIKELY TO EXPENSIVE TO FIX. I HAD BEEN DRIVING WITH THIS SERIOUS PROBLEM FOR A FEW WEEKS WITH NO IDEA OF THE DANGER THAT IT COULD CAUSE. THERE IS NO RECALL ON IT BUT I FEEL THAT WITH THE AMOUNT OF PEOPLE WITH THIS PROBLEM AND THE SEVERITY OF IT, FORD NEEDS TO DO SOMETHING ABOUT THIS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10649864October 25, 2014
AIR BAGS
THE AIRBAG LIGHT ON THE DASH BOARD FLASHES AS IT'S SUPPOSED TO AND THEN REMAINS ILLUMINATED. THIS DEFECT WAS PRESENT AND KNOWN ABOUT LONG BEFORE THE 2013 MODEL RECALL. INCLUDE EARLIER YEAR ESCAPES IN THE AIRBAG RECALL--WE ARE STILL DRIVING THEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10649081October 21, 2014
SUSPENSION
WE RECENTLY TOOK OUR 2004 FORD ESCAPE TO GET IT LOOKED AT BECAUSE EVERY TIME WE HIT A BUMP THERE WAS A LOUD THUD SOUND IN THE BACK RIGHT. WE FOUND OUT THAT THE REAR RIGHT WHEEL WELL OF OUR 2004 FORD ESCAPE IS COMPLETELY RUSTED OUT. THE CORROSION HAS CAUSED A MAJOR SUSPENSION PROBLEM AND IT'S BEEN DEEMED UNDRIVABLE. WHAT'S WORSE IS THAT NO MECHANIC OR BODY SHOP WILL ATTEMPT TO FIX THE ISSUE BECAUSE IT WOULD BE CONSIDERED A LIABILITY ISSUE IF ANYTHING WERE TO HAPPEN THEY WOULD BE AT FAULT. THE REST OF THE VEHICLE IS IN PERFECT CONDITION, BUT BECAUSE OF ONE AWFUL DEFECT ALL WE CAN DO IS SELL IT FOR PARTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10648651October 19, 2014
SUSPENSION
NOTICED A BURNING RUBBER SMELL. FOUND THAT REAR SHOCK TOWER HAD RUSTED THROUGH AND SHOCK WAS RUBBING ON TIRE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10640410October 1, 2014
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT HEARD A CLUNKING SOUND NEAR THE REAR PASSENGER SIDE OF THE VEHICLE. THE DEALER STATED THAT THE WHEEL WELL WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10639743September 29, 2014
STRUCTURE:BODY
RUNNING BOARD RUSTED AND FELL OFF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10639108September 25, 2014
WHEELS, STRUCTURE
THE RIGHTSIDE OF MY WHEELWELL WAS ROTTED OUT ALONG WITH THE FLOOR AROUND IT THAT HELD THE WHEEL WELL THE SHOCK NEEDED TO BE REPLACED AS WELL. WHEN I WENT TO THE DEALERSHIP TO GET THE WHEEL WELL THEY TOLD ME THIS WAS A WELL KNOWN PART TO BE REPLACED. SO I ASKED WHY WAS IT NOT A RECALL ON IT NO ANSWER COULD HE GIVE ME. I WAS GETTING A BURNING SMELL FROM MY EXHAUST (MUFFLER FUMES) AS I DROVE HOME MANY TIMES I FELT MYSELF GETTING SLEEPY AS I DROVE ON TO GET TO MY DESTINATION I PRAYED TOGET SAFELY THERE LITTLE DID I KNOW I WAS GETTING FUMES IN MY CAR THAT CAUSED THIS. I HAVE DRIVEN WITH MY YOUNG GRANDCHILDREN IN THIS DANGEROUS CONDITION IN THIS CAR MY QUESTION IS IF THE FORD DEALERSHIP KNEW OF THIS TO BE A WELL KNOWN PROBLEM WHY DID THEY NOT RECALL IT I ONLY THANK THE LORD THAT IT DID NOT KILL ME OR MY GRANDCHILDREN. ALSO IT PAST INSPECTION A YEAR AGO HOW COULD THEY HAVE NOT SEEN WHAT WAS HAPPENING IN THIS AREA. I DO HAVE PICTURES OF IT AND IT WAS EVEN WORST THEN THE PICTURES I HAVE SEEN ONLINE PROOF ONE MORE TIME THAT GOD IS ALWAYS ON YOURSIDE IF YOU BELIEVE EVERYONE ELSE PLEASE CHECK YOUR WHEEL WELL GOD BLESS! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10637714September 20, 2014
