Dodge Durango Complaints (2004)

1,115 consumer complaints on file.

#10683550February 15, 2015
ENGINE
AFTER A RAINSTORM, I WENT TO START MY VEHICLE AND IT WOULDN'T TURN OVER. THINKING IT WAS THE STARTER, I REPLACED THE STARTER AND VEHICLE STILL WOULD NOT START. AFTER MANUALLY ROTATING THE ENGINE BACK AND FORTH A FEW TIMES, THE ENGINE STARTED BUT THEN HAD A VERY LOUD ENGINE KNOCK. THE VEHICLE WAS NOT OFFICIALLY DIAGNOSED BY A MECHANIC BUT ALL INDICATIONS ARE THAT IT IS ENGINE ROD FAILURE DUE TO HYDROLOCK CONDITION. THIS IS SUPPORTED BY THE IDEA THAT THE ENGINE WOULD FREQUENTLY STALL DURING THE RAIN AND IN THE CAR WASH, AS MANY OTHERS HAVE REPORTED. IT HAD PROGRESSIVELY GOTTEN WORSE OVER THE COURSE OF A YEAR UNTIL THIS HAPPENED. VEHICLE WAS SOLD AS-IS FOR REPAIR OR ENGINE REPLACEMENT FOR FRACTION OF RETAIL VALUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10683280February 13, 2015
ENGINE
TL* THE CONTACT OWNS A 2004 DODGE DURANGO. WHILE STARTING THE VEHICLE, THE CONTACT HEARD AN ABNORMAL RATTLING SOUND. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE ENGINE HAD A HOLE BECAUSE THE ROD BLEW OUT OF THE ENGINE. THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 3/31/15*CN UPDATED 04/14/15
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10683069February 12, 2015
AIR BAGS
TL* THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V770000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10682185February 9, 2015
AIR BAGS
TL*THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V770000 (AIR BAGS) HOWEVER, THE PARTS NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10680682February 2, 2015
ENGINE, POWER TRAIN
STARTED CAR FOR FIRST TIME AFTER BAD RAINSTORM OVER WEEKEND. HEARD VERY LOUD CLANGING NOISE. HOLE IN OIL PAN, OIL LEAKED OUT EVERYWHERE. AFTER TAKING APART THE MOTOR, SERVICE CENTER DISCOVERED A ROD SHAFT HAD SHEARED IN HALF AND SHOT THROUGH THE ENGINE BLOCK AND OIL PAN. DISCOVERED IT WAS CAUSED BY WATER GETTING INTO ENGINE THROUGH SPARK PLUGS. BECAUSE OF THIS, THE WARRANTY COMPANY WON'T COVER AN ENGINE REPLACEMENT. WE HAVE TAKEN IN THIS VEHICLE TO SAME SERVICE STATION BEFORE OVER THE TWO YEARS WE HAVE OWNED IT BECAUSE IT WOULD STALL WHILE DRIVING IN BAD RAINSTORM. COULD NEVER FIND A PROBLEM. READ A LOT OF ARTICLES ONLINE ATTRIBUTING ALL OF THIS TO A DESIGN FLAW IN THE HOOD OF THIS VEHICLE. I KNOW WE ARE NOT THE ONLY OWNERS OF A 2004 DODGE DURANGO WHO HAVE EXPERIENCED THIS. SOMETHING NEEDS TO BE DONE TO RESOLVE THE DESIGN FLAW AND COMPENSATE US FOR HAVING TO REPLACE AN ENGINE THAT, APART FROM BEING IN A POORLY DESIGNED CAR, IS OTHERWISE IN GREAT CONDITION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10680514February 2, 2015
AIR BAGS
TL* THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER:14V354000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679266January 27, 2015
ENGINE
THE RAIN SHE ATTEMPTED TO START THE VEHICLE A LOUD UNKNOWN NOISE CAME FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THE ENGINE NEEDED TO BE REPLACED. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,000.[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10677126January 21, 2015
ENGINE
