Ford Ranger Complaints (2004)

405 consumer complaints on file.

#10154663April 5, 2006
VEHICLE SPEED CONTROL
WHILE COMING TO A STOP (TWICE) THE FORD RANGER ENGINE ACCELERATED SUDDENLY TO A POINT IT COULD NOT BE COMPLETELY STOPPED WITH THE BRAKE SYSTEM. HAD ANY TRAFFIC BEEN COMING I WOULD BE A DEAD MAN. I DID NOT HAVE MY FOOT ON ACCELERATOR NOR ARE THERE ANY FLOOR MATS IN THIS TRUCK TO GET STUCK UNDER THE ACCELERATOR. I'M SCARED TO DEATH TO DRIVE THIS VEHICLE AND I KNOW THAT IF I BRING IT TO THE FORD GARAGE THAT ITS GOING TO COST TONS OF MONEY AND THEY ARE GOING TO SAY THEY DON'T SEE ANYTHING WRONG. THERE IS OBVIOUSLY A SERIOUS PROBLEM WITH A CONTROL MECHANISM SOMEWHERE. THIS HAS HAPPENED TWICE. ONCE AFTER DRIVING THE VEHICLE ABOUT A MILE. THE SECOND TIME (TODAY) AFTER DRIVING FOR HOURS. CAN YOU PLEASE HELP ME OUT I REALLY AM SCARED TO DRIVE THIS TRUCK. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10154272March 31, 2006
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
DT*: THE CONTACT STATED INTERMITTENTLY THE VEHICLE ACCELERATED WHILE ATTEMPTING TO STOP. THIS OCCURRED 4-5 TIMES. ON ONE OCCASION, WHILE STOPPING AT AN INTERSECTION 10 MPH, THE VEHICLE BEGAN TO GAIN SPEED EVEN THOUGH THE CONTACT WAS APPLYING BRAKE PRESSURE. THE CONTACT SHIFTED THE VEHICLE TO NEUTRAL AND IT BEGAN TO DECELERATE. THE DEALERSHIP HAS BEEN ALERTED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10154125March 27, 2006
POWER TRAIN:MANUAL TRANSMISSION
2004 RANGER MADE A SCRAPING NOISE WHEN IN 2ND GEAR. WHEN CLUTCH IS DEPRESSED TO DISENGAGE GEARS OR SHIFT, THE ENGINE IDLE SPEED INCREASES. *TS THE CONSUMER WAS INFORMED THE IDLE HAD BEEN RESET, HOWEVER THE TRANSMISSION COULD NOT BE FIXED BECAUSE IT WAS A DESIGN FLAW. THE NOISE BECAME WORSE OVER TIME AND EVENTUALLY IT STARTED TO AFFECT THE 4TH AND 5TH GEARS. THE GEAR SHIFTER WAS REPLACED AND THE SHIFT PATTERN HAD A LOT OF PLAY. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10152278March 9, 2006
SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
FRONT SUSPENSION CAUSES SHIMS NEEDED IN FRONT END ALIGNMENT TO WEAR PREMATURELY AND CAUSE FRONT TIRES TO WEAR INCORRECTLY ON INSIDE OF FRONT TIRES. NEEDED TO GET FRONT END ALIGNMENT. FORD KNOWS ABOUT THIS AND DOES WARRANTY THESE PART FOR 12,000 MILES OR 12 MONTHS. SPOKE WITH FORD TECH AND AGREED WITH ME THAT THIS PROBLEM IS NOT NOTICEABLE UNTIL WELL AFTER THAT TIME FRAME. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10151844March 6, 2006
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
DT*: THE CONTACT STATED WHILE BRAKE PRESSURE WAS APPLIED AT A STOP SIGN, DUE TO THE PLACEMENT OF THE BRAKE AND ACCELERATOR PEDAL THE TWO WERE PRESSED AT THE SAME TIME WHICH CAUSED THE VEHICLE TO LURCH FORWARD RESULTING IN A REAR IMPACT COLLISION. NO ONE WAS INJURED AND SEAT BELTS WERE USED. MINOR DAMAGE WAS SUSTAINED TO BOTH VEHICLES. THE POLICE WERE CONTACTED AND A REPORT WAS TAKEN. THE VEHICLE WAS NOT SEEN BY A DEALER. UPDATED 04/06/06. *JB
