Ford Ranger Complaints (2006)

272 consumer complaints on file.

#10593297May 21, 2014
VEHICLE SPEED CONTROL, ENGINE
ROUGH IDLE NOTICED WHILE STOPPED AT AN INTERSECTION. CATASTROPHIC MISFIRE UPON ACCELERATION THROUGH AN INTERSECTION. TRUCK WAS ONLY ABLE TO "LIMP" 5 OR LESS MILES PER HOUR. CHECK ENGINE LIGHT HAD BEEN TURNING OFF AND ON HOWEVER DIAGNOSTICS SHOWED MISFIRE FOR UNKNOWN REASONS. SPARK PLUGS AND WIRES HAD BEEN REPLACED TWICE WITHIN A YEAR AS WELL. DEFECTED HEAD MANUFACTURED BY FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10585858May 1, 2014
SUSPENSION, STRUCTURE:BODY
I HAVE A 2006 FORD RANGER THAT I PURCHASED NEW (ITS MY SECOND RANGER I HAD A 1996 THAT I TRADED IN. I REALLY LIKE RANGERS BUT HAVE RUN INTO A MAJOR PROBLEM WITH RUST ON MY RANGER. THE SPRING SHACKLES RUSTED AND BROKE ON BOTH SIDES LAST WEEK. I TOOK MY BED OFF TO REPLACE THE SHACKLES AND FOUND THE BRACKETS WERE ALSO RUSTED OUT. THE FRAME IS VERY RUSTY AND THERE IS RUSTED HOLES THROUGH ON THE DRIVERS SIDE REAR FRAME. I HAVE NOT GOT TO THE FRAME UNDER THE CAB OR FRONT OF TRUCK YET. IS THERE A RECALL OR CAN I EXPECT HELP FROM FORD. THE SAFETY FACTOR OF THE FRAME CONCERNS ME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10585507April 29, 2014
SUSPENSION
TOOK MY TRUCK IN TO HAVE WHEELS CHANGED. WHEN PUT ON THE LIFT, I HEARD TO SOUNDS FROM THE SUSPENSION. BOTH SPRING SHACKLE HANGERS AND BRACKETS WERE RUSTED. THE SHACKLES ACTUALLY FELL APART. I HAVE REMOVED THE BED AND FOUND EXTENSIVE RUST OUT ON THE FRAME . THE DRIVER SIDE REAR FRAME IS BASICALLY GONE FROM RUST OUT. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10584391April 23, 2014
STRUCTURE:BODY
TL - THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT THE FRAME WAS COMPLETELY CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER. THE CONTACT MENTIONED THAT BOTH DRIVER AND PASSENGER SIDE REAR SPRING RAIL, MOUNTS AND SHACKLE WERE RUSTED PREVENTING HIM FROM PASSING STATE INSPECTION. THE TECHNICIAN VERIFIED THE FAILURE AND STATED THAT THE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 36,508. PM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10568429February 27, 2014
FUEL SYSTEM, GASOLINE, ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING
FORD VEHICLE LOST POWER AND STOPPED RUNNING WITH FULL TANK OF FUEL. WOULD NOT RESTART, HAD TOWED TO REPAIR SHOP. REPLACED FUEL PUMP FOR $606.99. DROVE ABOUT A MILE AND SAME THING HAPPENED AGAIN. FOUND THAT THE FUEL INERTIA SHUT OFF SWITCH NEEDED RE-SETTING. BOUGHT A FUEL PUMP I DIDN'T NEED. THIS HAS HAPPENED MULTIPLE TIMES THIS YEAR AGAIN. FORD DEALER SAID I NEEDED A FUEL PUMP. (35,000 MILES) AGAIN, NO WAY. THE REPLACEMENT PART (INERTIA SWITCH) MOVES THE SWITCH FROM PASSENGER FLOOR AREA TO SIDE KICK PANEL. THE DESIGN CHANGE SHOWS DESIGN FLAW. FORD SHOULD REPLACE FOR NO COST. VERY DANGEROUS WHEN ENGINE DIES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561509January 26, 2014
