Chevrolet Tracker Service Bulletins (1999)

85 manufacturer communications on file.

• May 9, 2014•Document ID: 10137901

  Service Bulletin/Repair Instructions
  FUEL SYSTEM, GASOLINE

  Mfr Comm. #:

  05-06-04-035D

  Date Added:

  May 21, 2018

  Manufacturer:

  BUICK

  Summary

  This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.

  Associated Products (754)

  2014 Buick Enclave2014 Buick Encore2014 Buick LaCrosse2014 Buick Regal2014 Buick Verano2014 Cadillac ATS2014 Cadillac CTS2014 Cadillac ELR2014 Cadillac Escalade2014 Cadillac Escalade ESV2014 Cadillac SRX2014 Cadillac XTS2014 Chevrolet Aveo2014 Chevrolet Camaro2014 Chevrolet Caprice2014 Chevrolet Colorado2014 Chevrolet Corvette2014 Chevrolet Cruze2014 Chevrolet Equinox2014 Chevrolet Express+ 734 more
  Associated Documents

  • DownloadMC-10137901-0001.pdf↗
• February 1, 2014•Document ID: 10190932

  Service Bulletin/Repair Instructions
  EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT; WHEELS

  Mfr Comm. #:

  99-08-51-007F

  Date Added:

  April 26, 2021

  Manufacturer:

  SATURN

  Summary

  Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed. Evaluating Damage In evaluating damage, it is the GM Dealer's responsibility to inspect the wheel for corrosion, scrapes, gouges, etc. The Dealer must insure that such damage is not deeper than what can be sanded or polished off. The wheel must be inspected for cracks. If cracks are found, discard the wheel. Any wheels with bent rim flanges must not be repaired or refinished. Wheels that have been refinished by an outside company must be returned to the same vehicle. The Dealer must record the wheel ID stamp or the cast date on the wheel in order to assure this requirement. Refer to Refinisher's Responsibility — Outside Company later in this bulletin.

  Associated Products (857)

  2015 Buick Enclave2015 Buick Encore2015 Buick LaCrosse2015 Buick Regal2015 Buick Verano2015 Cadillac ATS2015 Cadillac CT62015 Cadillac CTS2015 Cadillac ELR2015 Cadillac Escalade2015 Cadillac Escalade ESV2015 Cadillac SRX2015 Cadillac XT52015 Cadillac XTS2015 Chevrolet Aveo2015 Chevrolet Camaro2015 Chevrolet Caprice2015 Chevrolet City Express2015 Chevrolet Cobalt2015 Chevrolet Colorado+ 837 more
  Associated Documents

  • DownloadMC-10190932-0001.pdf↗
• February 1, 2014•Document ID: 10190931

  Service Bulletin/Repair Instructions
  EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; WHEELS

  Mfr Comm. #:

  99-08-51-007F

  Date Added:

  April 26, 2021

  Manufacturer:

  GMC

  Summary

  Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed. Evaluating Damage In evaluating damage, it is the GM Dealer's responsibility to inspect the wheel for corrosion, scrapes, gouges, etc. The Dealer must insure that such damage is not deeper than what can be sanded or polished off. The wheel must be inspected for cracks. If cracks are found, discard the wheel. Any wheels with bent rim flanges must not be repaired or refinished. Wheels that have been refinished by an outside company must be returned to the same vehicle. The Dealer must record the wheel ID stamp or the cast date on the wheel in order to assure this requirement. Refer to Refinisher's Responsibility — Outside Company later in this bulletin.

