Chevrolet Silverado Complaints (2019)

1,196 consumer complaints on file.

#11700074November 18, 2025
ENGINE
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving approximately 45 MPH, there was an abnormal knocking, popping, and rattling sound coming from the engine compartment. The contact stated that without shifting to park(P), the vehicle turned off unintendedly. The contact had not attempted to restart the vehicle. The vehicle was then towed to a dealer, where it was diagnosed, and it was determined that the lifters on the right side of the engine needed to be replaced. The contact stated that the camshaft was possibly replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699929November 17, 2025
POWER TRAIN
During the first transfer case fluid service on a 2019 light-duty 4WD truck equipped with an Autotrac two-speed transfer case, the drained fluid was bright red and consistent with automatic transmission fluid rather than the required GM Auto-Trak II blue/green fluid. The transfer case had never been serviced since new, so the fluid appeared to be the original factory fill. Before the discovery, the vehicle occasionally hesitated when shifting between drive modes and sometimes felt as if the system was binding or briefly locking up during transitions between 2WD, Auto, and 4WD modes. These symptoms were intermittent and no warning lights appeared. Using the wrong fluid in this type of transfer case can affect clutch-pack operation and may cause premature wear or loss of proper torque transfer. The system has now been refilled with the correct fluid, and the drained fluid is available for inspection. The issue has not yet been inspected or confirmed by a dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699528November 15, 2025
ENGINE
“2019 Silverado 5.3L – engine knock + oil leak post-warranty install = fire/breakdown risk”
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699245November 13, 2025
ENGINE
"The vehicle has developed a recurring ticking/knocking noise in the engine, worsening under acceleration, accompanied by excessive oil consumption. This is a repeat issue after a warranty repair on June 6, 2022, where all 8 lifters on the right bank were replaced due to AFM/DFM lifter failure. I believe the current problem is caused by metal debris from the initial failure scoring cylinder walls, rings, and bearings, leading to lower-end damage. GM denied coverage under Special Coverage Adjustment N242498000 despite the prior repair and matching symptoms in bulletin PIP5623. Johnson Motor Sales quoted $14,893.89 for engine replacement. The noise and oil loss pose a safety risk of sudden engine failure or loss of power while driving, potentially causing a crash."
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699276November 13, 2025
ELECTRICAL SYSTEM, SERVICE BRAKES, ENGINE
I own a 2019 Chevrolet Silverado 1500. While driving 35 MPH entering the flow of traffic, the vehicle lost power with the engine misfiring. The messages "Service Parking Brake" and "Service ESC" were displayed. The check engine warning light was also illuminated. I drove to the nearest dealership the vehicle was diagnosed that cylinder #5 lifters had collapsed. The dealer informed me that the cylinder lifters needed to be replaced. Additionally, the camshaft would be replaced as necessary. The vehicle was being repaired. The manufacturer will be notified of the failure. The failure mileage was approximately 88,000. and I was informed that my service contract had expired less than 2 months ago
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699073November 12, 2025
ENGINE
Engine lifter failure causing car to breakdown on highway. Car had to be towed and repaired with a new engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698501November 10, 2025
SERVICE BRAKES, ENGINE, ELECTRICAL SYSTEM
As I was driving the vehicle it seems to be hesitating or jerking and when I tried to start it,it would say put your foot on the brakes to start,but my foot was on the pedal and it was slow starting.Days later the engine light came on,took it to the dealership and they told me it was a problem with the brake system.I bought the vehicle brand new,only 41,000 miles,on it now,warranty went out in June of this year.I very rarely drives it and now they saying its a 4,000 job to get it fixed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698209November 7, 2025
POWER TRAIN
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving 40 MPH, the vehicle jerked and vibrated abnormally. In addition, the RPMs fluctuated, and there was an abnormal sound coming from the transmission. No warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the failure persisted. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697840November 6, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that the “Low Oil” warning light was illuminated often, and the contact was adding oil to the vehicle every 2 weeks. The contact became aware of Customer Satisfaction Program: N212326940 (Engine Oil Cooler Lines Detaching from Crimp). The dealer was contacted, and the contact was provided with an estimate of the cost for replacing the coolant lines. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to the dealer. The failure mileage was approximately 94,300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697654November 5, 2025
ENGINE
All or most of the 2019 Chevrolet Silverado 2500 and 3500 models are having the same exact issue, the coolant hoses that cools transmission oil are exposed metal to metal rubbing against each others, and over time from driving normally will eventually cause transmission oil leaks in different areas of the hose element, GM technicians acknowledge it a faulty design from the manufacturer , so GM adapted a customer loyalty program but only to deny a fix or repair at there own expense. This is definitely should fall under a manufacturer recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697660November 5, 2025
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle briefly shuddered and jerked before returning to normal functionality. The vehicle returned to normal functionality, but the failure became a regular occurrence. Several unknown warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the torque converter. The contact was informed that the transmission fluid was flushed and replaced. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 47,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697803November 5, 2025
