BMW B7 Service Bulletins (2018)
221 manufacturer communications on file.
- June 1, 2020•Document ID: 10177627Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B512119
- Date Added:
- July 27, 2020
- Manufacturer:
- BMW
SummaryACTIVE AIR FLAP FAULT DIAGNOSIS AND REPAIR: A check control message or MIL (Malfunction Indicator Lamp) may be illuminated, with faults stored related to the upper and/or lower active air flap(s).
Associated Products (51)Associated Documents - June 1, 2020•Document ID: 10177622Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B170420
- Date Added:
- July 27, 2020
- Manufacturer:
- BMW
SummaryCOOLANT LEVEL CHECK AND TOP-OFF AT SECOND OIL SERVICE: A new, additional coolant level check task is now linked to the second engine oil service (Service Counter 2 only). The scope of maintenance work will display in ISPA Next that applies to the high-temperature circuit. This new coolant check only pertains to the above listed models with gasoline engines. During the normal operation of the vehicle, there is a certain amount of coolant absorption by the various components/gaskets/seals contained within the coolant systems. Over time, the coolant absorption can cause the coolant level to fall below the maximum fill level in the reservoir. In some cases, the level may even fall low enough to cause the high-temperature circuit low coolant level warning light to illuminate, along with displaying the corresponding Check Control message.
Associated Products (49)Associated Documents - May 1, 2020•Document ID: 10176378Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
- Mfr Comm. #:
- B611020
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummarySERVICE ACTION - REPLACING THE RADIO/IHKA CONTROL PANEL: A CD cannot be inserted. Due to a logistics error in production an radio air conditioning control panel without a CD slot was installed.
Associated Products (23)Associated Documents - May 1, 2020•Document ID: 10176377Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B610520
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryCCM DISPLAYED "INCREASED BATTERY DRAIN" CAUSED BY CONTROLLER: A yellow CCM (Check Control Message) ID 415 is displayed- "Increased battery drain! // Battery. Electrostatic discharge at standstill / start engine. Energy management" The results of the Energy Diagnosis test plan identifies the Controller as the root cause of the CCM. The Controller delays the vehicle going to sleep by up to 6 minutes. In some cases this will cause the CCM 415 to be displayed when starting the vehicle. Replacing the Controller in this case will not correct this situation.
Associated Products (148)Associated Documents - May 1, 2020•Document ID: 10176375Service Bulletin/Repair InstructionsSEATS:FRONT ASSEMBLY:HEAD RESTRAINT; SEATS
- Mfr Comm. #:
- B520320
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryRATTLING NOISE FROM THE FRONT HEADREST: A rattling noise can be heard coming from the front seat headrest. This noise is only heard from headrests on vehicles equipped with the optional Executive Lounge Seating SA (Option Code) 04F4. Excessive movement between the headrest's internal rod and sleeve.
Associated Products (25)Associated Documents - May 1, 2020•Document ID: 10176374Service Bulletin/Repair InstructionsENGINE; ENGINE AND ENGINE COOLING; EQUIPMENT
- Mfr Comm. #:
- B512219
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryPASSENGER SIDE UPPER ACTIVE AIR FLAP STUCK OPEN/CLOSED: Upon visual inspection the passenger side upper active air flaps are either stuck open or closed and they will not move. There are no faults stored for the active air flaps.
Associated Products (43)Associated Documents - May 1, 2020•Document ID: 10176373Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B512119
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryACTIVE AIR FLAP FAULT DIAGNOSIS AND REPAIR: A check control message or MIL (Malfunction Indicator Lamp) may be illuminated with faults stored related to the upper and/or lower active air flap(s). Potential causes include: Faulty upper air flap actuator (G01 G02 G12 G30 G32) Faulty lower air flap assembly (G01 G02 G12 G30 G32) Software error in the DME affecting the upper flap (G01 G02 only)
Associated Products (51)Associated Documents - May 1, 2020•Document ID: 10176367Service Bulletin/Repair InstructionsLANE DEPARTURE; WHEELS
- Mfr Comm. #:
- B270220
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryJERKING OR SHUDDERING FROM THE DRIVELINE (XDRIVE TRANSFER CASE ATX13-X): There is a jerking or shuddering during either or both of the following: Cornering or accelerating from low speeds Driving with low to medium loads There are no warning lights or Check Control messages. CAUSE Unevenly worn or incorrect fitment tires are installed on the vehicle or the factory-filled transfer case oil does not meet BMW specifications.
Associated Products (66)Associated Documents - May 1, 2020•Document ID: 10176363Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B130420
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryTANK VENTILATION AND MIXTURE CONTROL FAULTS STORED IN THE DME: The Engine Malfunction Warning is illuminated and one or more of the following faults are stored in the DME. All models: FC 191C02 - Fuel tank ventilation system 2nd discharge point: malfunction FC 195014 - Differential pressure sensor tank vent valve signal: fixed FC 118001 - Mixture control: mixture too lean FC 118401 - Mixture control: mixture too lean large deviation I01 only: FC 124103 - Mixture control: mixture too lean FC 124101 - Mixture control: Mixture lean large deviation CAUSE Internal mechanical defect in the tank ventilation valve. The defect can also result in a very loud clicking noise when the valve is cycling.
