Ford Edge Service Bulletins (2019)
203 manufacturer communications on file.
- May 3, 2021•Document ID: 10194386Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN
- Mfr Comm. #:
- SSM 49769
- Date Added:
- June 1, 2021
- Manufacturer:
- FORD
SummarySome 2019-2021 Edge/Nautilus vehicles equipped with all-wheel drive (AWD) may exhibit a noise/vibration/chatter/shudder/grind/bind from the rear of the vehicle during low speed turning events. To correct the condition, reprogram the AWD module using the latest software level of the appropriate Ford diagnostic scan tool. For claiming use casual part RECAL and applicable labor times in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (9)Associated Documents - April 28, 2021•Document ID: 10191521Service Bulletin/Repair InstructionsBACK OVER PREVENTION:SOFTWARE
- Mfr Comm. #:
- SSM 49756
- Date Added:
- May 3, 2021
- Manufacturer:
- FORD
SummarySome 2018-2021 vehicles supported by FDRS may not list a software update for a module under the SW Updates tab although an SSM or TSB is published for a software update. This may be due to the module already being at the latest software level. A later software level may have been programmed at the assembly plant, during a previous dealer visit or by an over the air (OTA) update for vehicles that have automatic updates enabled in the SYNC system settings. To review a vehicle's OTA update history, visit the Connected Vehicle > OTA Dashboard tab in OASIS. Information about the OTA Dashboard can be found on FMCDealer.com when performing a search on OTA History Job Aid.
Associated Products (57)2021 Ford Bronco Sport2021 Ford Edge2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford Mustang2021 Ford Mustang Mach-E2021 Ford Ranger2021 Ford Transit2021 Lincoln Aviator2021 Lincoln Corsair2021 Lincoln Nautilus2021 Lincoln Navigator2020 Ford Edge2020 Ford Escape+ 37 moreAssociated Documents - March 19, 2021•Document ID: 10189572Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- SSM 49679
- Date Added:
- March 31, 2021
- Manufacturer:
- FORD
SummarySome 2015-2020 Edge, 2016-2018 MKX, and 2019-2020 Nautilus vehicles may require replacement of the roof opening panel track or frame for various conditions. When replacing the roof opening panel, the replacement component may have less magnet plates. In order to prevent any noise vibration or harshness (NVH) concerns, the magnets on the headliner around the roof opening panel that line up with the removed magnet plates should be discarded.
Associated Products (11)Associated Documents - March 19, 2021•Document ID: 10189788Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; POWER TRAIN
- Mfr Comm. #:
- TSB 21-2081
- Date Added:
- April 3, 2021
- Manufacturer:
- FORD
SummarySome 2019-2021 Edge and 2019-2020 Nautilus vehicles built on or before 11-Mar-2021 and equipped with a 8F35 transmission may exhibit a shudder/buck/jerk while driving up to 35 mph (57 km/h). This may be due to the software in the powertrain control module (PCM). To correct this condition, follow the Service Procedure steps to reprogram the PCM and the transmission solenoid strategy.
Associated Products (5)Associated Documents - March 18, 2021•Document ID: 10189590Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 49676
- Date Added:
- March 31, 2021
- Manufacturer:
- FORD
SummarySome 2021 Mustang Mach-E vehicles may experience a concern of the alarm activating when an unlocked door is opened, the driver door does not unlock/open when pressing the door activation switch, or the door activation switch not lighting up. This may be due to a software configuration in the body control module (BCM). To correct the condition, reprogram the BCM using the latest software level of the appropriate Ford diagnostic scan tool. For claiming, use causal part 15604 and applicable labor times in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (14)Associated Documents - March 16, 2021•Document ID: 10189566Service Bulletin/Repair InstructionsVISIBILITY:REAR WINDOW WIPER/WASHER:SWITCH/WIRING
- Mfr Comm. #:
- SSM 49668
- Date Added:
- March 31, 2021
- Manufacturer:
- FORD
SummarySome 2019-2020 Edge vehicles may exhibit a condition where the rear wiper continuously operates. This may be due to a pinched or damaged wire in the liftgate where the harness enters the liftgate causing a short to ground. To correct the condition, inspect the area where the wiring harness enters the liftgate and repair any damage found to the wiring.
