Saturn Ion Complaints (2005)

573 consumer complaints on file.

#11699599November 15, 2025
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, STEERING
This vehicle has an electrical issue from time to time seemingly out of nowhere. There is no power steering it just shuts off sometimes it’ll stay off for an hour sometimes it’ll stay off for weeks and I can’t figure out how to fix it. It randomly fixes itself same can be said for the air conditioning And the driver side, headlight all of these electrical functions, seemingly turn themselves up or down for no apparent reason.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674938July 21, 2025
ELECTRICAL SYSTEM:IGNITION
The contact owns a 2005 Saturn Ion. The contact stated that the ignition key was stuck inside the ignition key slot, and the vehicle failed to start. The cause of the failure was not yet determined. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 14V171000 (ELECTRICAL SYSTEM). The dealer was not contacted regarding the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 167,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648021March 13, 2025
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM, EXTERIOR LIGHTING
My key is stuck in the I can take it out the o2 seners not reading
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621152October 21, 2024
UNKNOWN OR OTHER
The ignition cylinder was replaced in my vehicle because the key would not turn in the ignition to start the car. It is actually, the fourth time this has happened. I understand that there have been two recalls on this issue in the past. The reason it was recalled is because the ignition has turned to the off position killing the car's engine while the driver is driving on the road which has caused serious accidents. I was lucky not to get into an accident from this. The last replacement has lasted almost ten years. However, my issue is that General Motors apparently keeps manufacturing a defective part. This is unacceptable because I had to pay $585.02 to have this work done due to the fact that the dealerships apparently are not required to replaced it at no charge to the vehicle owner. It could also be a potential safety issue again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515552April 5, 2023
AIR BAGS
Hello I am reaching out to complain about Courtesy Chevrolet - San Diego. I’ve been trying to get my car serviced in order to fIx the recalls. Unfortunately I have not been successful. I called the dealer to make an appointment but the dealer told me that the car has been discontinued and they can’t find the parts. The suggested to call somewhere else.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11500916January 9, 2023
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
When pressing the gas pedal 2/3 of the way down the pedal got stuck causing the engine to rev high while driving forward. I had to put the car in neutral, shut the engine off and manually get the gas pedal unstuck by reaching down to the floor and pulling the pedal upwards with my hands. Also I had no floor mats in my car for the pedal to get stuck on. This has happened on multiple occasions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498929December 27, 2022
ELECTRICAL SYSTEM, STEERING
Power steering intermittently fails at random and steering wheel suddenly becomes immovable nearly causing serious accidents and endangerment to myself, my family, and others drivers on the roads.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498467December 21, 2022
EXTERIOR LIGHTING
Headlights are to deem even on high beems.cant see anything coming or the on coming traffic can't see me coming.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11457641March 21, 2022
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
I turn my turn signals on and nonthing happens in the Frontline bulbs are brand new doesn't matter back turn signal work,front turn signal dont.this has been happening since forever my inlaws didn't know we didn't know until they gave car.so don't know how long seems like forever
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11454261February 26, 2022
UNKNOWN OR OTHER
My 2015 Saturn ION was on a Recalled Warranty issued and concerning faulty ignition Switch problem. I have brought my car in (5) times since (2014) and it has occurred again in (2021) and G,M, dealer Mauer Chevrolet has refused to honor warranty recall stating that Gm has sent them letter to not service any more Saturn's ION with this problem due to cost. they refused to take my car in with key stuck ignition switch. I have filed complaint with MN. Attorney General office Consumer Division and they agreed that my consumer rights had been violated but Mauer Chevrolet still refuse's to fix my problem. My car has been sitting for over (3) months due to this problem. I need your assistance and hope you intervene as this has caused stress ,hardship and depression being without a car. Car dealer is Mauer Chevrolet located inInver Grove Heights, MN. 1055 50th Street, 55075. (651-455-6283). Mauer Chevrolet has retained their attorney to assist them, so I need help, also. Please HELP!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11452729February 18, 2022
ELECTRICAL SYSTEM:IGNITION
