Hyundai Veloster Complaints (2015)

137 consumer complaints on file.

#11767280September 27, 2026
ELECTRICAL SYSTEM
Climate control module burnt out (highly common problem). Replaced it along with new connection and it melted the control switch and fried the connector again. Hyundai has acknowledged this very common issue but still hasn't done a recall for the cheap wiring in the vehicle. Ive had smoke come out of my dash the 1st time. They dont sell the control know individually so you have to buy the whole console and they dont sell new connector so you have to buy the entire wiring harness and either take the dash off yourself to replace or take it in to be fixed and pay the hefty price for it. Please make them fix this because im very surprised someone's car hasn't caught fire yet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748212July 3, 2026
STRUCTURE:BODY, ENGINE, SEAT BELTS
2015 Hyundai Veloster Turbo (original owner). The vehicle has three severe safety defects: TRUNK/HATCH LATCH FAILURE: The hatchback lift support/latch fails, refusing to stay open. It unexpectedly fell, which has caused repeated, severe impacts to my head and neck, resulting in an injury requiring surgery. I must manually prop it open with a mini ball to load cargo. ENGINE & TURBO FAILURE / OIL CONSUMPTION: History of engine acceleration issues and turbo failures since 4,000 miles. At 44,000 miles, the turbo completely failed, the car started to whine, then rattle, and completely turned off. Dealer (Hyundai Escondido) forced a $2,200 out-of-pocket replacement despite being under warranty, citing a lack of at-home oil change receipts. The vehicle now has a documented, rapid oil leak and excessive consumption issue that the dealer refuses to repair, despite being reported prior to warranty expiration. SEAT BELTS: The front and rear seat belt latches are malfunctioning, intermittently releasing on their own, failing to release properly, or failing to latch securely, compromising the safety of a [XXX] passenger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746142June 24, 2026
POWER TRAIN
The contact owns a 2015 Hyundai Veloster. The contact stated that upon starting the vehicle and shifting into gear, the vehicle failed to respond and became inoperable. There was no warning light illuminated. The vehicle was taken to the dealer, and the rear axle was replaced, the transmission fluid was flushed and refilled, and a shift analyzer software update was performed; however, the failure recurred days later. The vehicle was taken back to the dealer, where it was determined that the wheel speed sensor had failed. Upon investigating the failure online, the contact advised the dealer to inspect the crankshaft position sensor; however, the dealer informed the contact that the failure was related to the transmission. The contact was informed that the failure could not be duplicated. The vehicle was not diagnosed or repaired, and the contact was advised to retrieve the vehicle. The manufacturer was notified of the failure and covered the cost of the rear axle replacement under a goodwill assistance program. Several cases were filed, and the contact sent a video of the failure to the manufacturer. The failure mileage was approximately 62,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743354June 10, 2026
ELECTRICAL SYSTEM
The climate control fan knob suddenly stopped working. I smelled a burning smell on the interior of the car. I pulled the panel off and noticed that the plug to the climate control harness was burnt. I can no longer utilize the climate control system.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734516April 29, 2026
ENGINE
I am reporting a safety-related engine defect involving sudden internal engine failure, excessive oil consumption, persistent bearing knock, and overheating of the catalytic converter. The vehicle repeatedly triggered Bank 1&2O2 sensor fault codes due to oil blow-by and thermal overload. A certified mechanic documented the engine is failing internally and that the cat. converter has been damaged as a direct result of engine defect. The failure pattern is consistent with known Hyundai engine defect investigations involving bearing wear, oil consumption, stalling, and fire risk. The overheating cat. converter presents a significant safety hazard, including potential engine seizure. I purchased the vehicle used in March 2025. I am the third owner. Despite maintaining the vehicle responsibly (Regular oil changes), the engine failure progressed rapidly. Hyundai Motor America has denied a goodwill repair solely on the basis of mileage, even though the defect clearly originated long before my ownership and aligns with previously identified safety-related engine issues. Additionally, Hyundai's records show that this vehicle had an engine-related recall active during prior ownership period; the recall was never performed by the Hyundai dealership that sold the vehicle to the previous owner. This raises concerns about improper recall handling and whether the defect should have been corrected before the vehicle was resold. Given the safety implications, the documented defect pattern, and the unresolved recall history, I am requesting NHTSA's review of this matter. The engine failure poses a serious safety risk; Hyundai's refusal to address a known defect, the vehicle is unsafe to operate. Timeline: 2014 Hatchett Hyundai West, KS 17,665 mi.; 2017-H. West serviced vehicle, 58,918; 2019-Engine powertrain alert 83856mi; 2020- Edmund Hyundai, OK-engine power train 100179 mi; 2021- Edmund 145418mi.; Hy. Noblesville, IN 167,603mi.; 2024 - H.N. 171937; 2025 - denied repair 188890.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712779January 22, 2026
