Mitsubishi Lancer Evolution Complaints (2008)

36 consumer complaints on file.

#11142680October 25, 2018
UNKNOWN OR OTHER
AYE/ HYDRALIC PUMP WAS NEVER CHANGED OUT WAS TOLD WHEN I WENT TO DO A MANUFACTURING RECAL THAT IT WORKED FINE WHEN IT DIDNT AND AFTER WARDS HIT PAST THE 100,000 MILES AND WAS AUTOMATICALLY UNABLE TO GET THE REPLACEMENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10851019March 22, 2016
POWER TRAIN
AYC PUMP FAILURE AT 44 THOUSAND MILES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10664740December 17, 2014
POWER TRAIN
ACD/ AYC PUMP FAILURE, ONE TIME I WAS DOING FLUID INSPECTION ON MY CAR WHEN I NOTICE THE CARS ATF FLUID RESERVOIR IN THE TRUNK IS LOSING OIL. LOOKED AT THE FLOOR FOUND SOME RED OIL DRIPPING. IT MAY HAVE SEEM THAT PUMP MAY HAVE BEEN FAILING TO HOLD PRESSURE AND LOSE OIL. POSSIBLE GASKET FAILURE OR PUMP CRACK. BEEN SEARCHING ONLINE FOR SIMILAR PROBLEMS, I FOUND OUT IT SEEMED TO BE MOSTLY EVERY OWNERS PROBLEM. IS THIS SUPPOSE TO BE COVERED BY MANUFACTURER? SEEM LIKE POOR MATERIAL BUILD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10662884December 8, 2014
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN
VEHICLE WAS IN COLD WEATHER, AYC SYSTEM LIGHT TURNED ON. I CHECKED THE FORUMS AND FOUND THAT THIS IS A COMMON ISSUE THAT INDICATES THE PUMP IS BAD. THIS IS A VERY COMMON PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10659722November 20, 2014
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC)
IT WAS A COLD WINTER DAY, I STARTED DRIVING MY EVO TO A NEARBY GROCERY STORE. ENROUTE, THE AWD SYSTEM WOULD THROW A WARNING AND A DASHBOARD LIGHT LIT UP. I WAS CONCERNED, STOPPED THE VEHICLE AND FOUND NO LEAKS OR NO WEIRD NOISES. THE VEHICLE WAS UNABLE TO SHIFT INTO SNOW/TARMAC/GRAVEL MODE. FORTUNATELY I WAS NOT STRANDED ON THE ROAD SIDE. UPON FURTHER INVESTIGATION I CAME TO KNOW THAT THE ACD PUMP FAILED AND HENCE IT THREW AN AWD ERROR. ITS COSTING ABOUT 2200 DOLLARS TO FIX THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10640971October 2, 2014
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC), EQUIPMENT ADAPTIVE/MOBILITY
WHEN STARTING MY 2008 MITSUBISHI LANCER EVOLUTION GSR, I RECEIVED A WARNING MESSAGE ON THE CLUSTER DISPLAY SHOWING A YELLOW-ORANGE SYMBOL THAT SHOWS 4 WHEELS CONNECTED BY AXLES AND THE MIDDLE-SHAFT, WHERE THE FRONT TWO WHEELS ARE FACING AT AN ANGLE TO THE SIDE. THE ERROR CODE READ AS C161E: DTC C161E: ELECTRIC PUMP RELAY CIRCUIT SYSTEM (STUCK). THIS HAS BECOME A VERY COMMON ISSUE WITH THE 2008 MITSUBISHI LANCER EVOLUTION. SO COMMON THAT WHEN YOU SEARCH FOR THE CODE C161E, YOU CAN FIND COUNTLESS FORUM DISCUSSIONS ON MULTIPLE WEBSITES COMMENTING ON THE FREQUENCY OF THIS ISSUE. INCLUDING MYSELF, A SINGLE DISCUSSION IDENTIFIES AT LEAST 48 UNIQUE CARS, 42 OF WHICH ARE THE 2008 MODEL YEAR, WHERE THE