GMC Yukon Complaints (2002)

187 consumer complaints on file.

#10611391July 17, 2014
SERVICE BRAKES
DURING ROUTINE MAINTENANCE ON MY 2002 YUKON DENALI, HEAVY RUST/CORROSION WAS FIRST IDENTIFIED ON THE BRAKE LINE THAT RUNS UNDER THE RADIATOR. AS I FOLLOWED IT BACK, MORE RUST/CORROSION IS VISIBLE. THEY ARE RUSTING/CORRODING IN EXPOSED AS WELL AS PROTECTED AREAS. CONCERNED FOR SAFETY AND A POTENTIAL FAILURE I STARTED TO INVESTIGATE, ON LINE, AND FOUND THAT THIS ISSUE HAS AFFECTED MANY TRUCKS AND SUV'S IN AND AROUND MY MODEL YEAR. I ALSO FOUND THAT GM IS AWARE OF THE ISSUE BUT HAS FAILED TO INITIATE A RECALL. VEHICLES OF THIS SIZE ARE PURCHASED FOR LARGE FAMILIES, TOWING AND HAULING HEAVY LOADS. ALL THE MORE REASON FOR GM TO RECOGNIZE THE POTENTIAL DANGER AND ACT ACCORDINGLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609170July 9, 2014
SERVICE BRAKES
AFTER A MORNING OF DRIVING AROUND TOWN DOING ERRANDS I RETURNED HOME WITH GROCERIES. WHILE THERE I DECIDED TO SWAP OUT MY REVERSE LIGHT BULBS BEFORE DRIVING MY SON TO BASEBALL PRACTICE. WHILE MAKING THIS MAINTENANCE REPAIR THE BRAKES ON MY TRUCK FAILED COMPLETELY. THE BRAKES SANK ALL THE WAY TO THE FLOOR. FORTUNATELY I WAS ABLE TO KEEP THE TRUCK FROM BACKING INTO THE CARS PARKED ACROSS THE STREET BEHIND ME..AND THAT I HAD NOT GONE RIGHT OUT TO DRIVE MY SON TO BASEBALL. WHEN I GOT OUT TO INSPECT THE BRAKE LINES HAD COMPLETELY IMPLODED AND BRAKE FLUID WAS LEAKING EVERYWHERE. AFTER HAVING IT TOWED TO A REPAIR SHOP I WAS TOLD MY BRAKES HAD COMPLETELY RUSTED OUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10588484May 15, 2014
SERVICE BRAKES
BRAKES FAILED AS I TRIED TO STOP. ALL BRAKE LINES HAD TO BE REPLACED DUE TO CORROSION. THE VEHICLE WAS PURCHASED NEW AND IS ALWAYS KEPT IN A DRY GARAGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10586290May 3, 2014
SERVICE BRAKES
ABS AND BRAKE LIGHT DASHBOARD INDICATOR LIGHT ACTIVATES AFTER ANY RAIN OR UNDERSIDE OF CAR BECOMING WET DUE TO ROAD MOISTURE. WATER, SALT, AND OTHER ENVIRONMENTAL CONTAMINANTS CAUSE VARIOUS COMPONENTS OF THE ABS TO FAIL TRIGGERING THE ABS AND/OR BRAKE FAILURE LIGHT ON DASHBOARD TO TURN ON. VARIOUS GM DEALER RECOMMEND REPLACEMENT OF THE ELECTRONIC BRAKE CONTROL MODULE AND BRAKE PRESSURE VALVE IN ADDITION TO ASSOCIATED CONNECTION HARDWARE. ESTIMATED COST OF PARTS IS IN EXCESS OF $2K AND LABOR IS $500. NO ASSURANCES ARE GIVEN THIS WILL FIX PROBLEM. PREVIOUS RECALLS BY GM, VEHICLE OWNER COMPLAINTS, INTERNET WEBSITES, AND INTERNET FORUMS ADDRESS ONGOING ABS AND BRAKE LIGHT SYSTEM PROBLEMS DUE TO EXPOSURE TO WATER, MOISTURE, AND OTHER ENVIRONMENTAL ELEMENTS; INDICATES THE LIFE CYCLE OF GM ABS AND BRAKE SYSTEMS ARE SEVERELY REDUCED IN COMPARISON TO ALL OTHER MAKES AND MODEL CARS/TRUCKS WITH ABS SYSTEMS. THE NUMBER ONE NHTSA COMPLAINT ISSUE REMAINS THE ABS BRAKE SYSTEM