SAAB 9-5 Complaints (2001)

104 consumer complaints on file.

#10164523August 4, 2006
ELECTRICAL SYSTEM:IGNITION:MODULE
DT*: THE CONTACT STATED WHILE DRIVING THERE WAS A NOTICEABLE LOSS OF POWER. THE VEHICLE WAS TAKEN THE SERVICE DEALER WHERE A 24 POINT INSPECTION WAS PREFORMED AND THE THROTTLE BODY WAS CLEANED. WHILE TRAVELING AT 35 MPH., ON THE INTERSTATE HIGHWAY, ON A CLEAR, DRY DAY, THERE WAS LOSS OF ALL POWER. THE VEHICLE WAS TOWED TO THE SERVICE DEALER WHERE THE CONTACT WAS INFORMED THE ENGINE SUFFERED A COMPLETE ENGINE FAILURE AND NEEDED TO BE REBUILT. THE MANUFACTURER OFFERED TO COVER $2,000.00 OF THE ESTIMATED REPAIR COST HOWEVER THE CONTACT WAS UNABLE TO PROCEED WITH THE REPAIR WORK. SINCE THEN A RECALL NOTICE (05V399000) WAS RECEIVED REGARDING THE IGNITION DISCHARGE MODULE (SAAB RECALL # 05087). THE CONTACT BELIEVED THAT THE RECALL DEFECT WAS RESPONSIBLE FOR THE ENGINE FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10164441August 3, 2006
ENGINE AND ENGINE COOLING:ENGINE
AT 8:00 PM THIS EVENING, I WENT TO DINNER. EVERYTHING WAS WORKING NORMALLY ON MY CAR. AT 8:20 PM, TWENTY MINUTES LATER, I START MY CAR AND IT ENTERS "LIMP-HOME" MODE WITH A BLINKING CHECK ENGINE LIGHT, INDICATING MISFIRE. GIVEN THE WAY THE CAR WAS ACTING, THE TIMING BELT HAS BROKEN. IN MY RESEARCH, I HAVE FOUND THIS MOTOR IS A GM L81 MOTOR, 3.0L V6. THIS MOTOR HAS ALSO BEEN USED IN THE SATURN VUE AND CADILLAC CATERA. ACCORDING TO THE NHTSA RECORDS, THERE WAS A RECALL ON TIMING BELTS FOR THE 97-2002 CATERAS. AS STATED EARLIER, THIS IS THE SAME MOTOR IN MY 2001 SAAB 9-5 SE V6 3.0L. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162650July 12, 2006
ELECTRICAL SYSTEM:IGNITION:MODULE, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
2001 SAAB 9-5, CONSUMER HAS NOT RECEIVED REIMBURSEMENT FOR THE RECALL WORK DONE ON THE VEHICLE. *KB THE CONSUMER RECEIVED A RECALL LETTER IN THE MAIL ONE MONTH LATER, AFTER THE REPAIRS WERE ALREADY PAID FOR. WHEN THE CONSUMER CALLED TO INQUIRE ABOUT HER REFUND, SHE WAS TOLD BY THE MANUFACTURER, THAT THEY DIDN'T HAVE ALL OF THE PAPERWORK AND ALSO THEY DIDN'T HAVE HER ADDRESS. NINE MONTHS LATER, THE CONSUMER STILL HAS NOT RECEIVED REIMBURSEMENT. THE CATALYTIC CONVERTER WAS REPLACED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10157741May 17, 2006
ELECTRICAL SYSTEM:IGNITION:MODULE
IDM (IGNITION CASSETTE) FAILURE 1ST OCCURRENCE: 10/11/2005 (48,000 MILES) 2ND OCCURRENCE: 4/10/2006 (54,000 MILES). *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10157342April 27, 2006
ENGINE AND ENGINE COOLING:ENGINE
2001 SAAB 9-5 IDM IS DEFECTIVE, CONSUMER WAS TOLD THAT ALL THE SPARK PLUGS NEED TO BE REPLACED. *TS *NM***NAR***
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10157292April 26, 2006
ENGINE AND ENGINE COOLING:ENGINE
THE CONSUMER RECEIVED A LETTER FROM SAAB STATING THAT PROBLEMS WITH THE IDM COULD CAUSE REDUCED POWER AND ROUGH OPERATION. THE CONSUMER EXPERIENCED THIS PROBLEM WITH HIS 2001 SAAB 9/5. *NM THE CHECK ENGINE LIGHT BEGAN TO FLASH PRIOR TO THE VEHICLE STALLING. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10154737April 6, 2006
POWER TRAIN:AUTOMATIC TRANSMISSION
ABOUT 6 MONTHS AFTER THE SAAB SPECIFY TRANSMISSION FLUID CHANGE, MY 2001 SAAB 95SE WAGON WITH 66,363 MILES HAS DEVELOPED THE BELOW PROBLEM. APPROXIMATELY A MILE TO A MILE AND HALF AFTER DRIVING 20-40 MPH, THE CAR WOULDN'T MOVE FORWARD WHILE THE ENGINE WAS RUNNING FINE. TURNED THE IGNITION OFF FOR 10 MINUTES, RESTARTED THE CAR, MOVED ABOUT 100-200 FEET, THE SAME SYMPTOM HAPPENED AGAIN. THE CAR WAS TOWED TO AN INDY AND THEN TO A DEALER. INDY FOUND CODE P0730 BUT THE DEALER WAS NOT ABLE TO DUPLICATE THE SAME. DEALER CHARGED OVER $100 AND SAID THE CAR WAS FINE AFTER ALLEGEDLY TEST DRIVE "10 MILES". WE PICKED THE CAR. AFTER A MILE OF SLOW DRIVING, THE SAME SYMPTOM DEVELOPED. WITHOUT FINDING OUT WHAT'S THE CAUSE OF THIS PROBLEM NOR HAD THEY OPENED THE TRANSMISSION, THE DEALER CONCLUDED THAT I NEED A NEW TRANSMISSION. SAAB USA WAS INFORMED AND IT WAS SAAB USA DIRECTED ME TO THE DEALER. NOW THEY WANT TO CLOSE THE CASE, WITHOUT ANY ASSISTANCE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155206April 5, 2006
ELECTRICAL SYSTEM:IGNITION
2001 SAAB 9-5 RUNS ROUGH THE CONSUMER HAD TO REPLACE THE IDM DUE TO FAILURE. *TS ***NAR*** AFTER THE IDM REPAIRS WERE MADE THE CONSUMER RECEIVED A RECALL NOTICE WHICH REFERENCED THE PROBLEM THE CONSUMER HAD REPAIRED. THE CONSUMER SUBMITTED A CLAIM REQUESTING REIMBURSEMENT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10149105January 31, 2006
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR, ELECTRICAL SYSTEM:IGNITION
I OWN A 2001 SAAB 95 SE V6. WAS DRIVING DOWN THE NJ TPK AND THE CAR LOST POWER AND HAD A SMALL ELECTRICAL LIKE FIRE UNDER THE HOOD. HAD TO GET THE CAR TOWED FROM THE NJ TURNPIKE OFF AND THEN AGAIN TO MY PLACE IN BENSALEM PA. TOTAL COST $77 + 66. FOUND OUT THAT THE DI CASSETTE BURNED OUT, COST ME APPROX $600 TO FIX. A DAY LATER THE CAT CONVERTER FAILS (CHECK ENGINE LIGHT CAME ON AGAIN). THIS IS CERTAINLY DUE TO DI CASSETTE BURNING OUT. VERY FRUSTRATING FOR A CAR WITH ONLY 60K MILES ON IT. *NM
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10147327January 10, 2006
ELECTRICAL SYSTEM:IGNITION:MODULE
IGNITION MODULE FAILED WHILE DRIVING, LEADING TO LOSS OF POWER MAKING VEHICLE INOPERABLE. CATALYTIC CONVERTER WAS DAMAGED AND IT AND THE IGNITION MODULE NEEDED TO BE REPLACED. SECOND TIME WAS AFTER IGNITION MODULE REPLACE IN 10/05. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10143287November 20, 2005
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
FUEL PUMP SPRANG A LEAK PUMPING GASOLINE UNDER VEHICLE AS LONG AS ENGINE CONTINUED RUNNING. CAR WAS FLATBEDDED TO DEALER. NEW FUEL PUMP COST $810.00. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10143090November 18, 2005
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
DT: THE CONTACT STATED AFTER A SHORT DRIVE THERE WAS A FUEL SMELL. HE LOOKED UNDER THE VEHICLE AND FOUND A SPOT OF FUEL. HE INSPECTED THE VEHICLE, AND FOUND THERE WAS A LEAK WHERE THE FUEL PUMP COMES OUT OF THE GAS TANK. THE DEALERSHIP HAS BEEN CONTACTED, BUT THE PROBLEM HAS NOT BEEN CORRECTED AT THIS TIME. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10141851November 6, 2005
ELECTRICAL SYSTEM:IGNITION
I WAS DRIVING VEHICLE 2001 SAAB 9-5 SE (V6 ENGINE) WAGON AT 45-50 MPH WHEN IT SUDDENLY LOST POWER AND DECELERATED. I KNEW ABOUT DI CASSETTES FAILURE AND STOPPED IMMEDIATELY. NO WARNING LIGHTS ILLUMINATED PRIOR OR AFTER THIS EPISODE. VEHICLE WAS TOWED TO LOCAL SAAB DEALER. PROBLEM WAS DIAGNOSED AS A FAULTY DIRECT IGNITION CASSETTE AND REPLACED WITH A NEW PART FOR FREE DUE TO FUTURE RECALL (DI CASSETT ONLY). THE CATALYTIC CONVERTER WAS DAMAGED DUE FAILURE OF THE IDM TOO, BUT IT DOES NOT COVERED AND IT WAS REPLACED AT COST OF $2026.48. +10 DAYS I WAS WATING FOR PARTS. THIS CAR HAS HAD OTHER "SMALL" ELECTRICAL PROBLEMS LIKE MULTIPLE LIGHT BULB BURN OUTS, LOSS OF PIXELS ON THE SID DISPLAY, SUDDEN INCREASE BRIGHTNESS OF ALL LIGHTS, FAILURE OF REAR SEATS HEATER. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10141484November 1, 2005
ENGINE AND ENGINE COOLING:ENGINE
MY 2001 SAAB 9-5 STALLED ONE DAY ALL OF A SUDDEN AFTER I REACHED A SHOPPING MALL. I TOOK IT TO A LOCAL SAAB DEALER AND THEY REPLACED MY IGNITION SYSTEM FOR A CHARGE CLOSE TO 600 DOLLARS. THEY SPOKE TO ME THAT IT WAS AN ISOLATED EVENT. FROM THE RECALL NOTICE YOU RELEASE I REALIZE THAT IT WAS INTRINSIC MANUFACTURING DEFECT. THANK YOU ALL FOR THE GOOD WORK. I HOPE I WILL GET A REFUND. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138383October 26, 2005
WHEELS:HUB, WHEELS:LUGS/NUTS/BOLTS/STUDS
DT: THE CONTACT OWNS A 2001 SAAB 95. WAS NOT NOTIFIED OF A RECALL. THE CONTACT TOOK THE VEHICLE TO DEALER FOR SERVICE AND REPAIR. THE INVOICE STATED THAT THERE WAS NOT A RECALL. THE SERVICE DEPARTMENT REPLACED LUGS: BOLTS. THE CONTACT WAS UNAWARE OF THIS RECALL. *AK *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137639September 26, 2005
ELECTRICAL SYSTEM:IGNITION:MODULE
ON A 2001 SAAB 9-5 SE (V6 ENGINE) STATIONWAGON WHILE DRIVING ON AN INTERSTATE HIGHWAY, THE CAR SUDDENLY LOST POWER AND THE CHECK ENGINE LIGHT STARTED FLASHING. AS I PULLED THE CAR OFF THE HIGHWAY ONTO AN EXIT RAMP (WITHIN LESS THAN A MINUTE OF THE MALFUNCTION), THE CAR STALLED AND A BURNING SMELL WAS DETECTED INSIDE THE CAR AFTER WHICH THE CAR WAS TURNED OFF AND PARKED. THE CAR WAS TOWED TO THE LOCAL SAAB DEALER WHERE THE IGNITION DISCHARGE MODULE ON THE REAR CYLINDER BANK WAS DETERMINED TO HAVE FAILED. FAILURE OF THE IDM ON ONLY 3 OUT OF 6 CYLINDERS CAUSED UNBURNED GAS TO BE DISCHARGED INTO THE EXHAUST WHERE IT REACTED IN THE CATALYTIC CONVERTER, CLOGGING THE CONVERTER AND STALLING THE ENGINE. THE CATALYTIC CONVERTER WAS RUINED WHICH CAUSED THE BURNING SMELL. NO FIRE WAS DETECTED. THE IDM AND CATALYTIC CONVERTER WERE REPLACED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137693September 26, 2005
ELECTRICAL SYSTEM
I HAVE A 2001 SAAB AERO 9-5. I HAVE TAKEN THIS VEHICLE INTO THE SAAB SERVICE DEPARTMENT OVER 15 TIMES TRYING TO FIX MY PROBLEM. MY VEHICLE SHUTS DOWN WHILE DRIVING AND MANY TIMES WILL NOT RESTART. I HAVE ALSO HAD MANY ELECTRICAL ISSUES WITH MY VEHICLE INCLUDING BUT NOT LIMITED TO THE ELECTRICAL MODULES FOR THE HEAT AND AIR CONDITIONING, HEATED AND AIR CONDITIONED SEATS NOT WORKING AND MANY OTHER ELECTRICAL MODULES GOING OUT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10135009August 31, 2005
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
2001 SAAB 9-5 FUEL PUMP CLIP FAILED SPRAYING GASOLINE UNDER PRESSURE OVER EXHAUST SYSTEM BELOW REAR PASSENGER SEAT. THERE IS AN ACTIVE RECALL FOR THE 2001 SAAB 9-3 FOR THE SAME EXACT PROBLEM. NO RECALL FOR THE 2001 SAAB 9-5. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10134817August 30, 2005
ELECTRICAL SYSTEM:IGNITION:MODULE
DIRECT IGNITION CASSETTE FAILED ON TWO SEPARATE OCCASIONS, CAUSING CAR TO LOSE POWER AND STOP. VEHICLE IS A SAAB 95, 2001, V6, SE WAGON, DATE OF SECOND INCIDENT IS BELOW.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131920August 8, 2005
ELECTRICAL SYSTEM:IGNITION:MODULE
IGNITION CASSETTE FAILED WHILE DRIVING CAR. CAR SPEED WAS APPX 40 MPH, CHECK ENGINE LIGHT FLASHED AND I LOST ENGINE POWER. PULLED CAR OVER AND FOUND BLACK SMOKE COMING OUT OF IGNITION CASSETTE. CASSETTE WAS VERY HOT AND I WAS CONCERNED IT WOULD CATCH ON FIRE. CAR WOULD NOT START THEREAFTER. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to SAAB 9-5