Mercury Milan Complaints (2010)

1,062 consumer complaints on file.

#11768894October 5, 2026
ELECTRICAL SYSTEM, POWER TRAIN, STEERING
While driving my 2010 Mercury Milan, the steering suddenly went out, making the vehicle extremely difficult to control. I almost hit another car because I could not steer properly. This was a serious safety concern, and I believe the steering issue needs to be investigated immediately.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759497August 25, 2026
AIR BAGS
The contact owned a 2010 Mercury Milan. The contact stated that while driving at an undisclosed speed, the vehicle was involved in a crash. The contact stated that the vehicle flipped over and landed on its roof of the vehicle. The air bags did not deploy. The vehicle was towed to a local tow yard. The contact was later taken to the local medical center. The contact sustained pain and bruises to the chest area, the left and right knees from the impact of the steering wheel, the middle back, and the left side hip. A Police report was filed. The vehicle was deemed a total loss by the insurance company. In addition, the contact stated that an unknown recall for the air bag was completed in 2025. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11738608May 18, 2026
STEERING
While driving at low speed performing a turn in a residential area, the vehicle suddenly displayed a “Steering Assist Fault” warning message and the steering wheel became completely locked with essentially no movement possible. I attempted to turn the wheel with extreme force but it would barely move, creating a serious safety hazard. I was fortunately driving slowly at the time. If this had occurred at higher speed or in traffic, it could have caused a crash, serious injury, or even death. Prior to the incident, there had occasionally been a slight amount of unusual tension/resistance felt while turning the steering wheel, although it was minor and inconsistent before the complete failure occurred. The failure happened suddenly while driving normally. The issue appears related to the electronic power steering (EPAS) / steering assist system. Similar steering assist failure complaints and recalls/investigations have existed on related Ford Fusion/Mercury Milan vehicles involving sudden loss of steering assist and steering control concerns. The vehicle is also currently affected by brake recall 19S54/19V904 involving braking performance concerns, increasing overall safety concerns regarding the vehicle. At the time of filing this complaint, the steering issue has not yet received a complete repair or confirmed diagnosis because the manufacturer and dealer stated the VIN is not currently included under steering recall coverage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717622February 12, 2026
ELECTRICAL SYSTEM, STEERING
I was driving on the freeway and the steering began to stiffen. I got to my destination and decided to check the tires for any ice or snow, thinking that might be why it was difficult to drive but there was no buildup. I made it home and parked the car. The next day, I can't even turn the steering and a warning comes up that says service power steering and advancetrac.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704889December 13, 2025
STEERING
Bought this car less then a year ago with 38k miles and just last week after coming back from vacation my power steering system went while on the expressway. The advancetrac warning light came on and then the service power steering now. The steering wheel was impossible to turn and to make matters worse it was snowing out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689597September 25, 2025
STEERING, ELECTRICAL SYSTEM
The electric power steering has failed again this will make it twice in 18 months the last time it cost 1800 dollars to fix it know that only some of the 2010 Mercury Milans are on a recall list unfortunately mine is not on that list why because it is absurd that I should I have to make this repair for 1800 dollars again you cant safely drive this car it takes everything I have to turn the steering wheel
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689311September 24, 2025
SERVICE BRAKES
The safety recall 19S54 is affecting my vehicle. It was made at the same plant at the approved date range as the other vehicles on the recall list but it seems my vehicle wasnt added to the list because it is a hybrid but it has the same exact issue as the non hybrid models
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11680092August 12, 2025
SERVICE BRAKES, HYDRAULIC
The contact's mother owns a 2010 Mercury Milan Hybrid. The contact stated that while his mother was attempting to stop, the brake pedal was depressed but went to the floorboard, and the vehicle responded slowly. The ABS warning light was illuminated. The contact related the failure to NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic). The vehicle was taken to an independent mechanic who determined that the Hydraulic Electronic Control Unit (HECU) had failed. The local dealer confirmed that the VIN was not under recall for the failure. The vehicle was not diagnosed or repaired. The manufacturer stated that the vehicle was built a month after the recall date and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679284August 8, 2025
STEERING
The contact owns a 2010 Mercury Milan. The contact stated that while driving approximately 30 MPH, the "Service Traction Control" and “Power Steering Sensor” warning lights illuminated. The contact stated that the steering wheel became difficult to turn to the left or the right. The contact was able to drive the vehicle back to the residence. The local dealer was contacted and sent an agent to the residence to drive the vehicle to the dealer. The vehicle was diagnosed, and it was determined that the power steering assist had failed, and the steering gears and rack, and pinion needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 60,562.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678528August 5, 2025