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
OF THE TWO REAR CROSS MEMBERS THAT SUPPORT THE GAS TANK ONE SIDE HAS COMPLETELY ROTTED TWO INCHES OF METAL AWAY. THE FORWARD ONE IS NEAR FAILURE THE REAR ONE COMPLETELY FAILED ONE SIDE.WILL PUT SOME SORT WEB STRAP SYSTEM SO THE TANK DON'T FALL OUT TILL WE GET WARMER WEATHER AND REMOVE THE BED TO INSPECT FRAME RAIL. A FRIEND OF MINE HAD TO REPLACE THE WHOLE REAR FRAME ASSEMBLY. THE REAR SPRING SHACKLES ARE NEAR FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10559275January 9, 2014
STRUCTURE:BODY, SERVICE BRAKES
PURCHASED THIS VEHICLE IN 2007 WITH 8K MILES AND HAD SOME RUST ON THE FRAME. NOW, 2013 I HAVE 24K MILES AND THE FRAMES IS COMPLETELY CORRODED AND MY BRAKES ARE FAILING DUE TO THE RUST. HAVE ALREADY SANDED THE FRAME AND PAINTED, BUT THE RUST COMES BACK. THIS A BIG SAFETY CONCERN BECAUSE PARTS CAN BREAK WHILE DRIVING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552819November 18, 2013
SUSPENSION, TIRES:TEMPORARY/EMERGENCY SPARE TIRE
I WAS DRIVING DOWN THE ROAD AND I HIT A BUMP AND MY SPARE TIRE FELL DOWN AND OUT OF THE TRUCK ONTO THE HIGHWAY. I STOPPED IMMEDIATELY AND RETRIEVED MY WHEEL OF THE HIGHWAY AND SAW THAT IT WAS STILL CONNECTED TO PART OF THE MOUNT. THE NEXT DAY I DROVE TO A REPAIR SHOP TO PUT THE TRUCK ON A LIFT TO LOOK AT THE DAMAGE AND REALIZED THAT THE ENTIRE FRAME HAD ROTTED UNDER THE TRUCK. I LEFT THE REPAIR GARAGE AND WAS HEADING HOME WHEN I HIT A POTHOLE THE ENTIRE DRIVER SIDE FRONT FRAME ROTTED AND THE WHEEL FELL PARTIALLY OFF THE TRUCK, SO I HAD THE TRUCK TOWED TO MY OFFICE PARKING LOT AND PARKED IT, BECAUSE IT IS NOT DRIVABLE ANYMORE. I CONTACTED FORD THEY TOLD ME TO HAVE IT TOWED TO A LOCAL DEALERSHIP AND THEY WOULD SEND A REP OUT TO LOOK AT IT. SO I DID AND THE REP NEVER CAME OUT AND THEY TOLD ME TO HAVE IT REMOVED, THAT THE REP CALLED THEM AND SAID THEY WOULD NOT REPAIR ANYTHING, SO THE TRUCK STILL SITS ROTTED AND PARKED, AND REMEMBER IT ONLY HAS 17,900 MILES ON IT, THANK YOU. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10551065November 6, 2013
ENGINE, VEHICLE SPEED CONTROL
RUNS ROUGH AT STOP. HESITATES WHEN ACCELERATES. COULD CAUSE ACCIDENT AT INTERSECTIONS. VALVE RECESSION PROBLEM AS DESCRIBED IN FORD ISSUED TSB. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10533117August 1, 2013
SUSPENSION
REAR LEAF SPRING SHACKLES ARE BROKEN, FUEL TANK STRAPS ARE BROKEN REAR STRUTS ARE IN POOR CONDITION, EXTENSIVE RUST ON FRAME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10504047March 26, 2013
ENGINE
