Volkswagen Beetle Complaints (2000)

263 consumer complaints on file.

#11673213July 13, 2025
ELECTRICAL SYSTEM
Terminal Box above battery has a black wire that get extremely hot and melts in its receptacle in the terminal box. Have replaced the terminal box and that one was also melted within a few days after installation of the new box.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11324922May 18, 2020
SERVICE BRAKES, EXTERIOR LIGHTING
BRAKE LIGHT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11155433December 2, 2018
ELECTRONIC STABILITY CONTROL (ESC), ENGINE
I BOUGHT A BEETLE (136K M) FROM AN ACQUAINTANCE FOR $1600 CASH THERE WERE SOME ISSUES I.E. THE FAULTY TRUNK RELEASE DIDNT WORK, THE DRIVER SIDE DOOR HAD NO POWER, (TURNS OUT THE DOOR MOTOR IS A COMMON ISSUE BEETLE HAS) SUNROOF WAS STUCK PART OPEN, AND THE KEY FOB TO THE BEETLE HAD BEEN WORN/BROKEN. (FUN FACT: WITHOUT THE KEY FOB, ACCESS TO THE TRUNK, AND NO POWER TO THE DRIVER SIDE DOOR. THE STOCK ALARM IS VERY DIFFICULT TO DISABLE.) WE DROVE THE BEETLE FOR ABOUT A WEEK WHEN THE CLUTCH WENT OUT. A TRANSMISSION SPECIALIST QUOTED US $400 FOR THE HYDRAULIC LINE, AFTER FURTHER EXAMINATION THE ENTIRE CLUTCH WAS OUT (HE CHARGED ME $1100) THE VERY NEXT DAY THE OIL LIGHT WAS BLINKING, WE CHECKED THE OIL LEVEL AND IT WAS FULL. WE CONTINUED ON OUR BUSINESS THE CAR STARTED LOSING POWER, STALLING AND MAKING A HORRIBLE TAPPING/KNOCKING SOUND. THE ENGINE LIGHT STARTED BLINKING. WE WERENT ABLE TO PULL CODES BECAUSE THE ODB WAS DISCONNECTED DURING THE EXPENSIVE CLUTCH REPAIR. AT THIS POINT WE HAVE INVESTED A GREAT DEAL OF MONEY INTO THIS USED VEHICLE, WE ARE HESITANT TO TO TAKE IT TO THE CRUSHER. WE BOUGHT A HAYNES REPAIR MANUAL AND AFTER SOME LUCK, COMMON SENSE, AND TROUBLE SHOOTING WE WERE ABLE TO DIAGNOSE THE CAR WITH A FAULTY CAMSHAFT TIMING CHAIN TENSION GUIDE. THE REPAIR SEEMED EASY ENOUGH SO WE ENLISTED A OUR FAMILY MECHANIC TO PERFORM THE REPAIR. AFTER ANOTHER $575 WE DISCOVERED THAT THE TENSION GUIDE WAS IN FACT THE PROBLEM. WE WERE ABLE TO GET THE VEHICLE ALL PUT BACK TOGETHER WITH SEVERAL NEW VITAL PARTS. IT WILL NOT TURN OVER. THE MANUAL INDICATES IT MAY STILL BE OUT OF TIME OR WE MAY HAVE A BLOWN FUSE. AFTER I REPLACE THE FUSES AND REATTEMPT INSTALLING THE TIMING CHAIN, I WILL HAVE PUT 3 X AS MUCH MONEY INTO THIS CAR THAN ITS WORTH. I FEEL LIKE VOLKWAGEN IS PRODUCING LEMONS AND RIPPING OFF AMERICANS!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11101595June 13, 2018
SERVICE BRAKES