ENGINE
I took my car to Gilroy Hyundai November 11, 2025 at 10:30 a.m. because my engine was not running normal, it shook lightly while driving at an incline and the engine light would not shut off. they charged me $284.99 to tell me what needed to be fixed, engine was not looked per Ernesto Garcia. Ernest told me they go by mileage, not actually checking the engine. He also stated that the mechanic drove it and it was fine. December 28, I was driving from Chico, CA back home to Morgan Hill, CA and the car shook and just died and left me on the side of Highway 505 Winters/San Francisco. I had it towed to Moorehead Automotive in Fairfield, CA and they said this car needs a new engine. I still owe 7,000.00 on this car and have had trouble with both Hyundai and Power (the additional insurance I purchased when i bought this car.)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699391November 14, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2015 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, the vehicle hesitated. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic who performed a tune-up on the vehicle. The contact stated that several days after the tune-up, the failure reoccurred. The contact stated that while the vehicle was stopped at a traffic light, the vehicle hesitated and sounded as if the vehicle was going to stall. The vehicle was taken back to the independent mechanic, who diagnosed that the engine was losing pressure and needed to be replaced. The vehicle was not repaired due to the cost. The contact stated that before the vehicle had the tune-up, the engine was consuming an excessive amount of engine oil. The contact had not noticed any oil stains on the ground. The check engine light was occasionally illuminated. The manufacturer was not made aware of the failure. The failure mileage was approximately 72,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695740October 27, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2015 Hyundai Veloster. The contact reported that oil was leaking out of the exhaust. The vehicle was sputtering and running rough while driving at various speeds, and hesitated while accelerating. The check engine warning light was illuminated. The vehicle was taken to the dealer, who was unable to diagnose the failure. The dealer informed the contact that metal shavings were found in the oil pan during the oil change. The contact stated that the Oxygen sensors and catalytic converter were replaced; however, the failure persisted. The vehicle was contacted and advised the contact to return the vehicle to the dealer. The manufacturer was not informed of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695652October 26, 2025
ENGINE
Excessive engine oil consumption causing fouled spark plugs engine stalling. Engine was replace due to defective rod bearings at 98 000 mile under warranty and recall. Engine now ha 130,000 miles piston rings have failed. Stalled on busy freeway almost causing mutual crash.I have an appointment at the Hyundai delership October 28th 2015. Hyundai replaced one defective engine with another.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678279August 4, 2025
ENGINE, POWER TRAIN
The contact owns a 2015 Hyundai Veloster. The contact stated that the vehicle was taken to a local dealer for a recall repair; however, after leaving the dealer, while driving approximately 30-40 MPH, the vehicle stalled. The vehicle failed to shift into gear. The vehicle sat for two hours before being restarted and slowly driven to the place of employment, and was then driven to the residence. The contact was unable to determine if there were any warning lights illuminated. The contact called the dealer and was provided with information for towing services and a diagnostic test. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 176,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669788June 27, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM, ENGINE
ABS, EPS, check engine light appeared on dashboard then car’s steering wheel stiffed and car lost power. Vehicle’s hood smells burnt and has fumes come out after driving for 10-20minutes. My safety and my family’s was endangered as this happened while driving on the road. Not at a stop sign or a red traffic light but while driving. The dealer has refused to inspect/address the issue without having me paid close to $2,500.00 for other repairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667039June 15, 2025
