Dodge Dart Service Bulletins (2012)

152 manufacturer communications on file.

• January 8, 2016•Document ID: 10076429

  Service Bulletin/Repair Instructions
  SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

  Mfr Comm. #:

  D-16-01

  Date Added:

  July 14, 2016

  Manufacturer:

  JEEP

  Summary

  HYDRAULIC CLUTCH MASTER CYLINDER/RESERVOIR HOSE (X62)-2013-2015 DODGE DART AND 2014-2015 JEEP CHEROKEE.

  Associated Products (5)

  2015 Dodge Dart2015 Jeep Grand Cherokee2014 Dodge Dart2014 Jeep Grand Cherokee2012 Dodge Dart
  Associated Documents

  • DownloadMC-10076429-0001.pdf↗
• January 8, 2016•Document ID: 10074212

  Service Bulletin/Repair Instructions
  POWER TRAIN

  Mfr Comm. #:

  06-001-16

  Date Added:

  June 22, 2016

  Manufacturer:

  JEEP

  Summary

  SUMMARY TO BE PROVIDED ON A FUTURE DATE.

  Associated Products (4)

  2015 Jeep Cherokee2014 Dodge Dart2014 Jeep Cherokee2012 Dodge Dart
  Associated Documents

  • DownloadMC-10074212-0001.pdf↗
• December 22, 2015•Document ID: 10160073

  Service Bulletin/Repair Instructions
  POWER TRAIN; ELECTRICAL SYSTEM

  Mfr Comm. #:

  08-128-15

  Date Added:

  May 20, 2019

  Manufacturer:

  DODGE

  Summary

  Flash: Body Control Module (BCM) Diagnostic And System Improvements This bulletin involves updating the BCM software. Some customers may experience any of the following conditions: ? Engine starts then immediately stalls when using Remote Start system (Instrument Cluster may display the message ?Remote Start Disabled, Start Vehicle to Reset?). ? Engine cranks and does not start following the condition described above. ? Engine may be hard to re-start at ambient temps below -12°C (10°F). NOTE: The Powertrain Control Module (PCM) and Transmission Control Module (TCM) must be up to date for these changes to be effective.

  Associated Products (1)

  2012 Dodge Dart
  Associated Documents

  • DownloadMC-10160073-0001.pdf↗
• December 22, 2015•Document ID: 10160068

  Service Bulletin/Repair Instructions
  POWER TRAIN; ELECTRICAL SYSTEM

  Mfr Comm. #:

  21-069-15

  Date Added:

  May 20, 2019

  Manufacturer:

  DODGE

  Summary

  Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming of the Transmission Control Module (TCM) with the latest available software. Customers may experience any of the following symptoms: ? Transmission shift improvements when using cruise control. ? Improved garage shift feel and quality. NOTE: The Body Control Module (BCM) and Powertrain Control Module (PCM) must be up to date for these changes to be effective.

  Associated Products (1)

  2012 Dodge Dart
  Associated Documents

  • DownloadMC-10160068-0001.pdf↗
• December 22, 2015•Document ID: 10160066

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING; POWER TRAIN

  Mfr Comm. #:

  18-111-15

  Date Added:

  May 20, 2019

  Manufacturer:

  DODGE

  Summary

  Flash: 2.0L Powertrain Diagnostic And System Enhancements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) has been set in the PCM memory: ? P0456 - Evap System Small Leak. ? P0116 - Engine Coolant Temperature Sensor 1 Performance. ? P1D73 - AGS Performance - (Active Grille Shutters). ? P1607 - PCM Internal Shutdown Timer Rationality - (Powertrain Control Module). ? P2610 - PCM Internal Engine Off Timer Performance - (Powertrain Control Module). ? U0140 - Lost Communication With Body Control Module. ? P0335 - Crankshaft Position Sensor Circuit. ? P000B - Exhaust Slow Response Bank 1. ? P050B - Cold Start Ignition Timing Performance. ? P2173 - High Airflow/Vacuum Leak Detected (Slow Accumulation). In addition this software release includes improving the disable misfire monitor when P0335 (Crankshaft Position Sensor Circuit) is present.