  Associated Products (857)

  2015 Buick Enclave2015 Buick Encore2015 Buick LaCrosse2015 Buick Regal2015 Buick Verano2015 Cadillac ATS2015 Cadillac CT62015 Cadillac CTS2015 Cadillac ELR2015 Cadillac Escalade2015 Cadillac Escalade ESV2015 Cadillac SRX2015 Cadillac XT52015 Cadillac XTS2015 Chevrolet Aveo2015 Chevrolet Camaro2015 Chevrolet Caprice2015 Chevrolet City Express2015 Chevrolet Cobalt2015 Chevrolet Colorado+ 837 more
  Associated Documents

  • DownloadMC-10190931-0001.pdf↗
• January 1, 2014•Document ID: 10190934

  Service Bulletin/Repair Instructions
  STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS; EQUIPMENT ADAPTIVE/MOBILITY

  Mfr Comm. #:

  PI0281D

  Date Added:

  April 26, 2021

  Manufacturer:

  CHEVROLET

  Summary

  Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.

  Associated Products (857)

  2015 Buick Enclave2015 Buick Encore2015 Buick LaCrosse2015 Buick Regal2015 Buick Verano2015 Cadillac ATS2015 Cadillac CT62015 Cadillac CTS2015 Cadillac ELR2015 Cadillac Escalade2015 Cadillac Escalade ESV2015 Cadillac SRX2015 Cadillac XT52015 Cadillac XTS2015 Chevrolet Aveo2015 Chevrolet Camaro2015 Chevrolet Caprice2015 Chevrolet City Express2015 Chevrolet Cobalt2015 Chevrolet Colorado+ 837 more
  Associated Documents

  • DownloadMC-10190934-0001.pdf↗
• January 1, 2014•Document ID: 10190933

  Service Bulletin/Repair Instructions
  EQUIPMENT ADAPTIVE/MOBILITY; STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

  Mfr Comm. #:

  PI0281D

  Date Added:

  April 26, 2021

  Manufacturer:

  CHEVROLET

  Summary

  Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.

  Associated Products (857)

  2015 Buick Enclave2015 Buick Encore2015 Buick LaCrosse2015 Buick Regal2015 Buick Verano2015 Cadillac ATS2015 Cadillac CT62015 Cadillac CTS2015 Cadillac ELR2015 Cadillac Escalade2015 Cadillac Escalade ESV2015 Cadillac SRX2015 Cadillac XT52015 Cadillac XTS2015 Chevrolet Aveo2015 Chevrolet Camaro2015 Chevrolet Caprice2015 Chevrolet City Express2015 Chevrolet Cobalt2015 Chevrolet Colorado+ 837 more
  Associated Documents

  • DownloadMC-10190933-0001.pdf↗
• September 1, 2013•Document ID: 10246631

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

  Mfr Comm. #:

  130089009

  Date Added:

  December 11, 2023

  Manufacturer:

  PONTIAC

  Summary

  Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

  Associated Products (603)

  2005 Buick Century2005 Buick LaCrosse2005 Buick LeSabre2005 Buick Park Avenue2005 Buick Rainier2005 Buick Regal2005 Buick Rendezvous2005 Cadillac CTS2005 Cadillac Deville2005 Cadillac DTS2005 Cadillac Escalade2005 Cadillac Escalade ESV2005 Cadillac SRX2005 Cadillac STS2005 Cadillac XLR2005 Chevrolet Avalanche2005 Chevrolet Aveo2005 Chevrolet Blazer2005 Chevrolet Cavalier2005 Chevrolet Cobalt+ 583 more
  Associated Documents

  • DownloadMC-10246631-0001.pdf↗
• November 26, 2012•Document ID: 10112600

  Service Bulletin/Repair Instructions
  POWER TRAIN:AXLE ASSEMBLY

  Mfr Comm. #:

  PIP3720D

  Date Added:

  August 15, 2017

  Manufacturer:

  GMC

  Summary

  This Preliminary Information communication provides information to the technician with the axel setup information from American Axle Manufacturing. Technician should be advised that the maximum pinion shim to be used or stacked behind the pinion is 0.050?, and the minimum pinion shim is 0.020? for an 8.6 axle. The range for available pinion depth shims for the 10.5? axle is 0.006? to 0.024?. When setting the backlash it should be set between 0.003? to 0.005? on a new ring and pinion for any American Axle Manufacturing application. The ring and pinion can be reused or adjusted if the mileage is less than 500 miles, if not used for towing. Technician should be advised that a ?roller coaster? or ?hourglass? pattern on the bearings may be normal up to 10,000 miles and possibly longer. With a mis-machined housing you may get a heel pattern on both sides of the gear teeth at build up can generally be corrected with backlash adjustments. When setting up an 8.6? axle with a 5 cut gear set is to use a 0.035? pinion shim and set backlash to 0.004?. When using the newer 2 cut gear set also use a 0.035? pinion shim and still set backlash to 0.004?. To set the gear pattern use backlash to adjust the pattern heel to toe. Use the pinion shim to adjust the height of the pattern. The proper drive pinion bearing pre-load is from 15 - 30 inch pounds with new bearings. The total torque to turn after the differential case is installed should increase 5 - 10 inch pounds at the pinion. A new pinion nut must be used whenever the old one is removed. The axle shaft end play specification is 0.012? per side and the radial specification is 0.002? - 0.003?. Technician should be advised that synthetic lube can be used in all new American Axle Manufacturing axle assemblies. The new pinion seal for the 8.6? axle assembly is a two piece design.

  Associated Products (267)

  2013 Buick Enclave2013 Cadillac Escalade2013 Cadillac Escalade ESV2013 Cadillac SRX2013 Chevrolet Avalanche2013 Chevrolet Equinox2013 Chevrolet Silverado2013 Chevrolet Suburban2013 Chevrolet Tahoe2013 Chevrolet Traverse2013 GMC Acadia2013 GMC Sierra2013 GMC Terrain2013 GMC Yukon2013 GMC Yukon XL2012 Buick Enclave2012 Cadillac Escalade2012 Cadillac Escalade ESV2012 Cadillac SRX2012 Chevrolet Avalanche+ 247 more
  Associated Documents

  • DownloadMC-10112600-0001.pdf↗
• October 1, 2007•Document ID: 10023633

  Service Bulletin/Repair Instructions
  SUSPENSION:FRONT

  Mfr Comm. #:

  06186

  Date Added:

  January 17, 2008

  Manufacturer:

  CHEVROLET

  Summary

  SPECIAL COVERAGE ADJUSTMENT - FRONT SUSPENSION CROSSMEMBER CORROSION. *NJ

  Associated Products (6)

  2004 Chevrolet Tracker2003 Chevrolet Tracker2002 Chevrolet Tracker2001 Chevrolet Tracker2000 Chevrolet Tracker1999 Chevrolet Tracker
  Associated Documents

  • DownloadMC-10023633-0001.pdf↗
• October 1, 2005•Document ID: 10005527

  Service Bulletin/Repair Instructions
  UNKNOWN OR OTHER

  Mfr Comm. #:

  000089008E

  Date Added:

  March 2, 2004

  Manufacturer:

  TOYOTA

  Summary

  SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LIGHT DUTY TRUCKS. *TT

  Associated Products (68)

  2006 Hummer H22006 Hummer H32004 Cadillac Escalade2004 Chevrolet Cavalier2004 Chevrolet Malibu2004 Chevrolet Tracker2004 Hummer H22004 Oldsmobile Alero2004 Pontiac Grand AM2004 Pontiac Sunfire2003 Cadillac Escalade2003 Chevrolet Cavalier2003 Chevrolet Malibu2003 Chevrolet Tracker2003 Hummer H22003 Oldsmobile Alero2003 Pontiac Grand AM2003 Pontiac Sunfire2002 Cadillac Escalade2002 Chevrolet Cavalier+ 48 more
  Associated Documents

  • DownloadMC-10005527-0001.pdf↗
• December 1, 2004•Document ID: 10017439

  Service Bulletin/Repair Instructions
  SUSPENSION

  Mfr Comm. #:

  010863004

  Date Added:

  November 8, 2005

  Manufacturer:

  CHEVROLET

  Summary

  CREAKING OR POPPING TYPE SOUND FROM FRONT END OR SUSPENSION WHEN DRIVING OVER BUMPS OR IN TIGHT TURNS. *TT

  Associated Products (6)

  2004 Chevrolet Tracker2003 Chevrolet Tracker2002 Chevrolet Tracker2001 Chevrolet Tracker2000 Chevrolet Tracker1999 Chevrolet Tracker
  Associated Documents

  • DownloadMC-10017439-0001.pdf↗
• January 1, 2004•Document ID: 10006621

  Service Bulletin/Repair Instructions
  POWER TRAIN:AUTOMATIC TRANSMISSION

  Mfr Comm. #:

  01832

  Date Added:

  May 7, 2004

  Manufacturer:

  CHEVROLET

  Summary

  372LE AUTOMATIC TRANSMISSION NO FIRST GEAR. *MR

  Associated Products (6)

  2003 Chevrolet Tracker2002 Chevrolet Tracker2001 Chevrolet Tracker2000 Chevrolet Tracker1999 Chevrolet Tracker1998 Chevrolet Tracker
  Associated Documents

  • DownloadMC-10006621-0001.pdf↗
• January 1, 2004•Document ID: 10005472

  Service Bulletin/Repair Instructions
  EQUIPMENT

  Mfr Comm. #:

  01513

  Date Added:

  February 28, 2004

  Manufacturer:

  CHEVROLET

  Summary

  REPLACEMENT KEYS FOR ROOF RACK CROSS RAILS. *TT

  Associated Products (2)

  2001 Chevrolet Tracker1999 Chevrolet Tracker
  Associated Documents

  • DownloadMC-10005472-0001.pdf↗
• December 1, 2003•Document ID: 10005177

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

  Mfr Comm. #:

  010601015A

  Date Added:

  February 11, 2004

  Manufacturer:

  CHEVROLET

  Summary

  SOME CUSTOMERS MAY COMMENT ON A FRAYED SERPENTINE BELT AND/OR BELT SQUEAL. *TT

  Associated Products (5)

  2003 Chevrolet Tracker2002 Chevrolet Tracker2001 Chevrolet Tracker2000 Chevrolet Tracker1999 Chevrolet Tracker
  Associated Documents

  • DownloadMC-10005177-0001.pdf↗
• September 1, 2003•Document ID: 10004279

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING:ENGINE

  Mfr Comm. #:

  000601006D

  Date Added:

  December 1, 2003

  Manufacturer:

  CHEVROLET

  Summary

  A TICK TYPE NOISE COMING FROM THE ENGINE WHILE THE ENGINE IS RUNNING DURING COLD OR HOT OPERATION. *TT

  Associated Products (5)

  2003 Chevrolet Tracker2002 Chevrolet Tracker2001 Chevrolet Tracker2000 Chevrolet Tracker1999 Chevrolet Tracker
  Associated Documents

  • DownloadMC-10004279-0001.pdf↗
• September 1, 2003•Document ID: 10004278

  Service Bulletin/Repair Instructions
  UNKNOWN OR OTHER

  Mfr Comm. #:

  000089008B

  Date Added:

  December 1, 2003

  Manufacturer:

  CHEVROLET

  Summary

  SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LIGHT DUTY TRUCKS. *TT

  Associated Products (65)

  2004 Cadillac Escalade2004 Chevrolet Cavalier2004 Chevrolet Malibu2004 Chevrolet Tracker2004 Hummer H22004 Oldsmobile Alero2004 Pontiac Grand AM2004 Pontiac Sunfire2003 Cadillac Escalade2003 Chevrolet Cavalier2003 Chevrolet Malibu2003 Chevrolet Tracker2003 Hummer H22003 Oldsmobile Alero2003 Pontiac Grand AM2003 Pontiac Sunfire2002 Cadillac Escalade2002 Chevrolet Cavalier2002 Chevrolet Malibu2002 Chevrolet Tracker+ 45 more
  Associated Documents