ELECTRICAL SYSTEM
The climate control switch melted. Available for inspection I was getting smoked out by plastic fumes. Researched this issues with all data No No lights.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653606April 9, 2025
ENGINE
Motor started knocking yesterday 4/8/25 which was immediately followed by multiple dash sensors for oil and battery. As I pulled over to get assistance at a Jiffy Lube, the car stalled and wasn’t drivable but they also confirmed that the car should not be driven for risk of blowing the engine. Will be taking my vehicle in for an evaluation as soon as I am able to get it towed for further inspection and diagnostics.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643619February 19, 2025
ENGINE
Spun rod bearings. Noticed that was the issue with play in piston doing a screwdriver test and noticing thru under the oil pan before tear down. Had to pry the bearing off with pliers and hit with a screwdriver to remove. I have plenty of photos and videos
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11639657January 30, 2025
ENGINE, POWER TRAIN
I HAVE A RECALL ON THE HYUNDAI 2015 VELOSTER FOR FOUR YEARS SINCE THE LAWSUIT THAT YOU TOLD HYUNDAI CORP TO PUT LIFETIME WARRANTY ON DEFECTIVE CARS THGEY HAVE DONE NOTHING TO RESOLVE THE PROBLEM. MY CAR AGAIN IS BROKE DOWN TO OIL AROUND SPARKPLUGS I WENT THROUGH THE SAME PROBLEM IN OCT 2023 WHICH THEY PUT A GASKET ON IT AND CHARGE ME 505.00 DOLLARS. NOW THEY ARE MAKING IT HARD TO FIND A ENGINE TO REPLACED THE MANUFACTURED DEFECT ENGINE IN IT. DEBRIS IN CRANKSHAFT AND THEN SOLD WHICH CAUSE THE CONNECTING ROD PROBLEM PREMATURE. I NEED MY CAR AND CAN'T AFFORD ANOTHER PLEASE HELP ME GET THIS RESOLVE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634696January 7, 2025
ENGINE
Spontaneous rod knocking, hindered performance which in tern poor acceleration, which could become a safety risk especially when commuting on a freeway. High risk of motor vehicle accidents or could lead to a fatal incident if left stranded on major roadways and railroad crossings.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631975December 21, 2024
ENGINE, UNKNOWN OR OTHER
my car 2015 Hyundia Veloster has been under recall since 2021 for connecting rod failure in engine and oil leaking around spark plugs that could cause a fire plus what the other recall is. Hyundai Corp refuses to repair my car, it has ksds, oil consumption, refuse to do engine inspection, wanting to charge me for items related to a recall. my car as stated with you before eating oil, poor compression stalls knock loses power i recently had to pay 3200.00 for catalytic converters so i would have a car only to find out it could happen again due to recall number198. i need someone to help me get this resolve. why should have to replace my engine when it under recall and you can't sell your car due to that? i have been fighting Hyundai Corp for two years i had oil around my spark plugs in 2023, black spark plugs 2024
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618978October 9, 2024
ENGINE
The contact owns a 2015 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound and smoke coming from the engine compartment. The vehicle then lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle was able to be restarted. An unknown warning light was flashing before the vehicle had lost power; however, there were no warning lights illuminated once the vehicle was restarted. The vehicle was taken to the dealer, who was unable to duplicate the failure and had not provided the contact with a specific diagnostic report. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V746000 (Engine), but the VIN was not included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 44,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618231October 5, 2024
ENGINE
I HAVE BEEN TRYING FOR OVER A YEAR TO GET MY ENGINE REPLACED IT IS RECALL AND NO DEALER SHIP IN MACON GA OR MILLEDEGVILLE GA HAS DONE NOTHING BUT CHARGE ME UN NECESSARY MONEY. THE FIRST THING OIL CONSUMPTION, STALLS WHEN GOING OUT IN THE ROAD, LOST OF COMPRESSION, CLOGG MY CATALYTIC CONVERTERS WHICH COST ME 3200.00 WHICH I WAS TOLD IS GOING TO HAPPEN AGAIN WITH THE FAIL ENGINE. THE OTHER VISITS WERE AT DEALSHIP TOO OIL IN SPARK PLUGS STALLING OUT LUCKY TO GET IT HOME THAT TIME OCT 2023 AT MILLEDEGVILLE HYUNDAI THE OTHER TIME THERE ENGINE LIGHT CAME ON GASKET REPLACED AGAIN BLACK SPARK PLUGS 505.00 AND 405.00 ADDITIONAL MONEY CAN YOU PLEASE HELP ME . MY CAR IS STILL STALLING, NO COMPRESSION,OIL CONSUMPTION NUMBER 198
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11612425September 3, 2024
ELECTRICAL SYSTEM
AC Fan control switch has melted and filled car with smoke. Fan control switch has overheated. The switch has melted and will not work at all.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Veloster