Audi A6 Investigations (1999)

8 ODI actions on file.

• RQRQ06003RECALLOpened 2/27/2006
  DRIVER'S SIDE DASH FIRE
  ELECTRICAL SYSTEM

  VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.

• EAEA04017RECALLOpened 6/30/2004
  STUCK-OPEN THROTTLE
  FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

  VWOA HAS RECALLED APPROXIMATELY 28,300 MY 1998-99 A6 VEHICLES IN COLD WEATHER STATES THAT EXPERIENCED THE HIGHEST RATE OF THROTTLE ICING INCIDENTS IN THE SUBJECT VEHICLES (04V-495).THE FAILURE RATE IN THE A4 AND PASSAT VEHICLES IS MUCH LOWER THAN IN THE RECALLED VEHICLES.ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE A4 AND PASSAT VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE AUDI A4 OR VW PASSAT VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES. FOR FURTHER DETAILS SEE THE ATTACHED CLOSING REPORT.

• PEPE04023CLOSEDOpened 3/5/2004
  STUCK-OPEN THROTTLE
  FUEL SYSTEM, GASOLINE

  COMPLAINTS RECEIVED BY ODI AND AUDI ALLEGE THAT, IN EXTREME COLD WEATHER, THE THROTTLE MAY UNEXPECTEDLY FAIL TO RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, MAKING IT DIFFICULT TO STOP THE VEHICLE.IN MARCH OF 2004, AUDI PERFORMED A SERIES OF TESTS TO INVESTIGATE THE POSSIBLE CAUSES OF THROTTLE ICING.AUDI CONCLUDED THAT UNDER CERTAIN DRIVING CONDITIONS - ONLY SHORT DISTANCE TRIPS OVER SEVERAL WEEKS WHERE COOLANT TEMPERATURE REMAINS BELOW 70?C (158?F) - WATER MAY ACCUMULATE IN THE MOTOR OIL. WATER THAT HAS ACCUMULATED IN THE MOTOR OIL WILL EVAPORATE AFTER THE ENGINE OIL TEMPERATURE EXCEEDS 70?C (158?F) AND COULD, WITHIN 15 TO 20 MINUTES OF DRIVING AT A CONSTANT SPEED WITH AN OUTSIDE TEMPERATURE BELOW -20?C (-4OF), CAUSE ICE TO FORM IN THE THROTTLE BODY.ACCORDING TO AUDI, THIS CONDITION OCCURS AT RELATIVELY LOW THROTTLE SETTINGS AND RESULTS IN THROTTLE STICKING AT POSITIONS THAT CAN BE CONTROLLED BY BRAKING.DURING TYPICAL VEHICLE USAGE (MIXTURE OF SHORT AND LONG DISTANCE DRIVING) THIS PHENOMENON IS NOT EXPECTED TO OCCUR.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.

• EAEA03025RECALLOpened 11/25/2003
  DRIVERS SIDE DASH FIRE
  ELECTRICAL SYSTEM

  THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

• PEPE03035CLOSEDOpened 7/25/2003
  DRIVERS SIDE DASHBOARD FIRE
  ELECTRICAL SYSTEM

  OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.

• PEPE03019CLOSEDOpened 5/15/2003
  STEERING WHEEL HEATER OVERHEATS
  STEERING: STEERING WHEEL/HANDLE BAR

  THIS PE WAS OPENED BASED ON FOUR ODI COMPLAINTS THAT THE STEERING WHEEL OVERHEATS. VW HAS SHOWN THAT MOISTURE AND PRESPIRATION PERMEATE THE STEERING WHEEL COVER CAUSING THE HEATING ELEMENT TO CORRODE.THIS CORROSION MAY CAUSE A SMALL, LOCALIZED AREA OF THE STEERING WHEEL TO EXPERIENCE A BRIEF DURATION OF OVERHEATING.THERE ARE NO REPORTS OF THE STEERING WHEEL SUSTAINING COMBUSTION. THE INVESTIGATION HAS FOUND NO OCCURRENCES OF SEVERE BURNING AND NO CONSUMERS REQUIRED MEDICAL ATTENTION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

• PEPE02008CLOSEDOpened 1/23/2002
  BRAKE AND CLUTCH PEDAL BRACKET
  SERVICE BRAKES, HYDRAULIC
• PEPE99001RECALLOpened 1/1/1999
  FUEL EXPULSION
  VEHICLE SPEED CONTROL:LINKAGES

  BY LETTER DATED MARCH 22, 1999, VOLKSWAGEN NOTIFIED NHTSA THAT IT WOULD TAKE SAFETY RECALL ACTION TO CORRECT THE SPITBACK PROBLEM ON ALL THE SUBJECT VEHICLES.BASED ON THE MANUFACTURER'S RECALL ACTION (ODI 99V-058), THIS INVESTIGATION IS CLOSED.