Chevrolet Silverado Complaints (2006)

777 consumer complaints on file.

#10555161December 7, 2013
SERVICE BRAKES
WHILE STOPPING FOR TRAFFIC LIGHT, BRAKES WERE WEAK AND REQUIRED EXCESSIVE PRESSURE TO ACTIVATE ENOUGH TO STOP VEHICLE. PULLED INTO NEAREST PARKING LOT AND FOUND BRAKE FLUID DRIPPING FROM CHASSIS UNDER DRIVER DOOR AREA. CALLED TOW TRUCK TO TAKE VEHICLE TO DEALER. TRIED TO MOVE VEHICLE TO MAKE IT EASIER FOR TOW TRUCK OPERATOR TO HOOK UP AND PEDAL WENT COMPLETELY TO FLOOR WITH NO BRAKING EFFECT. USED PARKING BRAKE TO STOP. DEALER SAID ENTIRE BRAKE SYSTEM NEEDS TO BE REPLACED DUE TO CORROSION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10554244December 1, 2013
SERVICE BRAKES
THE BRAKE LINES RUSTED OUT AND THE FLUID LEAKED OUT CAUSING BRAKE FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10553245November 21, 2013
SERVICE BRAKES
BRAKE LINE TO THE REAR DRIVER'S SIDE BRAKE FAILED AND BROKE AND LOST HYDRAULIC PRESSURE TO BRAKING SYSTEM. PULLED OVER INTO A GAS STATION AND HAD THE VEHICLE TOWED TO LOCAL DEALER FOR REPAIR/REPLACEMENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552799November 18, 2013
SERVICE BRAKES, POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES, ELECTRICAL SYSTEM
SERVICE BRAKELINES ROTTED AND CAUSED A COMPLETE LOSS OF SERVICE BRAKES - WHILE DRIVING AND CLOSE TO HOME - USED EMERGENCY BRAKES AND LOW GEAR TO GET TO HOME. SPOKE TO FRIEND AT CHEVY DEALER. THEY ARE HAVING PROBLEMS WITH THIS TRUCK SERIES DUE TO CORROSION AND PREMATURE RUSTING. TRUCK IS CURRENTLY IN GARAGE DUE TO FAILURE (CORROSION) OF TRANSMISSION COOLING LINES. CURRENT MILEAGE 15,211. LOST BOTH ANTI-LOCK BRAKE MODULES AND ALTERNATOR AND TEMPERATURE SENSORS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552298November 14, 2013
SERVICE BRAKES
BRAKE LINE FAILURE. RUSTY BRAKE LINES. LEAVING FLUID ON GROUND ALMOST HITTING BUILDING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552034November 13, 2013
SERVICE BRAKES
COMPLETE BRAKE FAILURE DUE TO BRAKE LINE DEFECT / LEAK. REPAIR ESTIMATE FROM DEALERSHIP $2800.00+. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552062November 13, 2013
SERVICE BRAKES, FUEL/PROPULSION SYSTEM
CHEVROLET SILVERADO 2500 HD (2006) WAS PURCHASED NEW, FROM GENGRAS CHEVROLET-585 CONNECTICUT BLVD.- EAST HARTFORD, CT. 06108- TELEPHONE # 860-528-2575. BRAKE LINE RUPTURED DUE TO CORROSION, FORTUNATELY, VEHICLE WAS BEING OPERATED AT A SLOW SPEED (25) MPH. UPON INSPECTION OF UNDER THE VEHICLE, I WAS APPALLED AT THE CONDITION OF BRAKE LINES,FITTINGS,BRACKETS AND RELATED COMPONENTS. THE RUST ON THE UNDERSIDE INCLUDING THE FRAME WAS SUCH THAT IT COULD BE FLAKED OFF IN 1/16" THICK CHUNKS. THIS TRUCK HAS ONLY 9028 