Chevrolet Malibu Complaints (2004)

1,582 consumer complaints on file.

#10413305July 18, 2011
SEATS
THE 2004 CHEVY MALIBU MAXX HAS A FAULTY DRIVERS SEAT. THE BASE AND FRAME FRACTURE AND CAUSE THE SEAT TO LEAN TO THE RIGHT AND PROHIBIT IT FROM RISING. THIS HAPPENED ONCE AND WE HAD IT REPLACED AT A COST OF $900. IT HAS HAPPENED AGAIN. I SEARCHED ONLINE AND FOUND A NUMBER OF OTHERS WITH THIS VEHICLE WITH THE EXACT PROBLEM. MY WIFE CANNOT EVEN DRIVE THE CAR WITH THE SEAT SO LOW AND IT IS A SAFETY ISSUE. CHEVY NEEDS TO DO A RECALL AND STOP THOSE OF US WHO HAVE TRIED MULTIPLE FIXES AND IT CONTINUES TO BREAK. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10413371July 18, 2011
STEERING
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED, THE VEHICLE WOULD SUDDENLY LOSE POWER STEERING WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 85,188.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10412063July 12, 2011
SEATS
WHILE DRIVING OUR 2004 CHEVROLET MALIBU MAXX WITH A 6 POSITION DRIVER SEAT, I HIT A POTHOLE AND THE DRIVER SEAT BROKE LOOSE. THIS CAUSED THE SEAT TO DROP DOWN, BACK AND TO THE RIGHT. THIS RESULTED IN A MOMENTARY LOSS OF CONTROL CAUSING ME TO PULL THE STEERING WHEEL TO THE RIGHT AND ENDING UP OFF THE ROAD AND HITTING A SMALL TREE. THE CONTACT TO THE TREE CAUSED DAMAGE TO THE TRIM AROUND THE HEADLIGHT AND THE LENS. INSPECTION FOUND 2 WELDS ON THE SEAT FRAME HAD BROKEN. THE 1ST WELD IS ON THE FRONT CROSS BAR AND RIGHT FRAME RAIL. THE 2ND WELD HAD BROKEN ON THE REAR CROSS BAR AND THE FRAME WHERE THE SEATBELT RECEPTACLE IS ATTACHED. WE CALLED THE CHEVY CUSTOMER SERVICE LINE AND WE WERE TOLD THAT CHEVY HAD NOT HAD RECEIVED COMPLAINTS ABOUT BROKEN WELDS ON THE SEAT FRAME BUT WOULD BE HAPPY TO RECORD OUR CONCERN. WE TALKED TO THE DEALER AND WE WERE INFORMED THAT THIS WAS NOT COVERED UNDER WARRANTY. I ASKED ABOUT RECALLS AND TSB'S REGARDING THIS ISSUE AND WAS INFORMED THERE HAD BEEN NO RECALLS OR TSB'S REPORTED ON THE SEAT FRAME. IN FACT THIS WAS THE FIRST TIME OUR LOCAL DEALER HAD EVER SEEN THIS TYPE OF FAILURE. REPAIR FOR THE SEAT ALONE WILL BE OVER $1,000 NOT TO MENTION THE OTHER DAMAGE CAUSED BY RUNNING OFF THE ROAD.I CALLED IN OUR AREA AND WAS TOLD THIS WAS A COMMON PROBLEM AND THEY COULD NOT KEEP SEATS IN STOCK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10411688July 10, 2011
SEATS
DRIVER'S SEAT WELD IS BROKEN CAUSING SEAT TO TILT TO THE RIGHT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410819July 7, 2011
SEATS
THE FRONT DRIVER'S BECOME LOOSE AND ROCKET TO THE RIGHT SIDE. TOOK THE VEHICLE TO THE DEALER WHO SAID THE SEAT FRAME BROKE. DEALER STATES FRAME MUST BE REPLACED - COST $1200.00 I ASKED IF IT COULD BE WELDED AND HE SAID NO BECAUSE IT'S A SAFETY ISSUE. I'VE NEVER HAD A CAR WHOSE FRAME BROKE FROM NORMAL USE. I SEE ON THE INTERNET THAT THERE ARE MANY OTHER SIMILAR COMPLAINTS AND FEEL THIS SHOULD BE INVESTIGATED FOR A RECALL. I ONLY FOUND OUT ABOUT OTHER BECAUSE OF A AUTOMOTIVE FORUM. THERE ARE MANY OTHERS LIKE THIS WHO I'M SURE DON'T KNOW ABOUT YOUR WEBSITE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410906July 7, 2011
STEERING
2004 MALIBU MAXX HAS LOST POWER STEERING. WEEKS PRIOR THE STEERING TO THE LEFT IS LOOSE AND STEERING TO THE RIGHT IS TIGHT. MECHANIC CANNOT FIND AN ISSUE. FOUND OVER 40 COMPLAINTS IN ONLINE CAR BLOGS OF THE SAME ISSUE. SEVERAL HAD REPLACED STEERING COLUMN ONLY TO FIND THE ISSUE OCCURRED AGAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10409156June 28, 2011
STEERING
