Toyota Tacoma Complaints (2025)

85 consumer complaints on file.

#11746592June 25, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
The driver side inner door handle does not work. This is a huge safety issue because you can only open the door by rolling down the window and pulling the outer driver side door handle. I took the truck to the dealer and the part to fix it is on back order with no known date when they will get it. I am now forced to drive an un safe vehicle for who knows how long. This is a common issue with the 2024-2025 Tacomas and needs addressed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746472June 25, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
The interior driver-side door handle/release mechanism on my 2025 SR5 Toyota Tacoma failed without warning. The vehicle has low mileage and was being used normally. When attempting to open the driver door from the inside using ordinary force, an internal component appears to have detached or broken, leaving the interior handle completely inoperative. The handle simply hangs loose. Vehicle and failed component are available for inspection. This defect creates a significant safety risk because I cannot exit the vehicle through the driver door from inside the cabin. The only way to exit is to roll down the window, reach backward, and pull the exterior door handle. This requires an awkward twisting motion and causes shoulder pain. In an emergency such as a crash, fire, or water intrusion event, my ability to quickly exit the vehicle could be compromised. The defect also affects my ability to care for my young son, who has a medical condition and may require immediate assistance or rescue medication. If an emergency occurred while driving, I could be delayed in reaching him because I cannot promptly exit through the driver door as designed. A Toyota dealership inspected the vehicle and confirmed the failed interior door handle mechanism. However, the replacement part is on national backorder and unavailable. I was informed repairs will likely take more than a month and that the waiting list reportedly exceeds 2,000 vehicles. Numerous Tacoma owners have reported the same failure, suggesting a widespread defect. Despite reports of widespread failures and lengthy repair delays, there has been no recall, service campaign, or proactive communication from Toyota warning owners of the defect or providing guidance while awaiting repairs. There were no warning lights, messages, or advance symptoms before the failure. The handle functioned normally until it suddenly stopped working during routine use. The defect occurred without misuse, excessive force, collision, or damage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745636June 22, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
Both the front passenger and front driver's side doors will not open from the inside. First, the passenger side door handle became defective (I took it to the Toyota dealer and they said the interior handle assembly broke where the cable connects to the handle). The part is back ordered in the thousands. Then about a month later, the same thing happened to the driver's side door. That part is also back ordered in the thousands. Now, I am unable to open either front door from the inside - an obvious safety concern - being trapped in the car in the event of an accident. And this truck is a 2025 year with 8,800 miles on it. Toyota has provided no ETA for the new parts. A basic search online for the same issue has returned hundreds of similar stories for the same model truck. I have spoken to Toyota Corporate and they have not provided me with any sort of fix or ETA, other than to get in line and wait for the back ordered parts
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744969June 18, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My father and I both purchased a 2025 Toyota Tacoma SR5 2WD double cab last year brand new from different dealerships, both were in FL. My father was driving his new Tacoma with adaptive cruise control engaged, this was on an interstate, and the vehicle in front of him moved to the left lane next to him and started braking and this caused his vehicle to start braking extremely hard with no vehicles in front of him (he was driving about 55mph when this happened). He said this has happened to him before. I was in the vehicle with him when this happened. When I was driving from his home in GA a few days later, back to my home in FL, I was on the interstate ([XXX]) with the adaptive cruise control engaged and the exact same thing happened with my truck. A semi truck in front of me moved into the lane to the right and started braking. This caused my vehicle to start braking extremely hard with no vehicles in front of me. Had a vehicle been behind me, this could have caused me to be rear-ended going about 70mph. The sudden automatic braking with NO vehicles in front of you is aggressive enough to cause a rear-end collision and possibly cause the driver to make a startled, impulsive, corrective mistake to the sudden aggressive braking. Problem has not been confirmed or reproduced. Neither my father's or my vehicle has been inspected for this issue. Im betting its a software issue. No warning lights or messages before the aggressive braking in either mine or my fathers vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744724June 17, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
I went to open my drivers side door to get out, and the handle just flopped around and didnt open the door. Driver side door opener handle doesn't work. Have to roll down driver side window with truck engine on and lift outside door handle to open driver door. In case of emergency, and no power in truck, I would not be able to get out of my drivers side door.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744415June 16, 2026
SERVICE BRAKES, HYDRAULIC
The contact owns a 2025 Toyota Tacoma. The contact stated that while driving at approximately 10 MPH, the rear driver's and passenger’s side rotors and brake pads suddenly detached. No warning lights were illuminated. Upon further inspection, the contact became aware of metal debris on the ground by the rear wheels. The vehicle was scheduled to be towed to a local dealer for further investigation. The vehicle was not diagnosed or repaired. In addition, the contact related the failure to NHTSA Campaign: 25V058000 (Service Brakes, Hydraulic); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 18,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743810June 12, 2026
POWER TRAIN
Manufacturer Recall Number25TB11 NHTSA Recall Number25V656 Remedy has been pending for over 7 months! Concerned that I could be stranded if the vehicle drive shaft joint fails when off roading.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742223June 4, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
Front passenger door handle broke under normal use exiting truck resulting in inability to open door from inside, entrapping occupant. Warranty claim filed with Toyota dealership. Dealer service advisor stated this is a common failure on Gen 4.Tacomas, and Tundras. Part is on backorder. Service advisor stated backlog is large and no time estimate can be given when the repair can be made. This can result in entrapment in an accident if side windows lose power to roll down if capable of opening door from, or crawl in rear and exit through rear doors if child locks are not engaged. Recall is warranted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741639June 2, 2026