ACD PUMP FAILED, ALL OF WHICH HAVING DRIVEN FEWER THAN 75,000 MILES AND NEARLY 60% WITH LESS THAN 50,000 MILES (HTTP://WWW.EVOXFORUMS.COM/FORUMS/SHOWTHREAD.PHP?T=58221&HIGHLIGHT=C161E&PAGE=1). SEVERAL OF THESE VEHICLES REQUIRED MULTIPLE REPLACEMENTS OF THE SAME PART. THIS PROBLEM AFFECTS THE SAFETY AND EFFECTIVENESS OF THE VEHICLE'S ALL-WHEEL-DRIVE SYSTEM, LIKELY INCLUDING THE VEHICLE'S TRACTION CONTROL AND NEEDS TO BE RECALLED IMMEDIATELY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10607970July 3, 2014
ELECTRONIC STABILITY CONTROL (ESC)
LOSS OF ELECTRONIC STABILITY CONTROL. AYC/ACD PUMP FAILURE DUE TO POOR ENGINEERING. CAR HAS NO STABILITY CONTROL AND DRIVER IS MORE LIKELY TO LOSE CONTROL IN SEVERE WEATHER CONDITIONS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10595963June 4, 2014
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC), EQUIPMENT ADAPTIVE/MOBILITY
ACTIVE YAW CONTROL (AYC) AND ACTIVE CENTER DIFFERENTIAL (ACD) PUMP FAILED. NOT COVERED UNDER POWER TRAIN WARRANTY PUMP WAS CORRODED AND COULD NO LONGER PRODUCE ENOUGH PRESSURE. PUMP IN LOCATED DIRECTLY BEHIND PASSENGER REAR WHEEL EXPOSED TO WATER, SALT, AND OTHER ROAD DEBRIS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10594401May 27, 2014
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC)
WENT TO DEALER FOR TRANSMISSION CHECK AND AFTER A MILE AWC LIGHT CAME ON THEY SAID IT HAD NOTHING TO DO WITH COMPUTER UPDATE THEY DID.MIND YOU MY TRANNY WAS GOING BAD AND DEALER DID NOT WANT NOTHING TO DO WITH IT EVEN UNDER WARRANTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10587851May 12, 2014
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN
ELECTRONIC STABILITY CONTROL / S-AWC (TARMAC/GRAVEL/SNOW) INOPERABLE. TERRAIN SELECTION CAN BE PERFORMED AT 0MPH HOWEVER WHEN THE CAR IS PLACED IN MOTION: FORWARD / REVERSE, THE INSTRUMENT PANEL INDICATES THERE IS SERVICE REQUIRED IN THE AWD TRACTION CONTROL SYSTEM. THIS IS APPARENTLY A COMMON PROBLEM, FROM THE MULTITUDE OF COMPLAINTS FOR THIS SPECIFIC ISSUE POSTED HERE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10586681May 5, 2014
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN
ACD (ACTIVE CENTER DIFFERENTIAL) PUMP HAS FAILED AND WITHOUT THIS PUMP PROVIDING PRESSURE TO THE ALL WHEEL DRIVE SYSTEM, THE VEHICLE GETS STUCK ON DRIVEWAYS AT A STOP WHERE THE TIRE AND WHEEL PACKAGES ARE ON DIFFERENT ELEVATED SURFACES. THE REASON THE PUMP HAS FAILED IS DUE TO PLACEMENT OF THE PUMP ON THE VEHICLE. MITSUBISHI HAS DESIGNED THE VEHICLE TO HAVE THE PUMP TO BE LOCATED DIRECTLY BEHIND THE REAR PASSENGER WHEEL. DUE TO THIS, WHILE DRIVING ON SEVERE WEATHER ROADS (PARTICULARLY SNOW SALTED ROADS), THE DIRT, WATER AND SALT GETS KICKED UP TO THE POSITION OF THE PUMP WHICH CORRODES THE FITTINGS AND THE PUMP ITSELF. THIS THEN CAUSES THE PUMP TO FAIL OVER TIME. IT COULD HAVE BEEN EASILY REMEDIED BY RELOCATING THE PUMP OR ANTI-CORROSION PROTECTION AND BETTER SEALING. BEING LOCATED IN SOUTHERN CALIFORNIA, I WOULD HAVE THOUGHT THAT THIS WOULD HAVE NEVER HAPPENED TO ME, BUT EVEN DRIVING ONLY TWICE THROUGH SNOW ROADS IN THE PAST 3 YEARS HAS CORRODED THE PUMP TO FAILURE. MITSUBISHI HAS DENIED THAT THIS IS PART OF THE POWER TRAIN WARRANTY, WHICH MEANS IT WILL BE A $2000+ DOLLAR FIX. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10578875April 10, 2014
ELECTRONIC STABILITY CONTROL (ESC)
ACD (ACTIVE CENTER DIFFERENTIAL) PUMP FAILURE AT 43000 MILES. WAS REPAIRED UNDER WARRANTY BUT FAILED AGAIN 2 MONTHS AGO (LESS THAN 60000 MILES) JANUARY 2014. SO THE NEW PUMP INSTALLED DID NOT LAST FOR MORE THAN 15000 MILES. THIS IS A COMMON AND KNOWN ISSUE FOR ALL MITSUBISHI MODELS EQUIPPED WITH THAT ACD STABILITY CONTROL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10578365April 8, 2014
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN
AS MANY EVOLUTION OWNERS WHO LIVE IN THE MIDWEST CAN ALSO ATTEST, MY EXAMPLE NOW JOINS THE CLUB OF MODELS WITH DEFECTIVE ASC/AYC PUMP FAILURE. THE PUMP FAILS WHEN OUTSIDE TEMPERATURES RUN CLOSE TO FREEZING, ON TOP OF THE UNIT CORRODING, AND EVOLUTION OWNERS ARE BEING FORCED TO SHELL OUT $1800 MINIMUM TO MITSUBISHI FOR THE PUMP ALONE, NOT INCLUDING LABOR. I BELIEVE THIS HAS ONLY OCCURRED TO MY MITSUBISHI AFTER SIX YEARS BECAUSE I'VE BEEN VERY GOOD ABOUT KEEPING THE UNDERBODY CLEAN, AND IT'S NEARLY ALWAYS PARKED IN A HEATED GARAGE. WITHOUT THE PROPER FUNCTIONING OF THIS INTEGRAL DRIVETRAIN EQUIPMENT, WE AREN'T ABLE TO CONTROL POWER DELIVERY FRONT TO BACK AND THE VEHICLE COMPUTER GOES INTO A TYPE OF LIMP MODE WHERE NO CONTROL OF THE DELIVERY OF POWER TO THE WHEELS IS POSSIBLE. OF COURSE THE BRAKES WORK AND THE THROTTLE WORKS, BUT WHEREAS THE VEHICLE USED TO BE SELECTABLE FOR SNOW OR GRAVEL MODES, GREATLY IMPROVING TRACTION AND THE ABILITY TO LIMIT SLIPPAGE OF THE REAR WHEELS, WE INSTEAD STARE AT A DIGITAL READOUT INSTRUCTING US TO SERVICE THE UNIT THAT'S CORRODED AND THE PUMP HAS OVERHEATED AND ALSO FAILED AS A RESULT. WWW.EVOXFORUMS.COM AND WWW.EVOLUTIONM.NET HAS PLENTY OF OTHER CUSTOMERS WHO ARE BELONG FRUSTRATED WITH THIS ISSUE THAT MITSUBISHI DOESN'T WANT TO ADDRESS. NEARLY ALL OF US HAVE SPENT GOOD MONEY ON A VEHICLE WE THOUGHT WOULD BE A SOLID PERFORMER IN BOTH THE DRY, WET, AND SNOW AND INSTEAD, SOME OWNERS HAVE TO PAY NOT ONCE TO REMEDY THIS UNIT THAT'S FAILING ON ALL OUR CARS, BUT I'VE HEARD OF OWNERS HAVING TO DO IT TWO AND EVEN THREE TIMES. OWNERS ARE TRYING TO SAVE MONEY BY BREAKING DOWN THE UNIT AND REPAIRING THE INTERNAL MOTOR. PEOPLE ARE EXPERIMENTING WITH WAYS TO PREVENT THE UNITS THEY PURCHASE TO PREVENT THEM FROM RUSTING AND CORRODING. PLEASE PLEASE PLEASE CONTACT MITSUBISHI AND HELP US?? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574792March 25, 2014
