Chevrolet Silverado Complaints (2006)

777 consumer complaints on file.

#10625922August 18, 2014
SEATS
AFTER READING AN ARTICLE ABOUT A PARAPLEGIC WOMAN WHO GOT SEVERELY BURNED BY HER FRIENDS SUBURBAN'S HEATED SEATS, I FIND IT ESSENTIAL TO REPORT THAT I'VE ALWAYS FOUND THAT MY DRIVERS HEATED SEAT SOMETIMES GET EXTREMELY HOT. FORTUNATELY, I HAVE BEEN ABLE TO TURN THEM OFF BEFORE ANY INJURIES. THE WOMAN REPORTED NOT KNOWING HOW HER HEATED SEAT GOT TURNED ON. IF HER FRIENDS VEHICLE IS LIKE MINE, AN MANY OTHERS WHO HAVE COMPLAINED ON MULTIPLE OPEN FORUM WEBSITES, THE HEATED SEATS IN MANY OF CHEVROLET'S TRUCKS AND SUVS ARE KNOWN TO TURN ON THEIR OWN. I HAVE HAD TO UNPLUG MY SEATS DUE TO THE HEATER TURNING ON ERRATICALLY AND CYCLING THROUGH THE 3 HEAT LEVELS ON THEIR OWN. IT HAS BEEN REPORTED ON MULTIPLE WEBSITES THAT PEOPLE HAVE COMPLAINED TO GM ABOUT THIS ISSUE AND PEOPLE WHOSE VEHICLE WERE NOT COVERED UNDER WARRANTY HAVE BEEN FORCED TO PURCHASE A VERY EXPENSIVE DOOR SWITCH ASSEMBLY. ALTHOUGH NOT A SAFETY ISSUE TO ME, I CAN SEE HOW THIS ERRATIC BEHAVIOR OF THE HEATED SEATS AND THE POTENTIAL FOR EXTREMELY HIGH TEMPERATURES COULD BE A DANGER TO SOMEBODY WITHOUT ALL THE SENSATIONS IN THEIR LOWER HALF. I HOPE THAT THIS REPORT WILL HELP WITH ANY STATISTICAL ANALYSIS OF HEATED SEAT PROBLEMS THE NHTSA ACCOMPLISHES. AND I HOPE THE ISSUE IS RESOLVED BY GM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10622213August 14, 2014
SERVICE BRAKES
BRAKE LINES FAILED, CAUSING ME TO RUN OFF THE ROAD WHEN TRYING TO AVOID HITTING A DEER. HAD TO REPLACE ALL THE LINES DUE TO CORROSION ON MANY OF THEM. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10621317August 11, 2014
TIRES:SIDEWALL
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE VEHICLE IS EQUIPPED WITH FEDERAL COURAGIA A/T TIRES, SIZE 33512.50R/20LT (NA). THE CONTACT STATED THAT THE SIDEWALLS OF THE TIRES CONTAINED BUBBLES. THE TIRES WERE NOT REPLACED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE TIRE FAILURE MILEAGE WAS 103,000 AND THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10621087August 9, 2014
SERVICE BRAKES
IN THE PROCESS OF EXITING FROM OUR HOME, WHILE TOWING A LARGE BOAT, A BRAKE LINE RUPTURED RELEASING THE BRAKE FLUID AND CAUSING A COMPLETE FAILURE OF THE BRAKE SYSTEM. I INSPECTED THE RUPTURED AREA AND FOUND THAT ALL THE BRAKE LINES WERE SEVERELY RUSTED AND READY TO FAIL AT ANY TIME IN THE NEAR FUTURE. THE VEHICLE WAS TOWED TO A REPAIR FACILITY TO HAVE THE BRAKE LINES REPLACED. ESTIMATED COST IS $950. HAD THIS FAILURE HAPPENED ONE MINUTE LATER THE RESULTS COULD HAVE BEEN CATASTROPHIC! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10629779August 6, 2014
SERVICE BRAKES, HYDRAULIC
COMPLETE BRAKE FAILURE WHEN BRAKES APPLIED IN BRAKE SYSTEM. PEDAL WENT TO THE FLOORBOARD WITHOUT ANY WARNING OR BRAKING ACTION. REAR BRAKE LINE RUSTED THRU ABOVE GAS TANK AND EXPELLED ALL BRAKE FLUID WHEN PEDAL WAS DEPRESSED. THERE WAS NO BRAKING OR SLOWING FROM ANY WHEEL. FLUID WAS ALL OVER TIRE AND AXLE ON THE LEFT REAR. LUCKY THAT I DID NOT HAVE ANY VEHICLES DIRECTLY IN FRONT OF ME AS I HAD TO COAST TO A STOP. DEFINITELY READING THE OTHER POSTS ON THE WEB THAT THIS IS NO FLUKE AND DOES NOT NEED TO BE A HIGH MILEAGE VEHICLE. TRUCK IS NOT USED FOR SNOW REMOVAL AND SEES LIMITED DRIVING DURING WINTER MONTHS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10619419August 6, 2014
