Chevrolet Malibu Complaints (2004)

1,582 consumer complaints on file.

#11427384August 1, 2021
UNKNOWN OR OTHER
I have Chevy Malibu Maxx and none of the recall issues have been taken care of. I would like to get these recalls taken care of before I have accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11417453May 17, 2021
STEERING
Eps goes out. At first only happened when I first started my car but if I restarted it then the issue went away. Problem increased over time & power steering went out while driving. Now it just won’t come back on. Wheel “twitches” or “seizes” on its own. If I put cruise control on the speed increases slightly on its own overtime on its own. It is available for inspection upon request. My safety surely felt at risk & I felt my dogs safety was at risk too. Also any of my passengers safety or anyone else on the road at that time for that matter , had I not been paying 110% attention & noticed the check engine light some on / power steering go out, I could have crashed or someone else could’ve hit me, etc.. Power steering went out while driving quite a few times & I’ve seen numerous complaints for these issues with this same year & model so it has to be a defect not just a personal issue. Have seen comments/reviews all over the internet about these issue , mostly the electric power steering , and even some that say they had replaced their steering column on 3 separate occasions out of pocket with no help resolving this issue from gm or Chevrolet. They first appeared as soon as the power steering went out. No lights prier & no power steering warning on the radio dash thing. (It says when I’m low on washer fluid, or when the power steering goes out, etc.. across my radio)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11415321May 5, 2021
STEERING
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT 60 MPH, THE STEERING WHEEL SEIZED NOT ALLOWING THE CONTACT TO HAVE CONTROL OF THE VEHICLE. AS A RESULT, THE VEHICLE RAN INTO A SIDE BEARING. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED SOME BACK SORENESS. THE VEHICLE WAS ABLE TO START BACK UP AND THE CONTACT DROVE THE VEHICLE BACK HOME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 255,450.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11413507April 23, 2021
ELECTRICAL SYSTEM, STEERING
THE SENSOR AND OR POWER STEERING ASSIST IS MALFUNCTIONING AND SENDING WARNING AND SHUTS DOWN THE ELECTRIC STEERING ASSIST. MUST TURN VEHICLE OFF AND THEN RESTART SEVERAL TO GET STEERING TO RELEASE. THERE WAS NO NOTICE GIVEN TO [XXX] WHEN THE RECALL(S) WERE ISSUED FOR 2004 CHVY MALIBU. STATIONARY THUS FAR. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11408197April 15, 2021
SERVICE BRAKES, STEERING, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
POWER STEERING UPON IGNITION LIGHTS UP AND LOCKS POWER STEERING. TURN OFF AND RESTART SEVERAL TIMES BEFORE OPERATIONAL. ABS LIGHT INTERMITTENTLY COMES ON WHILE DRIVING. ELECTRIC ASSIST POWER STEERING. BOTH IN STATIONARY AND WHILE DRIVING IN CITY AND HIGHWAY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11399353March 5, 2021
STEERING
RECALL # 14E044000, VIN# [XXX]. THE VEHICLE EXHIBITS STEERING ISSUES AS DESCRIBED IN 14E044000 AND DIAGNOSED BY A MECHANIC. BROUGHT VEHICLE TO THE CHEVROLET DEALER AND THEY STATE THERE ARE NO RECALLS BASED ON VIN. HOW TO DETERMINE SPECIFIC VINS THAT ARE IMPACTED? WAS DRVING ON 3/1/21 AND STEERING BECAME ERRATIC. TOOK VEHICLE TO MECHANIC IMMEDIATELY WHERE IT WAS DIAGNOSED. MECHANIC STATED THERE WAS A RECALL AND TO CONTACT CHEVROLET. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11397298February 22, 2021