ON GMC YUKONS PRODUCED FROM 2000 TO 2006. THERE HAVE BEEN VARIOUS NHTSA/GMC RECALL NOTICES THAT ADDRESS PARTIAL FIXES TO THE ABS BUT NONE REQUIRING THE RECALL OF THE COMPLETE ABS SYSTEM ITSELF. FAILURE OF THE ABS WILL RESULT IN BRAKE LOCKUP AT ANY SPEED. THE FAILURE OF THE ABS SYSTEM TO FUNCTION PROPERLY BECAUSE GM DID NOT DESIGN THE SYSTEM FOR IT'S OPERATING ENVIRONMENT HAS CREATED A DANGEROUS EXPENSIVE PROBLEM FOR GMC YUKON OWNER/OPERATORS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10583177April 16, 2014
SERVICE BRAKES, UNKNOWN OR OTHER
I NOTICED SOME FLUID UNDER THE MIDDLE OF VEHICLE AND THOUGHT IT WAS WATER BUT AS I WAS HEADING TO CHURCH SUNDAY NIGHT MY BRAKE PEDDLE WENT ALL THE WAY TO THE FLOOR, WAS VERY DISTURBING AND SCARY TO ME BUT WAS ABLE TO STOP AND GET HOME SAFELY. NEXT DAY IN THE DAYLIGHT I CHECK OUT MY FLUID AND THE BRAKE FLUID BOX WAS COMPLETELY EMPTY! TOOK TO DEALERSHIP AND WAS INFORMED THAT BRAKE LINES RUSTED AND LEAKING PER SAY $1500 JOB TO FIX. ALSO, INFORMED THAT I NEEDED A NEW WATER PUMP TOO. I JUST REPLACED THE POWER STEERING PUMP 2 WEEKS BEFORE THIS OCCURRED. GMC NEEDS TO MAKE THIS A RECALL IMMEDIATELY BEFORE SOMEONE GETS KILLED. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10575390March 28, 2014
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2002 GMC YUKON. THE CONTACT STATED THAT THE IGNITION FAILED AND IT TOOK SEVERAL ATTEMPTS TO GET THE IGNITION SWITCH INTO THE START POSITION. THE CONTACT'S PERSONAL MECHANIC ADVISED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 148,809.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10564574February 16, 2014
SERVICE BRAKES
REAR BRAKE LINE FAILED WHILE DRIVING. CAR TOWED TO VAN CHEVROLET IN SCOTTSDALE, AZ. DEALER ONLY REPLACED ONE FAILED LINE. APPROX. 1 YEAR LATER, FRONT LEFT LINE FAILED, AGAIN WHILE DRIVING, AND WAS REPLACED. AFTER INSPECTION ALL HARD BRAKE LINES ARE SEVERELY CORRODED AND NEED REPLACEMENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10554095November 29, 2013
SERVICE BRAKES
DRIVING ON RT 22 IN NJ AT 55MPH WHEN TRAFFIC LIGHT CHANGED TO RED AND STEPPED ON BRAKES AND THE PEDAL WENT ALL THE WAY TO THE FLOOR. THE CAR ONLY SLOWED SLIGHTLY AND ENDED UP IN THE MIDDLE OF THE INTERSECTION BEFORE IT STOPPED. LUCKY THAT IT WAS IN THE MID AFTERNOON AND THE TRAFFIC WAS LIGHT BECAUSE THE DISTANCE TO STOP WAS ABOUT 5 TIMES THE NORMAL DISTANCE AND HAD TO USE EMERGENCY BRAKE TO STOP THE CAR. THERE WAS A SUDDEN FAILURE OF THE BRAKE LINE DUE TO CORROSION, I HAD THE CAR INSPECTED BY A MECHANIC, CAUSING THE PRESSURE TO DROP IN THE SYSTEM. AFTER THE INCIDENT I WENT ONLINE AND FOUND THAT THIS IS A PROBLEM FOR YEARS WITH THIS MAKE AND MODEL. I AM A SURGEON AND FIND IT WORRISOME THAT THIS AGENCY HAS NOT RECALLED THIS DEFECT AND THAT GMC HAS NOT NOTIFIED CONSUMERS OF THE POSSIBILITY SO THEY CAN HAVE THE BRAKE LINES CHANGED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552595November 17, 2013
