Toyota FJ Cruiser Complaints (2013)

23 consumer complaints on file.

#11736593May 8, 2026
STRUCTURE:BODY, SERVICE BRAKES, SUSPENSION
Please consider opening or expanding an investigation into frame, underbody, brake-line, and suspension-mount corrosion affecting Toyota FJ Cruisers. I own a 2013 Toyota FJ Cruiser 4WD. A professional inspection found multiple fluid leaks, heavy rust, rusted exhaust, leaking rear shocks, and brake line/hose concerns. After reviewing the condition, the mechanic essentially declined to repair it and recommended scrapping the vehicle. The attached photos show conditions that appear safety-relevant: rust perforation through underbody structural metal near a bracket/crossmember area; severe corrosion around brake lines and fittings; widespread scaling near suspension and frame components; a leaking rear shock; and badly deteriorated exhaust connections. This is not just appearance rust. Also note the contrast between the observable condition of the vehicle versus the problems hidden beneath. This rust is clearly outpacing normal wear and tear. The safety risk is straightforward. At interstate speeds, a corroded brake line could fail during emergency braking. A weakened shock mount, suspension bracket, or crossmember could fail when the vehicle hits a pothole, uneven bridge plate, or highway debris. In dense, aggressive traffic, especially where vehicles travel 70+ mph, any sudden loss of braking, stability, or rear-end structural integrity could cause a spinout, rollover, or multi-vehicle crash. I understand Toyota has previously addressed severe corrosion on other truck platforms. I urge NHTSA to review whether the FJ Cruiser has a similar pattern of premature or excessive structural corrosion. Owners may not know the vehicle is unsafe until a mechanic refuses repair or a component fails. Please review consumer complaints, inspection photos, and corrosion-related failures before this becomes a fatal incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717366February 11, 2026
STEERING, SUSPENSION, POWER TRAIN
I purchased my beloved 2013 FJ Cruiser from Wellesley Toyota 6.5 years ago and have really enjoyed it. I have had it serviced religiously at McGee Toyota of Hanover since my purchase and expected to continue to enjoy it for many years to come and was just informed by McGee Toyota that the frame is severly rusted out throughout. My truck only has 158K miles on it and I expected this to last at least twice as long. This appears to be the same issue Toyota experienced with the Tundra and Tacoma with premature rusting on their vehicles due to a manufacturing issue. There are numerous complaints online about this issue and even a current class action lawsuit. I have alerted Toyota Corporate of this and they are not standing behind their product.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648412March 14, 2025
AIR BAGS
I had a car accident on Feb 10, 2025 and my air bag did not deploy
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#11606446August 5, 2024
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
The contact owns a 2013 Toyota FJ Cruiser. Upon having the vehicle inspected by a State Inspector, the contact was informed that there was significant corrosion on the undercarriage of the vehicle. The contact took the vehicle to a dealer and was informed that the corrosion failure was a result of normal wear and tear. The contact was referred to an independent mechanic who specialized in vehicle undercoating to prevent further corrosion damage to the vehicle. Despite the vehicle being treated for the corrosion damage, the contact was recently informed that the corrosion damage had worsened, and that the vehicle was unsafe to drive. The manufacturer was notified of the failure; the contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465817May 23, 2022
