Mitsubishi Montero Complaints (1997)

92 consumer complaints on file.

#10865807May 19, 2016
TIRES, POWER TRAIN, SUSPENSION
TL* THE CONTACT OWNS A 1997 MITSUBISHI MONTERO SPORT. WHILE DRIVING BETWEEN 55 AND 65 MPH, THE FRONT END OF THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BALL JOINTS, WHEEL BEARINGS, TRANSMISSION MOUNT, UNIVERSAL BOLT, AND TIRES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 00V311001 (ENGINE AND ENGINE COOLING), BUT THE VIN WAS EXCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 114,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10705834April 15, 2015
ENGINE
VEHICLE LOST POWER STEERING AND STALLED. CRANKSHAFT PULLEY BOLT FELL OUT AND HARMONIC BALANCER FELL OFF.CAUSING LOSS OF CONTROL AND LIFE THREATENING SITUATION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10694085March 13, 2015
ENGINE
COMMON PROBLEM WITH THESE, CRANK SHAFT PULLEY BOLT DEFECTIVE SHOULD HAVE RECALLED ALL OF THEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10650739October 28, 2014
STEERING, POWER TRAIN
CRANKSHAFT PULLEY BOLT CAME LOOSE CAUSING LOSS OF STEERING. HAD TO STEER VERY HARD MANUALLY TO PARK CAR. DANGEROUS SITUATION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10597034June 9, 2014
SEATS, ELECTRICAL SYSTEM
ON 5/31/14, MY 1997 MITSUBISHI MONTERO WAS PARKED IN MY DRIVEWAY. WHEN I WENT TO GET INTO THE VEHICLE, I NOTICED A LARGE BURN IN THE BACK OF THE DRIVER'S SIDE SEAT. AFTER CALLING MITSUBISHI, THE FIRE DEPARTMENT CAME SINCE IT WAS STILL SMOLDERING AND DISCONNECTED THE BATTERY. THEY BELIEVED IT TO BE AN ELECTRICAL SHORT. AFTER MANY FOLLOW-UP CALLS TO MITSUBISHI, THEY BELIEVE IT WAS CAUSED BY WEAR AND TEAR SINCE THE CAR WAS 17 YEARS OLD. ALL OF THE COST TO FIX THE ISSUE WAS ON ME AS THE OWNER. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10396534April 16, 2011
ENGINE AND ENGINE COOLING:ENGINE
1997 MITSUBISH MONTERO 3.5 LITER AUTOMATIC- CRANK SHAFT BOLT HAS COME OUT ON 5 SEPARATE OCCASIONS AND HAS COST OVER $3000 TO HAVE IT REPLACED. THE INSIDE OF THE CRANKSHAFT WHERE THE BOLT GOES IS COMPLETELY STRIPPED TO THE POINT I NOW HAVE TO REPLACE THE ENGINE. THIS IS NOT AN ISOLATED ISSUE AS THIS APPEARS TO BE AN INHERENT PROBLEM WITH ALL YEARS OF MONTEROS. THERE SHOULD BE A RECALL FOR THIS AND MITSUBISHI SHOULD COVER THE COST FOR THERE NEGLIGENCE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10384572February 26, 2011
ENGINE AND ENGINE COOLING
CRANKSHAFT PULLEY PIN/BOLT GETS SHEARED OFF. DASH LIGHTS COME ON AND VEHICLE POWER STEERING STOPS WORKING AS THE PUMP IS NOT TURNING BECAUSE THE PROBLEM AFFECT THE ENTIRE PULLEY SYSTEM. IT ALSO AFFECTS THE TIMING GEAR/BELT/HARMONIC BALANCER. THIS IS THE 3RD TIME IN AS MANY YEARS THIS HAS HAPPENED. THIS IS THE 2ND MECHANIC WHO HAS TOLD ME THAT IT'S AN ENGINE DEFECT BECAUSE THE PIN/BOLT IS TOO SHORT. THERE IS NO WARNING BEFORE IT HAPPENS. IT OCCURS UNDER NORMAL CITY DRIVING CONDITIONS AT LOW OR NO SPEED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10326077April 16, 2010