SERVICE BRAKES
AFTER PICKING UP MY 5YR OLD GRANDSON, WE CAME TO A STOP SIGN AT A VERY BUSY INTERSECTION WHERE THE CROSS TRAFFIC IS GOING ABOUT 50-60MPH. WHEN I APPLIED THE BRAKES THE PEDAL WENT TO THE FLOORBOARD. I MANAGED TO DEPRESS THE EMERGENCY BRAKE JUST IN TIME TO KEEP FROM BEING HIT BY A SEMI TRUCK GOING VERY FAST. THERE WERE NO WARNING LIGHTS OR INDICATION THAT THERE WAS A PROBLEM WITH THE BRAKES. THE DEALER SAID THE BRAKE LINES HAD RUSTED OUT AND WOULD NEED REPLACEMENT. I CONTACTED GM CUSTOMER SERVICE AND FINALLY GOT TO A COST ASSISTANCE REPRESENTATIVE WHO INFORMED ME THAT GM WOULD NOT HELP DUE TO THE AGE AND MILEAGE OF THE VEHICLE. REALLY, THE TRUCK IS 8 YEARS OLD AND OTHERWISE IN VERY GOOD CONDITION. ALSO I DON'T UNDERSTAND HOW MILEAGE AFFECTS A NON-MOVING PART.I BELIEVE THE BRAKE LINES WERE MADE FROM INFERIOR METAL FOR THIS APPLICATION. TO ME, THE BRAKE LINES SHOULD BE CONSIDERED A SAFETY ITEM SIMILAR TO THE AIR BAGS. IF BRAKE LINES ARE NOW EXPECTED TO FAIL IN VEHICLES 8 YEARS OR OLDER I EXPECT THERE WILL BE A LOT OF INJURED OR DEAD PEOPLE DUE TO THIS. AFTER CHECKING THE INTERNET FOR THE SAME PROBLEM, I COUNTED OVER 300 PEOPLE WHO EXPERIENCED THE SAME ISSUE ON THIS VEHICLE. I BELIEVE GM SHOULD ACCEPT RESPONSIBILITY AND CORRECT THIS ISSUE AND REIMBURSE THOSE WHO HAVE ALREADY HAD THE LINES REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10618909August 5, 2014
SERVICE BRAKES, SUSPENSION, STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
I HAVE FOUND THAT THE STEEL LINES RUNNING ALONG THE FRAME RAILS ARE RUSTING AND FOUND A PATCH IN ONE PLACE AND THE POSSIBILITY OF MORE LEAKS HAPPENING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10619093August 5, 2014
FUEL/PROPULSION SYSTEM, SUSPENSION, SERVICE BRAKES, STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
WHILE LOOKING OVER MY TRUCK PRIOR TO INSPECTION I DISCOVERED THREE CROSS MEMBERS TOTALLY RUSTED THRU. THE ARE ALSO THE MAIN SUPPORTS FOR THE GAS TANK AND THE SHOCKS. I HAVE BEEN TRYING TO FIND REPLACEMENT PARTS AND THE MORE I LOOK THE MORE I HEAR HOW COMMON THE RUSTED CROSS MEMBERS ARE. I WENT TO THE LOCAL DEALERS PARTS DEPT. AND WHEN I ASKED FOR CROSS MEMBERS HE TOLD ME WHICH ONES I NEEDED AND POINTED THEM OUT ON AN ILLUSTRATED BRAKE DOWN. AFTER THE TRUCK BED WAS REMOVED I NOTICED THE EMERGENCY BRAKE CABLE IS RUBBING AGAINST THE PLASTIC GAS TANK AND IS JUST ABOUT WORE THRU THE TANK TO ABOUT THE THICKNESS OF A PLASTIC SANDWICH BAG. THE CABLE HAS ALSO RUBBED AGAINST IT'S SUPPORT BRACKET ALMOST ALL THE WAY THRU AS WELL AS INTO THE CABLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10617476July 30, 2014
SERVICE BRAKES
DRIVING AT ABOUT 35MPH WHEN THE CAR AHEAD PUT ON BRAKES MY PEDAL WENT STRAIGHT TO THE FLOOR AND I ENDED UP USING THE EMERGENCY BRAKE TO STOP. I HAD THE TRUCK TAKEN TO THE DEALERSHIP WHO TOLD ME THE BRAKE LINES WERE COMPLETELY RUSTED OUT. I CALLED CHEVROLET'S SERVICE NUMBER AND WAS TOLD THIS WAS NOT A PROBLEM WITH MY YEAR. BUT IT HAD BEEN IN THE PAST SO NO HELP AVAILABLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10616799July 28, 2014