SERVICE BRAKES
ON APRIL 19, 2013 I WAS DRIVING WITH MY DAUGHTER IN WILMINGTON DE TO THE AMTRAK STATION. APPROXIMATELY 3 BLOCKS AWAY FROM ARRIVING, MY BRAKES FAILED AS I ATTEMPTED TO STOP AT A TRAFFIC LIGHT. THE BRAKE PEDAL WENT COMPLETELY TO THE FLOOR. AS THERE WAS ALMOST NO STOPPING POWER LEFT, I PULLED THE EMERGENCY BRAKE AND DOWNSHIFTED TO LOW, AND PARTIALLY SLOWED, STOPPED IN THE LAST SECTION OF THE INTERSECTION. I PULLED TO THE SIDE OF THE ROAD AND HAD THE CAR TOWED TO MY AUTO SHOP. MY MECHANIC TOLD ME THE FRONT BRAKE LINES WERE RUSTED TO THE POINT OF CAUSING A MAJOR BRAKE FLUID LOSS. HE REPLACED THE BRAKE LINES WITH STAINLESS STEEL TUBING AND FITTINGS. I HAD TO PAY $485.35 TO MAKE THIS REPAIR. I NOW KNOW NHTSA IS INVESTIGATING THESE DANGEROUS AND DEFECTIVE GMC BRAKE LINES IN THE 'RUST STATES' INCLUDING MY HOME IN PENNSYLVANIA. THE US GOVT SHOULD FORCE GMC TO RECALL THESE INFERIOR CORROSIVE BRAKE LINES TO AVOID THE CHANCE FOR FATAL ACCIDENTS, AND GMC SHOULD REIMBURSE ME FOR MY COSTS. I WILL NOW FILE A SECOND NHTSA INCIDENT REPORT FOR A SECOND "REAR" BRAKE LINE FAILURE IN OCT 2013. -[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552596November 17, 2013
SERVICE BRAKES
I HAVE JUST SUBMITTED A FIRST COMPLAINT # 10552595 FOR DEFECTIVE GMC YUKON BRAKE LINES. I AM NOW SUBMITTING SECOND COMPLAINT FOR A SUBSEQUENT INCIDENT WITH THE SAME VEHICLE. ON OCT. 5, 2013 I WAS DRIVING ALONE TO THE SUPERMARKET IN PENNSYLVANIA. AS I WAS STOPPING FOR AN UPCOMING STOP SIGN, MY BRAKES FAILED TO OPERATE, AGAIN! THE BRAKE PEDAL AGAIN WENT COMPLETELY TO THE FLOOR. AS THERE WAS ALMOST NO STOPPING POWER LEFT, I AGAIN PULLED THE EMERGENCY BRAKE AND DOWNSHIFTED TO LOW, AND PARTIALLY SLOWED, AND STOPPED JUST AFTER THE INTERSECTION. I WAS WITHIN SIGHT OF MY AUTO SHOP, AND I VERY SLOWLY PROCEEDED THROUGH ONE ADDITIONAL INTERSECTION TO THE SHOP. WHEN I PULLED INTO HIS PARKING LOT, I COULD SEE THE HYDRAULIC BRAKE FLUID WAS RUNNING OUT OF THE REAR BRAKE LINE ONTO THE PAVEMENT! MY MECHANIC NOW TOLD ME THAT THE REAR BRAKE LINES WERE RUSTED TO THE POINT OF CAUSING A MAJOR BRAKE FLUID LOSS. HE REPLACED THE REAR BRAKE LINES WITH STAINLESS STEEL TUBING AND FITTINGS. I HAD TO PAY $509.45 TO MAKE THIS ADDITIONAL BRAKE LINE REPAIR. BASED UPON THE NHTSA IS INVESTIGATING THESE DANGEROUS AND DEFECTIVE GMC BRAKE LINES IN THE 'RUST STATES' INCLUDING MY HOME IN PENNSYLVANIA, THE US GOVT MUST NOW FORCE GMC TO RECALL THESE INFERIOR CORROSIVE BRAKE LINES TO AVOID THE CHANCE FOR FATAL ACCIDENTS. GMC SHOULD REIMBURSE ME FOR MY COSTS, NOW TOTALING $ 994.80. THIS IS NOW THE SECOND NHTSA INCIDENT COMPLAINT I HAVE FILED IN 2013 FOR THE TOTAL FAILURE OF MY CORRODED AND BURST GMC YUKON BRAKE LINES. (PLEASE NOTE THE MILEAGE OF MY VEHICLE ON 4/19/13 WAS 132,593 AND THEN ON 10/5/13 IT WAS 137,813.) -[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10549194October 23, 2013