UNKNOWN OR OTHER, FUEL SYSTEM, GASOLINE
THE VEHICLE WAS PARKED AND IDLING. I WAS IN THE DRIVER'S SEAT WHEN A FIRE BROKE OUT AND THE FLAMES CAUSED ME SEVERE BURNS TO MY BODY. I WAS NEARLY ASPHYXIATED. THE CAR WAS A TOTAL LOSS. *TR
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#10320369March 17, 2010
ENGINE AND ENGINE COOLING:ENGINE
1997 MITSUBISHI MONTERO CRANKSHAFT PULLEY CAME LOOSE THREE TIMES WHICH CREATED NO POWER STEERING AND NO CHARGING OF THE BATTERY PURCHASED NEW CRANKSHAFT PULLEY BUT DID NOT HELP THE THIRD TIME INSTALLED A LOCK WASHER ON THE BOLT AND RE TORQUED TO SPEC LAST WEEK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10283733September 11, 2009
STEERING
STEERING TERMINAL CAME OFF MAKING THE VEHICLE GO IN DANGER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10246235October 21, 2008
ELECTRICAL SYSTEM
TL*THE CONTACT OWNED A 1997 MITSUBISHI MONTERO SPORT. THE CONTACT STARTED THE VEHICLE SO IT COULD WARM UP BEFORE DRIVING AND WENT BACK INTO THE HOUSE. WHILE IN THE HOUSE, SHE HEARD A LOUD BOOM SIMILAR TO AN EXPLOSION. SHE FOUND THE VEHICLE COMPLETELY ENGULFED IN FLAMES. THE POLICE AND FIRE DEPARTMENTS WERE CALLED TO EXTINGUISH THE FIRE AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND THE INSURANCE COMPANY TOWED THE VEHICLE TO THE SALVAGE YARD. THE SIDE OF THE CONTACT'S RESIDENCE SUSTAINED PROPERTY DAMAGE. IN JULY OF 2008, THE CONTACT SMELLED SOMETHING BURNING WHEN SHE ACTIVATED THE HEADLIGHTS. THE HEADLIGHTS CAUGHT FIRE AND MELTED. THE DEALER STATED THAT DUE TO A SHORT ON THE CONNECTOR WIRE, THE AIR BAG CONNECTOR WIRE WAS REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 116,000. UPDATED 02/24/09. *LJ UPDATED 02/24/09. *JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10240750September 3, 2008
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 1997 MITSUBISHI MONTERO. WHEN THE VEHICLE WAS STARTED, THE CRANKSHAFT PULLEY DETACHED FROM THE VEHICLE. THE DEALER STATED THAT THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR. THE VEHICLE HAS NOT BEEN DRIVEN SINCE. THE FAILURE MILEAGE WAS 190,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10237991August 13, 2008
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 1997 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT THE NUT AND BOLT PULLED OUT FROM THE CRANKSHAFT PULLEY. WHILE ATTEMPTING TO MAKE A LEFT TURN AT A STOP SIGN, THE VEHICLE FAILED TO PULL TO THE LEFT. THE DEALER STATED THAT NOTHING COULD BE DONE TO REPAIR THE VEHICLE UNLESS THE MANUFACTURER APPROVED THE REPAIRS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 00V311001 (ENGINE AND ENGINE COOLING:ENGINE). THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 126,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10226494May 2, 2008
ENGINE AND ENGINE COOLING