SERVICE BRAKES
TL* THE CONTACT OWNS 2006 CHEVROLET SILVERADO. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 2 MPH IN REVERSE THE VEHICLE FAILED TO RESPOND TO DECELERATION ATTEMPTS. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE MECHANIC STATED THAT THE BRAKE LINES WERE COVERED WITH RUST. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10616940July 28, 2014
AIR BAGS
THE SERVICE AIRBAG LIGHT CAME ON. CALLED DEALER TOLD ME WARRANTY WAS OVER. I THOUGHT IT IS A NATIONAL WARRANTY ON AIRBAGS BECAUSE OF THE BEING A SAFETY HAZARD FOR THEM TO WORK PROPERLY. UPDATED 4/24/2015 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10616367July 25, 2014
STEERING
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE PIVOT ARM FAILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000. UPDATED 8/28/14*CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10616140July 24, 2014
SERVICE BRAKES
BRAKES SEEMED SOFT WHILE DRIVING ON MOUNTAIN ROADS YESTERDAY. THIS MORNING PUDDLE UNDER THE DRIVER SIDE DOOR AND BRAKES WENT TO THE FLOOR. NO BRAKE WARNING LIGHTS CAME ON. HOUR LATER WHEN TOW TRUCK CAME, MOVED TRUCK FOR TOWING AND BRAKE WARNING LIGHT CAME ON. IT DID NOT WANT TO STOP WITH BRAKES - ROLLED TO STOP. HAD IT TOWED TO DEALER WHO IS CHECKING FOR THE REASON FOR THE LEAK. NOT REPAIRED YET - WAITING FOR DEALER TO GET BACK TO ME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10614802July 20, 2014
SERVICE BRAKES
ANOTHER VEHICLE RAN A RED LIGHT IN FRONT OF ME AND I HAD TO APPLY BRAKES QUICKLY. THE BRAKE LINE RUPTURED , I SWERVED, AND BARELY MISSED THE OTHER CAR. THEY WOULD HAVE BEEN KILLED IF I WAS NOT ABLE TO MOVE INTO THE OPPOSITE LANE. LATTER FOUND THAT THE RUPTURE WAS CAUSED BY EXCESSIVE RUST. HAD THAT SECTION REPLACED BUT ITS TOO EXPENSIVE TO REPLACE ALL THE LINES - WAITING FOR ANOTHER FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610920July 16, 2014
AIR BAGS
7-12-14, 11:15 MTN TIME MY WIFE AND I WERE DRIVING WESTBOUND ON I-76, IN A 2006 CHEVY SILVERADO, 2500 HD DURAMAX DIESEL TOWING A 24" CATALINA 5TH WHEEL, APPROXIMATELY 6,500 LBS, IN THE RIGHT HAND LANE, AT APPROXIMATELY 50 MPH IN COMMERCE CITY, CO APPROACHING 104TH AVE. AT THE 104TH AVE OVERPASS A DRUNK DRIVER PULLED OUT FROM BEHIND THE OVERPASS SUPPORT COLUMN IN THE CENTER MEDIUM AREA OF THE DIVIDED HIGHWAY APPROXIMATELY 1-2 CAR LENGTHS IN FRONT OF US. WE IMMEDIATELY HIT HIS VEHICLE IN THE RIGHT REAR. AT THE TIME HE WAS MOVING FORWARD 2-5 MPH. THE COLLISION WAS CATASTROPHIC WITH VERY SIGNIFICANT DAMAGE TO ALL VEHICLES. THE FRONT AIRBAGS OF THE 2006 CHEVY SILVERADO DID NOT DEPLOY. THIS VEHICLE IS A ONE OWNER VEHICLE. IN 2007 IT WAS INVOLVED IN A FRONTAL ACCIDENT IN WHICH A DRIVER TURNED IN FRONT OF THE DRIVER AT AN INTERSECTION RESULTING IN A FRONTAL COLLISION AT 35 MPH AND THE FRONTAL AIRBAGS DID NOT DEPLOY. CHEVY DID THE REPAIR AND CERTIFIED THE REPAIR OF THE VEHICLE. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10611036July 16, 2014
AIR BAGS