ENGINE, ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
The contact stated that while driving in the rain, when passing another vehicle, the vehicle began shuddering and experienced a loss of power. The check engine light illuminated and multiple other warning indicators. The vehicle pulled over to the vehicle was stopped and eventually restarted. The vehicle was taken to a dealer were it was diagnosed with an air intake failure. Shortly after, the vehicle experienced the same issue. Again and was returned to a dealer. The dealer diagnosed with a turbo mud and water found inside the air intake, water is covering the filter and there was no additional repairs that could be completed so the vehicle. The manufacturer was not notified of the issue. The approximate failure mileage was 19,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740765May 29, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
The interior driver side door handle on my 2025 Toyota Tacoma failed and wouldn't open the door from the inside. I had to roll down my window to open from the outside. The dealership replaced the handle assembly under warranty. This happened at around 9300 miles on the odometer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740284May 27, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
Interior drivers side door handle broken. I thought it was the locking mechanism having issues and i had to hold the locking plastic tab in the unlock position to open the door from the inside. After the 3rd time exiting my tacoma the door handle snapped. Now i how to open the door from the outside by rolling down the window, making it inconvenient in the rain.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738127May 15, 2026
POWER TRAIN
The contact owns a 2025 Toyota Tacoma. The contact stated that she received an email for NHTSA Campaign Number: 25V656000 (Power Train). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact stated that the dealer failed to alert her of the recall prior to the sell. The manufacturer was contacted and referred her to the local dealer. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736190May 6, 2026
POWER TRAIN
In October of 2025 I was notified of a safety based recall for my 2025 Tacoma related to the front axle shafts possibly breaking which could cause loss of steering control should an incident occur. The recall is listed as 25TA11, (Interim notice 25TB11) and is attached to NHTSA ID 25V656. As of May 6th, Toyota lists this situation as still preparing the remedy. If the situation is truly a safety concern, I believe the length of time Toyota is taking to provide the remedy is unacceptable. I would like to politely suggest that Toyota have pressure put on them to provide the proper remedy in an actual timely manner for something that can cause loss of control or a rolling vehicle in the 'Limited' trim models.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735950May 5, 2026
ELECTRICAL SYSTEM
The driver's side window switch panel failed and caught on fire. It is available for inspection.It will be towed to a toyota dealership tomorrow. Nobody was in the vehicle when the fire started. The problem has not been confirmed or reproduced by a dealer. The vehicle has not been inspected, is going in for inspection tomorrow. There was no warning or indication prior to the fire starting.
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#11735371May 3, 2026
POWER TRAIN
Vehicle recalled, left at Dealership on October 10th 2025. Dealership and Toyota corporate have failed to rectify the recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733479April 24, 2026
STEERING, SUSPENSION
*Steering system - tie rod / steering nut lock was loose and discover after alignment service * Loose tie rod nut created a potential safety risk because it involves a steering component related to vehicle control. This could have put me, my passengers, and others drivers at risk if the condition had worsened while driving. *No, the condition has not yet been confirmed by a dealer or independent service center. I noticed abnormal steering/handling, inspected the vehicle myself, and discovered a loose tie rod nut. The vehicle is available for inspection upon request. *No the vehicle I available upon request *No
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733188April 23, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
Driver's side interior door handle mechanism broke during normal usage at 8 months/6,300 miles. Breakage occured within the door panel, leaving a non-functioning handle. After breakage, the door cannot be opened from the inside of the vehicle and the occupant cannot easily exit the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732972April 22, 2026
SEATS
Less than 5000 miles - seat popping and cracking noise. If you look it up online, a lot of the 4th Gen Tacomas are doing this but when you take it to a dealership they say that is normal. It feels like the seat will break and moves around alot but Toyota will not acknowledge the issue at the dealership and has no fix. Seems unsafe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732393April 20, 2026
POWER TRAIN
The contact owns a 2025 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 25V656000 (Power Train); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer, where it remained since October 2025, while the contact drove a rental vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729275April 5, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My 2025 Toyota Tacoma engaged the emergency braking/pre-collision system system while my vehicle was going under 10 mph on a steep road in winter conditions. My vehicle was completely under control before the system engaged and there was no risk of a collision with any vehicles in front of me. The emergency braking system engaged and rendered my vehicle completely out of control. I tried desperately to pump the brakes in hopes I could regain control of the vehicle, but the brakes were fully locked. Had the brakes dis-engaged, I could have easily avoided the collision. The car not only did not decelerate, it accelerated down the hill while the brakes were locked for several seconds. My vehicle eventually slid into another vehicle that had been parked on the side of the road. From doing extensive research I believe a perfect storm of events caused this malfunction. Previously on this day, several inches of snow had fallen. The road had not been plowed and cars were parked on the side of the road. There was also a curve in the road near my vehicle's collision where the other vehicle was parked. My windshield was also still defrosting in the uppermost section near the rear view mirror. It is also possible the radar block on the front of the vehicle had snow or ice on it. It was also actively snowing. From what I have read, any of the above factors can cause a malfunction in the emergency braking pre-collision system. I had never been in an accident in over 20 years of driving and my vehicle did the least safe maneuver it could have in the given situation. There is no circumstance where one would purposefully slam the brakes on a snowy/icy down hill road if they know how to drive in the snow (even if you were going under 10mph as I was). At the most basic level of failure, I can't imagine this system should ever engage if going as slow as I was. Also, the system is designed to decelerate (was accelerating) and I was pumping brakes in effort to disengage
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma