Mazda Mazda6 Service Bulletins (2021)
299 manufacturer communications on file.
- March 1, 2023•Document ID: 10233704Service Bulletin/Repair InstructionsVISIBILITY; VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
- Mfr Comm. #:
- SA-012-23
- Date Added:
- April 4, 2023
- Manufacturer:
- MAZDA
SummarySome customers may report an odor or water in the HVAC system and upon inspection, the cabin air filter may be found to be wet.
Associated Products (20)2023 Mazda CX-302023 Mazda CX-52023 Mazda CX-502023 Mazda CX-92023 Mazda Mazda32023 Mazda MX-52022 Mazda CX-302022 Mazda CX-52022 Mazda CX-92022 Mazda Mazda32022 Mazda MX-302022 Mazda MX-52021 Mazda CX-32021 Mazda CX-302021 Mazda CX-52021 Mazda CX-92021 Mazda Mazda22021 Mazda Mazda32021 Mazda Mazda62021 Mazda MX-5Associated Documents - February 28, 2023•Document ID: 10232299Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER; ELECTRICAL SYSTEM
- Mfr Comm. #:
- 09-016-23
- Date Added:
- March 3, 2023
- Manufacturer:
- MAZDA
SummarySpeedometer replacement procedure
Associated Products (11)Associated Documents - February 16, 2023•Document ID: 10232274Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 01-005-23
- Date Added:
- March 3, 2023
- Manufacturer:
- MAZDA
SummarySome customers may experience the check engine light ON with DTC P0126:00 (Thermostat stuck open) and one or more of the following symptoms: The engine takes longer to warm up. The engine temperature gauge fluctuates. The low coolant temperature indicator (blue) light stays on longer or comes on while driving. Poor heater performance, especially at idle. NOTE: Vehicles with SKYACTIV-G 2.5T are not applicable. If DTC P2B61:00 (Coolant control valve circuit range/performance) accompanies DTC P0126:00, this TSB is not applicable. Diagnose according to the instructions on MGSS online. Due to production variety of the failsafe thermostat integrated in the coolant control valve, engine coolant may enter into a dry hollow in the failsafe thermostat, resulting in unintended opening of the failsafe thermostat at lower temperatures (104-176 °F (40-80 °C)). To eliminate this concern, the production process of the coolant control valve has been modified.
Associated Products (8)Associated Documents - February 9, 2023•Document ID: 10232304Service Bulletin/Repair InstructionsSERVICE BRAKES, HYDRAULIC; VISIBILITY; EXTERIOR LIGHTING; ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SA-010-23
- Date Added:
- March 3, 2023
- Manufacturer:
- MAZDA
SummarySome customers may experience one or more electrical malfunctions after a vehicle body repair. The newly painted fender stay (2) may be causing a poor front harness (1) ground connection.
Associated Products (9)Associated Documents - February 7, 2023•Document ID: 10232401Service Bulletin/Repair InstructionsSEATS; ELECTRICAL SYSTEM
- Mfr Comm. #:
- 09-008-23
- Date Added:
- March 4, 2023
- Manufacturer:
- MAZDA
SummarySome vehicles may experience the seat ventilation system still on after the engine has been turned off, in some cases this causes the battery to be completely discharged and not rechargeable. This is caused by a deterioration in the seat ventilation control unit. To eliminate this concern, the material for the circuit of the seat ventilation control unit has been modified.
Associated Products (5)Associated Documents - February 3, 2023•Document ID: 10232271Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 01-004-23
- Date Added:
- March 3, 2023
- Manufacturer:
- MAZDA
SummarySome vehicles may have the check engine light on with DTC P0524:00 or P055F:00 stored in memory. Contamination in the engine oil may cause the engine oil solenoid valve to become stuck, resulting in improper operation of the oil pump and improper oil pressure. DTC P0524:00 (Engine oil pressure too low), DTC P055F:00 (Engine oil pressure malfunction). The control software of the PCM has been modified to eliminate this concern. In addition, the production process has been modified to reduce contamination in the engine oil solenoid valve, oil pump, spacer and oil filter.
Associated Products (4)Associated Documents - February 2, 2023•Document ID: 10232302Service Bulletin/Repair InstructionsWHEELS; STEERING
- Mfr Comm. #:
- SA-008-23
- Date Added:
- March 3, 2023
- Manufacturer:
- MAZDA
SummarySome vehicles may exhibit a steering shimmy or body vibration during the PDI test drive or during the first few miles of driving after the vehicle has been delivered to the customer due to flat spots on the tires. Flat spots on tires may be caused by improper maintenance during dealer storage (e.g.: Vehicle was left stationary for a prolonged period of time in high ambient temperatures).
Associated Products (18)Associated Documents - February 1, 2023•Document ID: 10232402Service Bulletin/Repair InstructionsSEATS
- Mfr Comm. #:
- 09-007-23
- Date Added:
- March 4, 2023
- Manufacturer:
- MAZDA
SummaryAt PDI or when new vehicle is delivered, some customers may complain about wrinkles on the leather seat cushion and/or seat back surface. Customers having this concern should have their vehicle repaired by a qualified upholstery repair specialist using the following repair procedure.
Associated Products (18)Associated Documents - February 1, 2023•Document ID: 10232300Service Bulletin/Repair InstructionsELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL; ELECTRICAL SYSTEM
- Mfr Comm. #:
- 07-002-23
- Date Added:
- March 3, 2023
- Manufacturer:
- MAZDA
SummarySome customers may complain that the ambient temperature on the instrument cluster is displayed more than 50 °F (10°C) lower than the actual temperature, resulting in insufficient performance of the air conditioning. This is caused by inappropriate soldering in the ambient temperature sensor. To eliminate this concern, the soldering process has been enhanced since December 2021 at the supplier.