STEERING
STEERING MECHANISM IS OUT CAN'T CONTROL CAR HAVE TO TURN IT OFF AND ON AND CONTINUES TO GO OUT WHILE DRIVING THE VEHICLE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11390770January 30, 2021
STEERING
DRIVING ON CITY STREETS AT APPROXIMATELY 35 MPH WHEN SUDDENLY THE POWER (ASSIST) STEERING GOES OUT...THE CHECK ENGINE LIGHT IS ILLUMINATING...THE RADIO SCREEN STATES 'POWER STEERING' AS AN AUDIBLE CHIME WAS HEARD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11389002January 20, 2021
EXTERIOR LIGHTING, STEERING
FIRST, THE CAR ROUTINELY BURNS OUT TURN SIGNALS, AND OVERHEATS THE TURN SIGNAL TO THE POINT THAT IT MELTS THE HOUSING THTA THE LIGHT BULB SNAPS INTO. I HAVE HAD TO REPLACE THE HEADLIGHT HOUSING/LAMP WIRINGS HARNESS MULTIPLE TIMES ALONG WITH MANY LIGHT BULBS. SECOND, THERE IS A RECALL FOR THE ELECTRONIC POWER STEERING. MY PARTICULAR VIN WAS RECALLED FOR AN ELECTRONIC POWER STEERING SENSOR. THE POWER STEERING HAS GONE OUT ON ME WHILE DRIVING TWICE, SO I BROUGHT IT TO THE DEALER. THEY INDICATED THE ELECTRONIC POWER STEERING MOTOR NEEDS TO BE REPLACED,AND IS NOT COVERED UNDER AND RECALLS. THERE APPEARS TOBE NUMEROUS RECALLS ON GM VEHICLES RELATED TO THE ELECTRONIC POWER STEERING, AND REPLACING MOTORS FOR THAT MATTER, BUT THE DEALER HAS INDICATED THERE IS NO SUCH RECALL RELATED TO MY PARTICULAR VEHICLE/VIN. THIS SEEMS RATHER SUSPECT WITH THE NUMBER OF RECALLS RELATED TO THESE VEHICLES, AND FOR ME TO HAVE THE STEERING GO OUT, BUT MY PARTICULAR VEHICLE DOES NOT QUALIFY. I WAS DRIVING ON A CITY STREET WHEN IT WENT OUT ONCE. I MADE IT HOME SAFELY, ALBEIT VERY HARD TO TURN THE WHEEL, AND THEN THE POWER STEERING WORKED AFTER TURNING OFF THE VEHICLE AND BACK ON AGAIN. IT WENT OUT AGAIN IN THE PARKING LOT OF THE CAR DEALER WHEN DROPPING IT OFF THE BE LOOKED AT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387454January 11, 2021
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
AFTER STARTING ENGINE, ENGINE WILL TURN OFF AND RADIO DISPLAY SCREEN WILL READ 'ENGINE POWER REDUCED.' ENGINE WILL NOT START FOR SEVERAL MINUTES, BUT THE LIGHTS, RADIO, DASH LIGHTS AND EVERYTHING WILL STILL WORK. THIS HAS HAPPENED IN MY DRIVEWAY. THE FIRST TIME THIS EVER HAPPENED I WAS ON A BUSY MAIN ROAD AT A STOP LIGHT IN THE LEFT TURN LANE. THE CAR SHUDDERED AND THE ENGINE LOST POWER. AGAIN, THE DISPLAY SCREEN DISPLAYED THE SAME MESSAGE. THE CAR WAS ROLLING BACKWARDS AND WOULD NOT ACCELERATE. AFTER SEVERAL ATTEMPTS THE ENGINE DID START AGAIN. THANKFULLY IT WAS 6:00 AM AND I WAS ON MY WAY TO WORK SO THERE WAS VERY LIGHT TRAFFIC.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11383780December 16, 2020
ENGINE, STEERING
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS, THE STEERING WHEEL WAS LOOSE. THE CHECK ENGINE AND POWER STEERING WARNING LIGHTS WERE ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS TAKEN TO SERRA CHEVROLET 7850 US-64, MEMPHIS, TN 38133, (901) 328-9262) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS IN BAD CONDITION. THE DEALER DECLINED TO COMPLETE THE RECALL REPAIR. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 225,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11374793November 16, 2020
ELECTRICAL SYSTEM, STEERING, SUSPENSION