2006 FORD RANGER. CONSUMER WRITES IN REGARDS TO VEHICLE DEFECTIVE CYLINDER HEADS. *SMD THE CONSUMER STATED ACCORDING TO FORDS TECHNICAL SERVICE BULLETIN 05-26-3 THE ENGINES WERE BUILT AT THE FACTORY WITH DEFECTIVE HEADS. IF THE CHECK ENGINE LIGHT ILLUMINATED, THE HEADS NEEDED TO BE REPLACED, AS IT WAS EXPLAINED TO HIM BY A MECHANIC AT A FORD DEALERSHIP. THE CONSUMER STATED IT APPEARED TO BE DEFECTIVE MATERIALS IN THE HEADS, WHICH REQUIRED THE HEADS TO BE REMOVED AND SCRAPPED, ALONG WITH THE HEAD GASKETS. THE HEADS APPEARED TO BE MADE OF SOFT IRON, WHERE THE BASE METAL WAS PERHAPS NOT HEAT TREATED. THE ESTIMATES FOR THE REPAIR OF THE ENGINE, WERE BETWEEN $3,000-$6,000 DEPENDING ON WHAT WAS NEEDED TO FIX THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10492126January 10, 2013
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE SPARE TIRE DETACHED FROM THE VEHICLE. THE CONTACT MERGED TO THE SHOULDER AND ATTEMPTED TO SECURE THE TIRE BACK IN THE SUPPORTING RACK BY USING HANGERS AND ROPE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THAT THE CHASSIS FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 65,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10480704October 16, 2012
FUEL/PROPULSION SYSTEM
THE FIRST INCIDENT I WAS DROPPING MY GRANDDAUGHTER OFF AT SCHOOL WENT OVER A SPEED BUMP AND THE TRUCK STALLED OUT HAD IT TOWED HOME AND IT STARTED ONCE OFF THE TOW TRUCK.THIE SECOND INCIDENT I WAS GOING THROUGH A PARKING LOT AND WENT OVER A SPEED BUMP AND THE TRUCK STALLED OUT, HAD TO HAVE IT TOWED AND THEY REPLACED THE FUEL PUMP. THE NEXT INCIDENT I WAS IN RUSH HOUR TRAFFIC ON A FEEDER ROAD AND IT STALLED WAS NEXT TO THE SERVICE STATION WHERE IT WAS PREVIOUSLY FIXED AND AFTER APOLICEMAN STOPPED TRAFFIC AND HAD ME PUSHED TO THE SERVICE STATION WAS TOLD BY A SENIOR TECHNICIAN THAT THIS WAS A KNOWN ISSUE ON THE RANGER AND TO PUSH THIS BUTTON WHENEVER IT HAPPENED. I HAVE BEEN DOING THIS A LOT SINCE THIS TIME AND HAVE HAD SOME VERY CLOSE CALLS DUE TO THE STALLING, WITH THE LATEST ALMOST CAUSING A MAJOR ACCIDENT DUE TO OCCURRING A HIGH SPEED AFTER HITTING A ROAD BUMP. THE INERTIA SWITCH ON FORD RANGER?S 2003 THROUGH 2006 ARE DEFECTIVE IN THREE MANNERS ONE THE CONNECTORS BURN DUE TO A HIGH CURRENT DRAW, THE SWITCH ACTIVATES WITHOUT WARNING, AND DUE TO NO KICKPLATE PASSENGERS CAN ACTIVATE THE SWITCH. THIS SWITCH IS USED TO CUT THE FUEL OFF DURING A ROLL OVER CRASH SCENARIO. THERE ARE NUMEROUS COMPLAINTS ON THE INTERNET IN REGARD TO THE FIRE AND SAFETY ISSUES THIS DEFECTIVE PART HAS CAUSED. TO DATE FORD HAS NOT ISSUED A RECALL, OR NOTIFIED THE CONSUMER BASE OF THE POTENTIAL HAZARDS SURROUNDING THIS ISSUE, BUT HAS ISSUED A REDESIGNED SWITCH THAT NOW COMES WITH A COVER AND UPDATED CONNECTOR FOR PURCHASE WHEN REPLACING THE OLD SWITCH. PLEASE INVESTIGATE SINCE PEOPLE'S LIVES ARE BEING IMPACTED DUE TO THE MULTIPLE SAFETY ISSUES AND ALSO DUE TO THE COST ASSOCIATED WITH DIAGNOSING THIS ISSUE. MY COST TO DATE IS IN EXCESS OF $1300.00, AND I AM IN THE PROCESS OF REPLACING IT MYSELF DUE TO MY CONCERNS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10476905September 24, 2012