ENGINE
While driving down the road the engine quit. There were NO indicators of anything wrong. Check engine light was NOT on. It just quit while driving. I didn’t have any notice. I wasn’t even able to get it off of the road. When it did come to a stop. The engine would not restart. I was stranded and had to get a tow. I had it towed to my mechanic and upon inspection, he says it needs a new motor. My truck has ran fine with all the regular maintenance up to this point.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697377November 4, 2025
ENGINE, POWER TRAIN
When driving normal speeds to work on a county road, engine light comes on, service light comes on. There was a tapping noise and reduced power. Luckily, there was a sports field parking lot that I could pull into to get out of traffic. We had the truck towed to our house through our roadside assistance program so that we could determine what to do. If we had not been able to pull off the road as quickly as we did, we probably would have been hit by the semi that was barreling behind us. The truck had reduced power.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697162November 3, 2025
ENGINE
- The engine failed in my 2019 Silverado 1500 6.2l. The truck is available for inspection. - The engine could have seized up while driving causing an accident at any time. - Yes, the dealer found metal shavings in the oil in addition to engine codes P0016 and P0017. - No, the dealer is the only one who has inspected the vehicle and components. - The check engine light came on and the engine was making a loud noises.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697283November 3, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving and depressing the accelerator pedal, the vehicle failed to exceed 35 MPH. The check engine, parking brake, and service engine warning lights were illuminated. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed and determined that the lifters and camshaft needed to be replaced. The vehicle was not repaired. The manufacturer was notified on the failure and informed the contact that the dealer would be contacted; however, the contact was later informed that there would be no assistance provided to repair the vehicle. The approximate failure mileage was 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696987November 2, 2025
ENGINE, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
I was on my way to work and I stoped along the side of the road to help with a car accident. After helping the person and the ambulance arrived I went back to my truck. when I got in it everything was on but I noticed that it was quite and that’s when I realized the truck was not running anymore. I tried to turn it on and off but nothing happened besides all the dash stuff came on. It had been making a ticking noise but it would go away after a certain speed. After the engine would not turn on I had a friend that is a certified Chevy mechanic take a look and he told me the engine seized. It took 2-3x the torque to crank it over and when he was able to do that he found lots of metal shavings in the oil. I been out of a vehicle for almost 2 years now because of this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696902November 1, 2025
ENGINE
engine Failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696804October 31, 2025
ENGINE, ENGINE AND ENGINE COOLING
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at undisclosed speeds and accelerating from a stop light, the vehicle operated under reduced power. The vehicle was sputtering and shuddering. The check engine warning light was illuminated. The contact stated that the failure was related to NHTSA Action Number: EA25007 (Engine, Engine and Engine Cooling). The vehicle was taken to the local dealer, where it was diagnosed with engine failure before reaching the bay. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 136,524.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696851October 31, 2025
POWER TRAIN, SERVICE BRAKES
Truck lost power and began to shake while on the interstate traveling at 75 mph. The check engine light came on. The screen also displayed a message to service the ESC system and the parking brake system. The truck has been maintained at the recommended service intervals. The dealership said the lifters needed to be replaced as well as the electronic brake control module. With a cost of over $8000. The truck has 108,000 miles on it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696384October 29, 2025
ELECTRICAL SYSTEM, ENGINE
There is a common and very dangerous electrical wire routing problem on my vehicle, along with 3 dozen others and my dads (separate but same truck) i confirmed with (FB group for owners of 17-19 L5P GMC diesel trucks) where the alternator positive wire from the alternator to the battery is run right along and across a rather sharp part of molding from the air intake tube. This routing location and rough intake plastic molding rubs through the alternator wire creating a possible electrical short/ corrosion problems that can lead to battery and electrical system compromise, as well as fire risk! A short-circuit condition can cause damage to engine components and, in rare cases, start a fire in the engine compartment. I have 92,000 miles on this 2019, my father has the problem starting on his at only 40,000 miles and may others have issues as well to very degrees of severity between 25 and 150k miles. I discovered this issue while performing routine air filter maintenance and happened to see the rub damage. no modifications have been done, this is the way the wire is routed from the factory. IMO and estimations This issue far supercedes the danger and severity of the recall that currently exists for the engine block heater cord for these models of trucks. 2 of the photos show the damage and exposed wire as soon as i found it. The last shows the location and the part that caused the rub damage along with a temporary mitigation method: electrical tape with a rubber hose installed as a buffer until a permanent fix can be installed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Silverado