Mercury Sable Recalls (1999)

5 recalls on file.

• Recall04V332000July 15, 2004
  SUSPENSION:FRONT:SPRINGS:COIL SPRINGS

  ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.

  Remedy

  DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

• Recall99V250000September 20, 1999
  SEAT BELTS:FRONT:ANCHORAGE

  VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.

  Remedy

  DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.

• Recall98V288000November 9, 1998
  POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

  VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.

  Remedy

  DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.

• Recall98V204000September 1, 1998
  VEHICLE SPEED CONTROL

  VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.

  Remedy

  DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.

• Recall98V198000August 25, 1998
  SEAT BELTS:FRONT:ANCHORAGE

  VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.

  Remedy

  DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.