Associated Products (2)Associated Documents - February 15, 2021•Document ID: 10187981Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 49571
- Date Added:
- March 3, 2021
- Manufacturer:
- LINCOLN
SummarySome 2019-2021 Edge/Nautilus, 2020-2021 Escape/Corsair, 2021 Bronco Sport vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events due to fluid contamination. Drain and refill the rear drive unit (RDU), refer to Workshop Manual Section (WSM) 205-02. Drive for 8 km (5 miles) in stop and go conditions with right and left turns and re-evaluate. If the issue is still present, continue with WSM diagnostics. For claiming, use base (4000) causal part.
Associated Products (13)Associated Documents - February 10, 2021•Document ID: 10187945Service Bulletin/Repair InstructionsEQUIPMENT; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 49565
- Date Added:
- March 3, 2021
- Manufacturer:
- LINCOLN
SummarySome 2019-2020 Edge/Nautilus vehicles may exhibit an inoperative power liftgate with or without diagnostic trouble code U3000-49 stored in the rear gate trunk module (RGTM). This may be due to the RGTM software. To correct the condition, reprogram the RGTM using the latest software level of the appropriate Ford diagnostic scan tool. For claiming use causal part 14B291 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (6)Associated Documents - February 3, 2021•Document ID: 10187930Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SSM 49541
- Date Added:
- March 3, 2021
- Manufacturer:
- FORD
SummarySome 2018-2020 Ford and Lincoln vehicles equipped with TCU and WiFi Hotspot, May display Vehicle Hotspot feature not enabled on this vehicle when attempting to enter the Hotspot menu. When using the FordPass/Lincoln Way application, the customer may receive a message saying Wi-Fi has been disabled from this vehicle. Check the vehicle specifications or vehicle build information for the mfal code on the PTS website (Detailed Vehicle Specifications). If mfal = WAFAC or WAFAB do not replace the TCU, engineering is currently investigating this condition. Inform customers Ford is developing a software fix that is expected in early March. In the interim, let the customer know they can continue to drive the vehicle and schedule a follow-up appointment with the customer for early March. Monitor OASIS for updates.
Associated Products (69)2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Nautilus+ 49 moreAssociated Documents - January 20, 2021•Document ID: 10186620Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SSM 49477
- Date Added:
- February 4, 2021
- Manufacturer:
- LINCOLN
SummarySome 2015-2021 F-150, 2016-2018 MKX, 2019-2021 Nautilus, 2015-2021 Edge, 2017-2019 Fusion, 2017-2020 MKZ And 2017-2020 Continental vehicles equipped with a 2.7L/3.0L EcoBoost engine may appear to have a low engine oil level if the proper procedures are not followed. Refer to the Owner's Manual > Maintenance > Engine oil check section. When checking the engine oil level after shutting off the engine wait at least 15 minutes prior to checking in order to allow the oil to drain back to the oil pan. The engine oil level can be checked immediately if the engine has not been started. When changing the engine oil the engine needs to be at normal operating temperature and the oil filter removed before draining the oil. Allow the oil pan to drain completely for up to 5 minutes. Check oil level after filling by following the oil level check procedure.
Associated Products (34)2021 Ford Edge2021 Ford F-1502021 Lincoln Nautilus2020 Ford Edge2020 Ford F-1502020 Lincoln Continental2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Nautilus2019 Ford Edge2019 Ford F-1502019 Ford Fusion2019 Lincoln Continental2019 Lincoln MKX2019 Lincoln MKZ2019 Lincoln Nautilus2018 Ford Edge2018 Ford F-1502018 Ford Fusion2018 Lincoln Continental+ 14 moreAssociated Documents - January 5, 2021•Document ID: 10186564Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 49427
- Date Added:
- February 4, 2021
- Manufacturer:
- FORD
SummarySome 2019-2020 Edge/Nautilus/Ranger, 2020 Escape and 2020-2021 Corsair/Explorer vehicles equipped with a 2.0L/2.3L EcoBoost may exhibit a lack of power with an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P02AB, P0243, P0299, P1464, P25B3, P25B4, P2AB7, P2AB8 and/or P2AB9. This may be due to a missing wastegate actuator e-clip. A lower level service component has been released, K2GZ-9G488-B for Edge/Nautilus/Escape/Corsair vehicles and LB5Z-9G488-B for Explorer/Ranger vehicles, for service to replace the actuator, actuator rod and both e-clips. Turbocharger replacement is not necessary for missing wastegate actuator e-clips.