ENGINE
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING 45 MPH THE ENGINE MISFIRED, CAUSING THE VEHICLE TO ROUGH IDLE AND STALL. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC FOR DIAGNOSTIC TESTING. THE TEST RESULTS CONCLUDED THAT THE VEHICLE NEEDED A TUNE-UP. THE TUNE-UP WAS PERFORMED HOWEVER, THE FAILURE WAS NOT CORRECTED. THE CONTACT TOOK THE VEHICLE BACK TO THE LOCAL MECHANIC WHERE A SECOND DIAGNOSTIC WAS PERFORMED, CONCLUDING THAT THE VEHICLE WAS IN NEED OF A TUNE-UP. THE VEHICLE WAS NOT FURTHER SERVICED. THE FAILURE MILEAGE WAS 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10468046July 27, 2012
STRUCTURE:BODY
THE DOOR AJAR LIGHT CAME ON AND WARNING BUZZER SOUNDED AND DOME LIGHT CAME ON TOO. AFTER DAYS OF REPLACING PARTS IN THE DOOR AND LUBE ADDED TO THE LATCHES IN BOTH THE MAIN DOOR AND SMALL DOOR THE SMALL DOOR LATCH WILL NOT STAY LATCHED !! KEEPING THE DOME LIGHT ON AND THE DOOR AJAR ON IN THE DASH. IT'S NOT THE LIGHT SWITCH THAT'S NOT WORKING IT TESTES GOOD AND NOTHING WRONG WITH IT. THE DOOR LATCH IS DEFECTIVE IN THE SMALL DOOR, WON'T STAY LATCHED OR IN THE CLOSED POSITION , IT ON LATCHES ON IT'S OWN OR AFTER HITTING A SMALL HOLE OR BUMP IN THE ROAD .AND IT DON'T TAKE MUCH TO ON LATCH IT YOU CAN DO IT VERY EASY BY JUST GRABBING THE BOTTOM OF THE DOOR AND PULL IT A LITTLE AND IT LETS GO!! NOT VERY SAFE AND VERY DANGEROUS I WOULD SAY IN A WRECK OR ROLL OVER IT WOULD FLY OPEN YOU WOULD BE THROWN FROM THE TRUCK I WOULD SAY!! THE SEATBELTS ARE ATTACHED TO THIS SMALL FOR YOU IN THE FRONT SEAT AND ANY BODY IN THE SMALL SEAT BEHIND YOU!! THIS SERIOUS AND FORD MADE TO RECALL THESE TRUCKS AND FIXED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10448901February 22, 2012
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT THERE WAS A DEFECT WITH THE SAFETY SWITCH, WHICH CAUSED THE VEHICLE TO STALL WITHOUT WARNING. THE DEALER DIAGNOSED THAT THERE WAS A SHORT IN THE SAFETY SWITCH, WHICH CUT FUEL LINES THAT ALLOWED THE VEHICLE TO OPERATE. THE DEALER REPLACED THE SAFETY SWITCH. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE FAILURE. THE FAILURE MILEAGE WAS 18,000 AND THE CURRENT MILEAGE WAS 23,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10448975February 22, 2012
SUSPENSION