WENT OUT TO START VEHICLE IN THE MORNING AND IT WOULD NOT CRANK OVER. TRIED SEVERAL TIMES, IT WAS RAINING AT THE TIME. LEFT VEHICLE FOR A FEW HOURS, RETURNED LATER TO START AND LOUD CLUNK COMING FROM MOTOR. LIFTED HOOD AND FOUND INTAKE TO BE TOTALLY COVERED IN WATER. WATER WAS FLOWING DOWN WINDSHIELD AND DIRECTLY OVER TOP OF MOTOR. UPON INSPECTION CONNECTING ROD WAS BROKEN DUE TO HYDRO LOCKING. APPARENTLY THIS IS A PROMINENT ISSUE WITH THIS MODEL. ENGINE NEEDS TO BE REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10676619January 20, 2015
ENGINE
TL* THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT STATED THAT WHILE PARKED, THE HYDRO EXTENSION CYLINDER BECAME FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 111,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10676419January 19, 2015
ENGINE
DAUGHTER WAS DRIVING VEHICLE ON THE HIGHWAY. VEHICLE STARTED SHAKING AND THEN MADE LOUD NOISE LIKE A HAMMER HITTING ENGINE, THEN STARTED SMOKING WHITE SMOKE COMING FROM THE ENGINE. VEHICLE QUIT RUNNING. DAUGHTER WAS ABLE TO GET TO THE SHOULDER. TRIED STARTING AGAIN AND ENGINE WAS RUNNING VERY ROUGH, SMELLED LIKE ELECTRICAL BURN AND BLOWING WHITE SMOKE. SHUT OFF ENGINE AND HAD VEHICLE TOWED. MECHANIC STATED ENGINE HAS TO BE REPLACED. HAVING VEHICLE TOWED TO DODGE DEALER FOR SECOND OPINION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10676245January 17, 2015
ENGINE
AS I WAS DRIVING DOWN THE STREET IN LIGHT RAIN MY 2004 DODGE DURANGO BEGIN TO SHAKE AND STALL. AS I CAME TO A STOP I RECALL THE SUV SMOKING. I STOP THE SUV IMMEDIATELY AND COULD TELL THE SMOKE WAS COMING FROM UNDER THE HOOD. I NOTIFIED MY MECHANIC AND HAD THE TRUCK TOWED TO THE SHOP WHERE HE TOLD ME THE COWL PANEL WAS ALLOWING WATER TO LEAK ONTO MY ENGINE WHICH WOULD CAUSE WATER TO GET INTO MY INTAKE THAT WOULD RESULT INTO A BLOWN ENGINE. I NOTIFIED CHRYSLER/DODGE TO NO AVAIL THEY ACT AS IF THEY HAVE NEVER HEARD OF THE ISSUE, WHICH IS SURELY INCORRECT BECAUSE OF ALL THE POST OF PEOPLE WOULD COMMON ISSUES WITH THERE DODGE DURANGO. THIS SHOULD DEFINITELY BE A RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10673000January 16, 2015
ENGINE
TL* THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ON THE FIRST ATTEMPT. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10672782January 15, 2015
ENGINE
WE HAVE KEPT THIS DURANGO IN IMMACULATE SHAPE AND HAVE CONSISTENTLY DONE OF THE RECOMMENDED UPKEEP ON THE VEHICLE. WE CHANGE THE OIL EVERY 3,000 MILES. I WAS DRIVING DOWN THE ROAD GOING APPROXIMATELY 50 MILES PER HOUR WHEN WITHOUT WARNING THE ENGINE JUST STARTED MAKING A LOUD NOISE. IT WAS DANGEROUS BECAUSE I HAD NOWHERE TO PULL OVER AND HAD TO CONTINUE APPROXIMATELY 1 MILE BEFORE I COULD GET TO A SHOULDER AND BEHIND ME WERE MULTIPLE VEHICLES. UNDERNEATH THE VEHICLE WAS OIL. THE MECHANIC SAYS THAT THERE IS A HOLE IN THE ENGINE AND IT IS COMPLETELY BLOWN-CATASTROPHIC. ENGINE FAILURE THAT WILL COST $6000 TO REPLACE. ALTHOUGH WE HAVE USED THE VEHICLE FOR 10 YEARS, WE HAVE BARELY PUT 12000 MILES PER YEAR ON IT. AFTER SOME RESEARCH ON THE INTERNET WE FOUND OUT THAT THERE HUNDREDS IF NOT THOUSANDS OF OTHER SIMILAR COMPLAINTS ON THIS ENGINE, MANY OF THEM PROBABLY UNREPORTED TO THE NHTSA. THE '05 AND LATER MODELS DO NOT SHOW ANYWHERE NEAR A SIMILAR AMOUNT OF ENGINE FAILURE COMPLAINTS. I WOULD HAVE TO BELIEVE THAT THERE HAVE. WE ARE DISGUSTED AND WOULD LIKE SOMEONE TO LOOK INTO THIS-A CLASS ACTION LAWSUIT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10671879January 12, 2015