SUSPENSION
I went down the road & hit a bump my car rocked a little so I stopped to check the lug nuts & see if anything was wrong. I did not see anything. So, I continued to go pick my friend up as I was driving down the freeway anytime I hit a bump the car rocked more the faster I went. So I slowed down & watched traffic around me. Picked my friend up, went on the ramp and hit another bump and bam, my vehicle went so high up in the air my friend thought we were going to roll over. I immediately got off the freeway & there was a dealership right there. I asked if they could look at it & they wouldn't, they were too busy. I managed to baby it all the way back to my dealership. They said the control bar came away from the frame that was rotted. I called my insurance co. they said nothing they could do because of wear & tear. They did not view anything but pictures. I called claims & they said my VIN has no recalls that they won't do anything. They did not look at anything. I asked that they call my dealership to have them tell them how serious this could have been. They said my warranty was up in July of 2021. I had no letters to tell me this. I have only had it serviced at the dealership when it was due for service, nowhere else. I found out claims previously have been paid through a lawsuit on frames. Frames should last longer than this even in inclement weather. I also had it fluid filmed. Nobody will do anything & it's scary. Sad they want an accident before they look at things. I hope you can address this some way. Thank You.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443720December 14, 2021
SUSPENSION, STRUCTURE:BODY
Frame rust. Gas tank strap rust. Undercarriage rusted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11436206October 10, 2021
STRUCTURE:BODY
Severely rusted & rotting frame. Diagnosed by Mike’s Automotive, Sturgeon Bay, Wi.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11429121August 14, 2021
UNKNOWN OR OTHER
Severe frame, structural and fuel tank strap rust.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422743June 29, 2021
STRUCTURE:BODY
The frame on my vehicle is incredibly rusty. Upon further research, I've found that this is a chronic problem FJ Cruisers. Many frames have rusted to the point where there is structural damage thereby rendering the vehicle unsafe to drive. I know that Toyota issued a recall for Tacoma trucks for this very issue, and I would like to have a recall issued for the FJ as I'm incredibly concerned for my safety.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11419119May 31, 2021
UNKNOWN OR OTHER
I purchased a used Toyota FJ Cruiser in June 2019 with 25,441 miles on it from Luv Toyota in Lakewood, NY. The car was purchased sight unseen with cash from a Toyota dealership and shipped to me in Sugar Land, TX. When the vehicle arrived it was covered in frame and total underbody rust. The vehicle is completely unsafe to drive and I have driven it less than 1000 miles since it was purchased 2 years ago. After numerous attempts to receive a refund from Luv Toyota and Toyota Motors Corp I have given up. A 5 year old vehicle with less than 30,000 miles should not be completely rusted out. This is a complete fraudulent transaction. Toyota Corp does not stand by their vehicles or their franchise dealerships.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11395818February 11, 2021
POWER TRAIN
FROM ACCELERATION; BETWEEN 30MPH AND 45MPH MY VEHICLE SHUDDERS AND SHAKES. I BELIEVE THE ISSUE IS COMING FROM THE TRANSMISSION AND OR DIFFERENTIAL OF MY VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11384336December 21, 2020