ELECTRICAL WIRES/COMPONENTS ISSUES, INSTRUMENT CLUSTER LIGHTS NOT TURNING ON, VEHICLE WITH A WRENCH INDICATOR LIGHT COMES ON & OFF, TRACTION CONTROL WITH A SLASH ON TC INDICATOR LIGHT COMES ON & OFF (TC/), WHEN MY CAR IS RUNNING AN IDLING OR PARKED OR IDLING AT A STOP LIGHT OR DRIVING IN A CERTAIN SPEED LIMIT THE STEERING WHEEL SHACKS/SHUDDERS REPEATEDLY MOVING ON ITS OWN ONCE IN A AWHILE BUT NOW IT CONSTANTLY GETTING WORSE LASTING LONGER, ENGINE LIGHT STAYS ON EVEN AFTER I REPLACED THE PARTS OBDLL SCANNER SAY WHAT TO FIX & REPLACE, OWNED THE CAR OVER A 1 YEAR AN BUILD KNOWLEDGE ABOUT THE CAR AND GOOGLE RECALLS AFTER OWNING IT. I BELIEVE IT'S (POWER STEERING WHEEL COMPONENTS OR POWER STEERING WHEEL ASSIST MOTOR) I WAS DRIVING IN THE FREEWAY WITH MY BABIES GOING 65 SPEED LIMIT & I LITERALLY SEEN LIFE FLASHED BEFORE MY EYES WHEN THE STEERING WHEEL WON'T TURN/LOCKS UP IN A BUSY FREEWAY. IT WAS BEYOND THE WORSE EXPERIENCE OF MY LIFE BECAUSE MY BABIES IS IN THE CAR WHEN IT HAPPENED, I DON'T EVER WANT IT TO HAPPEN AGAIN EVER OR TO ANYONE ELSE. PLEASE & THANK YOU IF YOU CAN FIX IT, IT'S OUR ONLY TRANSPORTATION FOR MY SPOUSE & BABIES. AN ONE MORE OTHER THING IS "I DON'T KNOW IF IT'S A PART OF IT THE THROTTLE BODY MALFUNCTION". I HOPE THAT'S ENOUGH & ACCURATE INFORMATION ABOUT IT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11360041September 20, 2020
STEERING
IT FEELS AS THOUGH THE STEERING IS LOOSENING. ALIGNMENT IS OFF AS WELL. BOTH ISSUES BEGAN ABOUT THE SAME TIME. A DULL CLUNKING SOUND CAN BE HEARD WHEN TURNING RIGHT. THIS CAR APPEARS TO HAVE ALREADY HAD THE STEERING REPLACED FROM THE 2014 RECALL BUT I BELIEVE THE REPLACEMENT PARTS ARE ALSO DEFUNCT AND SHOULD AND WILL BE RECALLED AGAIN. IT IS NOT SEEMINGLY DEPENDENT ON SET RPM OR MPH TO MAKE THE NOISE OR FEEL LOOSE IN MY HANDS. IT IS INTERMITTENT AND UNPREDICTABLE. CRUISE CONTROL STILL WORKING, EPS LIGHT NOT LIT. STRUTS ARE GOING SO MAY BE THE ISSUE. JUST IN CASE IT IS THE POWER STEERING HAVING NOT PROPERLY BEEN REPAIRED AFTER THE RECALL, OR REPAIRED WITH SHODDY PARTS, I THOUGHT IT BEST TO REPORT THE ISSUE. LIVES WERE LOST TO THE IGNITION SWITCH FAILURES FROM CHEVY, LUCKILY I PULLED INTO A SHOP IMMEDIATELY AFTER MY CAR SHUT OFF THE FIRST TIME AND GOT IT REPAIRED. MONTHS LATER PEOPLE WERE DYING. FRIENDS OF MINE. NOT ME. I TRUSTED MY GUT. I KNEW THAT WAS DANGEROUS AND I HAVE THE SAME INCLINATION NOW WITH THIS ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11353253September 4, 2020
ELECTRONIC STABILITY CONTROL (ESC), STEERING, WHEELS
WHILE DRIVING CAR STEERING WHEEL STARTED TO MAKE A CLICKING SOUND BOTH LEFT AND RIGHT THEN WHEN I STOPED CAR BATTERY NEEDED TO BE JUMPED STARTED BECOME HARD TO CONTROL CAR AND IT SEEMED AS IF CAR WANTED TO LOSE POWER I WAS ON WATERMAN AND BASELINE. ON THE STREET WHEN IT BEGAN..07/15/2020 I HAD RECALL N140226 14116 WITH A CHEVY MANUFACTURER MALIBU DEALERSHIP
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11353046September 3, 2020
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED HOWEVER, THE BRAKE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE MECHANIC DETERMINED THAT THE BRAKE MODULE NEEDED TO BE REPLACED. PORTER CHEVROLET (414 E CLEVELAND AVE, NEWARK, DE 19711) WAS CONTACTED AND INFORMED THAT THE FAILURE NEEDED TO BE REPAIRED OUT OF POCKET. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT SUBJECTED TO ANY RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 169,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11349163August 14, 2020