Associated Products (14)Associated Documents - January 31, 2023•Document ID: 10230891Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 01-003-23
- Date Added:
- February 2, 2023
- Manufacturer:
- MAZDA
SummarySome vehicles may have a "LOW ENGINE OIL LEVEL" warning message and an engine oil level warning light on in the instrument cluster with DTC P250F:00 stored in memory, and the oil level has actually decreased to near low. - DTC P250F:00 - Engine oil level signal: engine oil level low This is caused by an oil consumption increase due to damage of the valve seals on the exhaust side. To eliminate this concern, the design of these valve seals has been modified.
Associated Products (7)Associated Documents - January 23, 2023•Document ID: 10230902Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- 09-006-23
- Date Added:
- February 2, 2023
- Manufacturer:
- MAZDA
SummaryWhen encountering a vehicle with paint damage, refer to the "Mazda Paint Warranty Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
Associated Products (17)Associated Documents - January 23, 2023•Document ID: 10230865Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- RF-23-01
- Date Added:
- February 2, 2023
- Manufacturer:
- MAZDA
SummaryWhen servicing SKYACTIV engine vehicles requiring to replace the Oil Galley Plug and Crush Washer, order the required part numbers below. These parts are not listed in GEPC and were previously listed as "non-serviceable" in the cylinder block diagram.
Associated Products (19)Associated Documents - January 12, 2023•Document ID: 10230870Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:INFOTAINMENT; EQUIPMENT
- Mfr Comm. #:
- SA-001-23a
- Date Added:
- February 2, 2023
- Manufacturer:
- MAZDA
SummarySome customers may complain about infotainment center display: - Ghost Touch - DTC B108E:04 may be stored (Touch screen operates by itself) - Surface Peeling - DTC B108E:04 may be stored - Spider Cracks - White dots IMPORTANT NOTE: DO NOT replace the infotainment center display assembly. Low cost repair kits are available to repair the infotainment center display screen.
Associated Products (5)Associated Documents - January 12, 2023•Document ID: 10230864Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- RF-22-01R3
- Date Added:
- February 2, 2023
- Manufacturer:
- MAZDA
SummaryThis Parts Flash replaces RF-22-01R2 released January 04, 2022. It includes new display repair kit part numbers for the 2018-2019 Mazda2, 2018-2020 CX-3 and 2018-2020 MX-5. Repair kits are available to replace just the screen. There is no need to replace the entire infotainment display unit as the supply chain has been heavily impacted due to the global shortage of semiconductors.
Associated Products (5)Associated Documents - January 11, 2023•Document ID: 10230875Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- SA-003/23
- Date Added:
- February 2, 2023
- Manufacturer:
- MAZDA
SummarySome vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. If you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur, and to better assist the customer in resolving their specific brake concern.
Associated Products (15)Associated Documents - January 4, 2023•Document ID: 10230863Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:INFOTAINMENT; EQUIPMENT
- Mfr Comm. #:
- RF-22-01R2
- Date Added:
- February 2, 2023
- Manufacturer:
- MAZDA
SummaryThis Parts Flash replaces RF-22-01R released November 21, 2022. It includes a new display repair kit part number for the 2020-2022 MX-5. Repair kits are available to replace just the screen. There is no need to replace the entire infotainment display unit as the supply chain has been heavily impacted due to the global shortage of semiconductors.
Associated Products (5)Associated Documents - January 3, 2023•Document ID: 10230869Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:INFOTAINMENT; EQUIPMENT
- Mfr Comm. #:
- SA-001-23
- Date Added:
- February 2, 2023
- Manufacturer:
- MAZDA
SummarySome customers may complain about infotainment center display: - Ghost Touch - DTC B108E:04 may be stored (Touch screen operates by itself) - Surface Peeling - DTC B108E:04 may be stored - Spider Cracks - White dots IMPORTANT NOTE: DO NOT replace the infotainment center display assembly. Low cost repair kits are available to repair the infotainment center display screen.
Associated Products (5)Associated Documents - December 20, 2022•Document ID: 10228657Service Bulletin/Repair InstructionsSERVICE BRAKES, HYDRAULIC
- Mfr Comm. #:
- SA-078-22
- Date Added:
- January 5, 2023
- Manufacturer:
- MAZDA
SummarySome vehicles exhibit brake related concerns such as brake noise, brake judder or brake dragging. If you encounter a customer complaint for any one of these symptoms, refer to the following information to understand why symptoms may occur, and to better assist the customer in resolving their specific brake concern.
Associated Products (15)Associated Documents - December 7, 2022•Document ID: 10228651Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SA-016-22a
- Date Added:
- January 5, 2023
- Manufacturer:
- MAZDA
SummaryThere are currently 2 methods for cutting a new auxiliary key blank. A. Auxiliary Key Trace Cut Method B. Auxiliary Key Code Cut Method
Associated Products (19)Associated Documents - December 1, 2022•Document ID: 10228648Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- MT-004-22
- Date Added:
- January 5, 2023
- Manufacturer:
- MAZDA
SummarySome vehicles may experience the Check Engine Light ON with DTC P0171 (Fuel Trim too Lean) and possibly DTCs P030X (Misfire). Vehicles having this concern should use the following Inspection/Repair procedure.
Associated Products (18)Associated Documents