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10151981March 6, 2006
SUSPENSION
DT*: THE CONTACT STATED WHILE THE VEHICLE WAS TAKEN TO THE DEALER FOR REGULAR MAINTENANCE, THE TIRES WERE WORN. UPON INSPECTION, THE TECHNICIAN DISCOVERED THE REAR SUSPENSION SETTLED AFTER A PERIOD OF TIME AND RESULTED IN EXCESSIVE WEAR IN THE MIDDLE OF THE TIRES. THE VEHICLE IS CURRENTLY UNDERGOING ADDITIONAL TESTING BEFORE REPAIRS ARE MADE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10151518March 1, 2006
ELECTRICAL SYSTEM:WIRING
PROBLEM WITH LOSS OF ALL DIRECTIONAL AND ABS/BRAKE INDICATOR ON DASHBOARD ON MY 2004 FORD RANGER PICKUP. WHEN PULLING OUT OF STOP ONTO A MAIN THOROUGHFARE, MY DIRECTIONAL QUIT WORKING AS I MADE THE TURN. I TRIED TO CLICK THEM MANUALLY, BUT TO NO AVAIL...AT THE SAME TIME AS I LOST MY DIRECTIONAL, MY ABS/BRAKE FAILURE INDICATORS ILLUMINATED ON THE DASHBOARD. NOT ONLY WAS I NOT ABLE TO SIGNAL A TURN (AT 20:00 HOURS), BUT OTHER DRIVERS COULD NOT SEE MY HAND SIGNALS BECAUSE IT WAS SO DARK. IN THE PROCESS OF TRYING TO MAKE A TURN (TO RETURN HOME), ANOTHER DRIVER HONKED AT ME (FOR LACK OF TURN INDICATION) AND CUT ME OFF, CAUSING ME TO JAM ON MY BRAKES. WITH NO ABS AVAILABLE, I OF COURSE STARTED TO SLIDE. I QUICKLY LET OFF THE BRAKE PEDAL TO MANUALLY PUMP MY BRAKES TO SLOW DOWN. I BROUGHT THE VEHICLE TO THE LOCAL FORD DEALERSHIP THE FOLLOWING DAY. THE REPORT FROM THE DEALERSHIP IS AS FOLLOWS; CUSTOMER REPORTS ABS LIGHT ON', 'CUSTOMER REPORTS ALL DIRECTIONAL INOPERABLE. VERIFIED CONCERN. FOUND FUSE #20-10AMP BLOWN, REPLACED FUSE, BLEW AGAIN. FOUND WIRING ON FRAME RAIL CORRODED AND SHORT TO GROUND. REPAIRED AND CHECKED, ALL OK'. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10151522March 1, 2006
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
MY 2004 FORD RANGER PICKUP HAS 45,265 MILES ON THE ODOMETER. I BROUGHT THE VEHICLE TO THE LOCAL FORD DEALERSHIP TO GET BRAKE WORK DONE PLUS ANOTHER ISSUE AS OUTLINED IN NHTSA COMPLAINT/CONFIRMATION#10151518. I WAS TRYING TO GET MY VEHICLE AN INSPECTION STICKER FOR THE STATE OF MASSACHUSETTS AS WELL. I WAS TOLD THAT I NEED NEW LOWER BALL JOINTS PN#F87Z-3050-BA IN ORDER TO GET MY STICKER. MY VEHICLE IS A 2004, WITH 45.264 MILES OF HIGHWAY AND SECONDARY ROAD USAGE ONLY! NO OFF ROAD OR SEVERE USAGE AT ALL! BALL JOINT REPLACEMENT AND REQUIRED FRONT-END ALIGNMENT COST ME OVER $430.00! I HAVE THE BAD BALL JOINTS IN MY POSSESSION. VEHICLE IS DRIVEN BY ME DAILY, TO AND FROM WORK ONLY!*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147534February 7, 2006
POWER TRAIN:AUTOMATIC TRANSMISSION
2004 FORD RANGER FIRE STARTED UNDER HOOD. *TS THE CONSUMER WAS ADVISED THAT THE CAUSE OF FIRE WAS DUE TO A TRANSMISSION FLUID LEAK WHICH LEAKED ONTO THE WIRES AND IGNITED. *JB *NM
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10149404February 3, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