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN BEETLE. WHILE DRIVING 55 MPH, SMOKE APPEARED FROM THE REAR OF THE VEHICLE AND THE ABS WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD. THE CONTACT NOTICED SMOKE COMING FROM THE REAR DRIVER'S SIDE AREA BY THE TIRE ALONG WITH AN ABNORMAL ODOR. THE CONTACT STATED THAT THE ODOR SMELLED LIKE COOLANT. THE CONTACT WAITED A FEW MINUTES AND WAS ABLE TO DRIVE THE VEHICLE; HOWEVER, THE FAILURE RECURRED WHEN THE VEHICLE ACCELERATED BETWEEN 40 AND 60 MPH. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11085131April 15, 2018
ELECTRICAL SYSTEM
ELECTRICAL SURGES...BLOWS FUSE BLOCK...MELTS DOWN FUSE BLOCK. REPLACED FUSE BLOCK ABOVE THE BATTERY THREE TIMES SINCE OWNING THE CAR. CAR WAS BEING USED IN THE CITY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11042541November 2, 2017
STRUCTURE:BODY, AIR BAGS
TL* THE CONTACT OWNED A 2000 VOLKSWAGEN BEETLE. WHILE DRIVING APPROXIMATELY 40 MPH, THE DRIVER FELL ASLEEP BEHIND THE WHEEL AND CRASHED INTO A GUARDRAIL. THE AIR BAGS DID NOT DEPLOY. THE DRIVER EXITED THE VEHICLE AND WALKED A FEW YARDS AWAY FROM THE VEHICLE WHEN IT SUDDENLY EXPLODED WITHOUT WARNING. THE DRIVER SUSTAINED A MINOR INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOTALED AND WAS TOWED TO A TOW YARD. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT NOTHING COULD BE DONE. THE CONTACT WAS PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000. THE VIN WAS NOT PROVIDED.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11010895July 27, 2017
EXTERIOR LIGHTING
THE FRONT LIGHTS ON BOTH SIDES GO OUT WITHOUT WARNING. I CHANGE OUT THE BULBS AND THEY WORK INTERMITTENTLY. AS I WAS DRIVING OVER COLIMA ROAD TOWARD WHITTIER, CA ON THE WAY HOME, ONE LIGHT WENT OUT AND THEN THE OTHER. COLIMA RD IS AN UNLIT ROAD. I DON'T DRIVE AT NIGHT. I HAVE SPENT OVER 150.00 ON MECHANICS TRYING TO GET IT FIXED. I READ ON THE INTERNET THAT MANY ARE HAVING THE SAME PROBLEM. THIS ITEM SHOULD BE INVESTIGATED, AND IN MY OPINION SHOULD BE RECALLED BY THE MANUFACTURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10943730January 8, 2017
ELECTRICAL SYSTEM
HIS COMPLAINT CONSISTS OF A 2000 VOLKSWAGEN BEETLE, IN WHICH IT DOESN'T APPLY TO ANY WARRANTY WHATS SO EVER. WHETHER IT'S A NEW VEHICLE OR NOT. THE PROBLEM IS WITH THE SWITCHBLADE PROGRAMMABLE TYPE KEY WITH REMOTE. VOLKSWAGEN HAS KNOWN ABOUT THE PROBLEM WITH THESE TYPE KEYS FOR SOMETIME BUT HAS FAILED THE CONSUMERS AND THE GOVERNMENT TO PROVIDE A SOLUTION TO THE PROBLEM. THEY INSTEAD TAKE THE APPROACH, WHICH PROFIT OUTWEIGHS THE CONSUMERS, THEY PUT PROFIT BEFORE CONSUMERS, AND SAFETY. THESE KEYS PRODUCE A ''DANGER'' TO NOT ONLY THE CONSUMERS BUT EVERYONE ON THE HIGHWAYS AROUND THEM THE SAFETY AND MARKSMANSHIP OF THE KEY CAN BREAK OFF DURING USE, SO IF THIS HAPPENS DURING A CRASH, THE CONSUMER WOULD BE UNABLE TO TURN OFF THE VEHICLE WHICH AGAIN PRODUCES AN IMMEDIATE ''DANGER''. THE REMOTE SWITCHBLADE KEY IS ONLY SECURED BY A VERY CHEAP MADE PLASTIC. IT'S VERY POORLY DESIGNED AND MADE. IF THE ENCASING THAT HOLDS THE KEY WAS MADE OUT OF METAL OR ALUMINUM THIS WOULD SOLVE THE PROBLEM. ANOTHER PROBLEM WITH THE KEY, IS THAT VOLKSWAGEN MADE THE KEY PROGRAMMABLE WITH A CHIP, SO THE KEY HAS TO BE CUT DOWN THE MIDDLE, AND PROGRAMMED, WHICH MEANS THE VEHICLE HAS TO BE CONNECTED TO A COMPUTER AT THE DEALERSHIP AND USUALLY TAKES ABOUT ONE HOUR AT A COST OF $245.00. IT'S VERY OBVIOUS THAT THE MANUFACTURE DOES THIS FOR PURE PROFIT, AND TO DETER THE CONSUMER FROM GOING ELSEWHERE TO HAVE SUCH KEY MADE. I URGE NHTSA TO TAKE IMMEDIATE ACTION TO ELIMINATE ANYONE FROM BEING INJURED OR KILLED. THESE EMAILS WILL BE KEPT AS PROOF AND FOR THE RECORD THAT THIS VERY ''IMPORTANT AND SAFETY ISSUE'' HAS BEEN SENT TO YOU AS EVIDENCE, FOR FUTURE LAWSUITS ETC CONCERNING THIS MATTER. HAPPENED WHILE DRIVING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10860094April 18, 2016
SERVICE BRAKES, ENGINE, EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN BEETLE. WHILE DRIVING AT A LOW SPEED, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. IN ADDITION, THE BRAKE WARNING LIGHT ILLUMINATED EVEN THOUGH THE EMERGENCY BRAKE WAS DISENGAGED. THE CHECK ENGINE WARNING LIGHT ALSO ILLUMINATED INTERMITTENTLY. THE CONTACT ALSO STATED THAT THE LOW BEAM HEAD LAMPS FAILED TO FULLY ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10838858February 28, 2016
ELECTRICAL SYSTEM
I WAS DRIVING THIS CAR AND JUST STALLED ON AN INTERSECTION AND SMOKE JUST CAME OUT UNDER THE HOOD AND I SMELLED IT TOO, OPENED THE HOOD AND FUSE BOX HAD MELTED WHICH IS LOCATED ON TOP OF BATTERY AND FIRE INSIDE THE ENGINE COMPARTMENT, UNDER THE BATTERY HAS BEEN BURNING AND ALSO MELTED THE WIRES.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10812006December 23, 2015
ELECTRONIC STABILITY CONTROL (ESC), ELECTRICAL SYSTEM
FUSE BOX ON TOP OF BATTERY MELTED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10785097October 21, 2015
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE BRAKE LIGHT FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE BRAKE LIGHT SWITCH AND WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10767302September 22, 2015
ENGINE
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN BEETLE. WHILE DRIVING AT 15 MPH, THERE WAS A LOUD ABNORMAL NOISE AND THE VEHICLE OVERHEATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT AND THE MOTOR MOUNT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, HOWEVER THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10717821May 21, 2015
ENGINE