SUSPENSION, ELECTRICAL SYSTEM
LOUD RATTLE THEN GRINDING NOISE. WHEN I PULLED OVER I HAD TO REMOVE THE SHOCK MOUNT WHICH WAS JAMMED BETWEEN THE CAR AND MY TIRE. THE SHOCK HAS NOW POPPED THROUGH THE PLASTIC. THIS IS MY ONLY FORM OF TRANSPORTATION AND THE DEALER SAID THERE WAS NO RECALL. THE OTHER SIDE IS RUSTED OUT AS WELL. IN ADDITION, WHEN DAMP OUT, THE #5 PLUG IS MISSING CAUSING DAMAGE TO THE CONVERTER. TOTAL ESTIMATED TUNE UP REPAIR CLOSE TO $400. DURING THE PAST YEAR TYROD, BRAKES & ROTORS, WHEEL BEARING, BRAKE HOSES, POWER STEERING, RADIO STAYS ON WHEN CAR IS SHUT OFF UNLESS FUSE IS PULLED. FUEL PUMP WAS REPLACED AT 70000 IN 2011. HAVE TO TAKE THE LOSS. FORD SHOULD REFUND FOR THIS DEFECT. THE MOUND IS NOT RUSTED, JUST THE WHEEL WELLS IT IS ATTACHED TO. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10636913September 17, 2014
SUSPENSION
VEHICLE BROUGHT INTO REPAIR SHOP AND FOUND THAT THE ENGINE CRADLE AND WAS ROTTED CONSIDERABLY. A RECALL NOTICE ON THIS PROBLEM WAS SENT TO THE CUSTOMER AND CUSTOMER TOOK INTO BRIGHT FORD, INC FOR THE RECALL. REPAIR WAS DONE SEVERAL MONTHS LATER AND RETURNED TO CUSTOMER MAY 16, 2004. THREE MONTHS LATER WE AGAIN HAVE THIS VEHICLE IN THE SHOP AND UPON INSPECTION THE LOWER CONTROL ARM BRACKET ROTTED OFF OF THE CRADLE AND CAUSED THE LOWER CONTROL ARM TO BE ONLY MOUNTED BY THE REAR BOLT. THIS CAR IS CONSIDERED A HAZARD TO DRIVE DUE TO THE RIGHT FRONT TIRE MOVEMENT NOT BEING CONTROLLED BY STEERING. BRIGHTON FORD ON THEIR INVOICE #19744, FOUND THE FRONT SUB FRAME RUSTING THROUGH ON RIGHT HAND SIDE. SENT QUOTE FOR NEW SUB-FRAME AND WERE DENIED AND THEY WERE TOLD TO PUT THIS CROSS BRACE ON THE VEHICLE. THIS REPAIR IS NOT IN LINE WITH THE REPAIRS THAT WERE NEEDED. THE VEHICLE CANNOT BE DRIVEN AT THIS TIME AND BRIGHTON FORD SAYS IT IS YOUR RESPONSIBILITY TO DETERMINE REPAIR. THIS WAS NOT A SAFE REPAIR AND KNOWINGLY TOLD CUSTOMER THAT IT WAS REPAIRED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10636915September 17, 2014
SUSPENSION, ENGINE, STRUCTURE
VEHICLE BROUGHT INTO REPAIR SHOP AND FOUND THAT THE ENGINE CRADLE AND WAS ROTTED CONSIDERABLY. A RECALL NOTICE ON THIS PROBLEM WAS SENT TO THE CUSTOMER AND CUSTOMER TOOK INTO BRIGHT FORD, INC FOR THE RECALL. REPAIR WAS DONE SEVERAL MONTHS LATER AND RETURNED TO CUSTOMER MAY 16, 2004. THREE MONTHS LATER WE AGAIN HAVE THIS VEHICLE IN THE SHOP AND UPON INSPECTION THE LOWER CONTROL ARM BRACKET ROTTED OFF OF THE CRADLE AND CAUSED THE LOWER CONTROL ARM TO BE ONLY MOUNTED BY THE REAR BOLT. THIS CAR IS CONSIDERED A HAZARD TO DRIVE DUE TO THE RIGHT FRONT TIRE MOVEMENT NOT BEING CONTROLLED BY STEERING. BRIGHTON