MILES, WHAT KIND OF AUTO INDUSTRY DO WE HAVE !!!!! ? I WAS MADE AWARE OF THIS CORROSION PROBLEM (THAT CHEVROLET IS AWARE OF) BY A LOCAL AUTO MECHANIC THAT THIS CORROSION PROBLEM WAS IN PRIMARILY (2004-2005-2006) SILVERADOS. THE MATERIALS GM IS USING TO CAUSE THESE PROBLEMS IS A DISGUSTING SAMPLE OF OUR MANUFACTURING SYSTEM. THIS VEHICLE WAS PARKED OUTDOORS (ON A ASPHALT DRIVEWAY). THE REPAIRS FOR THIS SITUATION ARE IN LINE WITH THE POOR QUALITY MATERIALS THAT WERE USED, I WAS INFORMED THAT THE BODY OF THE TRUCK BED HAD TO BE REMOVED (LIFTED-OFF) TO ACCESS BRAKE LINES AND GET THIS, THE FUEL LINE IS ALSO IN THE SAME LOCATION, MIGHT BE SUSPECT TO CORROSION. THE COST OF THESE REPAIRS IS OFF THE CHARTS. (WHO IS RESPONSIBLE FOR THESE DESIGN FLAWS). AS AN AMERICAN, WHO ADVOCATES BUYING DOMESTIC VEHICLES, I WONDER WHO IS WATCHING WHAT IS GOING ON. I HOPE SOMEONE OF AUTHORITY READS THIS AND ACTS ON IT, BEFORE IT IS TO LATE FOR ALL OF US. REMEMBER, THIS VEHICLE HAS (9028) MILES ON IT, AND EXPERIENCING THESE PROBLEMS. YES, THAT IS CORRECT (9028) MILES !!!!!!!!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10550858November 4, 2013
SERVICE BRAKES
MY TRUCK HAS A SERIOUS RUST PROBLEM. I WAS DRIVING FROM PENNSYLVANIA TO BUFFALO WHEN MY BRAKE LINE SNAPPED "SPEWING BRAKE FLUID ALL OVER"ON THE HIGHWAY WHILE DRIVING AT 65MPH. AT THE DEALER I WAS SHOWED THAT NOT ONLY WHERE MY BRAKE LINES ROTTED BUT EVERYTHING INVOLVING THE BRAKES "CALIPERS,ROTORS, PADS " FUEL LINES, FRAME CONTROL ARMS, EVERYTHING UNDER THE TRUCK, WHICH WAS BOUGHT NEW. THE BRAKE PADS, CALIPERS & ROTORS WERE REPLACED BY MY MECHANIC AT 25,000 WITH PARTS BOUGHT BY GM. MY TRUCK IS IN EXCELLENT SHAPE FROM WHAT YOU CAN SEE & IS GARAGE KEPT.FROM WHAT I SEE THIS IS A COMMON PROBLEM WITH GM TRUCKS FROM 2000-2012. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10550319October 31, 2013
SERVICE BRAKES
STEPPED ON THE BRAKES, THE BRAKE PEDAL WENT TO THE FLOOR. I WAS FORTUNATELY ABLE TO EXIT THE ROAD AND, UPON INSPECTION, SAW FLUID LEAKING FROM A HEAVILY CORRODED FRONT LEFT BRAKE LINE. I HAD TO HAVE BOTH FRONT BRAKE LINES REPLACED BY THE DEALER AT A VERY SIGNIFICANT COST. I HAVE N EVER HAD A CORRODED BRAKE LINE ON ANY OTHER VEHICLE. I BELIEVE GM SHOULD TAKE RESPONSIBILITY FOR THIS PROBLEM ? IT IS A SAFETY ISSUE CAUSED BY THE USE OF INFERIOR MATERIALS OR IMPROPER BRAKE LINE PLACEMENT/LAYOUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10548397October 18, 2013
SERVICE BRAKES