AIR BAGS, ELECTRICAL SYSTEM
BROUGHT CAR INTO DEALER LAST MONTH FOR NEW HORN AS IT WAS A WEAK VOLUME AND WOULD NOT PASS INSPECTION IN MASSACHUSETTS. WAS REPLACED. WORKED FOR A WEEK OR TWO THEN CEASED TO COMPLETELY FUNCTION. BROUGHT BACK IN TODAY AND WAS TOLD BY DEALER CLOCK SPRING/SPIRAL CABLE WAS CORRODING. REMINDED OF OLD RECALL ON VARIOUS PAST TOYOTAS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11363658October 10, 2020
STRUCTURE:BODY
EXCESSIVE RUST ON FRAME, CHASSIS, TIE ROD ENDS AND ALL OTHER METAL PARTS, ALTHOUGH CAR IS MAINTENED PROPERLY, ONLY 40K MILES, GARAGE PARKING, NO OFF-ROAD USAGE AND NO SALT EXPOSED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11278666November 7, 2019
STRUCTURE:BODY
THE FRAME AND GAS TANK STRAPS AND REAR BUMPER ARE RUSTING TO AN UNSAFE CONDITION. VEHICLE IS 2013 WITH ONLY 66000MILES. I AM SPENDING COUNTLESS DOLLARS YEARLY TO PREVENT THE RUST AND IT ISN'T GETTING ANY BETTER. OTHER VEHICLES THAT SHARE THE SAME FRAME HAVE HAD RECALLS ON THE FRAME AND THIS VEHICLE SHOULD ALSO BE INCLUDED
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11252836September 3, 2019
STRUCTURE:BODY, FUEL/PROPULSION SYSTEM, SUSPENSION
SEVERE RUST UNDER CARRIAGE INCLUDING FUEL TANK STRAPS AND SUSPENSION COMPONENTS. NUMBER IS RUSTED AND SKID PLATES. RUST BASICALLY COVERING UNDER VEHICLE. CONCERNED ABOUT INTEGRITY DURING A CRASH
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11245781August 22, 2019
STRUCTURE:BODY
FRAME RUST, REAR BUMPER RUSH, UNDER CARRIAGE RUST, FRONT LOWER A-ARM RUST, DIFFERENTIAL RUST.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10909738September 26, 2016
AIR BAGS
TL* THE CONTACT OWNS A 2013 TOYOTA FJ CRUISER. WHILE A PASSENGER WAS SEATED IN THE FRONT PASSENGER SEAT, THE AIR BAG WARNING INDICATOR FAILED TO ILLUMINATE. THE OVERWEIGHT PASSENGER TRIGGERED THE AIR BAG SENSOR AND CAUSED IT TO FAIL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10667244December 19, 2014
SERVICE BRAKES
DECEMBER 17, 2014 I WAS ENROUTE TO WORK BETWEEN 9:00-9:30 AM. AND AS I AM DRIVING ALONG HUGHEY ROAD APPROACHING ROBINSON STREET A CROSS ROAD THE LIGHT TURNED YELLOW, SO I APPLIED MY BRAKES WHILE GOING OVER THE RAIL ROAD TRACKS AND I LOSS MY BRAKES ENDING UP IN THE INTERSECTION AND MY FRONT END IN THE PEDESTRIAN WALK WAY NEARLY RUNNING OVER TWO PEDESTIRANS, THEY WERE SO CLOSE THEY COULD TOUCH MY TRUCK. IT WAS A THREE LANE ROAD AND I WAS IN THE MIDDLE THE TWO OTHER CARS WERE ABLE TO STOP BUT I WASN'T AND KEPT GOING WITH MY FOOT PLANTED FIRMLY ON THE BRAKE. I COULD FEEL THE GRINDING OF MY BRAKE PEDAL LIKE IT WAS A COMPUTER THINKING. I CALLED THE TOYOTA CUSTER CARE CENTER AND THEY GAVE ME A CASE #[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10637842September 21, 2014
STEERING
IN THE 60-70 MPH RANGE THE STEERING WHEEL SHIMMIED BACK AND FORTH AS MUCH AS 1-2 INCHES. THE VEHICLE FEELS UNSTABLE IN THIS RANGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10509449April 24, 2013
VISIBILITY/WIPER, STRUCTURE:BODY
WHEN DRIVING IN SNOW CONDITIONS THE WINDSHIELD WIPERS BUILD UP AMAZING AMOUNTS OF ICE. I SPOKE WITH DEALERSHIP AND THEY CLAIM IT DOES THAT BECAUSE OF THE ANGLE OF THE WINDSHIELD. I WAS HAVING TO PULL OVER AND STOP TO BREAK THE ICE OFF MY WIPERS BECAUSE THEY STOPPED CLEARING THE WINDSHIELD AND I WOULD LOOSE VISIBILITY. ALSO, THE UNDERSIDE OF THE FJ CRUISER BUILDS UP AND COLLECTS ICE LIKE NOTHING I HAVE EVER SEEN. I AM A OVER THE ROAD TRUCK DRIVER AND HAVE DRIVEN IN ALL TYPES AND LEVELS OF BAD WEATHER, I HAVE NEVER SEEN ICE BUILD UP LIKE IT DOES ON THE FJ CRUISER.. THE FIRST TIME I THOUGHT IT MIGHT HAVE JUST BEEN A FLUKE BUT IT REPEATED THE ICE BUILD UP YESTERDAY WHEN IT SNOWED AGAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota FJ Cruiser