  • DownloadMC-10004278-0001.pdf↗
• June 1, 2003•Document ID: 10002832

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING:ENGINE

  Mfr Comm. #:

  000601006C

  Date Added:

  September 26, 2003

  Manufacturer:

  CHEVROLET

  Summary

  A TICK TYPE NOISE COMING FROM THE ENGINE WHILE THE ENGINE IS RUNNING DURING COLD OR HOT OPERATION. *TT

  Associated Products (5)

  2003 Chevrolet Tracker2002 Chevrolet Tracker2001 Chevrolet Tracker2000 Chevrolet Tracker1999 Chevrolet Tracker
  Associated Documents

  • DownloadMC-10002832-0001.pdf↗
• January 1, 2003•Document ID: 10000937

  Service Bulletin/Repair Instructions
  SERVICE BRAKES, HYDRAULIC

  Mfr Comm. #:

  030523001

  Date Added:

  April 5, 2003

  Manufacturer:

  CHEVROLET

  Summary

  BRAKE PULSATION / VIBRATION, CONTAMINATION / CORROSION BETWEEN HUB AND ROTOR AND / OR DRUM AND AXLE FLANGE. *TT

  Associated Products (5)

  2003 Chevrolet Tracker2002 Chevrolet Tracker2001 Chevrolet Tracker2000 Chevrolet Tracker1999 Chevrolet Tracker
  Associated Documents

  • DownloadMC-10000937-0001.pdf↗
• October 1, 2002•Document ID: 10007838

  Service Bulletin/Repair Instructions
  POWER TRAIN

  Mfr Comm. #:

  990730016A

  Date Added:

  July 13, 2004

  Manufacturer:

  GMC

  Summary

  DIAGNOSTIC INFORMATION FOR INTERMITTENT TRANSMISSION DOWNSHIFT, SLIP, BUSY/CYCLING TCC OR NOISY COOLING FAN. *TT

  Associated Products (120)

  2003 Cadillac Escalade2003 Chevrolet Blazer2003 Chevrolet Express2003 Chevrolet Silverado2003 Chevrolet Suburban2003 Chevrolet Tahoe2003 Chevrolet Tracker2003 GMC Savana2003 GMC Sierra2003 GMC Yukon2003 Hummer H22002 Cadillac Escalade2002 Chevrolet Blazer2002 Chevrolet Express2002 Chevrolet Silverado2002 Chevrolet Suburban2002 Chevrolet Tahoe2002 Chevrolet Tracker2002 GMC Savana2002 GMC Sierra+ 100 more
  Associated Documents

  • DownloadMC-10007838-0001.pdf↗
• April 1, 2002•Document ID: 634987

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

  Mfr Comm. #:

  000601006B

  Date Added:

  October 11, 2002

  Manufacturer:

  CHEVROLET

  Summary

  A TICK TYPE NOISE COMING FROM THE ENGINE WHILE THE ENGINE IS RUNNING DURING COLD OR HOT OPERATION. *TT

  Associated Products (4)

  2002 Chevrolet Tracker2001 Chevrolet Tracker2000 Chevrolet Tracker1999 Chevrolet Tracker
  Associated Documents

  • DownloadMC-634987-0001.pdf↗
• March 1, 2002•Document ID: 629488

  Service Bulletin/Repair Instructions
  VISIBILITY:WINDSHIELD

  Mfr Comm. #:

  020864004

  Date Added:

  April 2, 2002

  Manufacturer:

  CHEVROLET

  Summary

  SOME CUSTOMERS MAY COMMENT THAT ONE OR MORE WINDOWS BINDS OR TO TIPS FORWARD WHEN OPENING. *JG

  Associated Products (4)

  2002 Chevrolet Tracker2001 Chevrolet Tracker2000 Chevrolet Tracker1999 Chevrolet Tracker
  Associated Documents

  • DownloadMC-629488-0001.pdf↗