Associated Products (13)Associated Documents - November 11, 2020•Document ID: 10183569Service Bulletin/Repair InstructionsFUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP; ENGINE AND ENGINE COOLING; EQUIPMENT
- Mfr Comm. #:
- SSM 49328
- Date Added:
- December 4, 2020
- Manufacturer:
- FORD
SummarySome 2019 MKC, 2019-2020 Edge/Nautilus/Escape/Ranger, 2020 Corsair, 2019-2021 Explorer vehicles equipped with 2.0L and 2.3L EcoBoost engines may exhibit a light to moderate ticking type noise at idle (600-700 RPM). The noise is usually more prominent in the area of the high-pressure fuel pump, located on the top of the engine just behind the number 4 ignition coil. This noise is not detrimental to engine function and has no short or long-term effects on engine durability. This an operating characteristic of these engines and no repairs should be attempted.
Associated Products (15)Associated Documents - October 29, 2020•Document ID: 10181931Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
- Mfr Comm. #:
- SSM 49292
- Date Added:
- November 4, 2020
- Manufacturer:
- FORD
SummarySome 2018-2020 Ford and Lincoln vehicles may exhibit inoperative remote features via the Ford Pass/Lincoln Way mobile app, incomplete user authorization, no modem electronic serial number (ESN) displayed or DTCs U2100 and/or B156D in the telematics control unit (TCU). These symptoms may persist even after performing a TCU software update and/or replacement. To correct this condition, start a new session with the latest version of the appropriate diagnostic scan tool and perform a PMI on the TCU. If issues persist, open a hotline assistance request and include the IDS version (if applicable) used to perform the PMI and the Authorization Status PID value in the TCU datalogger. For claiming use causal part 14H092 and applicable labor times in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (49)2020 Ford Edge2020 Ford Expedition2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Nautilus2020 Lincoln Navigator2019 Ford Edge2019 Ford Escape2019 Ford Expedition+ 29 moreAssociated Documents - October 26, 2020•Document ID: 10181913Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SSM 49284
- Date Added:
- November 4, 2020
- Manufacturer:
- FORD
SummarySome 2018-2020 Ford and Lincoln vehicles equipped with TCU and WiFi Hotspot, May display Vehicle Hotspot feature not enabled on this vehicle when attempting to enter the Hotspot menu. When using the FordPass/Lincoln Way application, the customer may receive a message saying Wi-Fi has been disabled from this vehicle. Check the vehicle specifications or vehicle build information for the mfal code. If mfal = WAFAC or WAFAB do not replace the TCU, engineering is currently investigating this condition. Inform customers Ford is developing a software fix that is expected in early January. In the interim, let the customer know they can continue to drive the vehicle and schedule a follow-up appointment with the customer for early January. Once the update becomes available, contact the customer and confirm the service appointment is going forward. Monitor OASIS for updates.
Associated Products (71)2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ+ 51 moreAssociated Documents - October 20, 2020•Document ID: 10181924Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 20-2363
- Date Added:
- November 5, 2020
- Manufacturer:
- FORD
SummarySome 2019 MKZ, 2019-2020 EcoSport/Mustang/Continental/Fusion/F-150/Transit Connect/Ranger/Edge/Nautilus and 2020 Escape/Corsair/Aviator/Explorer/Expedition/Navigator/F-Super Duty vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure.
