Chevrolet Bolt EV Complaints (2022)

59 consumer complaints on file.

#11517716April 18, 2023
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, VEHICLE SPEED CONTROL
Not necessarily a failure or malfunction. When making right/left turns vehicle will accelerate for apparently no reason. Each time entering a parking lot or making a standard right/left turn. Each time this has happened during this acceleration it has almost caused a vehicle crash with another car in front or in another incident almost hit pedestrian. Found that the Rocker switch for Cruise control is being hit accidentally causing Cruise control to become activated causing the vehicle to accelerate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516832April 13, 2023
ELECTRICAL SYSTEM, STRUCTURE, SEAT BELTS
The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) and 22V930000 (Structure, Seat Belts) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11513951March 27, 2023
TIRES:SIDEWALL
The contact owns a 2022 Chevrolet Bolt EV equipped with Michelin Tires, Tire Line: Energy Saver A/S, Tire Size: 215/50/R17, And DOT Number: N/A. The contact stated that while driving over a pothole the front driver's side tire sidewall failed causing the tire to go flat. The contact stated upon inspecting the vehicle tires, he noticed a bubble on the rear driver's side tire. The vehicle taken to the local dealer who replaced the tire; however, while driving over a pothole, the replacement tire experienced a sidewall failure. The contact stated that the same tire sidewall had failed on three separate occasions. The manufacturer was not notified of the failure. The cause of the failure were not determined. The failure mileage was 5,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11513502March 23, 2023
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
The contact owns a 2022 Chevrolet Bolt EV. The contact stated while pulling out of a parking lot, the vehicle stalled, failed to shift into gear and would not turn off. A towing agent disconnected the battery and the vehicle turned off. The vehicle was then towed to the dealer where it was diagnosed that the service disconnect fuse had blown. The vehicle was repaired; however, the failure reoccurred while driving. The vehicle was towed to the dealer where the engine control module (ECM) was replaced, however, the failure reoccurred upon starting the vehicle. The vehicle was towed to the dealer. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened; however, the manufacturer had not followed up or returned the contact's calls. The failure mileage was approximately 6,612.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504229January 28, 2023
SERVICE BRAKES
While braking I have had multiple cars almost crash into the rear of my vehicle due to the breaking system of the vehicle. The break lights are too low and people expect the “running lights” on the rear to indicate breaking. I have also had multiple people tell me my break lights are out due to this. This is a safety issue be the design of the breaking system, I have found multiple forums of owners who have been rear ended for this exact issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11500805January 9, 2023
AIR BAGS
The contact owns a 2022 Chevrolet Bolt EV. The contact stated while driving 10 MPH, the air bag SRS warning light illuminated. The contact stated that the failure recurred intermittently. The vehicle was taken to the dealer where it was diagnosed that an air bag electrical wire was loosened. The dealer tightened the air bag wire; however, the failure persisted. The vehicle was taken back to the dealer where it was diagnosed that an unknown air bag needed to be replaced; however, the part would not be available for three months. The dealer later informed the contact that the part was available, and the vehicle was taken back to the dealer. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 2,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11499592December 30, 2022
POWER TRAIN
While driving at highway speed, vehicle lost drive and a message stating to pull over was displayed. Vehicle then shifted into Park (P) and was unable to shifted into Drive (D) or Reverse (R). Vehicle towed to dealer, where it was for 7+ weeks before being repaired.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11495267November 29, 2022
LANE DEPARTURE: ASSIST, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, UNKNOWN OR OTHER
The system in question is the Super Cruise hands free driving system. There has been several instances where the system has swerved the vehicle without warning or reason. There have been several instances where the system has failed on mapped road. There have been several instances where the vehicle wouldn't drive in the center of the lane, but instead on the lines or too close to other vehicles. I have dash cam footage and cell phone footage of the system failing and can duplicate it without issue. The vehicle spent over 30 days at the dealer and they were unable to fix it. The message that will appear when the system intermittently won't activate is "super cruise unavailable" I have attempted to work with my dealer, GM, and Onstar and nothing has been done to take my safety seriously or to fix the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11494379November 21, 2022
EXTERIOR LIGHTING
The car was changed for 2022 where the brake lights are no longed displayed with the tail lights and instead lower down in the bumper area on small lights. Cars following me do not notice these lights and end up almost hitting me. The dealer states that this is how GM has changed the lights from the prier year. Last year they would only go to the lower light if the tail gate was open for some reason. Which I thing is a good design but the way my car is now is very dangerous and is an acident waiting to happen.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11493485November 14, 2022
POWER TRAIN