TL* THE CONTACT OWNS A 2006 FORD RANGER. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SHIFT SIDEWAYS ABNORMALLY. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE WHEEL WAS EMITTING SMOKE AND THE WHEEL WAS PARTIALLY DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING WHERE THE MECHANIC STATED TO THE CONTACT THAT THE WHEEL BEARING WAS FRACTURED AND WOULD HAVE TO BE REPLACED. AFTER THE REPAIR, THE CONTACT NOTICED A WHINING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC WHERE THE MECHANIC STATED HAT THE FRONT WHEEL BEARING AND AXLE WOULD HAVE TO BE REPLACED. THE CONTACT WAS NOT AWARE IF THE FAILURE OCCURRED ON THE DRIVER OR PASSENGER SIDE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 23,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10441291December 27, 2011
VEHICLE SPEED CONTROL
THE FIRST INCIDENT OCCURRED ON 12/15/2011 AS I WAS TRAVELING FROM SAVANNAH, GA. TO ATLANTA, GA. I WAS GETTING OFF MY EXIT TO THE I675 AND SLOWED DOWN BY HITTING THE BRAKE AND THE VEHICLE STARTED TO SPEED UP. I WAS NOT USING THE SPEED CONTROL AT ALL AS I MISSED MY EXIT AND SHUT THE VEHICLE OFF IN ORDER TO STOP. ON 12/22/2011 I WAS COMING HOME TO DETROIT, MI. AND HAD AN ACCIDENT IN GA. I WAS TRAVELING AT 35 MPH, IT WAS RAINING HEAVILY AND AS I PROCEEDED TO SLOW DOWN AROUND A CURVE I IMMEDIATELY LOST CONTROL OF VEHICLE AS THE TRUCK FISHTAILED INTO ONCOMING TRAFFIC AND I TURNED MY WHEEL TO AVOID A COLLISION WITH 2 VEHICLES IN THAT LANE AND ENDED UP IN A CULVERT.I SUSTAINED MINOR INJURIES BUT LUCKILY THERE WERE NO OTHER INJURIES OR DEATHS AS THIS VEHICLE WAS THE ONLY ONE INVOLVED. AT THAT TIME I DID NOT PUT 2 AND 2 TOGETHER AS I THOUGHT THE ROAD WAS SLIPPERY AND I COULDN'T AVOID WHAT HAD HAPPENED. ON 12/24/2011, I VISITED MY FAMILY IN ROCHESTER, MI. AND WENT TO SLOW DOWN AT A LIGHT AND THE VEHICLE BEGAN SPEEDING UP AGAIN CAUSING ME TO GO THROUGH THE LIGHT AND I TURNED THE ENGINE OFF BECAUSE I COULD NOT STOP THE VEHICLE AND I REALIZED THE PEDDLE WAS TO THE FLOOR. LUCKILY I WAS DRIVING THIS VEHICLE INSTEAD OF MY SISTER WHO ACTUALLY OWNS THIS. THIS IS MY FIRST ACCIDENT SINCE I HAVE GOTTEN MY LICENSE BACK IN 1968 AND IT COULD HAVE BEEN A LOT WORSE. AT NO TIME WAS I USING THE SPEED CONTROL. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10410633July 6, 2011
FUEL SYSTEM, GASOLINE
DRIVING DOWN NJ GSP AND 2006 FORD RANGER ENGINE STOPPED COLD IN HEAVY TRAFFIC. FUEL CUT OFF SWITCH ACTIVATED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10408562June 22, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THE VEHICLE WAS COMPLETELY DESTROYED DUE TO A FIRE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE AND THEY STATED THE FIRE COULD HAVE BEEN CAUSED BY THE BATTERY. THE CONTACT DID NOT CONTACT THE MANUFACTURER REGARDING THE FIRE. THE VEHICLE FIRE COULD HAVE BURNED DOWN HER HOME IF THE VEHICLE WAS PARKED CLOSER TO THE HOUSE. THE MILEAGE AND VIN WERE UNKNOWN.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0

← Back to Ford Ranger