Associated Products (37)2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-7502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln Nautilus+ 17 moreAssociated Documents - October 16, 2020•Document ID: 10181909Service Bulletin/Repair InstructionsSTRUCTURE:BODY:HATCHBACK/LIFTGATE; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SSM 49267
- Date Added:
- November 4, 2020
- Manufacturer:
- FORD
SummarySome 2019-2020 Edge/Nautilus vehicles may exhibit an inoperative power liftgate with diagnostic trouble code (DTC) B144F:79 stored in the rear gate trunk module (RGTM). This may be due to the calibration of the RGTM. To resolve the concern, reprogram the RGTM using the latest software level of the appropriate Ford diagnostic scan tool. For claiming use causal part number 14B291 and Section 10 of the Service Labor Time Standards (SLTS) Manual. Do not replace the power strut unless DTC B144F remains after reprograming the RGTM.
Associated Products (4)Associated Documents - October 16, 2020•Document ID: 10181908Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 49266
- Date Added:
- November 4, 2020
- Manufacturer:
- LINCOLN
SummarySome 2020 Edge/Nautilus vehicles built on 12-Aug-2020 and through 22-Aug-2020 may exhibit a customer concern of the FordPass or Lincoln Way mobile apps unable to connect to the vehicle. The customer may state that there is no activate button on the FordPass or Lincoln Way mobile app. This may be due to the telematics control unit (TCU) module. To correct the condition, reprogram the TCU using As-Built data. For claiming use causal component 14G087 and labor operations from Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (4)Associated Documents - September 29, 2020•Document ID: 10180674Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:ADAS:BLINDSPOT:SOFTWARE; EQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- SSM 49217
- Date Added:
- October 6, 2020
- Manufacturer:
- FORD
SummarySome 2015-2020 F-150/Mustang, 2016-2020 Edge, 2016-2018 MKX and 2019-2020 Nautilus vehicles built on or before 18-Jan-2020 may exhibit a mirror click and/or ratcheting noise when using memory functions or easy entry/exit function. This may be due to the software in the driver door module (DDM) and passenger door module (PDM). To correct the condition, reprogram the DDM and PDM with the latest software level of the appropriate Ford diagnostic scan tool. For claiming use causal part 14B291 and applicable labor times in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (24)2020 Ford Edge2020 Ford F-1502020 Ford Mustang2020 Lincoln MKX2020 Lincoln Nautilus2019 Ford Edge2019 Ford F-1502019 Ford Mustang2019 Lincoln MKX2019 Lincoln Nautilus2018 Ford Edge2018 Ford F-1502018 Ford Mustang2018 Lincoln MKX2017 Ford Edge2017 Ford F-1502017 Ford Mustang2017 Lincoln MKX2016 Ford Edge2016 Ford F-150+ 4 moreAssociated Documents - September 25, 2020•Document ID: 10180428Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SSM 49210
- Date Added:
- October 6, 2020
- Manufacturer:
- FORD
SummarySome 2009-2020 Ford and Lincoln vehicles equipped with turbochargers may exhibit an oil leak from the turbocharger oil supply or return tubes, O-rings or 6.7L pedestal gasket. Although oil may collect on the turbocharger, it is very rare for a turbocharger to leak oil. To isolate the source of the leak, refer to Workshop Manual (WSM), Section 303-00 General Information > Diagnosis and Testing > Engine > Engine Oil Leaks - Fluorescent Oil Additive Method procedure. When an oil leak is present at a turbocharger oil supply or drain tube, remove the affected oil tube and inspect for damage, and replace the O-ring seals, pedestal gasket or oil tube as required. Refer to WSM, Section 303-04. For claiming, use the affected oil tube or pedestal gasket as the causal part and applicable labor operations in Sections 6 and 9 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (150)2020 Ford Edge2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Navigator2019 Ford Edge2019 Ford Escape2019 Ford Expedition2019 Ford Explorer2019 Ford F-150+ 130 moreAssociated Documents - September 14, 2020•Document ID: 10180392Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 49179
- Date Added:
- October 6, 2020
- Manufacturer:
- LINCOLN
SummarySome 2015-2020 Edge, 2016-2018 MKX, and 2019-2020 Nautilus vehicles may exhibit the parking lamps stay on and/or the trailer lights flicker with vehicle turned off when a trailer is connected to the vehicle. This may be due to the software in the trailer module (TRM). To correct the condition, reprogram the TRM with the latest software of the appropriate Ford diagnostic scan tool. Use causal part 19H332 and applicable labor times from Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (13)Associated Documents