FORD ON THEIR INVOICE #19744, FOUND THE FRONT SUB FRMAE RUSTING THROUGH ON RIGHT HAND SIDE. SENT QUOTE FOR NEW SUB-FRAME AND WERE DENIED AND THEY WERE TOLD TO PUT THIS CROSS BRACE ON THE VEHICLE. THIS REPAIR IS NOT IN LINE WITH THE REPAIRS THAT WERE NEEDED. THE VEHICLE CANNOT BE DRIVEN AT THIS TIME AND BRIGHTON FORD SAYS IT IS YOUR RESPONSIBILITY TO DETERMINE REPAIR. THIS WAS NOT A SAFE REPAIR AND KNOWINGLY TOLD CUSTOMER THAT IT WAS REPAIRED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10633588September 16, 2014
POWER TRAIN
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10632770September 12, 2014
SUSPENSION, WHEELS
NOTICED LOUD RATTLE, KNOCKING IN REAR OF TRUCK. STOPPED TO HAVE MECHANIC LOOK AT IT. DISCOVERED SEVERE EROSION IN REAR WHEEL WELL AND SHOCK MECHANISM COMPLETELY SEPARATED FROM VEHICLE. APPEARS TO BE VERY COMMON FOR 2004-05 ESCAPES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10631901September 9, 2014
STEERING, SUSPENSION, WHEELS
ON A TRIP TO UPPER PENINSULA, MICHIGAN THIS PAST WEEK WE EXPERIENCED A FAILURE OF THE FRONT SUBFRAME CROSSBRACE, A NEAR CATASTROPHIC EVENT AS THE PIECE BROKE. WE WERE IN GRAYLING, MICHIGAN AND WERE STOPPED NEAR AN INDEPENDENT SERVICE PROVIDER WHO SHOWED US THE DAMAGE AND ATTEMPTED TO FIND A USED PART. THE ONE HE FOUND HAD THE EXACT SAME RUST AND BREAK AS OURS AND THUS HE ORDERED A NEW ONE FROM FORD. IN THE MEANTIME WE WERE FORCED TO RENT A CAR AND CONTINUE ON TO OUR VACATION DESTINATION. AFTER WE RETURNED HOME I LEARNED THAT THERE HAD BEEN A RECALL OF THESE VEHICLES FOR JUST SUCH A FAILURE. I TOOK THE CAR AND THE BROKEN CROSSBRACE TO MIKE CASTRUCCI FORD IN ALEXANDRIA, KY WHERE THE WARRANTY OFFICER INFORMED ME THAT OUR ESCAPE WAS NOT PART OF THE FACTORY RECALL. SHE WAS ABLE TO TELL ME WHY AND WAS VERY HELPFUL ALTHOUGH CLEAR THAT NOTHING COULD BE DONE. THE ARGUMENT WAS PRESENTED THAT THE FAILED PART IN THE RECALL WAS MADE BY A PARTICULAR MANUFACTURER AND USED IN CERTAIN PLANTS OR VEHICLES. I GET THE POINT BUT I HAVE A CAR THAT FAILED IN EXACTLY THE SAME WAY DUE TO EXCESSIVE RUST AND PRESENTED THE SAME RISK OF CATASTROPHIC FAILURE THAT WE NARROWLY AVOIDED BY LUCK. THE REPAIR REPLACEMENT COST OVER $1000 PLUS LABOR. I BELIEVE VEHICLES LIKE MINE SHOULD BE PART OF THE RECALL. OUR FRONT WHEEL COULD HAVE TOTALLY COLLAPSED WHILE WE WERE TRAVELING AT HIGH SPEED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10631549September 8, 2014
SUSPENSION
THE RIGHT REAR WHEEL WELL IS RUSTING OUT SO THAT THE SHOCK TO BREAK LOOSE. I WAS TOLD IT'S UNSAFE BY SEVERAL MECHANICS/BODY SHOPS TO DRIVE. THIS IS THE ONLY CAR THAT I HAVE TO TRANSPORT MY THREE CHILDREN AND IT'S NOT GOING TO BE A CHEAP FIX. THIS NEEDS TO BE RECALLED BEFORE SOMEONE GETS INJURED OR WORSE!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10631399September 7, 2014
SUSPENSION