  Associated Products (1)

  2012 Dodge Dart
  Associated Documents

  • DownloadMC-10160066-0001.pdf↗
• December 22, 2015•Document ID: 10074645

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  08-128-15

  Date Added:

  June 22, 2016

  Manufacturer:

  DODGE

  Summary

  SUMMARY TO BE PROVIDED ON A FUTURE DATE.

  Associated Products (1)

  2012 Dodge Dart
  Associated Documents

  • DownloadMC-10074645-0001.pdf↗
• December 18, 2015•Document ID: 10160052

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING; POWER TRAIN; ELECTRICAL SYSTEM

  Mfr Comm. #:

  18-006-15 REV H

  Date Added:

  May 20, 2019

  Manufacturer:

  DODGE

  Summary

  Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: 2015 UF Vehicles with (Sales Codes ED6, ED8) ? Improved vehicle acceleration. ? P0480 - Cooling Fan 1 Control Circuit/Open. ? P0456 - Evap System Small Leak. ? U0402 - Implausible Data Received From TCM. ? Engine Startup Flare and Idle Surge. ? P2172 - High Airflow/Vacuum Leak Detected. ? P1D73 - AGS Performance. ? U0140 - Lost Communication With Body Control Module. ? P0441 - Evap Purge System Performance. ? P0116 - Engine Coolant Temperature Sensor 1 Performance. ? P050D - Cold Start Rough Idle. 2015 PF Vehicles with (Sales Codes ED6, ED8) ? P0133 - O2 Sensor 1/1 Slow Response. ? P0456 - Evap System Small Leak. ? Low Idle Speed After Cold Start between 14°F to 32°F (-10°C to 0°C). ? Cold Idle Surge With AC Engaged. ? Improve cabin warm up in cold weather, when the vehicle is in park or neutral and the temperature is between 10°F to 40°F (-12°C to 4.5°C). ? P219A - Bank 1 Air-Fuel Ratio Imbalance. ? P2172 - High Airflow/Vacuum Leak Detected. ? P1D73 - AGS Performance. ? U0140 - Lost Communication With Body Control Module. ? P0116 - Engine Coolant Temperature Sensor 1 Performance. ? P050B - Cold Start Ignition Timing Performance. ? P050D - Cold Start Rough Idle. ? P061A - Level 2 Torque Performance. ? P2172 - High Airflow/Vacuum Leak Detected (Instantaneous Accumulation). 2013-2014 PF Vehicles (Sales Codes ED6)

  Associated Products (4)

  2015 Chrysler 2002015 Dodge Dart2014 Dodge Dart2012 Dodge Dart
  Associated Documents

  • DownloadMC-10160052-0001.pdf↗
• December 18, 2015•Document ID: 10074394

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM:SOFTWARE

  Mfr Comm. #:

  18-006-15 REV. H

  Date Added:

  June 22, 2016

  Manufacturer:

  DODGE

  Summary

  SUMMARY TO BE PROVIDED ON A FUTURE DATE.

  Associated Products (4)

  2015 Chrysler 2002015 Dodge Dart2014 Dodge Dart2012 Dodge Dart
  Associated Documents

  • DownloadMC-10074394-0001.pdf↗
• December 9, 2015•Document ID: 10159990

  Service Bulletin/Repair Instructions
  WHEELS; EQUIPMENT

  Mfr Comm. #:

  06509898A

  Date Added:

  May 20, 2019

  Manufacturer:

  JEEP

  Summary

  Part Description: Nut - Front Hub & Bearing Issue Description: Whenever replacing the front Hub & Bearing Halfshaft Nut, make sure to torque to proper spec of 150 ft/lbs (200 Nm) and crimp according to procedure in TechConnect. (This torrque is higher than other platforms). Failure to do so will result in eventual Hub & Bearing failure (noise).~

  Associated Products (4)

  2015 Dodge Dart2014 Dodge Dart2014 Jeep Cherokee2012 Dodge Dart
  Associated Documents

  • DownloadMC-10159990-0001.pdf↗
• October 26, 2015•Document ID: 10074730

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

  Mfr Comm. #:

  SB-18-020-15-B

  Date Added:

  June 22, 2016

  Manufacturer:

  DODGE

  Summary

  SUMMARY TO BE PROVIDED ON A FUTURE DATE.

