Chevrolet Aveo Complaints (2004)

206 consumer complaints on file.

#10596682June 6, 2014
AIR BAGS
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE FLOOR MAT SENSOR AND CLOCK SPRING NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,950.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10595801June 3, 2014
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT WHEN THE KEY WAS REMOVED FROM THE IGNITION, IT WAS EXTREMELY HOT. THE VEHICLE WAS TAKEN TO MULTIPLE INDEPENDENT MECHANICS. THE TECHNICIANS WERE UNABLE TO PROPERLY DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10592542May 19, 2014
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM:IGNITION
WHILE IN MY DRIVEWAY, I WENT TO TURN IGNITION ON, AND CAR WOULD NOT START. RADIO TURNED OFF. IT WAS NOT UNTIL I FLOORED THE PEDAL THAT THE GAS AND MOTOR STARTED. IT HAPPENS OFF AND ON. ALSO THE KEY AND IGNITION SWITCH ENTRY AREA ARE EXTREMELY HOT. I AM WORRIED THIS IS IN FACT ONE OF THE IGNITION PROBLEMS THAT CHEVY DID NOT LIST OR IS REFUSING TO FIX. PLEASE HELP,. IT IS NOT THE BATTERY. UPDATED 12/8/2014 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10578600April 9, 2014
POWER TRAIN, VEHICLE SPEED CONTROL, ENGINE
THIS IS THE SAME VEHICLE AS NHTSA INCIDENT 10393028 (SNAPPED PLASTIC THERMOSTAT HOUSING UNIT). DRIVING ON A MULTIPLE LANE FREEWAY AT ~65MPH AND THE TIMING BELT SNAPPED (HIGH PITCHED WHISTLE LIKE THE CAR WINDOW WAS SLIGHTLY OPEN). IMMEDIATELY LOST ALL SPEED CONTROL AND BEGAN RAPIDLY DECELERATING. THANKFULLY, WAS IN RIGHT HAND LANE AND WAS ABLE TO COAST OFF THE NEXT AVAILABLE EXIT. LIKELY WOULD HAVE BEEN KILLED HAD I BEEN IN ANY OTHER LANE IN MORNING TRAFFIC AND LOST CONTROL OF VEHICLE. ONCE STOPPED, CAR COULD NOT BE TURNED BACK ON AND WOULD NOT MOVE UNTIL TURNED INTO ACC MODE WHERE IT FINALLY ALLOWED ME TO SHIFT INTO NEUTRAL. HAD TO BE TOWED, EVENTUALLY TO THE DEALERSHIP. ENGINE DAMAGE WAS CATASTROPHIC AND REQUIRED EXTENSIVE AND EXPENSIVE REPAIRS (3 WEEKS AND APPROXIMATELY $2,700). SNAPPED TIMING BELT ALSO BENT PISTONS AND VALVES AND REQUIRED THE WATER PUMP TO BE REPLACED. THIS IS CLEARLY A KNOWN ISSUE THAT SHOULD BE DEALT WITH BY CHEVROLET, RATHER THAN HIDING BEHIND THE 60,000 MILE REPLACEMENT, WHICH IS LAUGHABLY LOW FOR A TIMING BELT. FURTHER - MY TIMING BELT WAS SUPPOSED TO HAVE BEEN REPLACED AT 50,000 MILES AND THUS NOT ONLY DID A CHEVROLET DEALERSHIP LIE TO ME, THEY PUT MY LIFE AT RISK BY KNOWING THIS WAS AN ISSUE THAT WOULD INEVITABLY OCCUR LONG BEFORE THE NEXT SCHEDULED BELT REPLACEMENT. THIS CAR HAS BEEN METICULOUSLY MAINTAINED WITH OIL CHANGES EVERY 3,000 MILES AND ONLY 5,000-10,000 MILES DRIVEN/YEAR. THERE WAS NO REASON FOR THE TIMING BELT TO SNAP OTHER THAN BEING A FAULTY PART THAT SHOULD HAVE BEEN RECALLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573489March 19, 2014