STEERING
THERE HAS ALREADY BEEN A RECALL THAT THEY SAY WAS FIXED. HOWEVER IT IS DOING THE EXACT SAME THING NOW.I HAVE PAID TO FIX IT AND IT HAD A RECALL. WHAT HAPPENS IS YOU R JUST DRIVING AND ALL OF A SUDDEN THE POWER STEERING GOES OUT. YOU CAN BARELY STEER THE CAR TO GET IT OFF THE ROAD. I DO NOT HAVE THE MONEY TO KEEP FIXING THE SAME PROBLEM OVER AND OVER. IT IS DOING IT NOW.. THIS WILL HAPPEN ANYWHERE CITY, HIGHWAY. LITERALLY ANYWHERE YOU MIGHT BE. IT HAS HAPPENED NUMEROUS TIMES BUT I PUT THE LAST DATE IT HAPPENED. I HAVE PRETTY MUCH HAD TO STOP DRIVING THE CAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11342187July 30, 2020
SEAT BELTS, SEATS
THE DRIVER SIDE SEAT THAT IS WELDED TO THE FRAME OF THE CAR HAS BROKE. THE RIGHT SIDE OF MY DRIVERS SIDE SEAT NOW COLLAPSES WHEN DRIVING WHICH IS EXTREMELY DANGEROUS NOT TO MENTION THE SEATBELT IS ATTACHED TO THE RIGHT SIDE OF THE SEAT AND BUCKLED INTO IT WHICH IS NOW COLLAPSED WHICH COULD CAUSE A MAJOR ISSUE IF I WAS TO EVER GET INTO AN ACCIDENT. I HAVE DONE SOME REASEARCH ONLINE AND THIS APPEARS TO BE A COMMON ISSUE AMONGSTS MOST 2004 MALIBU OWNERS. I AM THE SECOND OWNER AND I GET THE CAR IS CLOSE TO BEING 20 YEARS OLD BUT MINE ONLY HAS 60K MILES THE DRIVERS SEAT WELD SHOULD NOT JUST DETACH AND COLLAPSE WHILE DRIVING ON A PRACTICALLY BRAND NEW CAR. NOT TO MENTION I AM AN AVERAGE SIZED MAN 200 LBS 5 FOOT 7 ON TOP OF THAT I ENQUIRED TO FIX IT AT MY LOCAL CHEVROLET DEALER AND IT WILL COST WELL OVER 1000 DOLLARS BASED ON A VERBAL ESTIMATE. I CAN JERRY RIG THE SEAT TO NOT COLLAPSE BUT THAT DOESNT STOP THE FACT THAT GOD FORBID IM IN AN ACCIDENT MY DRIVERS SEAT COULD POTENTIALLY BECOME DETACHED HURLING MYSELF AND THE SEAT INTO THE WINDOW CAUSING SEVERE BODLY HARM OR WORSE DEATH. PLEASE LOOK INTO THIS AS IM SURE MANY OTHER PEOPLE HAVE THIS SAME PROBLEM IT IS A FAULTY WELD IN THE DRIVERS SEAT AND NEEDS TO BE ADRESSED BY THE MANUFACTURER CHEVROLET
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11338113July 8, 2020
ELECTRONIC STABILITY CONTROL (ESC), STEERING, SUSPENSION
THE DASH HAS ABS, TCH AND SECURITY LIGHT COMES SHORTLY AFTER CAR HAS BEEN STARTED WITH IN SCOUND COMES A BEEPING SOUND WERE ALL THREE LIGHTS STAY ON UNTIL ENGINE IS CUT OFF. THE LIGHT BULBS HAS MELTED PLASTIC COVER ON THE FRONT TURN SIGNAL/PARK LAMP DRL. WHEN SPEED IS INCREASING ON HIGH WAY FREE WAY CAR TENDS TO PULL LEFT ON ITS OWN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11338166July 8, 2020
ELECTRONIC STABILITY CONTROL (ESC), ELECTRICAL SYSTEM, EXTERIOR LIGHTING
HAD TO REPLACE HEAD LIGHT BULBS HAS MELTED PLASTIC COVER DASHBOARD HAS WARNING LIGHTS THAT COME ON AND STAY ON
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11329336June 17, 2020
POWER TRAIN
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN THE VEHICLE SHIFTED INTO NEUTRAL INDEPENDENTLY WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL TO STOP THE VEHICLE. THE CONTACT ATTEMPTED TO MANUALLY SHIFT THE VEHICLE INTO PARK HOWEVER, THE TRANSMISSION FAILED TO ENGAGE. THE CONTACT PUSHED THE VEHICLE OVER TO THE SIDE OF THE ROADWAY. THE VEHICLE WAS TOWED TO MIDWAY CHEVROLET (2323 W BELL RD, PHOENIX, AZ) WHERE IT WAS DIAGNOSED AND DETERMINED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) AS A POSSIBLE SOLUTION TO THE FAILURE, HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS CONTACTED HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Malibu