2005 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH PROBLEM. THE CONSUMER STATED THE KEY WOULD FREQUENTLY BECOME STUCK IN THE IGNITION. THE DEALER MADE MULTIPLE REPAIR ATTEMPTS BUT, THE FAILURE RECURRED. THE CONSUMER REQUESTED TO HAVE THE VEHICLE REPAIRED UNDER RECALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11434203September 24, 2021
STEERING, UNKNOWN OR OTHER, ELECTRICAL SYSTEM:IGNITION
It says I have 0 I repaired recalls. I have had the powers steering fail 2x. More importantly, the ignition cylinder locks up and I can’t get my keys out. I have to wait most times after turning the car off - for 3-5 minutes through a series of clicking noises in the ignition before the key will release. It is concerning because sometimes I have to get out immediately and the keys don’t release. The car automatically locks itself and if I don’t roll the window down- I become locked out. It yesterday had a issue with ignition all together and I wonder if it’s related. I was made aware again there were many recalls on this issue and hoped to get it repaired. However it now states there are none unrepaired. I’m wondering if it is a ongoing problem with the vehicle, it’s repair parts etc and if it’s just not been addressed because it’s so old that so few are left on the road. Thank you. This is a increasing problem and a daily or every time I drive it issue now. I worry too the power steering will just go out in the interstate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11425536July 19, 2021
STEERING
The contact owns a 2005 Saturn Ion. The contact stated that while operating the vehicle, the power steering malfunctioned, and the steering wheel became very difficult to turn in either direction. During the failure, the power steering message was displayed. The cause of the failure was not yet determined. The vehicle was not repaired. The local dealer was notified of the failure. The manufacturer was not contacted. The contact stated that the vehicle was previously repaired under the NHTSA campaign number: 14V153000 (Steering) but the failure occurred. The failure mileage was 167,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11416273May 12, 2021
ELECTRICAL SYSTEM, ENGINE, STEERING
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE LOSS MOTIVE POWER WITHOUT WARNING. THE CONTACT STATED THAT STEERING ASSIST AND GAUGES WERE IN OPERABLE. THE CONTACT COASTED TO THE SIDE OF THE ROAD AND RESTARTED THE VEHICLE. THE CONTACT STATED THAT SEVERAL OF THE ELECTRICAL FUNCTIONS RETURNED HOWEVER, THE ELECTRICAL FUNCTIONS FAILED INTERMITTENTLY. THE POWER STEERING ASSIST WARNING LIGHT ILLUMINATED INTERMITTENTLY WHEN THE POWER STEERING ASSIST WAS INOPERABLE. OCEAN CREST CHEVROLET BUICK GMC CADILLAC (855 ALTERNATE HWY 101, WARRENTON, OR 97146, (866)607-2902) WAS CONTACTED AND INFORMED OF THE FAILURE. THE DEALER SUGGESTED THAT THE VEHICLE BE TAKEN IN TO BE DIAGNOSED WHICH WAS STILL PENDING. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11394883February 5, 2021
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL
DASH LIGHTS GO OUT AND ALL SYSTEMS ARE YOU FUNCTIONING PROPERTY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11378287December 7, 2020
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT UPON ACTIVATION OF THE HEADLIGHTS, THE HEADLIGHTS WERE DIM CAUSING POOR FORWARD VISIBILITY WHILE DRIVING AT NIGHT OR IN LOW LIGHT CONDITIONS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 09E012000 (EXTERIOR LIGHTING) HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11374991November 17, 2020
AIR BAGS
TL* THE CONTACT OWNED A 2005 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A TREE. DURING THE CRASH THE PASSENGER SIDE OF THE VEHICLE WAS SEVERELY DAMAGED BUT NO AIR BAGS HAD DEPLOYED. THE DRIVER SUSTAINED AN INJURED NECK AND WAS TRANSPORTED TO THE HOSIPITAL. A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE WAS DESTROYED AND TOWED AWAY. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE INCIDENT. THE FAILURE MILEAGE WAS 174,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11298156January 9, 2020
STEERING
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT THE STEERING WHEEL WOULD MOVE UNCONTROLLABLE. THE VEHICLE WAS TOWED TO THE DEALER (GLENN H. WRIGHT, BS 1517 W GARVEY AVE N, WEST COVINA, CA 91706 (626) 962-6061) BY ROADSIDE ASSISTANCE AND LEFT AT THE DEALER FOR 6 DAYS. THERE WAS NO DIAGNOSTIC TESTING PERFORMED AND THE VEHICLE WAS NOT REPAIRED. HOWEVER, THE FAILURE RECURRED AND THE VEHICLE WAS UNSAFE TO DRIVE. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) AS A POSSIBLE SOLUTION TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT NO FURTHER ASSISTANCE WAS TAKEN THE CONTACT WAS PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11230171July 8, 2019
ENGINE
TL* THE CONTACT OWNED A 2005 SATURN ION. THE CONTACT'S SON OBSERVED AN ORANGE GLARE COMING FROM THE BACK OF THEIR HOUSE. THE FAMILY RAN OUTSIDE TOGETHER AND DISCOVERED THAT THE SON'S VEHICLE WAS ON FIRE. THE FIRE DEPARTMENT WAS DOWN THE STREET, BUT TOOK TWENTY MINUTES TO ARRIVE AT THE SCENE. THE CONTACT'S NINETEEN YEAR OLD SON EXTINGUISHED THE FIRE WITH WATER FROM THE HOUSE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOTALED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 217,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11222492June 25, 2019
ELECTRICAL SYSTEM, UNKNOWN OR OTHER, EXTERIOR LIGHTING
DAYTIME RUNNING LIGHT TURN SIGNAL DONT WORK FOR THE PASSENGER SIDE WHICH CAN CAUSE A SAFETY PROBLEM TO OTHER DRIVERS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Saturn Ion