AIR BAGS, FUEL/PROPULSION SYSTEM
I collided with three parked vehicles and my airbags did not deploy causing me to hit my head
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11671729July 7, 2025
SERVICE BRAKES, HYDRAULIC
The contact owns a 2010 Mercury Milan. The contact stated that while depressing the brake pedal to the floorboard, the vehicle failed to immediately stop. The vehicle was taken to the local brake service center, but the cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V904000 (SERVICE BRAKES, HYDRAULIC). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was approximately 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655144April 17, 2025
FUEL/PROPULSION SYSTEM, STEERING, SUSPENSION
Check engine light is on mechanic says it's a fuel tank issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11640467February 3, 2025
STEERING
I experienced a loss of power steering while driving and a dash display "Service Power Steering Now" and "Service Advancetrac". The messages started just before the failure. The lack of power steering was a risk to everyone as the car could only be turned with significant effort and not respond to quick movement. The dash messages are still on after a restart and the car cannot be driven because of safety. My independent mechanic confirmed the issue and fix to be a bad rack. He noted the rack part number is the same as the 2011 Milan, currently under recall for this issue. However, the 2010 is not included.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11639152January 28, 2025
SERVICE BRAKES
Whenever the car engine isn't warm and I slam on the brakes, they barely respond. I have replaced the master cylinder, abs hydraulic module, brake booster, calipers, pads, and rotors, and it still has about 20% normal braking power when the engine is cold. Just got it back from the dealership again. Dealer said no vacuum leak found, no leaks found, abs module checks out fine, and said the check valve passed diagnostics. The problem remains. This has been ongoing for several years now. May have contributed to an accident in 2023. Not sure as my wife was driving. When the engine is warm, the brakes work perfectly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625230November 14, 2024
STEERING
The contact owns a 2010 Mercury Milan. The contact stated while driving at various speeds, the steering wheel was difficult to turn. Additionally, the contact stated while driving 30-35 MPH, the steering wheel seized inadvertently. There were no warning lights illuminated. The contacted depressed the brake pedal and pulled over to the side of the road and parked the vehicle. The contact stated that upon returning to the vehicle, the vehicle was restarted, and the steering wheel was no longer seized, but the steering wheel was difficult to turn. The contact was able to drive the vehicle; however, the failure recurred while driving. The dealer was notified of the failure and informed the contact that the failure was related to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623168November 1, 2024
STEERING
The contact owns a 2010 Mercury Milan. The contact stated while driving at approximately 45 MPH while turning the steering wheel to the right, the steering warning illuminated, and the steering wheel became difficult to turn. The contact stopped and turned off the vehicle and the power steering function returned. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 15V340000 (Steering). The manufacturer was informed of the failure. The failure mileage was approximately 126,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622282October 28, 2024
SERVICE BRAKES, HYDRAULIC
The contact owns a 2010 Mercury Milan. The contact stated that while operating the vehicle, the "Check Brake System" and "Service Advance Track" messages remained displayed. The cause of the failure was not yet determined. The contact indicated that the failure had occurred days after the vehicle was repaired under NHTSA Campaign Number: 19V904000 (SERVICE BRAKES, HYDRAULIC). The manufacturer and local dealer were notified of the failure. The failure mileage was 240,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617343September 30, 2024
STEERING
started vehicle, "power steering assist fault" message appeared on dash message center, unable to turn steering wheel. Turn car off, waited, turn back on, message appeared again. tried an additional 3 times, same results. Had to leave the car where i was visiting.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614194September 12, 2024
STEERING
My power steering light came on and then immediately the wheel got tight. I was unable to turn the wheel and then eventually the car is un drivable. There is a lot of complaints about this happening to thousands of cars and it is still under investigation. Imagin someone jumps out in front of you and you are stopping and unable to maneuver your car out of the way. By the grace of God I was able to do so. Please advise me when this recall is open.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11610808August 26, 2024
STEERING
The contact owns a 2010 Mercury Milan. The contact stated that the power steering assist became inoperable. The driver was unable to turn the steering wheel. The contact stated that the steering wheel had seized. The vehicle was restarted, and the steering wheel operated as designed. The power steering assist fault and service power steering soon messages were displayed. The contact stated that the failure was related to NHTSA Campaign Number: 15V340000 (Steering). The local dealer was contacted, and the contact was referred to the Ford Warranty Department for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 38,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mercury Milan