Volvo · Model Report
Showing safety data for the 2007 model year only.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
ON CERTAIN SPORT UTILITY VEHICLES, UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL MODULE (CCM) MAY RECEIVE A 'SHUT-DOWN SIGNAL' FROM THE ENGINE CONTROL MODULE (ECM) AFTER IGNITION KEY INSERTION. IF THIS CONDITION OCCURS, THE CLIMATE CONTROL FUNCTIONS WILL NOT BE AVAILABLE (INCLUDING THE DEFROSTER) DURING THAT DRIVING CYCLE.
While driving the vehicle under normal conditions, a sudden electrical fire occurred, requiring immediate evacuation. The vehicle was pulled over safely and the driver exited before the fire escalated. The fire department responded and the vehicle was declared a total loss due to fire damage. The failure is believed to have originated from an electrical short involving the climate control/defroster system. The affected wiring and components were destroyed by the fire and are not available for inspection. The day prior to the fire, the fuse controlling both the climate control system and the instrument cluster blew twice when the defroster was activated. The fuse was replaced, and the defroster was not used again. At the time of the fire, the defroster systems was not operating. There were no warning lights or alerts immediately prior to the fire. The fire occurred while the vehicle was in motion, creating a serious safety risk to the occupant and surrounding traffic. The incident has not been reproduced or inspected by a dealer. The vehicle was inspected by the fire department. No manufacturer inspection has occurred.
The contact owns a 2007 Volvo XC90. The contact stated that the air bag warning light was illuminated on the instrument cluster. The local dealer was contacted, and it was diagnosed that the failure was due to the air bag module. The vehicle was repaired, but the failure recurred. The vehicle was taken to an independent mechanic, but the result was unknown. The manufacturer was contacted, and a recorded message referred her to the dealer. The approximate failure mileage was 80,000.
No injuries · No fire · No crash
I am writing to bring to your attention a concerning matter regarding my recently acquired 2007 Volvo XC90. Upon refueling the vehicle to a level exceeding half the tank capacity, there is a discernible and persistent odor of gasoline within the cabin. Given the potential safety implications associated with such an issue, I am seeking your guidance on the appropriate course of action. In researching this matter, I have come across similar concerns raised by other owners of the same vehicle model. This has heightened my awareness of the need to address this issue promptly and comprehensively. In an effort to troubleshoot the matter, I have inspected the fuel cap and surrounding areas for visible leaks. However, the matter persists, prompting my inquiry. Additionally, I would appreciate it if you could advise on any potential recalls, technical service bulletins, or common issues related to the fuel system in the 2007 Volvo XC90. Thank you for your time and expertise in addressing this concern. I look forward to your guidance on resolving this matter promptly and ensuring the continued safety and reliability of my vehicle.
No injuries · No fire · No crash
Drivers side fuel tank sending unit print or sending unit top leaking fuel, a check engine light appeared and almost instantly started smelling like gas. The check engine said small evap leak. This is a huge safety concern for my family and I. No further action has been done.
No injuries · No fire · No crash
IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. This Recall Was Done for a 2004 Volvo xc90 . I am currently Experiencing the same problem with my 2007 volvo Xc90 AWD. Every time, I fill up to 1/2 a tank or full , I start to smell the fumes inside the vehicle . I took it to get inspected , and the mechanic said the fuel pump assembly usually cracks and the vapor goes inside the cabin. I personally think this is not safe for us drivers or the passengers. living in Arizona with high temperatures usually all plastic have wear and tear , but On the fuel pump housing ? It's not where we want it.
No injuries · No fire · No crash