THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.
THE POSITIVE BATTERY CABLE TERMINAL AT THE STARTER SOLENOID MAY BE FORMED INCORRECTLY. INCORRECTLY FORMED TERMINALS CAN CONTACT THE STARTER SOLENOID HOUSING AND CAUSE AN ELECTRIC SHORT CIRCUIT.
1993 SATURN SC2 FRONT SEAT BACK RECLINER MECHANISM FAILED CAUSING SEAT BACK TO RECLINE SUDDENLY AND ALMOST INJURING PASSENGER IN THE CAR. SEAT WILL NO LONGER STAY FORWARD WHICH RESULTS IN SEAT GOING BACK A SOON AS YOU PRESS GAS PEDAL. *TR
No injuries · No fire · No crash
DRIVER'S SEAT BACK RECLINER MECHANISM FAILED CAUSING SEAT BACK TO RECLINE SUDDENLY AND LOSS OF CONTROL OF VEHICLE. DISASSEMBLY OF THE SEAT AND INSPECTION OF THE RECLINER MECHANISM REVEALED A DESIGN DEFECT WHICH MAKES SUDDEN FAILURE OF THIS MECHANISM HIGHLY LIKELY. FOR THE RECLINER TO HOLD THE SEAT BACK IN POSITION, TWO INTERNAL OPERATING LEVERS MUST REMAIN ALIGNED IN THE SAME PLANE. THESE ARE HELD IN ALIGNMENT BY A VERY THIN METAL PLATE (ABOUT 1MM THICK). THIS PLATE WAS BENT CAUSING THE INTERNAL OPERATING LEVERS TO MISALIGN AND THE SEAT BACK TO COLLAPSE. DUE TO THE THINNESS AND LACK OF STRENGTH OF THE ALIGNMENT PLATE, THIS FAILURE IS EXTREMELY LIKELY. YOUR DATABASE SHOWS AT LEAST TWO OTHER SIMILAR FAILURES IN 1993 SATURNS. ALSO NOTE NHTSA ORDERED A RECALL FOR THIS PROBLEM IN 1994 SATURNS. THE FAILED SEAT BACK RECLINER MECHANISM IS AVAILABLE FOR INSPECTION BY NHTSA PERSONNEL. THIS IS NOT A NORMAL WEAR AND TEAR ISSUE, SINCE THIS SEEMS TO BE A COMMON PROBLEM WITH OTHER 1993 SATURNS. *TR
No injuries · No fire · No crash
CONSUMER WAS DRIVING AT APPROXIMATELY 25 MPH AND SUDDENLY THE LIGHTS WENT DIM AND SMOKE BEGAN COMING FROM THE FRONT OF THE VEHICLE. THE SERVICE MANAGER TOLD CONSUMER THAT THERE WAS A FIRE COMING FROM THE ENGINE COMPARTMENT, AND THE WIRE THAT CONNECTED TO THE ALTERNATOR MELTED. *AK
CONSUMER COMPLAINED ABOUT MULTIPLE FAILURES. THE TRUNK FAILED TO CLOSE ON ITS OWN. WHILE DRIVING THE TRUNK WOULD OPEN AND WOULD NOT CLOSE, AND WILL NOT LOCK. ALSO, CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. THE BRAKES GRABBED SLOWLY AND CAUSED LOSS OF BRAKING POWER. CONSUMER TOOK VEHICLE TO DEALER FOR INSPECTION. CAUSE HAD NOT BEEN DETERMINED. *AK
No injuries · No fire · No crash
DUE TO PLASTIC DOOR SKIN (OUTER PANELING ) OPENING THE DOOR IN A LOW SPEED CAR ACCIDENT IN ADDITION TO PASSIVE SEAT BELT FALURE (INTERMITTENTLY WORKED)I WAS EJECTED FROM CAR AND LEFT PARALYZED. AUTOMATIC DOOR LOCKING WAS REJECTED BY SATURN DUE TO COST LEAVING SAFETY OUT OF CONCERN. *JB