ENGINE, POWER TRAIN
I WAS DRIVING APPROXIMATELY 25MPH WHEN SUDDENLY I HEARD A STRANGE, LOUD RUBBING/ CLATTERING NOISE COMING FROM UNDER THE HOOD. I PULLED THE VEHICLE OVER AND TURNED THE ENGINE OFF. MY BOYFRIEND, WHO IS A MECHANIC, LOOKED AT THE ENGINE AND SAID THE TIMING BELT WAS BROKEN. THE VEHICLE WOULD NOT RESTART AND HAD TO BE TOWED. NOW I AM FINDING OUT THAT THIS IS A KNOWN PROBLEM IN THIS PARTICULAR 4 CYLINDER GM VEHICLE. THIS ENGINE IS AN INTERFERENCE ENGINE. THIS MEANS THAT THE ONLY THING PREVENTING THE VALVES FROM STRIKING THE PISTONS DURING VEHICLE OPERATION IS THE TIMING BELT. IF/ WHEN IT BREAKS, IT CAUSES CATASTROPHIC ENGINE DAMAGE, OFTEN REQUIRING ENGINE REPLACEMENT. ONE OR MORE OF THE TIMING BELT PULLEYS ARE MADE OF PLASTIC. WHEN THE TIMING BELT PULLEY BREAKS, SHARDS OF PLASTIC SNAP OFF AND BECOME LODGED INSIDE OF THE ENGINE, RENDERING THE ENGINE USELESS. ALSO, AT HIGH RATE OF SPEED, THE VALVES BECOME BENT WHEN THE BELT/ PULLEY(S) MALFUNCTIONS. THIS IS BOTH COSTLY AND DANGEROUS TO THE CONSUMER, AND THE MANUFACTURER SHOULD HAVE MADE ALL PULLEYS AND MOVING PARTS ON THE ENGINE OUT OF METAL INSTEAD OF PLASTIC. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573281March 18, 2014
STEERING
I STOPPED AT STOP SIGN MOVED THROUGH INTERSECTION THE SUDDENLY DOVE TO THE DITCH .I WAS MOVING AT HIGHWAY SPEEDS ON I75 5 MINUTES EARLIER THEN TURNED ON THE SIDE ROAD S TO MY HOME .THE RACK AND PINION BROKE IN TWO SENDING ME INTO DITCH. IF THIS HAPPENED 10 MINUTES EARLIER I WOULD BE DEAD. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10565807February 25, 2014
SEAT BELTS
DRIVER SEAT BELT BUCKLE FROZE UP AND THE BUCKLE WOULD NOT ENGAGE. THIS BUCKLE HAS EXHIBITED DIFFICULTY IN THE LAST COUPLE OF MONTHS. MANY TIMES WOULD HAVE TO PUSH BELT INTO SLOT 2X OR 3X BEFORE THE BUCKLE WOULD CATCH. NEVER THOUGHT IT WOULD BE A ISSUE. THANK GOD MY DAUGHTER WASN'T DRIVING TO SCHOOL AND THE THING LOCKED UP OR SOMETHING. NOW, IT WILL COST APPROX. $200 TO HAVE JUST THE BUCKLE REPLACED AT THE ORIGINAL DEALERSHIP I PURCHASED IT FROM. ALL I CAN SAY IS THAT THERE ARE TOO MANY PROBLEMS WITH THE AVEO SEAT BELTS STARTING FROM 2004. I LIKED THIS LITTLE CAR BUT I AM DONE. I THINK I'LL STICK WITH DODGE. THIS IS JUST MY OPINION. UNFORTUNATELY, THERE ARE OVER 1800 COMPLAINTS ON THIS VEHICLE BETWEEN 2004 AND 2011; THE MOST BEING 2004 AND 2005. I THINK MY ISSUE JUST SLIDE PAST THEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10523757July 8, 2013
ENGINE