WHILE DRIVING NOTICED WHITE SMOKE BEHIND THE VEHICLE, THEN ALL ELECTRONICS FAILED BUT CAR REMAINED RUNNING, PULLED TO SIDE OF THE ROAD AND ENGINE COMPARTMENT ENGULFED IN FLAMES. THE CAR WAS QUICKLY ON FIRE FROM THE DASH FORWARD. TRIED CALLING VW COSTUMER CARE AND THERE ARE NO RECALLS ON THE VEHICLE PERTAINING TO FIRE. AFTER SEARCHING ONLINE FOUND DOZENS OF SIMILAR IF NOT EXACT INCIDENTS. THIS WAS MY DAUGHTERS CAR (17) AND CARRIED ONLY LIABILITY. ONLY REASON FOR WRITING IS TO EDUCATE SO THAT OTHERS ARE NOT FACING A LIFE THREATNING EVENT, AS VW DENIES ANY WRONG DOING.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10714203May 2, 2015
ELECTRICAL SYSTEM
MY DAUGHTER'S CAR WAS BEING DRIVEN BY MY NIECE ON THE FREEWAY WHEN THE LIGHT WENT ON SIGNALING IT WAS OVER HEATING SO SHE PULLED OVER TO A CALL BOX AND WHILE SHE WAS MAKING THE CALL FOR ASSISTANCE SHE HEARD A POP POP AND THE FRONT HOOD WAS ON FIRE AND A MAN PULLED OVER AND TRIED TO PUT IT OUT WITH HIS EXTINGUISHER WHICH DIDN'T WORK AND THE WHOLE CAR WENT UP IN FLAMES WITHIN A MATTER OF MINUTES. IT WAS COMPLETELY BURNED UP WHICH ALSO BURNED DOWN THE CALL BOX ON THE FREEWAY. SHE HAD JUST SPENT APROXIMATELY $1, 400 ON REPAIRS ON THE CAR WHICH WAS MAINLY ON THE COOLING SYSTEM. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10689767February 21, 2015
AIR BAGS, SERVICE BRAKES, ELECTRICAL SYSTEM
I BOUGHT THIS CAR FOR MY GRANDSON TO DRIVE TO WORK..THE GUY I BOUGHT IT FROM SWORE IT WAS IN EXCELLENT SHAPE, THAT HIS DAUGHTER DROVE IT TO SCHOOL ETC......WHEN WE GOT IT, I TOOK IT TO THE VOLKSWAGEN DEALER TO MAKE SURE IT WAS SAFE FOR MY GRANDSON TO DRIVE, THEY BEGAN TO FIND THINGS WRONG AND THE COST WAS MOUNTING UP AND UP AND THEY EVEN HAD US TAKE IT HOME ONLY TO TAKE IT RIGHT BACK BECAUSE IT HAD NO HEAT (AND ITS VERY COLD HERE) SO THEY WORKED ON IT SOME MORE...BOTTOM LINE IS SO FAR THEY HAVE CHARGED ME 3 TIMES WHAT I PAID FOR IT AND WHEN I LOOKED IT UP ON LINE, EVERY THING THEY DID WAS A RECALL....MY QUESTION TO YOU IS..HOW LONG ARE THE RECALLS GOOD FOR AND I FIND IT HARD TO BELIEVE THE GUY WAS APPRAISED OF THEM OR HE WOULDN'T HAVE LET HIS DAUGHTER DRIVE IT LIKE THAT ....I HAVE THE PAPERWORK RIGHT HERE WHERE IT SHOWS 9 RECALLS AND 62 SERVICE BULLETINS...PLEASE ADVISE ME OF MY OPTION AS I COULD HAVE BOUGHT HIM A MUCH NICER CAR FOR WHAT I HAVE IN THIS!!! THANK YOU SO MUCH FOR YOUR TIME [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10667382December 19, 2014
POWER TRAIN, AIR BAGS