I OWN A 1997 MITSUBISHI MONTERO SPORT LS. THERE WAS A RECALL FOR A CRANKSHAFT PULLEY BOLT, NHTSA RECALL ID: 00V311001. I TOOK MY VEHICLE TO THE MITSUBISHI DEALER AND THEY REPLACED THE BOLT. THIS WAS BACK IN 2000. IN FEBRUARY OF 2008 I WAS DRIVING, GETTING READY TO GET ON THE HIGHWAY WHEN I HEARD A GRINDING AND THEN A LOUD NOISE FROM THE ENGINE, I LOST POWER STEERING AND QUICKLY PULLED OVER. POPPED THE HOOD OF MY VEHICLE AND NOTICED THAT THE CRANKSHAFT PULLEY HAD BROKEN OFF. I TOWED IT TO MY MECHANIC WHO STATED THAT THE CRANKSHAFT PULLEY BOLT HAD BROKEN. HE GAVE ME AN ESTIMATE OF $2400 TO HAVE THE CRANKSHAFT REPLACED, OR $3100 TO PUT IN A REBUILT ENGINE. I CALLED MITSUBIHSI AND TALKED TO S LADY WHO WAS VERY RUDE, SHE WOULD HARDLY LET ME SAY ANYTHING. SHE STATED THAT THERE WAS NOTHING THAT THEY COULD DO AND TO CONTACT THE DEALERSHIP THAT HAD REPLACED THE BOLT. THAT DEALERSHIP IS NO LONGER THERE, WENT OUT OF BUSINESS. LOOKING ONLINE I HAVE FOUND NUMEROUS COMPLAINTS ABOUT THIS HAPPENING TO PEOPLE WHO OWN BOTH THE 97 AND 98 MODELS OF MONTERO SPORTS, EVEN AFTER BRINGING THEIR VEHICLES IN FOR THE RECALL. IF THIS HAD OCCURRED WHILE I WAS TRAVELING ON THE HIGHWAY I COULD HAVE BEEN SERIOUSLY INJURED AS I LOST ALL POWER STEERING. I FEEL THAT THIS IS A SERIOUS SAFETY ISSUE, I KNOW THAT MITSUBISHI ISSUED A RECALL TO FIX THIS BUT THEIR FIX DID NOT RESOLVE THE PROBLEM. I ALSO FEEL THAT MITSUBISHI SHOULD PAY FOR FIXING MY VEHICLE AS IT IS RELATED TO THE BOLT BREAKING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10215166January 16, 2008
ENGINE AND ENGINE COOLING, SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
TL*THE CONTACT OWNS A 1997 MITSUBISHI MONTERO SPORT. HER VEHICLE WAS REPAIRED ACCORDING TO RECALL #00V311001 AFFECTING THE ENGINE AND ENGINE COOLING:ENGINE THE MECHANIC TIGHTENED THE CRANKSHAFT PULLEY BOLT. AFTER SIX MONTHS DRIVING APPROXIMATELY 10 MPH THE ENGINE, OIL, AND BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE STEERING COLUMN ALSO BEGAN TO TIGHTEN UP. AFTER INSPECTING THE VEHICLE SHE NOTICED THAT THE CRANKSHAFT PULLEY FELL OUT OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER SINCE HER VEHICLE WAS PREVIOUSLY REPAIRED PER THE RECALL. THE DEALER STATED THAT THE CONTACT IS RESPONSIBLE FOR THE COST OF REPAIRS. THE CRANKSHAFT PULLEY WAS REPLACED. TWO MONTHS LATER THE ENGINE MADE A LOUD SHUTTER THEN THE PULLEY FELL OUT OF THE VEHICLE AGAIN. THE MANUFACTURER DID NOT PROVIDE HER WITH ANY ASSISTANCE. SHE HAS PICTURES OF THE FAILED COMPONENT. THE FAILURE AND CURRENT MILEAGES WERE 149,000. UPDATED 02-11-08 *BF THE CONSUMER STATED SHE HAD TO PAY OUT OF POCKET FOR REPAIRS $1,300.00 AND RECEIVED A DISCOUNT OF $200 FROM THE DEALER. THE CONSUMER FURTHER STATED THE DEALER ALSO FOUND ANOTHER DEFECT IN THE VEHICLE IN WHICH THE CONSUMER ALSO HAD TO PAY OUT OF POCKET. THE CONSUMER ALSO STATED THERE WAS A 2ND INCIDENT WITH THE BRAKE RECALL. UPDATED 02/11/08 *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10196657July 18, 2007
EQUIPMENT:APPLIANCE:AIR CONDITIONER, ENGINE AND ENGINE COOLING