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE TRAVELING 55 MPH, THE TIMING BELT FAILED. THE CONTACT STATED THAT THE FAILURE CAUSED DAMAGE TO THE VALVES. THE CONTACT SPOKE TO A DEALER AND WAS TOLD THAT THE BELT AND VALVES WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 140,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10513747May 28, 2013
ENGINE
I WAS DRIVING MY CAR ON MY LUNCH BREAK, AND HAD JUST MADE A LEFT TURN ONTO A MAJOR HIGHWAY. ABOUT 5 SECONDS AFTER I MADE THE TURN, I FELT A JOLT AND HEARD AN ODD GRINDING SOUND. MY CAR LOST POWER AND ALL THE DASHBOARD LIGHTS CAME ON. I WAS FORTUNATELY ABLE TO SAFELY STEER THE CAR FROM THE LEFT LANE TO THE RIGHT SHOULDER BEFORE IT FINALLY STOPPED. I HAD THE ADDED FORTUNE OF BREAKING DOWN IN FRONT OF A REPAIR SHOP. IT WAS DETERMINED THAT MY TIMING BELT HAD BROKEN AND HAD BENT ALL THE VALVES IN THE ENGINE. IT TOOK 5 DAYS AND $1875 TO FIX. I HAVE SEEN DOZENS OF OTHER COMPLAINTS FROM AVEO OWNERS ABOUT TIMING BELT FAILURES LONG BEFORE THE RECOMMENDED 100K REPLACEMENT MARK, BUT CHEVROLET REFUSES TO ACKNOWLEDGE THE PROBLEM AND WON'T ISSUE A RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10510316May 1, 2013
ENGINE AND ENGINE COOLING
IT'S THE 3RD TIME IT HAS HAPPENED. IT OCCURRED TWICE WITH MY DAUGHTER AND HER BABY IN THE CAR, TODAY WHEN I PICKED MY KID UP FROM SCHOOL; THE CAR CUT OFF WHILE IN MOTION. I HAVE CHANGED THROTTLE POSITION SENSOR, CRANK SENSOR, COOLING TEMPERATURE SENSOR, 15 AMP FUSE TWICE, REPLACED THE HEAD GASKET, SEALANT, EGR VALVE AND EGR GASKET. CLEANED OFF ALL OIL RESIDUE ON ENGINE, ON HEAD GASKETS, ON SPARK PLUGS. RECENTLY REPLACED THERMOSTAT, RADIATOR, TIMING BELT AND HAVE ALSO DID A TRANSMISSION OIL CHANGE. THE CAR IS NOT WORKING APPROPRIATELY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10505451April 2, 2013
ENGINE, STEERING, VEHICLE SPEED CONTROL
AS I BEGAN TO ACCELERATE ONTO THE HIGHWAY, I FELT THAT MY CAR WAS NOT PICKING UP, I COULD ONLY GET TO AROUND 40-45MPH ON A HIGHWAY THAT IS 65MPH. I NEARLY GOT REAR-ENDED BY CARS FLYING UP ON ME AND I QUICKLY PULLED OFF TO THE SHOULDER JUST IN TIME AS THE POWER STEERING ALSO WENT OUT AND THE CAR APPEARED TO HAVE STOPPED RUNNING. I COULD NOT GET THE CAR TO START AGAIN. THE DIAGNOSTICS CAME BACK THAT THE TIMING BELT HAD GONE AND IT COULD BE FIXED FOR ANYWHERE BETWEEN $800 TO NEEDING A BRAND NEW MOTOR. THIS FLOORED ME AS I ALWAYS HAD THE OIL AND FLUIDS REPLACED AND THE CAR ONLY HAD 84K MILES ON IT. I BEGAN TO RESEARCH THE AVEO AND BAM, THERE IT WAS, OVER AND OVER AGAIN ON-LINE. OWNERS ALL COMPLAINING OF THE SAME PROBLEM WITH THEIR AVEO. THE TIMING BELT ON THE AVEO, ESPECIALLY THE 04-07 MODELS GO AND WILL REQUIRE ANYWHERE FROM A MAJOR FIX TO A BRAND NEW ENGINE. THIS IS A BIG PROBLEM ON A LITTLE