I HAVE A 2004 FORD RANGER WITH 12000 MILES AND THE FRONT BRAKES STARTED TO PULSE VERY MUCH. AFTER TAKING IT TO A MECHANIC I WAS TOLD THAT THE FRONT ROTORS WERE SHOT. THE MECHANIC TOLD ME THAT THE ROTORS METAL WAS PEELING OFF. I HAD THE ROTORS REPLACED. I DID SAVE THE OLD ROTORS.*NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148356January 23, 2006
VEHICLE SPEED CONTROL, SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
DT*: THE CONTACT STATED WHILE APPROACHING AN INTERSECTION AT 40MPH THE VEHICLE IN FRONT STOPPED SHORT. WHEN THE BRAKES WERE DEPRESSED THE VEHICLE SEEMED TO ACCELERATE RATHER THAN SLOW DOWN. THE CONTACT SWERVED TO AVOID A DIRECT REAR END COLLISION, BUT CLIPPED THE VEHICLE IN THE RIGHT REAR BUMPER. BOTH VEHICLES SUSTAINED ONLY MINOR DAMAGE. THE POLICE FILED A REPORT AT THE SCENE. THE CONTACT EXPERIENCED TWO PREVIOUS FAILURES WITH THE BRAKES, BUT NO ACCIDENTS RESULTED IN THE OTHER INCIDENTS. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE PROBLEM COULD NOT BE DUPLICATED. HOWEVER, THE DEALER REPLACED THE BRAKE PADS.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10139345January 11, 2006
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES, EQUIPMENT
SEAT BELT PROBLEM. 2004 FORD RANGER 2 WHEEL DRIVE. V-6, EXT CAB, THE SEAT BELT ALARM DOES NOT WORK AFTER IT IS DRIVEN A FEW HUNDRED FEET, CAN UN-BUCKLE BELT WITH NO INDICATION IT IS UN-BUCKLED, DRIVER AND PASSENGER BELT, VERIFIED THIS PROBLEM WITH ANOTHER RANGER AT THE DEALER, FORD MT CO KNOWS OF THIS PROBLEM BECAUSE I NOTIFIED THEM AND RECEIVER A PHONE CALL ABOUT THIS PROBLEM, THIS MAY BE A SYSTEMIC PROBLEM WITH 04 RANGERS AND IS SAFETY RELATED. *JB *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147027January 5, 2006
ENGINE AND ENGINE COOLING:ENGINE
THE CHECK ENGINE LIGHT ON MY 2004 FORD RANGER KEPT COMING ON, I WAS TOLD BY ONE DEALER THAT IT WAS AN EMISSION SIGNAL AND THAT IT WOULD RESET. IT DID BUT KEPT COMING BACK. THE TRUCK THEN STARTED RUNNING BAD, SO I TOOK IT TO ANOTHER DEALER, WHO TOLD ME THAT THERE WAS A TECHNICAL SERVICE BULLETIN OUT ABOUT THIS PROBLEM AND THEY HAD TO REPLACE BOTH OF MY ENGINES HEADS. AND OF COURSE BECAUSE OF THE MILES ON MY TRUCK, I WOULD HAVE TO PAY FOR THESE REPAIRS. I SAID THAT IF FORD KNEW ABOUT THIS DEFECT THEN WHY HAVEN'T THEY RECALLED THESE ENGINES. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146676January 1, 2006
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
SEAT HEAD RESTRAINTS ARE SO HIGH THAT THEY PREVENT GOOD VISIBILITY IN REAR VIEW MIRROR OR WHEN LOOKING BACK. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10143484November 22, 2005
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
DT: THE CONTACT STATED THIS WAS A COMPANY FLEET VEHICLE AND IT WAS LEAKING FUEL. THE VEHICLE HAS NOT BEEN TO A DEALERSHIP. THE COMPANY HAD ANOTHER VEHICLE WITH THE SAME FUEL LEAKING PROBLEM DUE TO A BROKEN FUEL LINE. THE CONTACT ASSUMED THE SAME PROBLEM EXISTED WITH THIS VEHICLE SINCE THE FUEL WAS LEAKING FROM THE SAME AREA. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144248November 15, 2005
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
