Chevrolet Trailblazer Recalls (2003)

9 recalls on file.

• Recall05V494000October 27, 2005
  LATCHES/LOCKS/LINKAGES:DOORS:LATCH

  CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.

  Remedy

  DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.

• Recall05V198000May 5, 2005
  EXTERIOR LIGHTING:TURN SIGNAL

  ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.

  Remedy

  DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.

• Recall04V527000November 1, 2004
  EXTERIOR LIGHTING:BRAKE LIGHTS

  ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.

  Remedy

  DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.

• Recall04V046000February 4, 2004
  VISIBILITY:WINDSHIELD WIPER/WASHER

  CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.

  Remedy

  DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.

• Recall03V250000July 15, 2003
  EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

  CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.

  Remedy

  OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

• Recall03V151000April 23, 2003
  SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

  CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH A LEFT-FRONT BRAKE PIPE WITH A CIRCUMFERENTIAL SCORE AT A RANDOM LOCATION ALONG THE LENGTH OF THE PIPE AS THE RESULT OF THE MANUFACTURING PROCESS. IF THE BRAKE PIPE PARTIALLY OR FULLY FRACTURED, BRAKE PEDAL TRAVEL WOULD IMMEDIATELY INCREASE AND FRONT BRAKE PERFORMANCE WOULD BE REDUCED.

  Remedy

  DEALERS WILL REPLACE THE LEFT-FRONT BRAKE PIPE. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-8006.

• Recall03V075000March 6, 2003
  POWER TRAIN:AUTOMATIC TRANSMISSION

  CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN ADDITION, THESE VEHICLES HAVE AN OVERRIDE THAT CAN ALLOW THE TRANSMISSION TO BE SHIFTED OUT OF PARK WITH THE IGNITION IN THE OFF POSITION.

  Remedy

  DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR HUMMER AT 1-866-486-6376.

• Recall03V051000February 14, 2003
  AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

  ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.

  Remedy

  DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.

• Recall02V222000August 9, 2002
  AIR BAGS:FRONTAL

  CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

  Remedy

  DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.