SERVICE BRAKES
BRAKE FLUID LEAKING - BRAKES WENT OUT. FOUND A PREMATURE LEAK IN A BRAKE LINE ABOUT 12 INCHES BELOW THE MASTER CYLINDER. ALL LINES ARE SEVERELY CORRODED AND MUST BE REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10545720September 27, 2013
SERVICE BRAKES, FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2002 GMC YUKON DENALI. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 15 MPH, THE BRAKES WERE DEPRESSED AND THE VEHICLE FAILED TO SLOW DOWN UNTIL THE BRAKE PEDAL WAS APPLIED REPEATEDLY. THE CONTACT STATED THAT PRIOR TO THE FAILURE WHILE SHIFTING FROM PARK INTO REVERSE, THE PEDAL TRAVELED TO THE FLOORBOARD UPON ENGAGEMENT. THE TECHNICIAN INFORMED THE CONTACT THAT THE ENTIRE BRAKE AND FUEL LINES WERE SEVERELY CORRODED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544688September 20, 2013
SERVICE BRAKES
THE REAR MAIN BRAKE LINE BROKE RIGHT HALF INTO WHEN I HAD TO APPLY A VERY HARD STOP ON INTERSTATE 64 I WAS TRAVELING AT 65 MPH WHEN A SMALL CAR ABRUPTLY CHANGED LANES THERE WASN'T EFFICIENT ENOUGH SPACE FOR THE CAR TO MOVE IN AS HE MOVED OVER I HAD TO HIT MY BRAKE RATHER HARD TO GIVE THIS IDIOT ENOUGH ROOM TO MERGE IN THE ABS KICKED IN AND THE TIRES SQUEALED I CAME VERY VERY CLOSE TO REAR ENDING THIS GUY BUT I HAD JUST ENOUGH BRAKE TO SLOW MY CAR UP WITHOUT INCIDENT AFTER THAT MY BRAKES WENT TO THE FLOOR WHEN I EXITED THE INTERSTATE SOMEHOW IT DID STOP LUCKY ME. SOON AS I SAW A STORE I STOPPED AND PURCHASED 4 CANS OF BRAKE FLUID REFILLED THE RESERVOIR AND MADE IT HOME WITH THAT. I JACKED MY YUKON UP AND SAW A VERY RUSTY STEEL LINE BROKE OFF AT THE FITTING IT DIDN'T PULL OUT OF THE FITTING IT ACTUALLY BROKE INTO AND OF COURSE FLUID WAS EVERYWHERE. THIS INCIDENT COULD HAVE BEEN A BAD DISASTER THERE WAS A LOT OF TRAFFIC ON THE INTERSTATE RIGHT AT THE PEAK OF THE DAY WHEN EVERYONE WAS LEAVING WORK TRYING TO GET HOME. I AM THANKING MY LUCKY STARS I MADE IT HOME SAFE. NOW I HAVE TO FIGURE OUT THE REPAIR PART OF THIS WHOLE THING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544196September 18, 2013
AIR BAGS
TL* THE CONTACT OWNS A 2002 GMC YUKON. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, HE CRASHED INTO THE PASSENGER'S SIDE OF ANOTHER VEHICLE AND THE AIR BAGS FILED TO DEPLOY WITH THE IMPACT. IN ADDITION, THE SEAT BELT FAILED TO SECURE AS DESIGNED. THE CONTACT SUSTAINED A BRUISED RIB AND AN INJURY TO THE LEFT LEG. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE FACILITY. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATELY FAILURE MILEAGE WAS 142,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10543190September 11, 2013
SERVICE BRAKES