  Associated Products (1)

  2012 Dodge Dart
  Associated Documents

  • DownloadMC-10074730-0001.pdf↗
• October 24, 2015•Document ID: 10151774

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING; ENGINE

  Mfr Comm. #:

  18-006-15 REV-G

  Date Added:

  December 17, 2018

  Manufacturer:

  DODGE

  Summary

  Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: 2015 UF Vehicles with (Sales Codes ED6, ED8). ? Improved vehicle acceleration. ? P0480 - Cooling Fan 1 Control Circuit/Open. ? P0456 - Evap System Small Leak. ? U0402 - Implausible Data Received From TCM. ? Engine Startup Flare and Idle Surge. ? P2172 - High Airflow/Vacuum Leak Detected. ? P1D73 - AGS Performance. ? U0140 - Lost Communication With Body Control Module. ? P0441 - Evap Purge System Performance. ? P0116 - Engine Coolant Temperature Sensor 1 Performance. ? P050D - Cold Start Rough Idle. 2015 PF Vehicles with (Sales Codes ED6, ED8), built on or before July 24, 2015 (MDH 0724XX). ? Low Idle Speed After Cold Start between 14°F to 32°F (-10°C to 0°C). ? Cold Idle Surge With AC Engaged. ? Improve cabin warm up in cold weather, when the vehicle is in park or neutral and the temperature is between 10°F to 40°F (-12°C to 4.5°C). ? P219A - Bank 1 Air-Fuel Ratio Imbalance. ? P2172 - High Airflow/Vacuum Leak Detected. ? P1D73 - AGS Performance. ? U0140 - Lost Communication With Body Control Module. ? P0116 - Engine Coolant Temperature Sensor 1 Performance. ? P050B - Cold Start Ignition Timing Performance. ? P050D - Cold Start Rough Idle. ? P061A - Level 2 Torque Performance. ? P2172 - High Airflow/Vacuum Leak Detected (Instantaneous Accumulation). 2013-2014 PF Vehicles. ? P219A - Bank 1 Air-Fuel Ratio Imbalance. ? P2251 - O2 Sensor 1/1 Negative Current Control Circuit Open. ? P106A - Cylinder 3 Oil Supply Solenoid Valve Switch Off Time Out Of Range. ? P2172 - High Airflow/Vacuum Leak Detec

  Associated Products (4)

  2015 Chrysler 2002015 Dodge Dart2014 Dodge Dart2012 Dodge Dart
  Associated Documents

  • DownloadMC-10151774-0001.pdf↗
• October 24, 2015•Document ID: 10151773

  Service Bulletin/Repair Instructions
  ENGINE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

  Mfr Comm. #:

  18-020-15 REV-B

  Date Added:

  December 17, 2018

  Manufacturer:

  DODGE

  Summary

  Flash: Driveability Enhancements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Codes (DTCs) have been set: ? P1128 - Closed Loop Fueling Not Achieved - Bank 1 Upstream ? P1D73 - 00 - AGS Performance ? P1CEA - Boost Side Evap Purge System Performance ? P0456 - Evap System Small Leak Customers may also experience any of the following symptoms: ? Customer experiences cold start issues below 14°F ( -10°C) ambient temperatures; engine turns over faster (loss of compression) during crank and possibly does not start until a key cycle is performed. ? Engine cranks as if it has no compression. ? Engine sounds like it is knocking at idle, noise goes away when off idle. ? Spark knock when using low octane fuel in the vehicle. ? Black smoke from tail pipe on initial start up during cold ambient temperatures. ? Uneven acceleration feeling under moderate to heavy throttle input. ? Bump or surge noticed prior to engine reaching normal operating temperature. ? Rough idle during A/C engagement/disengagement. ? During periods of extended idle or short hot soak events and ambient temperatures below 15°F (-9°C), engine idle speed may increase to 1800 RPM if coolant temperature drops below 158°F (70°C). Condition is only present when the transmission is in park. ? Low speed engine response improvements in city and traffic driving conditions. Updating the PCM software will correct the condition listed above.

  Associated Products (1)

  2012 Dodge Dart
  Associated Documents

  • DownloadMC-10151773-0001.pdf↗
• October 24, 2015•Document ID: 10074729

  Service Bulletin/Repair Instructions
  POWER TRAIN

  Mfr Comm. #:

  SB-18-006-15-G

  Date Added:

  June 22, 2016

  Manufacturer:

  CHRYSLER

  Summary

  SUMMARY TO BE PROVIDED ON A FUTURE DATE.