7-12-14, 11:15 MTN TIME MY WIFE AND I WERE DRIVING WESTBOUND ON I-76, IN A 2006 CHEVY SILVERADO, 2500 HD DURAMAX DIESEL TOWING A 24" CATALINA 5TH WHEEL, APPROXIMATELY 6,500 LBS, IN THE RIGHT HAND LANE, AT APPROXIMATELY 50 MPH IN COMMERCE CITY, CO APPROACHING 104TH AVE. AT THE 104TH AVE OVERPASS A DRUNK DRIVER PULLED OUT FROM BEHIND THE OVERPASS SUPPORT COLUMN IN THE CENTER MEDIUM AREA OF THE DIVIDED HIGHWAY APPROXIMATELY 1-2 CAR LENGTHS IN FRONT OF US. WE IMMEDIATELY HIT HIS VEHICLE IN THE RIGHT REAR. AT THE TIME HE WAS MOVING FORWARD 2-5 MPH. THE COLLISION WAS CATASTROPHIC WITH VERY SIGNIFICANT DAMAGE TO ALL VEHICLES. THE FRONT AIRBAGS OF THE 2006 CHEVY SILVERADO DID NOT DEPLOY. THIS VEHICLE IS A ONE OWNER VEHICLE. IN 2007 IT WAS INVOLVED IN A FRONTAL ACCIDENT IN WHICH A DRIVER TURNED IN FRONT OF THE DRIVER AT AN INTERSECTION RESULTING IN A FRONTAL COLLISION AT 35 MPH AND THE FRONTAL AIRBAGS DID NOT DEPLOY. CHEVY DID THE REPAIR AND CERTIFIED THE REPAIR OF THE VEHICLE. *TR
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#10610047July 12, 2014
SERVICE BRAKES
MY WIFE WHILE DRIVING THE ABOVE TRUCK STATED THAT THE BRAKE PEDDLE "FELT FUNNY" AND CONTINUED TO DRIVE IT. SHE STATED THAT SHE HAD ALMOST COMPLETELY LOST THE ABILITY TO STOP. WHEN I WAS ABLE TO INSPECT THE TRUCK I FOUND A RUPTURED BRAKE LINE THAT LEAD TO THE REAR BRAKES. ALSO ALL THE BRAKE FLUID HAD LEAKED OUT OF THE RUPTURED LINE. I HAVE SINCE HAVE HAD ALL THE BRAKE LINES REPLACED WITH STAINLESS STEEL LINES. I AM LEARNING THAT THIS IS AN ON GOING ISSUE WITH THIS MODEL OF TRUCK AND MY CONCERN SHOULD BE OBVIOUS. MY WIFE COULD HAVE SERIOUSLY INJURED HERSELF OR OTHERS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609221July 9, 2014
SERVICE BRAKES
BRAKES FAILED, PEDAL WENT TO THE FLOOR WHEN I WAS PULLING INTO MY DRIVEWAY. CHECKED UNDER TRUCK AND THE BRAKE LINES ARE RUSTED AND 1 OR 2 WERE LEAKING BRAKE FLUID. COULD STOP ONLY BY USING EMERGENCY BRAKE. IF I WAS DRIVING ON THE ROAD I WOULD HAVE HAD AN ACCIDENT. BRAKE LINES SHOULD NOT RUST OUT IN 8 YEARS. THESE TRUCKS NEED TO BE RECALLED. IT IS GOING TO COAST CLOSE TO $1000 IF I REPLACED ALL THE LINES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609256July 9, 2014
SERVICE BRAKES
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE CONTACT DEPRESSED THE BRAKE HARDER AS A RESULT, THE BRAKE LINES FRACTURED AND THE BRAKE FLUID WAS LEAKING. THE CONTACT DISCOVERED THAT THERE WAS RUST UNDER THE VEHICLE WHERE THE BRAKE LINES WERE LOCATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609049July 8, 2014
SERVICE BRAKES
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT AFTER REVERSING OUT OF THE RESIDENTIAL DRIVEWAY, THE FRONT AND REAR BRAKES FAILED. THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT MENTIONED THAT THE VEHICLE CAME TO COMPLETE STOP AFTER THE EMERGENCY BRAKE WAS ENGAGED. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT BRAKE FLUID WAS LEAKING FROM THE BRAKE LINES. THE CONTACT ADDED MORE BRAKE FLUID INTO THE VEHICLE BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE BRAKE LINES WERE FAULTY DUE TO THE SALT DAMAGE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 74,000 AND THE CURRENT MILEAGE WAS 78,000. UPDATED 9/12/14*CN UPDATED 2/12/2015 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Silverado