POWER STEERING WENT OUT SUMMER 2010; REPLACED POWER STEERING @40,000 MILES. NOW AT 45,000 MILES HAVING SAME PROBLEM. POWER STEERING GOES OUT..NO WARNING; HAVE ALMOST HAD SEVERAL ACCIDENTS BECAUSE OF IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10409232June 28, 2011
STEERING
A CLUNKING NOISE WAS DISCOVERED DURING DRIVING MY NEW CAR. SEND IT BACK TO THE DEALERSHIP AND IT WAS GREASED AND IT STOPPED FOR AWHILE. I HAVE HAD 4 DIFFERENT CHEVY DEALERSHIPS IN CENTRAL TEXAS LOOK AT IT SINCE IT WAS A NEW CAR. IT STILL HAS THAT NOISE AND 190,000 MILES ON IT. IF WHEN AND HOW CAN IT BE FIXED? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10409039June 27, 2011
STEERING
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE POWER STEERING WOULD INTERMITTENTLY FAIL WHILE DRIVING 45 MPH. IN ORDER TO CORRECT THE FAILURE, THE CONTACT WOULD PULL THE VEHICLE OVER AND RESTART IT. THE VEHICLE WAS NEVER TAKEN TO ANY MECHANIC FOR INSPECTION ON THE STEERING. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 87,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10408503June 22, 2011
STEERING
MY POWER STEERING ON MY 2004 MALIBU MAXX LOCKS UP AT RANDOM TIMES, THROWS THE CAR TO THE LEFT, I WAS GETTING THE BATTERY LIGHT AND A DING WHEN THIS WOULD HAPPEN. I HAD THE SERPENTINE BELT CHANGED IN MARCH 2011 THEN THE TENSIONER IN JUNE 2011. I WAS TOLD THAT THIS WOULD CURE THE PROBLEM, AS THESE COMPONENTS ARE LINKED TO THE ALTERNATOR AND THE POWER STEERING PUMP/MOTOR. THIS PROBLEM IS STILL HAPPENING, HOWEVER NOW, I DO NOT GET THE BATTERY LIGHT, JUST A DING WHEN THE STEERING LOCKS AND THE CAR VEERS TO THE LEFT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10408413June 21, 2011
STEERING
DRIVING THROUGH A RESIDENTIAL DISTRICT THE CHECK POWER STEERING MESSAGE FLASHED ON THE DASHBOARD AND THEN THE POWER STEERING JUST STOPPED FUNCTIONING. CAR WAS VERY HARD TO MANEUVER AND STEER. ONCE RESTARTED, POWER STEERING RESUMED. SINCE THAT INCIDENT, THE POWER STEERING FAILED ONCE AGAIN WHILE CAR WAS IN PARK ON 6/20/2011. THEN ONCE CAR WAS RESTARTED THE POWER STEERING RESET ITSELF. VERY VERY DANGEROUS!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407577June 20, 2011
STEERING
WHILE DRIVING, THE SERVICE WARNING LIGHT WOULD COME ON AND THE POWER STEERING ASSIST WOULD GO AWAY. I AM LEFT WITH NO POWER ASSISTED STEERING. THIS IS A VERY SCARY AND DANGEROUS PROBLEM TO HAVE. MOST OF THE TIME I HAVE BEEN ABLE TO PULL OVER, SHUT OFF THE CAR, AND THEN STEERING WOULD COME BACK. THIS MORNING, THE STEERING WENT OUT WHILE DRIVING ON A CURVY ROAD. FIRST THE STEERING WHEEL SHOOK WHILE ENTERING A TURN, THEN I ALMOST LOST CONTROL AND HIT ANOTHER CAR HEAD-ON WITH MY KIDS IN THE CAR. AS I SEARCHED THE INTERNET I DISCOVERED THIS PROBLEM HAS BEEN REPORTED THOUSANDS OF TIMES. HOW CAN THIS NOT BE A RECALL? IS IT BECAUSE ENOUGH PEOPLE HAVEN'T DIED YET? *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407348June 18, 2011
STEERING
ELECTRIC ASSIST POWER STEERING UNIT FAILED. NEARLY CAUSING A SERIOUS ACCIDENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407285June 17, 2011
STEERING