  Associated Products (4)

  2015 Chrysler 2002015 Dodge Dart2014 Dodge Dart2012 Dodge Dart
  Associated Documents

  • DownloadMC-10074729-0001.pdf↗
• October 15, 2015•Document ID: 10151757

  Service Bulletin/Repair Instructions
  EQUIPMENT; ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL

  Mfr Comm. #:

  08-098-15

  Date Added:

  December 17, 2018

  Manufacturer:

  DODGE

  Summary

  Hands Free Feature Inoperative This bulletin involves updating the Convergence Telematics Module (CTM) software. NOTE: Convergence Telematics Module (CTM) was also known as the Hands Free Module (HFM). The customer may notice that the hands free feature (Bluetooth) does not work. On further inspection one or more of the following DTCs may be found: ? U11F6-00 Lost Communication With Convergence Telematics Module. ? U11F6-87 Lost Communication With Convergence Telematics Module - Missing Message.

  Associated Products (4)

  2016 Dodge Dart2015 Dodge Dart2014 Dodge Dart2012 Dodge Dart
  Associated Documents

  • DownloadMC-10151757-0001.pdf↗
• October 3, 2015•Document ID: 10151728

  Service Bulletin/Repair Instructions
  SERVICE BRAKES

  Mfr Comm. #:

  05-011-15

  Date Added:

  December 17, 2018

  Manufacturer:

  DODGE

  Summary

  Front Brake Squeak/Squeal Noise This bulletin involves replacing the front brake rotors, front brake pads, and related hardware. The customer may describe a front brake squeak/squeal high frequency noise in the 6-7 kHz range while stopping, noise may be intermittent (not every stop).

  Associated Products (3)

  2015 Dodge Dart2014 Dodge Dart2012 Dodge Dart
  Associated Documents

  • DownloadMC-10151728-0001.pdf↗
• August 27, 2015•Document ID: 10148994

  Service Bulletin/Repair Instructions
  POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

  Mfr Comm. #:

  18-020-15 REV-A

  Date Added:

  November 26, 2018

  Manufacturer:

  DODGE

  Summary

  Flash: Driveability Enhancements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Codes have been set: ? P1128 - Closed Loop Fueling Not Achieved - Bank 1 Upstream. ? P1D73-00-AGS Performance. ? P1CEA- Boost Side Evap Purge System Performance. ? P0456- Evap System Small Leak. Customers may also experience any of the following symptoms: ? Engine cranks as if it has no compression. ? Engine sounds like it is knocking at idle, noise goes away when off idle. ? Spark knock when using low octane fuel in the vehicle. ? Black smoke from tail pipe on initial start up during cold ambient temperatures. ? Uneven acceleration feeling under moderate to heavy throttle input. ? Bump or surge noticed prior to engine reaching normal operating temperature. ? Rough idle during A/C engagement/disengagement. ? During periods of extended idle or short hot soak events and ambient temperatures below 15°F (-9°C), engine idle speed may increase to 1800 RPM if coolant temperature drops below 158°F (70°C). Condition is only present when the transmission is in park. ? Low speed engine response improvements in city and traffic driving conditions. Updating the PCM software will correct the condition listed above.

  Associated Products (1)

  2012 Dodge Dart
  Associated Documents

  • DownloadMC-10148994-0001.pdf↗
• August 27, 2015•Document ID: 10058924

  Service Bulletin/Repair Instructions
  ENGINE; EQUIPMENT

  Mfr Comm. #:

  SB18-020-15REV-A

  Date Added:

  December 21, 2015

  Manufacturer:

  DODGE

  Summary

  2012-2013 DODGE DART CUSTOMERS MAY NOTICE A MALFUNCTION INDICATOR LAMP ILLUMINATION. ALSO THE ENGINE MAY CRANK AS IF IT HAS NO COMPRESSION, ENGINE KNOCKING SOUNDS AT IDLE AND WHEN USING LOW OCTANE FUEL SPARK KNOCK IS PRESENT. *CN

  Associated Products (1)

  2012 Dodge Dart
  Associated Documents

  • DownloadMC-10058924-0001.pdf↗
• August 18, 2015•Document ID: 10148976

  Service Bulletin/Repair Instructions
  EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