I'VE HAD MY BEETLE SINCE 2005, AND THE AIRBAG LIGHTS CONTINUOUSLY COME ON AS WELL AS ISSUES WITH THE TRANSMISSION. I'VE TAKEN IT TO VW ONCE FOR REPAIR, AND THEY COME BACK ON MONTHS LATER. I'VE READ SIMILAR COMPLAINTS FROM OTHER VW OWNERS CONCERNING THE AIRBAG AND TRANSMISSION. I CAN'T UNDERSTAND WHY THIS ISN'T A RECALL ISSUE PARTICULARLY SINCE THERE WAS A DEATH IN 2007 WITH ANOTHER OWNER. THE AIRBAG WILL NOT DEPLOY WHEN THE LIGHT IS ON. THE WEB PAGE BELOW VOICES THE FRUSTRATIONS OF MANY OWNERS, AND I DO NOT UNDERSTAND WHY THESE COMPLAINTS AREN'T BEING TAKEN SERIOUSLY. THE REPAIRS COST OVER $1600. HOW IS THIS FAIR WHEN HAVING TO GET IT REPAIRED EVERY YEAR? ARE YOU PROTECTING VW? TRYING TO FIND SOMEONE TO CLEAR THE CODES IS DIFFICULT BECAUSE THEY HAVE TO GO UNDER THE SEAT TO ADJUST WIRES AND USING THE COMPUTER TO CLEAR THEM, BUT THEY COME BACK ON A DAY OR TWO LATER. HTTP://WWW.ARFC.ORG/COMPLAINTS/2000/VOLKSWAGEN/BEETLE/AIR_BAGS/PROBLEM.ASPX. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10653969November 10, 2014
SEAT BELTS
CABLE HAS COMPLETELY SEVERED ON DRIVER'S SEAT BELT RECEPTOR. THIS IS NOT THE RESULT OF AN ACCIDENT BUT JUST DUE TO USE AS INTENDED. ISSUE WAS DISCOVERED ON EXAMINATION ON 7 NOVEMBER 2014. INFORMED VOLKSWAGEN OF AMERICA WHO DECLINED TO REPAIR THE PROBLEM DESPITE SAFETY IMPLICATIONS. INFORMAL COMMUNICATION WITH DEALER SERVICE DEPARTMENT IS THAT THE ISSUE WAS CAUSED BECAUSE A PLASTIC SLEEVE AROUND THE TWO CABLES AT THE LATCHING MECHANISM HAD SLIPPED DOWN THE CABLE ALLOWING THE CABLE TO BEND BACK AND FORTH, EVENTUALLY CAUSING STRESS FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10593826May 24, 2014
ELECTRICAL SYSTEM, ENGINE
THE FUSE BOX ATOP THE BATTERY MELTED ON 2/18/2009 CAUSING A FIRE IN THE ENGINE COMPARTMENT. REPAIRS INCLUDING NEW FUSE BOX AND OTHER DAMAGED PARTS COST ME $1500.00. ON 7/15/2011 THE FUSE BOX MELTED CAUSING A/C TO STOP WORKING. THE OUTSIDE TEMPERATURE AT THE TIME WAS IN THE HIGH 90'S DURING A PROLONGED HEAT WAVE IN THE NORTH EAST. COST TO REPAIR $400.00. ON 5/18/2014 ONCE AGAIN THE FUSE BOX MELTED, COST TO REPAIR AND REPLACE $700. TWO DAYS LATER THE REPAIR (5/20/2014) THE CAR WENT DEAD IN TRAFFIC CAUSED BY A DRAINED BATTERY COST OF TOWING $150.00 + NEW FUSE BOX MELTED. IN CHECKING VW OWNERS FORUMS AVAILABLE ON THE INTERNET, THIS IS A COMMON PROBLEM AND COMPLAINT (FUSE BOX MELTING) IN THE VW PRODUCT LINE. WHY HASN'T VW BEEN FINED AND ORDERED TO RECALL THEIR DEFECTIVE CARS? *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10587686May 11, 2014
SEAT BELTS
THE STEEL CABLE SECURING THE DRIVER SIDE SEAT BELT BUCKLE TO THE SEAT CAGE BROKE LEAVING ME UNPROTECTED IN THE VEHICLE. THIS IS A SERIOUS SAFETY ISSUE COMMON TO THE VW NEW BEETLE AND CITED BY OWNERS ACROSS MODEL YEARS. ALSO, THE MANUFACTURER COMPLICATES WHAT WOULD BE AN EASY FIX BY ATTACHING THE PART TO THE SEAT CAGE WITH FASTENERS THAT CANNOT BE REMOVED WITHOUT A PROPRIETARY TOOL. IT'S LIKE STRONG-ARM ROBBERY! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volkswagen Beetle