WHILE DRIVING HEARD A LOUD CLUNKING NOISE COMING FROM THE PASSENGER SIDE REAR WHEEL WELL. ARRIVED HOME TO INSPECT THE AREA OF CONCERN. FOUND THAT THE PASSENGER SIDE REAR SHOCK MOUNT HAD COMPLETELY SEPARATED FROM THE WHEEL WELL DUE TO EXTENSIVE RUSTING. THIS ALLOWED THE SHOCK TO TRAVEL UPWARD STRIKING THE PLASTIC INTERIOR TRIM PANEL. THIS VEHICLE WAS GARAGE KEPT UNTIL TWO YEARS AGO. IT ALSO PASSED STATE INSPECTION REQUIREMENTS NINE MONTHS AGO. I AM NOT A MECHANICAL ENGINEER. HOWEVER, I DO NOT BELIEVE A CRITICAL SUSPENSION COMPONENT SHOULD BE ATTACHED TO SHEET METAL THAT IS PRONE TO RUST. I HAVE TAKEN THE TIME AND MADE THE EFFORT TO INSPECT SEVERAL OTHER VEHICLE MANUFACTURERS AND FIND THAT THEIR SUSPENSION SYSTEM IS CONNECTED TO A SOLID COMPONENT OF THE FRAME. OBVIOUSLY THIS IS AN ENGINEERED DESIGN FLAW OF A CRITICAL SAFETY COMPONENT THAT POSSIBLY COULD RESULT IN UNSAFE HANDLING AT HIGHWAY SPEED. WITH ONLY ONE REAR SHOCK ATTACHED TO THE VEHICLE AN UNCONTROLLABLE REAR SWAY COULD OCCUR RESULTING IN A POSSIBLE ROLL OVER. GIVEN THE NUMBER OF REPORTED COMPLAINTS OF THE SAME NATURE, WHICH GIVEN KNOWN STATISTICS IS A SMALL PERCENTAGE OF ACTUAL CASES, I DO REQUEST A RECALL TO BE MADE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10631192September 5, 2014
SUSPENSION
THE RIGHT REAR SHOCK TOWER RUSTED THROUGH AND THE SHOCK HAS COME THROUGH THE PLASTIC MOULDING. THE CAR DRIVES BUT IS UNSTABLE AND UNSAFE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10629957September 2, 2014
STRUCTURE:BODY, SUSPENSION, WHEELS
I WAS DRIVING HOME FROM THE STORE AND STARTED HEARING A LOUD BANGING NOISE COMING FROM THE REAR OF THE TRUCK. UPON INVESTIGATION I DISCOVERED WHAT I BELIEVE TO BE A MAJOR SAFETY CONCERN IN MY 2004 FORD ESCAPE. THE REAR PASSENGER SIDE WHEEL WELL OVER THE SHOCK TOWER COMPLETELY RUSTED OUT AND SEPARATED OVER THE SHOCK. I HAVE BEEN TOLD AND SEEN THAT THIS SEEMS TO BE A COMMON PROBLEM WITH MY VEHICLE AND OTHER YEARS OF ESCAPES. AFTER SPEAKING WITH AN INDEPENDENT BODY SHOP IN MY AREA THEY INFORMED ME THIS WAS A COMMON PROBLEM THEY HAVE SEEN SEVERAL TIMES BEFORE. BUT WHEN I CONTACTED 3 LOCAL FORD DEALERS THEY ALL CLAIMED TO HAVE NEVER SEEN IT BEFORE. AND WANTED TO CHARGE ME A HUNDRED DOLLARS JUST TO LOOK AT IT. I AM TOLD THE VEHICLE IS UNDRIVEABLE IN THIS CONDITION. AND THAT IN MOST CASES CAN NOT BE REPAIRED. AFTER DOING MUCH RESEARCH ONLINE I FOUND HUNDREDS OF OTHER PEOPLE WITH THE SAME EXACT PROBLEM. I HAVE ALSO CONTACTED FORD AND AM AWAITING A RESPONSE. I WOULD LIKE TO SEE A RECALL MADE ON THIS AS I CAN SEE THIS BEING A MAJOR PROBLEM THAT COULD HAVE CAUSED AN ACCIDENT. AND IS GOING TO BE A VERY EXPENSIVE REPAIR JOB IF IT IS EVEN REPAIRABLE. I HAVE PHOTOS BUT AM NOT SURE HOW TO ATTACH THEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10627401August 22, 2014
STEERING
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V165000 (STEERING) BUT THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Escape