ENGINE
TL* THE CONTACT OWNS A 2004 DODGE DURANGO. WHILE DRIVING 40 MPH, THE CONTACT HEARD A BANGING NOISE COMING FROM THE VEHICLE AND THE ENGINE COMPLETELY SHUT OFF WITHOUT WARNING. THE VEHICLE RESTARTED AND WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ENGINE WAS FAULTY. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10671898January 12, 2015
POWER TRAIN
NOTICED THE SVC 4WD LIGHT CAME ON THE DASH BOARD AND THEN THE VEHICLE'S REAR WHEELS LOCKED WHEN MAKING A TIGHT TURN INTO A PARKING SPACE. THE VEHICLE STOPPED AND WAS UNABLE TO MOVE AS IF BRAKE HAD BEEN APPLIED VERY HARD. UNPLUGGED THE BATTERY FOR ABOUT A MINUTE TO ALLOW THE SYSTEM TO RESET. THE SVC 4WD LIGHT DOESN'T COME ON. HOWEVER, THE VEHICLE STILL LOCKS ITS REAR WHEELS WHEN MAKING A TIGHT TURN INTO A PARKING SPACE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10671635January 11, 2015
ENGINE
TRIED TO START MY TRUCK AND ALL I AM HEARING IS LOUD KNOCKING. NO NOTICE OF ANYTHING BEING WRONG! ACCORDING TO ALL THE RESEARCH I HAVE DONE TO FIGURE OUT WHAT THE SOUND IS, IT IS MOST LIKELY THE HYDROLOCK PROBLEM THAT CHRYSLER IS AWARE OF. I AM LUCKY THAT THIS DID NOT HAPPEN WHEN I WAS DRIVING , OR SOMEONE COULD HAVE GOTTEN SERIOUSLY HURT OR KILLED . IS THAT WHAT CHRYSLER IS WAITING FOR BEFORE SOMETHING IS DONE? IF WE WOULD HAVE KNOWN THIS ISSUE WAS EVEN POSSIBLE OF HAPPENING WE MAY HAVE BEEN ABLE TO PREVENT IT BY FIXING THE SEAL. NOW WE HAVE A VEHICLE THAT LOOKS PRETTY, BUT IS UNDRIVABLE, AND CAN'T AFFORD TO FIX IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10668740December 29, 2014
ENGINE
HAD JUST FIXED THE SENSORS ON THE TRUCK, PUT NEW BATTERY AND NEW TIRES. TOTALING OVER $1200. DRIVING THROUGH UNAVOIDABLE PUDDLES ON THE HIGHWAY, DURING A HEAVY RAIN IN MY AREA OF 4.5 INCHES. PARKED THE CAR IN MY DRIVEWAY AND WENT TO START IT THE NEXT MORNING AND HEARD THIS VERY LOUD GRINDING. HAD THE CAR TOWED. DIAGNOSIS: ENGINE HYDROLOCK. APPARENTLY DODGE HAS KNOWN OF THIS PROBLEM AS I SEE THOUSANDS OF COMPLAINTS ON YOUTUBE AND SIMILAR SITES. A $130 PART COULD'VE PREVENTED THIS FROM HAPPENING BUT WE WERE NEVER NOTIFIED OF THE PROBLEM. NOT SURE WHAT TO DO AT THIS POINT. DODGE REFUSING TO HELP AND INSURANCE SAYING IT IS A KNOWN DEFECT SO THEY WON'T COVER IT EITHER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10668330December 26, 2014
ENGINE
TL* THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THE VEHICLE STARTED SHAKING AND STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT SMELLED A BURNING ODOR AND SAW SMOKE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 132,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10667872December 23, 2014
ENGINE
TL* THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE AREA. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 111,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10667452December 20, 2014
FUEL/PROPULSION SYSTEM
I WAS FILLING UP MY GAS TANK WHEN THE CAR STARTED SPITTING OUT GAS AT ME. LUCKILY I STOPPED IT FAST ENOUGH BUT HAD SOME GAS ON ME AND ALL OVER THE SIDE OF MY CAR. I'VE LOOKED THIS UP AND IT SEEMS TO BE A BIG PROBLEM WITH THE DURANGOS. I REALLY WOULD LIKE TO FILL MY CAR UP WITHOUT WORRYING ABOUT BEING COVERED IN GAS OR MY CAR STARTING TO RUST. *DT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Dodge Durango