CAR. I WENT ON CRAIGSLIST TO LOOK FOR A NEW ENGINE, BUT INSTEAD FOUND 10 AVEOS IN ONE HOUR... THAT WERE BEING SOLD FOR PARTS BECAUSE THEIR TIMING BELT WENT! PLEASE TAKE A LOOK AT THIS PROBLEM, I BELIEVE THERE IS A MAJOR PROBLEM WITH THE AVEO DESERVING OF A RECALL, AND OWNERS SHOULD BE MADE AWARE OF THIS SERIOUS PROBLEM AND THE PERSISTENT NEED TO HAVE THEIR TIMING BELT REPLACED OR FACE A TOTAL ENGINE REPLACEMENT. I COULD HAVE EASILY BEEN REAR-ENDED OR WORSE BECAUSE OF THE LOSS OF POWER AND POWER STEERING. THANK YOU. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10482944November 2, 2012
ENGINE
THE TIMING BELT BROKE IN OUR VEHICLE WHILE WE WERE DRIVING. THE CAR MADE A HORRIBLE RACKET, THEN COMPLETELY LOST POWER BEFORE IT DIED COMPLETELY, WHEN IT BROKE, IT BENT THE RODS AND PISTONS IN THE HEADS. NOW JUST TWO WEEKS AGO, IT HAS DONE THE SAME THING. CHEVY NEEDS TO MAKE A RECALL ON THIS BECAUSE ITS GOING TO END UP KILLING SOMEONE AND THIS ISN'T THE ONLY AVEO TO HAVE DONE THIS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10479671October 10, 2012
AIR BAGS
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR INSPECTION BUT THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 103,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10472847August 28, 2012
POWER TRAIN, ENGINE
DRIVING AT 55 MPH THE CAR FELT LIKE CAME OUT OF 5TH GEAR. I CHECKED TO MAKE SURE THE CAR WAS IN GEAR. PUSHED THE CLUTCH IN (VERY TIGHT). THE CAR WAS LOOSING POWER BUT TACH WAS STILL AT 3000. I COASTED TO THE SIDE OF THE ROAD AND THE CAR HAD NO SPARK. LIGHTS STILL WORKED. I HAD THE CAR TOWED AND FOUND THAT THE TIMING BELT FAILED WHICH TOOK OUT THE WATER PUMP AND DAMAGED MY HEAD. THERE WAS NO WARNING AT ALL. AT THIS TIME I HAVE BEEN TOLD BY MECHANIC AND 2 CHEVROLET DEALERSHIPS THAT THIS IS A COMMON OCCURRENCE. THANK GOD IT WAS 5:15 AM AND NOT A LOT OF TRAFFIC ON THE ROAD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10472696August 27, 2012
ENGINE
TIMING BELT BROKE WHILE ON A MAJOR HIGHWAY DOING 65 MPH. CAUSING THE CAR TO SHUT OFF AND LEAVE ME STRANDED WHEN IT BROKE IT CRUSHED ALL 4 CYLINDER HEADS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10470014August 9, 2012
SEAT BELTS:REAR/OTHER, SEAT BELTS
WE PURCHASED THIS CAR FROM A USED CAR DEALERSHIP THIS YEAR. THE REAR SEAT BELTS DON'T EXTEND OR RETRACT. THERE WAS A SAFETY RECALL ISSUED ON OCTOBER 15, 2004 (RECALL # 04V407000). CHEVROLET'S RECALL CENTER HAS TOLD ME IT'S NO LONGER THEIR RESPONSIBILITY TO REPAIR THE REAR SEAT BELTS, BECAUSE ALTHOUGH THIS IS A PASSENGER SAFETY CONCERN, THIS RECALL ITEM IS NOW IN A, "CLOSED" STATUS. MY QUESTIONS IS, "REALLY"?! DEFECTIVE PASSENGER SEAT BELTS ARE NO LONGER CHEVY'S RESPONSIBILITY AFTER A CERTAIN TIME PERIOD? PLEASE LOOK INTO THIS AND PLEASE ADVISE ME AS TO WHAT MY RIGHTS ARE AS A CHEVY OWNER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10463476June 28, 2012