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING A RECURRING FAILURE IN WHICH THE POWER STEERING WOULD FAIL AND THE STEERING WHEEL WOULD BE VERY DIFFICULT TO TURN. THE FAILURE OCCURRED WHILE DRIVING AT VARIOUS SPEEDS. WHENEVER THE FAILURE OCCURRED, THE VEHICLE WOULD BE NAVIGATED TO THE EMERGENCY LANE AND SHUT OFF. AFTER ALLOWING THE VEHICLE TO COOL DOWN IT WOULD RESTART AND FUNCTION NORMALLY. DURING THE FAILURE, A POWER STEERING SERVICE LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT THE FAILURE ONLY OCCURRED DURING WARM WEATHER AND THE STEERING COLUMN WAS REPLACED PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON SEVERAL OCCASIONS WHERE THE CONTACT WAS INFORMED THE STEERING COLUMN NEEDED THE BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 43,000 AND THE CURRENT MILEAGE WAS 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407321June 17, 2011
STEERING
MY 2004 CHEVY MALIBU IS HAVING AN ISSUE WITH THE POWER STEERING ASSIST SYSTEM. YOU LOSE POWER STEERING WITHOUT WARNING. I CONTACTED CHEVY OVER THIS AND THEY PRETTY MUCH SAID THERE WAS NOTHING THEY COULD DO. BUT THERE IS NUMEROUS ISSUES WITH THIS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407117June 16, 2011
SEATS
DRIVER SEAT BROKEN AT WELD MOUNT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407188June 16, 2011
STEERING
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT WAS DRIVING 55 MPH WHEN THE STEERING WHEEL LOCKED ABNORMALLY AND THE CONTACT WAS UNABLE TO MANEUVER THE STEERING WHEEL. HE ALSO MENTIONED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER BUT THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE, STATING THAT THERE WERE NO RECALLS FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 113,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10405568June 8, 2011
STEERING
ON TUESDAY, JUNE 7, 2011 THE POWER STEERING ON MY 2004 CHEVY MALIBU LS SUDDENLY WENT OFF WHILE USING THE TURN SIGNAL TO CHANGE LANES AT 5-10MPH. A POWER STEERING PROBLEM WAS POSTED ON THE DIGITAL DISPLAY AND THE CAR ICON WITH A WRENCH LIT UP. STEERING WAS VERY DIFFICULT, WORSE THAN MANUAL AND FELT LOCKED. I WAS TERRIFIED AND IMMEDIATELY DROVE TO THE MECHANIC AND LEFT THE CAR FOR THEM TO INSPECT. THEY REPORTED THAT THE CAR STARTED UP PROPERLY AND THERE WAS NO PROBLEM WITH THE POWER STEERING THAT THEY COULD DETECT. THEY DROVE IT SEVERAL TIMES DURING THE DAY BUT DID NOT EXPERIENCE THE POWER STEERING FAILURE. THEIR RESEARCH INDICATED THAT THERE WERE COMPLAINTS ON THIS MODEL AND THE STEERING COLUMN MAY BE DEFECTIVE. I ALSO CHECKED ON THE INTERNET AND FOUND MANY COMPLAINTS WITH THE SAME PROBLEM. I BELIEVE THAT THIS PROBLEM IS POTENTIALLY A SERIOUS ACCIDENT THREAT WITH POSSIBLE DEATH OCCURRING AND SHOULD BE RECOMMENDED FOR RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10405647June 8, 2011
STEERING
I OWN A 2004 MALIBU MAXX,IMY POWER STEERING GOES OUT CONSTANTLY,WHILE DRIVING AT A SPEED OF 30 MPH OR 60 MPH.I RECENTLY WAS ON THE HIGHWAY WITH MY CHILDREN AND IT WENT OUT WHILE I WAS MAKING A TURN AND I ALMOST WENT OFF THE ROAD .SCARED ME AND MY KIDS TO DEATH....SOMETHING HAS TO BE DONE ABOUT THIS....I HAVE READ TOO MANY STORIES ABOUT THE SAME PROBLEMS WITH VARIOUS PEOPLE..DOES SOMEONE HAVE TO LOOSE THEIR LIFE TO GET A RECALL ON THIS OR WHAT!!!!!!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10404155June 2, 2011
SEATS
THE DRIVERS FRONT SEAT LEANS TO RIGHT WHEN TILTED HAVE TO KEEP ALL THE WAY DOWN SO IT DOESN'T WOBBLE. THE WELD ON THE SEAT FRAME BROKE CAUSING IT TO LEAN TO THE RIGHT AND BE UNSTABLE. ALSO POWER STEERING WILL RANDOMLY STOP WORKING IN THE MIDDLE OF DRIVING. YOU HAVE TO SHUT THE CAR OFF AND TURN IT BACK ON TO GET POWER STEERING BACK. DEALER SAID THEY RECALLED THE ISSUE BEFORE WE BOUGHT THE CAR AND IT IS BACK AGAIN SAME ISSUE NOW ITS APPARENTLY NOT COVERED SINCE THEY SAID THEY FIXED IT BEEN HAPPENING FOR A FEW YEARS NOW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Malibu