HIT BRAKES, STARTED TO SLOW THEN PEDDLE DROPPED, NO WARNING LIGHT . PEDDLE SANK TO FLOOR ,PUMPED PEDDLE TO STOP, HIT LIGHTPOLE AFTER WHICH BRAKE WARNING LIGHT CAME ON . ON INSPECTION ,BRAKE LINE BETWEEN ABS BOX AND REAR AXLE BADLY RUSTED , FAILED AT POINT ABOVE CROSSMEMBER ,IN FRONT OF GAS TANK. HAVE HAD ABOUT 16 CARS ,NEVER SAW LINE RUST THIS BAD ON A CAR LESS THEN 20 YEARS OLD. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10535499August 15, 2013
SERVICE BRAKES
2002 GMC YUKON SUFFERED MULTIPLE BRAKELINE FAILURES DUE TO CORROSION. REAR BRAKE LINES RUNNING ALONG THE AXLE WERE ORIGINALLY REPLACED UPON VISUAL INSPECTION. THE REAR MAIN LINE FROM THE ABS MODULATOR FAILED SHORTLY AFTER FROM A CORROSION INDUCED LEAK WHERE THE LINE PASSES OVER THE FUEL TANK. THE FRONT LINES WERE SCHEDULED FOR REPLACEMENT AS A PRECAUTION BUT FAILED PRIOR TO REPAIR WHERE THE LINE PASSES OVER THE RADIATOR BRACE. ALL BRAKE LINES AND FUEL LINES SHOW SIGNIFICANT CORROSION DAMAGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10532280July 29, 2013
SERVICE BRAKES
I WAS EXITING THE FREEWAY AND STARTED TO BRAKE AND THEN THE PEDAL WENT TO THE FLOOR. I HAD THE STAND ON IT TO SLOW DOWN ENOUGH TO KEEP FROM HITTING THE CAR IN FRONT OF ME. UPON EXAMINATION OF THE VEHICLE I FOUND A RUPTURED BRAKE LINE. FURTHER REVIEW FOUND ALL 4 LINES 8 INCHES BELOW THE MASTER CYLINDER AND LOWER SERIOUSLY CORRODED. FLUID RESERVOIR WAS STILL FULL OF FLUID. THE LINE BROKE OUT UNDER THE CARRIAGE, FRONT DRIVER SIDE, JUST BEHIND THE FRONT WHEEL WELL. PICTURES ARE AVAILABLE OF THE CORRODED LINES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10531984July 26, 2013
TIRES
TL* THE CONTACT OWNS A 2002 GMC YUKON WITH MICHELIN TIRES, SIZE: 265/70/R16. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE REAR PASSENGER'S SIDE TIRE BLEW WITHOUT WARNING. THE VEHICLE WAS TAKEN TO MICHELIN FOR DIAGNOSIS BUT THEY WERE UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 8,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10520326June 17, 2013
SERVICE BRAKES
BRAKE PEDAL WENT TO THE FLOOR WHEN APPLIED AT 30 MPH. ALL LINES AND HOSES WERE SEVERELY CORRODED, NOT MERELY SURFACE RUSTED. BRAKE HOSE NUTS RUSTED TO CALIPERS, COULD NOT BE REMOVED, REQUIRING 2 CALIPERS TO BE REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10481965October 23, 2012
SERVICE BRAKES
BRAKE LINES SEVERELY RUSTED. WHILE DRIVING HOME FROM TOWN, BRAKES WENT FROM WORKING GREAT---TO BRAKE PEDAL HITTING THE FLOOR, STOPPED AND FOUND LARGE AMOUNT OF BRAKE FLUID LEAKING ONTO GROUND. WAS ABLE TO MAKE IT HOME WITH BRAKE PEDDLE HITTING FLOOR AND BRAKE LINE FAILURE LIGHT AND AUDIO WARNING. APPROX. ONE MONTH EARLIER, PARKING BRAKE LINE, RUSTED THROUGH AND BROKE. UPON SEARCHING FOR BRAKE LINE LEAK, I WAS FRIGHTENED ON HOW RUSTED OUT ALL THE BRAKES LINES ARE,. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to GMC Yukon