CONSUMER SPARE TIRE WAS NOT THE CORRECT SIZE TO FIT ON 2004 FORD RANGER. *TS THE DEALER WAS NOT WILLING TO GIVE THE CONSUMER A SPARE TIRE AT THEIR EXPENSE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138556October 4, 2005
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
DT: THE CONTACT OWNS A 2004 FORD RANGER EDGE. THE CONTACT STATED HE HAS BEEN HAVING BRAKE PROBLEMS WITH THIS VEHICLE. WHILE DRIVING AT 65 MPH AND APPLYING THE BRAKES THE VEHICLE WOULD NOT STOP. THE PEDAL HAD A SPONGY FEEL WHEN IT WAS PRESSED DOWN. THE SERVICE DEALER REPLACED THE CAP ON THE RESERVOIR TO THE MASTER CYLINDER. THIS DID NOT REMEDY THE PROBLEM. THEN, THE DEALERSHIP REPLACED THE RESERVOIR, THIS STILL DID NOT REMEDY THE PROBLEM. THE DEALER REPLACED THE SEALS, AND THIS SEEMED TO STOP THE LEAK OF THE BRAKE FLUID, BUT DID NOT HELP THE BRAKING CAPABILITY. THE BRAKING PROBLEM RESULTED IN AN ACCIDENT BECAUSE HE COULD NOT AVOID AN ANIMAL IN THE ROAD. WHEN HE APPLIED THE BRAKES THE VEHICLE SKIDDED AND HE COULD NOT GAIN COMPLETE CONTROL OF THE VEHICLE. THE VEHICLE FLIPPED OVER SIX TO SEVEN TIMES. THE CONSUMER WAS DRIVING 75 MPH WHEN THE ACCIDENT OCCURRED. THERE WAS ONE FATALITY, AND TWO INJURIES AS A RESULT OF THIS ACCIDENT. THE CONSUMER HAS NOT CONTACTED THE MANUFACTURER OR THE SERVICE DEALER BECAUSE OF INJURIES SUSTAINED FROM THE ACCIDENT. THE CONSUMER LEFT THE VEHICLE IN A TOW YARD IN WINSLOW, ARIZONA. *AK
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
1
#10136221September 12, 2005
VEHICLE SPEED CONTROL
(1) WHEN I (THE DRIVER) HAVE ATTEMPTED TO STOP THE VEHICLE (A 2004 FORD RANGER WITH AUTOMATIC V-6), THE THROTTLE FAILS TO DISENGAGE AND EVEN APPEARS TO BE WORKING TO OVERCOME THE BRAKES. THIS HAS OCCURRED (3) TIMES SINCE THE VEHICLE'S PURCHASE ON JULY 30, 2005. (2) WHILE THE OCCURRENCES APPEAR RANDOM IN NATURE, THE ENGINE RACES, TIRES SPIN/SQUEAL EVEN WITH THE BRAKE PEDAL FULLY DEPRESSED. THE PROBLEM HAS OCCURRED EACH TIME WHEN THE ENGINE IS WARM AND ALWAYS WHEN ATTEMPTING TO COME TO A STOP AT LOW SPEEDS, SUCH AS AT A STOP SIGN OR IN A PARKING LOT. NO ACCIDENT HAS OCCURRED YET, HOWEVER, THIS WAS PURELY A MATTER OF LUCK AND TIMING. (3) THE VEHICLE HAS BEEN RETURNED TO THE FORD DEALERSHIP TWICE AND NO CORRECTIVE ACTIONS HAVE TAKEN PLACE, AS THE DEALERSHIP CAN NOT DUPLICATE THE RANDOM EVENT. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132088August 30, 2005
TIRES:TREAD/BELT
DT: THERE WAS TREAD SEPARATION ON ALL FOUR TIRES. THE TIRE MANUFACTURER PRORATED THE PRICE TO REPLACE THE TIRES. THE LEFT FRONT TIRE WAS REPLACED ON 6-21-05 AND THE OTHER THREE WERE REPLACED ON 7-26-05. *AK *NM *JB WHILE DRIVING ABOVE 35 MPH THE CONSUMER HEARD THUMPING NOISES AND THE STEERING WHEEL SHOOK. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10134312August 26, 2005
LATCHES/LOCKS/LINKAGES:DOORS:LATCH, SEAT BELTS
ROLLOVER; DRIVER'S DOOR CAME OPEN; SPOOL OUT OF SEATBELT.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
1

← Back to Ford Ranger