Associated Products (140)Associated Documents - May 1, 2020•Document ID: 10176360Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- B110120
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryB58C AND B58M ENGINES ENGINE OIL FILTER INSERT IS DIFFICULT TO REMOVE - REMOVAL: On rare occasions during an engine oil service the BMW Original (Genuine) engine oil filter insert is either difficult to remove or breaks apart in the oil filter housing. The engine oil filter is broken. The paper is torn and the lower plastic section is stuck in the engine oil filter housing.
Associated Products (131)Associated Documents - May 1, 2020•Document ID: 10176356Service Bulletin/Repair InstructionsSTEERING; AIR BAGS; ELECTRICAL SYSTEM
- Mfr Comm. #:
- B011219
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryFRONT GRILLE UPPER/LOWER ACTIVE AIR FLAPS - LTD WTY EXT TO 15 YEARS/150000: A check engine light or check control message is present for the active air flaps behind the kidney grilles. The potential component-related causes of these faults are a: 1. Mechanical issue with the linkage of the upper or lower active air flap; and/or an 2. Internal short circuit of the adjustment motor.
Associated Products (20)Associated Documents - May 1, 2020•Document ID: 10176355Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B010119
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryFRONT GRILLE UPPER/LOWER AIR FLAPS - LTD WTY EXT TO 10 YRS/120000 MILES: Component-Specific Limited Warranty Extension For the eligible vehicles BMW of North America LLC (BMW NA) is extending the limited warranty for the vehicle's Radiator Grille Upper and Lower Active Air Flaps to: 10 years/120000 miles as determined by the vehicle's original in-service date.
Associated Products (16)Associated Documents - May 1, 2020•Document ID: 10176381Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B661120
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummaryREVERSING ASSISTANT LIMITATIONS: The Reversing Assistant function is not operating to customer expectations. Some possible customer concerns are: Vehicle does not avoid objects in its path tires or wheels contact the curb reversing Assistant only works for a short distance.
Associated Products (38)Associated Documents - May 1, 2020•Document ID: 10176380Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B660920
- Date Added:
- June 15, 2020
- Manufacturer:
- BMW
SummarySURROUND VIEW WRONG VEHICLE DISPLAYED AFTER PROGRAMMING: After programming the wrong vehicle model is displayed in the Central Information Display (CID) when the Surround View is activated.
Associated Products (69)Associated Documents - April 1, 2020•Document ID: 10175293Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B840220
- Date Added:
- May 18, 2020
- Manufacturer:
- BMW
SummaryREMOTE 3D VIEW NOT AVAILABLE: Remote 3D View cannot be launched In the BMW ConnectedDrive App. Software error in the Advanced Telematics Module 2 (ATM2).
Associated Products (66)Associated Documents - April 1, 2020•Document ID: 10175292Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B840120
- Date Added:
- May 18, 2020
- Manufacturer:
- BMW
SummaryBMW CONNECTEDDRIVE SERVICES ARE NOT AVAILABLE: The BMW ConnectedDrive services are not available for an extended period. This may include: Calls in the BMW Assistance app (Concierge Service) Vehicle data and status in the BMW ConnectedDrive app Remote services Remote 3D View Real Time Traffic Information (RTTI) Weather News Software error in Advanced Telematics Module 2 (ATM2).
Associated Products (66)Associated Documents - April 1, 2020•Document ID: 10175290Service Bulletin/Repair InstructionsBACK OVER PREVENTION: SENSING SYSTEM: CAMERA; LANE DEPARTURE: SENSING SYSTEM: CAMERA; FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA
- Mfr Comm. #:
- B661020
- Date Added:
- May 18, 2020
- Manufacturer:
- BMW
SummaryKAFAS04 (CAMERA-BASED DRIVER ASSISTANCE SYSTEMS) LIMITATIONS: Various functions of the KAFAS (without radar installed) are not operating up to customer expectations.
Associated Products (34)Associated Documents - April 1, 2020•Document ID: 10175289Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B660820
- Date Added:
- May 18, 2020
- Manufacturer:
- BMW
SummarySERVICE ACTION - REPLACE RIGHT REAR SHORT RANGE RADAR SENSOR (SRR): The functionality of the right rear SRR sensor could be reduced which would display the Driving Assistance Check Control Message.
Associated Products (45)Associated Documents - April 1, 2020•Document ID: 10175285Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B611420
- Date Added:
- May 18, 2020
- Manufacturer:
- BMW
SummaryDEACTIVATION OF THE INTERIOR MOVEMENT DETECTOR/TILT ALARM SENSOR IS NOT POSSIBLE: Customer complains that the interior movement detector and the tilt alarm sensor system cannot be deactivated by pressing the lock button on the remote control / BMW display key twice. The second button press on the radio remote control / BMW display key is not detected. Customer may have to press the button 3 times to deactivate the interior movement detector and tilt alarm sensor. CAUSE Software error in the control unit of the roof function center (FZD).
Associated Products (77)Associated Documents - April 1, 2020•Document ID: 10175284Service Bulletin/Repair InstructionsEQUIPMENT; ELECTRICAL SYSTEM
- Mfr Comm. #:
- B611320
- Date Added:
- May 18, 2020
- Manufacturer:
- BMW
SummarySERVICE ACTION - CHECKING THE DUAL STORAGE SYSTEM AND REPLACE IF NECESSARY: In the event of an accident the two-battery Dual Storage System (DSS) is disconnected from the electrical system via an internal relay. In some cases the relay is stuck closed and a fault is set. In these circumstances: A crash shutdown of the DSS does not occur The power distribution box is supplied with power until the DSS is fully discharged
Associated Products (33)Associated Documents