STARTED CAR, NOTICED 3 RANDOM LIGHTS ILLUMINATED ON INSTRUMENT CLUSTER. THEN POWER STEERING WAS INTERMITTENT. THEN A/C WENT OUT AND WOULD NOT COOL DOWN. THEN POWER STEERING FAILED COMPLETELY. CAR WAS DRIVEN TO REPAIR SHOP NEARBY, SINCE NO LOCAL MITSUBISHI DEALER. MECHANIC FOUND CRANKSHAFT BOLT BROKEN THAT LED TO POWER STEERING AND A/C PULLEY NOT WORKING. INCIDENT LED TO NEAR LOSS OF CONTROL DURING TURNING , AS POWER STEERING WOULD "KICK" IN AT TIMES DURING CORNERING AND LEAD TO OVERSTEER. HAD TO CHANGE CRANKSHAFT BOLT, HARMONIC BALANCER, TIMING BELT GEAR, AND SOMETHING ELSE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10191637May 24, 2007
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
TL*THE CONTACT OWNS A 1997 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT THE BOLT IN THE VEHICLE'S CRANKSHAFT PULLEY BACKED OUT. THE FAILURE CAUSED THE PULLEY TO BECOME LOOSE AND SHEER THE PIN ON THE END OF THE CRANKSHAFT. WHILE DRIVING 35 MPH, THE POWER STEERING, BRAKES, AND ENGINE FAILED. THE VEHICLE HAD TO BE TOWED. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 109,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10164861August 7, 2006
ENGINE AND ENGINE COOLING
DT*: THE CONTACT STATED THE CRANKSHAFT PULLEY AND BOLT BECAME DISCONNECTED. THIS OCCURRED TWICE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140768October 25, 2005
ENGINE AND ENGINE COOLING
DT: THE CONTACT STATED THE CRANK SHAFT PULLEY BOLT BROKE ON 10-24-05. SHE HAD RECALL 00V311000 REPAIR WORK DONE IN OCTOBER -2002. THE CONTACT WANTED TO FILE A COMPLAINT BECAUSE SHE WAS STILL HAVING PROBLEMS WITH THE CRANK SHAFT. SHE FELT THIS SHOULD HAVE BEEN FIXED PROPERLY THE FIRST TIME. SHE SPOKE TO THE DEALER AND TO MITSUBISHI. MITSUBISHI TOLD HER TO CONTACT THE DEALER AND IT MAY OR MAY NOT BE COVERED. SHE CONTACTED THE DEALER, AND HE TOLD HER THAT AT THE TIME OF THE RECALL THEY TIGHTENED THE BOLT, AS STATED IN THE RECALL. SHE THOUGH THE RECALL NOTICE SHOULD HAVE STATED THE DEALER SHOULD HAVE ACTUALLY CHANGED THE BOLT.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138715October 5, 2005
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
DT: THE CONTACT OWNS A 1997 MITSUBISHI MONTERO SPORT. IN 6-03 HE BROUGHT THE CAR I TO DEALER BECAUSE THE TIMING BELT CAME OFF. THE REPAIR WORK COST $463.06. ON 7-26-03 THE CONTACT BROUGHT IT BACK BECAUSE THE TIMING BELT CAME OFF AGAIN. HE FOUND THERE WAS RECALL 00V311001 AND THE DEALER FIXED IT AT NO COST LAST WEEK ON 9-29--0) THE TIMING BELT CAME OFF AGAIN. HE HAD THE VEHICLE TOWED, AND THE MECHANIC COULD SEE THE BOLT STICKING OUT. TALKED TO THE DEALER, AND THE DEALER ORIGINALLY SAID THEY WOULD REPAIR IT BECAUSE IT HAD A LIFETIME WARRANTY. LATER THE CONTACT FOUND OUT FROM THE DEALER THAT THE WARRANTY EXPIRED. THE ESTIMATE REPAIR EXPENSE WOULD BE $500.00. HE CALLED THE MANUFACTURER AND NEITHER WANTED TO ACCEPT RESPONSIBILITY. THE MANUFACTURER WOULD NOT PAY FOR THE REPAIRS BECAUSE THE DEALER DID NOT REPAIR IT CORRECTLY. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mitsubishi Montero