POWER TRAIN
CAR SYSTEMS ACD PUMP SYSTEM HAS FAILED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10562067January 29, 2014
POWER TRAIN, ENGINE AND ENGINE COOLING
VERY COLD DAY OUT, ABOUT -15 F, WARMED UP MY VEHICLE FOR ABOUT 5 MINUTES PLUS. ONCE I BEGAN DRIVING, ABOUT 10 MPH MY SERVICE REQUIRED LIGHT CAME ON FOR MY AYC PUMP. DEALER SAID THAT IS WAS NOT COVERED UNDER WARRANTY OF ANY KIND. MITSUBISHI HAS KNOWN THAT IS A COMMON ISSUE IN COLD CLIMATES THAT USE SALT ON THE ROADS. THE SALT CORRODES THE PUMP AND MAKES IT FAULTY/MALFUNCTION. THIS IS A SAFETY ITEM THAT NEEDS TO BE RECALLED DUE TO THE KNOWLEDGE THAT AN EVO DRIVER HANDLES THEIR CAR [THAT THEY PURCHASED AS SUCH] AND LOOSES THAT RIGHT WITH A FAULTY AYC PUMP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10558783January 7, 2014
POWER TRAIN
I STARTED MY CAR AND THE AWC SERVICE LIGHT CAME ON. IT WAS ABOUT 0 DEGREES OUT THAT DAY, WHICH IS A VERY UNUSUAL TEMPERATURE FOR S. INDIANA. WHEN I STARTED THE CAR IT SCREECHED FOR JUST A SECOND AND THEN POPPED UP THE CODE. I RESTARTED THE CAR, JUST AS THE MANUAL HAD SAID AND WHEN I RESTARTED IT THE LIGHT WAS STILL ON. I WAS ABLE TO GET THE CODE READ IT THREW A C161E CODE WHICH IS AN ACD/AYC PROBLEM. AFTER DOING A LOT OF RESEARCH I FOUND OUT ITS A COMMON PROBLEM AND ITS AN EXPENSIVE PROBLEM, ABOUT $2,000+. I CALLED THE DEALER AND WAS TOLD MY WARRANTY DOES NOT COVER THIS, IT IS NOT PART OF THE POWER TRAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10557872December 30, 2013
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN
I STARTED MY CAR AND THE AWC SERVICE LIGHT CAME ON. I CAME TO A CONTROLLED STOP, AND RESTARTED THE CAR PER THE INSTRUCTIONS IN THE VEHICLE MANUAL. UPON RESTART, THE SAME SERVICE LIGHT CAME ON. AFTER THE DEALER RAN A DIAGNOSTIC, IT WAS FOUND THAT THE HIGH PRESSURE PUMP FOR THE ACTIVE STABILITY CONTROL SYSTEM HAD FAILED. I WAS TOLD THAT THIS PART WAS NOT PART OF THE DRIVE TRAIN AND WOULD NOT BE COVERED UNDER WARRANTY. THE DAY THE PUMP FAILED IT WAS VERY COLD AND THERE WAS PACKED SNOW ON THE ROADWAYS. IF I WAS DRIVING AT HIGHER SPEEDS AND THIS PUMP HAD FAILED, I BELIEVE THE AUTOMOBILE WOULD NOT HAVE BEHAVED AS EXPECTED WITH THE AWC STABILITY ACTIVE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10557147December 24, 2013
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC)