I WAS GOING BACK TO MY JOB LOCATION AFTER LEAVING A TRAINING CLASS. APPLIED BRAKES AS I APPROACHED A STOP SIGN. BRAKE PEDAL HAD NO RESISTANCE AND WENT TO THE FLOOR. LUCKILY, I WAS ON SCHOOL DISTRICT PROPERTY SO THE SPEED LIMIT WAS 15. WAS ABLE TO GET TO MY LOCAL MECHANIC WHO FOUND A RUPTURED BRAKE LINE. HE ALSO INFORMED ME THAT ALL BRAKE LINES WERE RUSTED AND WHILE HE COULD NOT SAY ANOTHER ONE WILL RUPTURE TOMORROW, HE FELT TO BE SAFE THEY SHOULD ALL BE REPLACED. WE TOW A CAMPER WITH THIS TRUCK AND WHILE I KNOW THE CAMPER'S BRAKES WILL STOP THE TRUCK, SOME OF THE CAMPGROUND WE VISIT ARE MOUNTAIN CAMPGROUNDS WITH STEEP GRADES AND WHEN WE LEAVE THE CAMPGROUND TO DO SOMETHING (EXAMPLE: GO OUT TO EAT), NOT KNOWING IF THE TRUCK BRAKES WILL WORK IS NOT VERY COMFORTING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10547099October 7, 2013
SERVICE BRAKES
UPON DRIVING HOME ON MY STREET MY BRAKE PEDAL WENT TO THE FLOOR. HAVE BREAK LINE CORRODED AND LEAKING BELOW DRIVER SIDE DOOR. WAS ABLE TO STOP SAFELY AS I WAS ON A RESIDENTIAL ROAD WITH A LOW SPEED LIMIT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10546522October 2, 2013
SERVICE BRAKES
I WAS DRIVING ON THE HIGHWAY, AND APPROACHING A RED LIGHT, STEPPED ON THE BRAKES. UPON DOING SO, THE BRAKE PEDAL WENT TO THE FLOOR. I WAS ABLE TO PUMP THE PEDAL, AND DRIVE INTO THE NEXT PARKING LOT. I WALKED AROUND TO THE REAR OF THE TRUCK, WHERE I SAW A PUDDLE OF BRAKE FLUID. I LOOKED UNDER THE TRUCK, AND SAW THE FLUID LEAKING FROM A HEAVILY CORRODED BRAKE LINE. WHEN I GOT THE TRUCK HOME, I DID A MORE THOROUGH INSPECTION, AND DISCOVERED THAT ALL THE BRAKE LINES WERE HEAVILY CORRODED, AND WOULD NEED REPLACEMENT. I ORDERED AN AFTERMARKET, PRE-BENT STAINLESS LINE KIT. I TOOK THE TRUCK TO A LOCAL MECHANIC WHO WAS ABLE TO REPLACE THE LEAKING LINE, AND A FEW OTHERS, BUT WAS UNABLE TO REPLACE THE LINES GOING INTO THE ABS MODULE DUE TO THEIR LOCATION ON TOP OF THE FRAME, UNDER THE CAB. I AM ABLE TO DRIVE THE TRUCK NOW, BUT WILL NEED TO FIND ANOTHER MECHANIC WHO IS WILLING TO SEPARATE THE CAB FROM THE FRAME TO REPLACE THE REST OF THE LINES. I HAVE OWNED MANY VEHICLES OVER THE YEARS, AND NONE HAVE EVER HAD A CORRODED BRAKE LINE. THE LAST TRUCK I OWNED WAS A 1993 CHEVY SILVERADO, WHICH I HAD FOR 15 YEARS, AND RACKED UP 300,000 MILES, WITH NO BRAKE OR FLUID LINE ISSUES, AND DRIVEN IN THE SAME NORTHEAST CLIMATE AS THE 2006 SILVERADO. JUDGING BY THE AMOUNT OF COMPLAINTS I HAVE READ ONLINE, DESCRIBING THE SAME PROBLEM I AM EXPERIENCING, I BELIEVE GM SHOULD TAKE RESPONSIBILITY FOR THE REPAIRS. THIS PROBLEM IS A SAFETY ISSUE CAUSED BY WHAT I BELIEVE TO BE THE USE OF INFERIOR MATERIALS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10546541October 2, 2013
ENGINE