  Mfr Comm. #:

  08-080-15

  Date Added:

  November 26, 2018

  Manufacturer:

  DODGE

  Summary

  RE2 RE6 RB5 RB6 Radio Software Enhancements This bulletin involves updating the radio software and navigation if equipped. A customer may experience one or more of the following conditions: ? Radio display screen will lock up and reset intermittently (2013-2014 MY Vehicles). ? Navigation screen goes blank (Software has been updated to better address this condition). ? Navigation system freezes/locks up (Software has been updated to better address this condition). ? Vehicles with Mopar special edition radio, update radio?s splash screen. (2013 Vehicles). ? Incorrect routing directions to fuel stations when using Travel Link. ? Unable to turn on heated seats, icon is greyed out. ? Navigation Icon shows the vehicle going backward when it is moving forward. ? Map Checksum error may be displayed when attempting to update the navigation system maps.

  Associated Products (3)

  2015 Dodge Dart2014 Dodge Dart2012 Dodge Dart
  Associated Documents

  • DownloadMC-10148976-0001.pdf↗
• August 15, 2015•Document ID: 10148971

  Service Bulletin/Repair Instructions
  POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); EQUIPMENT

  Mfr Comm. #:

  18-006-15 REV-F

  Date Added:

  November 26, 2018

  Manufacturer:

  DODGE

  Summary

  Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: 2015 UF Vehicles with (Sales Codes ED6, ED8), built on or before June 16, 2015 (MDH 0616XX). ? U0402 - Implausible Data Received From TCM. ? Engine Startup Flare and Idle Surge. ? P2172 - High Airflow/Vacuum Leak Detected. ? P1D73 - AGS Performance. ? U0140 - Lost Communication With Body Control Module. ? P0441 - Evap Purge System Performance. ? P0116 - Engine Coolant Temperature Sensor 1 Performance. ? P050D - Cold Start Rough Idle. 2015 PF Vehicles with (Sales Codes ED6, ED8), built on or before July 24, 2015 (MDH 0724XX). ? Low Idle Speed After Cold Start between 14°F to 32°F (-10°C to 0°C). ? Cold Idle Surge With AC Engaged. ? Improve cabin warm up in cold weather, when the vehicle is in park or neutral and the temperature is between 10°F to 40°F (-12°C to 4.5°C). ? P219A - Bank 1 Air-Fuel Ratio Imbalance. ? P2172 - High Airflow/Vacuum Leak Detected. ? P1D73 - AGS Performance. ? U0140 - Lost Communication With Body Control Module. ? P0116 - Engine Coolant Temperature Sensor 1 Performance. ? P050B - Cold Start Ignition Timing Performance. ? P050D - Cold Start Rough Idle. ? P061A - Level 2 Torque Performance. ? P2172 - High Airflow/Vacuum Leak Detected (Instantaneous Accumulation). 2013-2014 PF Vehicles. ? P219A - Bank 1 Air-Fuel Ratio Imbalance. ? P2251 - O2 Sensor 1/1 Negative Current Control Circuit Open. ? P106A - Cylinder 3 Oil Supply Solenoid Valve Switch Off Time Out Of Range. ? P2172 - High Airflow/Vacuum Leak Detected. ? P1D73 - AGS Performance. ? U0140 - Lost Communication With Bod

  Associated Products (4)

  2015 Chrysler 2002015 Dodge Dart2014 Dodge Dart2012 Dodge Dart
  Associated Documents

  • DownloadMC-10148971-0001.pdf↗
• August 15, 2015•Document ID: 10058714

  Service Bulletin/Repair Instructions
  EQUIPMENT

  Mfr Comm. #:

  SB18-006-15REV-D

  Date Added:

  November 5, 2015

  Manufacturer:

  DODGE

  Summary

  CUSTOMERS MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP ILLUMINATION. POWER CONTROL MODULE REQUIRES REPROGRAMMING WITH LATEST SOFTWARE AVAILABLE *CN UPDATED 12/21/15 *CN

  Associated Products (4)

  2015 Chrysler 2002015 Dodge Dart2014 Dodge Dart2012 Dodge Dart
  Associated Documents

  • DownloadMC-10058714-0001.pdf↗