ENGINE
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, HE HEARD A KNOCKING SOUND FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER ADVISED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE AND CURRENT MILEAGE WAS 58,995.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10462676June 21, 2012
SERVICE BRAKES
MY PASSENGER REAR SHOE BROKE IN HALF. IN THE FOLLOWING MONTHS, APPROXIMATELY ONCE EVERY WEEK TO TWO WEEKS MY SPRINGS AND SELF ADJUST FALL OFF. WHEN THE DRUM IS PULLED OFF THEY ARE EITHER COMPLETELY DETACHED OR HANGING BY A HAIR. THEY ARE NOT CONNECTED NOR ARE THEY DOING ANY GOOD FOR THE BRAKING SYSTEM. IN THE 7 MONTHS THAT I HAVE HAD THE CAR, I HAVE HAD IT WORKED ON 18 OR MORE TIMES ON THE EXACT SAME BRAKE. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461886June 15, 2012
ENGINE, ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. THE ENGINE WAS RESTARTED AFTER THE FIRST ATTEMPT AND THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED NINE TIMES ON SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND THEY WERE UNABLE TO DETECT A CAUSE OF FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 39,500. UPDATED 07/25/12*LJ THE CONSUMER STATED THE DEALER KEPT THE VEHICLE FOR EIGHT DAYS. UPDATED 07/25/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460333June 2, 2012
ENGINE
MY STEPDAUGHTER AND HER FRIEND WERE TRAVELING CROSS-COUNTRY FROM CALIFORNIA TO ILLINOIS. CAR HAD JUST BEEN CHECKED BY A MECHANIC PRIOR TO TRIP AND SAID WAS OK. ON I-40, ABOUT 40 MILES WEST OF ALBUQUERQUE NM, SHE REALIZED THE CAR WAS GETTING WARM, THEN THEY SAW STEAM FROM HOOD, CHECK ENGINE LIGHT CAME ON. SHE IMMEDIATELY PULLED TO THE SIDE OF THE ROAD AND CALLED ME, IN ILLINOIS. THEN SHE CALLED AAA FOR TOWING, AND WAS TOWED TO GALLES CHEVROLET IN ALBUQUERQUE. THE NEXT DAY THEY DIAGNOSED TOTAL ENGINE FAILURE DUE TO OVERHEATING; CAUSE OF FAILURE LIKELY A BROKEN THERMOSTAT HOUSING. I SEARCHED FOR THIS ISSUE AND FOUND MANY SIMILAR COMPLAINTS IN EDMUNDS FORUM; THIS CERTAINLY SEEMS TO BE A COMMON PROBLEM. IN THE END THE GIRLS WERE SAFE, THANK GOD. NOT ONLY WAS THIS A VERY EXPENSIVE INCIDENT (~$5000), BUT IT COULD HAVE BEEN A VERY SERIOUS SAFETY ISSUE, LEAVING TWO YOUNG COLLEGE GIRLS STRANDED IN A REMOTE DESERT LOCATION ON A HOT DAY, VERY VULNERABLE. THE NEXT PERSON THIS HAPPENS TO MIGHT NOT BE SO FORTUNATE. I URGE YOU TO TAKE ACTION TO REQUIRE GM TO RECALL AND FIX THIS ISSUE. THANK YOU. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Aveo