2006 CHEVROLET SILVERADO 1500 WITH 5.3L V8 MAKES TICKING NOISE WHEN COLD. EXHAUST SMELL IN PASSENGER CABIN. NOISE DECREASES AS ENGINE HITS NORMAL OPERATING TEMPERATURE. AFTER A SERVICE CALL TO REPAIR. THE MECHANIC STATED THAT THE FORWARD MOST AND REAR MOST EXHAUST MANIFOLD BOLTS WERE BROKEN OFF INSIDE THE ENGINE BLOCK ON THE DRIVER SIDE OF THE ENGINE, THIS ALLOWS EXHAUST GAS TO ESCAPE WHEN COLD AND ACCOUNTS FOR EXHAUST SMELL IN THE CABIN. PER THE MECHANIC THIS IS VERY COMMON AND SHOULD BE A RECALL ITEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10546564October 2, 2013
SERVICE BRAKES
WHILE DRIVING AT 10 MPH THE REAR BRAKES FAILED. UPON INVESTIGATION IT WAS FOUND THAT THE REAR BRAKE LINE HAD RUSTED OUT AT THE CONNECTION TO THE SPLITTER LOCATED ON FRAME ABOVE THE REAR AXLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10545653September 27, 2013
SERVICE BRAKES, SUSPENSION, FUEL/PROPULSION SYSTEM
EVERY BRAKE GAS AND COOLING LINE RUSTED. I HAVE LOOKED AT OTHER VEHICLES OF SAME YEAR AND MILES DIFFERENT MAKES. NO WHERE AS RUSTED AS MY 06 SILVERADO. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10545466September 26, 2013
STEERING
I PURCHASED THIS VEHICLE FROM A DEALER WITH A ONE YEAR CERTIFIED USED WARRANTY AT 49K MILES. WITHIN A MONTH OF PURCHASE I NOTICED AN EXCESSIVE AMOUNT OF FREE-PLAY IN THE STEERING AND NOTICED A LOOSE PITMAN ARM WHEN ROTATING THE STEERING WHEEL AND OBSERVING THIS PART. I TOOK THE VEHICLE TO TWO DIFFERENT DEALERS IN THE INDIANAPOLIS AREA. AFTER THEIR INSPECTION AND CONSULTING GM CONCERNING THIS ISSUE, I WAS TOLD FREE-PLAY WAS NORMAL OR WITHIN PARAMETERS. ONE YEAR LATER AND 69K MILES, I TAKE THE VEHICLE IN FOR SERVICE (OIL & FILTER CHANGES ETC) AND TO HAVE THEM PLEASE LOOK AT THE BRAKES AS I COULD FEEL A VIBRATION. THE VEHICLE IS NOW OUT OF WARRANTY... THEY TELL ME NOW THAT THESE PARTS (PITMAN ARM / STEERING BOX) WILL NEED TO BE REPLACED ALONG WITH BOTH FRONT WHEEL BEARINGS TO THE TUNE OF JUST UNDER $2,000. I HAVE DONE MY OWN RESEARCH AND HAVE FOUND MANY COMPLAINTS IN REGARDS TO STEERING ASSEMBLY / PARTS ON THESE TRUCKS. NOTHING I HAVE FOUND SAYS THAT THIS MUCH FREE-PLAY IS "NORMAL" IN REGARDS TO THIS VEHICLE AND IN FACT, SOME FRONT WHEEL AXLES AND WHEEL ASSEMBLIES HAVE ACTUALLY SEPARATED FROM THE VEHICLE. MY WHEELS OR BEARINGS (I SAW FOR MYSELF WHEN IT WAS ON THE LIFT AND I HAVE THE OLD PARTS) HAD A DANGEROUS AMOUNT OF WOBBLE IN THEM, WITH THE RIGHT WHEEL HAVING IN EXCESS OF 1" OF TILT OR LOOSENESS. THIS IN MY OPINION DOES NOT CONSTITUTE "NORMAL" PLAY AND I QUESTION GM'S HONESTY CONCERNING THIS ISSUE... WHY IS THIS ACCEPTABLE WHEN UNDER WARRANTY BUT NEEDS EXPENSIVE REPAIR WHEN ITS ON MY DIME? I BELIEVE GM IS AWARE OF THE PROBLEM BUT IS PUSHING THE COST OFF TO THEIR CUSTOMERS. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10545566September 26, 2013
SERVICE BRAKES