The contact owns a 2022 Chevrolet Bolt EV. The contact stated that while his wife was driving 70 MPH, the vehicle inadvertently decelerated to 30 MPH with the transmission warning light and three other unknown warning lights illuminated. The failure nearly caused a collision. The vehicle was towed to the dealer; however, the dealer was unable to duplicate the failure. The dealer determined that the negative battery terminal cable was faulty and replaced the negative battery terminal cable. The failure recurred, and the vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 9,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11488609October 10, 2022
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Around 5 PM on 10/7/22 I was driving on Purcell Road in Manassas VA. The car has a 60% charge on it EV battery showing a range of around 170 miles. As I was driving I felt the Chevrolet Bolt stutter twice, as if it was loosing power. Then, when I stopped at the stop light at Purcell and Hoadly the car shifted into park and would not shift into any other gear, including neutral. Any attempts to shift would give an error warning "Conditions Not Correct for Shift" In addition to being unable to move the car out of the intersection, the car could not be shut down. Pressing the power button would make the screen flicker for a moment and then it would power itself back on with the same "Conditions Not Correct for Shift" error. Onstar was called about the problem and shortly after the police arrived to tow the car. The car was a traffic hazard since it could not be put into neutral to get it out of traffic. The car was taken to Lindsay Chevrolet Service Center (15605 Jefferson Davis Hwy, Woodbridge, VA 22191) for diagnostic and repairs. They have reported that the problem was a wiring harness.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11485623September 21, 2022
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
I was driving the vehicle approx 35mph on a surface street when it suddenly lost propulsion. There was no warning. The display suddenly showed 0 rand and 0% high voltage battery SOC. I had to cross multiple lanes of rush hour traffic with no propulsion to coast to a stop. Once parked the vehicle would not go in gear and would not move. It was towed to a dealer where a blown manual service disconnect lever (high voltage battery fuse) was found to be blown. The dealer determined the root cause to be a faulty level 2 charging station I used earlier in the day. After contacting the charging station vender there was no fault found with the station and no other complaints filed with its operation. The fuse blew 6 miles after being charged, not while it was charging. I asked for the dealer to contact Chevrolet engineering and they declined. I contacted Chevrolet customer service and was not able to speak with anyone that is familiar with their EV products.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11485155September 19, 2022
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
2022 CHEVROLET BOLT. CONSUMER WRITES IN REGARD TO NHTSA SAFETY RECALL 21V-650 BEING INCOMPLETE. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING/DETERMINING A FIX FOR THE RECALL REPAIR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11483455September 8, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM
The contact owns a 2022 Chevrolet Bolt EV. The contact stated that the computer would intermittently glitch while driving at various speeds. The contact also stated that upon approaching a stop, the brakes failed to operate as needed and the contact was forced to depress the brake pedal to the floorboard. There was no warning light illuminated. The contact called the dealer and an appointment was scheduled to have the vehicle serviced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was 635.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11483093September 6, 2022
ELECTRICAL SYSTEM
The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11479796August 17, 2022
FUEL/PROPULSION SYSTEM
Vehicle will not charge passed 30%, receiving a reduced propulsion reduced message. Code P0BBD. Also No air conditioning. GM is holding the car till there's a fix and they have NO ETA and NO communication about an ETA. I'm irate and need my car back yesterday.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11479297August 15, 2022
POWER TRAIN
While pulling into a parking spot the car made a loud noise and came to a complete stop. Car was able to pull into the spot. When the car was turned on after parking a warning message came up to service transmission, unable to shift soon. Vehicle was driven to dealer for service and would make thud noises when decelerating at low speed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476434July 28, 2022
FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
As I drove my brand new 2022 Bolt (in use 30 days) into garage, the dash check engine light came on with a notice "reduced power propulsion." The battery was at about 50%. I tried to charge it and the dash indicated "charge complete." The reduced power propulsion message is concerningly similar to the error from the previous Bolt recalls that have resulted in fires. I took the car to my dealer and they have had it for 40 days and counting and say they don't know when it will be fixed nor do they know yet how to fix it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476226July 27, 2022
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
My backup camera and surround cameras are not working. I’m getting a triangle icon and camera icon with a line through it. It first appeared when I was backing out of my driveaway then the camera worked again briefly. Now the camera is not turning on at all.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11475409July 22, 2022
POWER TRAIN
Bought vehicle 22 jul 2022 new 5 mi on odometer. System displays: service transmission unable to shift soon. Please google it. It's a common issue that isn't safe. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Bolt EV