THIS IS REPORT OF A KNOWN FAILURE BY MITSUBISHI MOTOR CORP. AT 50,800 MILES ON 12/17/2013 MY CARS SUPER-ACTIVE CENTER DIFFERENTIAL (S-ACD) STARTED BLINKING AT ME. IT WOULD NOT ALLOW CHANGING OF THE SETTINGS ANYMORE FOR TARMAC/GRAVEL/SNOW. IMMEDIATELY THERE AFTER, THE DRIVER INFORMATION PANEL POPPED UP WITH A YELLOW "AWD SERVICE REQUIRED" INDICATOR. I BROUGHT MY CAR TO NASHUA, NH MITSUBISHI/HYUNDAI FOR DIAGNOSIS ON 12/19/2013. THERE THEY APPLIED TSB-SC11-002. THIS UNFORTUNATELY DID NOT RESOLVE THE ISSUE. I WAS THEN INFORMED THAT THE CAR REQUIRED A REPLACEMENT ACD PUMP AND WAS QUOTED $1,995 FOR THE REPAIR, WHICH CONFUSED ME DUE TO THE FACT THAT MY CAR WAS STILL UNDER MANUFACTURERS POWER TRAIN WARRANTY, AND A PUMP, THAT CONTROLS THE AWD SYSTEM OF A CAR, SEEMS TO BE POWER TRAIN RELATED, AT LEAST IN MY EYES. THE NORTH EAST REGIONAL REPRESENTATIVE WAS CONTACTED ON MY BEHALF BY THE DEALERSHIP TO REQUEST COVERAGE OF THIS ITEM, WHICH WAS ULTIMATELY DENIED. THIS IS A SEVERE SAFETY ISSUE, AS THE CAR NO LONG HANDLES PROPERLY IN CONDITIONS IT WAS DESIGNED FOR. I AM NO LONGER ABLE TO SELECT THE CAR FOR SNOW, LIVING IN THE NORTH EAST, DRIVING A CAR MARKETED IN THE NORTH EAST, THIS IS A HUGE PROBLEM. TO FURTHER THE ISSUE, THIS PROBLEM IS WELL KNOWN BY MITSUBISHI, IT HAS BEEN DOCUMENTED WELL, TRACING ALL THE WAY BACK TO CARS MANUFACTURED IN 2006. 90% OF ALL PUMP FAILURES COULD BE COMPLETELY ELIMINATED BY ADDING A SEAL TO STOP CORROSION INSIDE THE PUMP WHICH LEADS TO THE UNTIMELY FAILURES. IF NO RECALL IS ISSUED FOR THIS FAILURE, AT THE VERY LEAST, MITSUBISHI MOTORS SHOULD BE FORCED TO COVER THIS UNDER POWER TRAIN WARRANTY FOR 5YRS/60K MILES. INSTEAD OF LIMITING IT TO 3YRS/36K BUMPER TO BUMPER. LINK TO DOCUMENTED CASES - HTTP://FORUMS.EVOLUTIONM.NET/EVO-X-GENERAL/655162-THOSE-YOU-ACD-PUMP-FAILURES-MERGED.HTML. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552515November 15, 2013
POWER TRAIN
(COMPLAINT IS APPLICABLE ONLY TO GSR TRIM EQUIPPED WITH A 5MT TRANSMISSION) - DIFFICULTY SHIFTING FIRST TO SECOND GEAR, AND SECOND TO THIRD. GEARSHIFT IS NOTCHY AND HARD TO ENGAGE. CAUSES LONGER THAN DESIRABLE TIME-GAP IN POWER TO THE WHEELS, RESULTING IN LOSS OF SPEED DURING ACCELERATION PHASE FROM A STOP. - GEARSHIFT IS NOT SMOOTH IN GENERAL. KEYWORDS : NOTCHY, GRINDING. - IT IS A WIDELY REPORTED PROBLEM IN THIS PARTICULAR MODEL AS EVIDENT FROM OWNER SURVEYS ON A PROMINENT INTERNET FORUM (SEE HTTP://FORUMS.EVOLUTIONM.NET/EVO-X-ENGINE-TURBO-DRIVETRAIN/333385-OFFICIAL-EVO-X-NOTCHY-GRINDING-TRANSMISSION-THREAD.HTML). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10543666September 15, 2013
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN
BECAUSE OF THE LOCATION (REAR WHEEL WELL) AND DESIGN OF MITSUBISHI'S ACTIVE CENTER DIFFERENTIAL PUMP, THEY ARE PRONE TO FAILURE. SEVERAL FACTORS AID IN THE GALVANIZED CORROSION OF THE PUMP'S INTERNAL PLATE, SOME OF WHICH INCLUDE TEMPERATURE FLUCTUATION AND WEATHER. VEHICLES THAT ARE IN SERVICE THROUGHOUT THE SNOW BELT STATES IN THE US AND WELL INTO CANADA SEEM TO BE THE MOST AFFECTED. MY VEHICLE WAS JUST OUTSIDE OF THE VEHICLE WARRANTY RANGE FOR TIME BUT VERY WELL INSIDE THE RANGE FOR MILEAGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mitsubishi Lancer Evolution