DRIVING HOME FROM STORE ONLY TO HAVE A VEHICLE STOP SHORT IN FRONT OF ME. APPLIED BRAKES AND TO MY SURPRISE THE PEDAL WENT TO THE FLOOR. LUCKILY I HAD ROOM TO MANEUVER AROUND TRAFFIC AND AVOID AN ACCIDENT. VEHICLE WAS TOWED TO REPAIR SHOP AND I WAS TOLD LEFT FRONT BREAK LINE RUSTED OUT. I PURCHASED THIS VEHICLE NEW AND I CAN ATTEST THAT NO UNUSUAL CIRCUMSTANCES OCCURRED TO WARRANT BRAKE LINE RUSTING OUT. MOVING FORWARD 16 MONTHS I WAS LEAVING THE HOUSE ONLY TO HAVE BRAKES GO TO THE FLOOR. VEHICLE TOWED TO CHEVY DEALER. DEALER TELLS ME ALL BRAKE LINES RUSTED BADLY (EXCEPT ONE PREVIOUSLY REPLACED) AND IN NEED OF REPLACEMENT TO THE TUNE OF $2700.00. GOOD THING I WAS NOT DRIVING OR WORSE YET PULLING MY 8000 POUND CAMPER. IS IT GOING TO TAKE SOME ONE GETTING KILLED BEFORE CHEVY IS MADE TO ADMIT THEY HAVE A SERIOUS SAFETY ISSUE WITH THESE BRAKE LINES. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544718September 21, 2013
EXTERIOR LIGHTING
I SEE YOU RECALLING BMW CARS FOR LIGHTS FAILING! WHY DON'T YOU RECALL GM TRUCKS AND SUV'S FOR FAILING RUNNING LIGHTS? FROM THEIR INTRODUCTION THEY HAVE BEEN ADVERTISED AS A SAFETY FEATURE! I WOULD GUESS 97% OF ALL GM TRUCKS AND SUV'S HAVE ONE OR BOTH OF THE LIGHTS NOT WORKING! AN OBVIOUS DESIGN FLAW!! MY 2006 SILVERADO HAS HAD THE PASSENGER SIDE LIGHT REPLACED 4 TIMES. IF THIS IS NOT A SAFETY ISSUE, EVEN THOUGH ADVERTISED AS SUCH, IT COST OWNERS A BIG SUM OF MONEY TO KEEP REPAIRING THEM BECAUSE OF GM'S OBVIOUS FAULTY DESIGN!! WHY DOES GM GET A PASS BUT BMW DOES NO? THANKS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544377September 19, 2013
SERVICE BRAKES
WHILE DRIVING I WENT TO STOP AT INTERSECTION AND THE BRAKE PEDAL WENT TO THE FLOOR,AND I USED PARKING BRAKE TO STOP.I GOT OUT AND THERE WAS BRAKE FLUID ALL OVER,I CAREFULLY DROVE HOME ,1/2 MILE AND CHECKED OUT TRUCK AND THE BRAKE LINES WERE ALL RUSTED AND LEAKING. I TRIED TO FIX WITH NEW PARTS BUT AFTER FIXING IT WOULD LEAK IN ANOTHER SPOT. I HAVE TO REPLACE ALL BRAKE LINES TO BE SAFE. I THINK THAT GM SHOULD HAVE TO HAVE A RECALL ON THESE BRAKE LINES. THANKS *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544523September 19, 2013
SERVICE BRAKES
RETURNING HOME, I APPROACHED A 4-WAY STOP AT ABOUT 40 MPH. ATTEMPTED TO STOP, ONLY LIMITED BRAKES. GEARING DOWN AND DEFENSIVE DRIVING NECESSARY TO AVOID ACCIDENT AT INTERSECTION. ABLE TO COMPLETE SHORT DISTANCE HOME WHERE I INSPECTED BRAKES AND UNCOVERED RUSTED AND LEAKING BREAK LINES. VEHICLE WITH LESS THAN 90,000 MILES. EXTREMELY DANGEROUS AND GM/NHTSA SHOULD BE ASHAMED THAT A RECALL HAS NOT BEEN INITIATED. ONLY A MATTER OF TIME BEFORE SOMEONE IS NOT AS LUCKY AS ME AND OTHER COMPLAINANTS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Silverado