Hyundai · Model Report
Showing safety data for the 2003 model year only.
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 Âsalt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
HYUNDAI IS RECALLING 83,355 MY 2001-2003 SANTA FE VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE REAR TRAILING ARMS, WHICH COULD LEAD TO THINNING OR PERFORATION OF THE REAR TRAILING ARM STEEL. OWNERS MAY SEE OR FEEL SLIGHT TO MODERATE CHANGES IN VEHICLE OPERATION WHICH WILL INCREASE IF THE VEHICLE IS NOT REPAIRED. THESE CHANGES INCLUDE A LOWERING OF VEHICLE HEIGHT THAT CAN LEAD TO TIRE MISALIGNMENT AND STEERING PULL. OWNERS MAY ALSO NOTICE A CREAKING SOUND.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5 LITER V-6 ENGINES, 4-WHEEL DRIVE AND ANTILOCK BRAKING SYSTEMS (ABS), IF THE BRAKE PEDAL IS DEPRESSED AT SPEEDS BETWEEN 3 AND 12 MPH WHEN THE BRAKE PAD FRICTION SURFACES ARE WET, A VIBRATION MAY OCCUR BETWEEN THE BRAKE DISCS AND PADS CAUSING ABS SENSOR ELECTRONIC SIGNAL NOISE TO DEVELOP. AT SPEEDS BELOW 5 MPH, THE ABS SENSOR SIGNAL NOISE MAY CAUSE THE ABS ELECTRONIC CONTROL UNIT (ECU) TO ACTIVATE THE ABS, EXTENDING THE STOPPING DISTANCE.
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
The contact owns a 2003 Hyundai Santa Fe. The contact stated while driving 30 MPH, the ABS system activated, and there was an abnormal shuddering in the brake pedal. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the ABS needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
No injuries · No fire · No crash
The driver's side rear trailing arm lower broke again. Was driving all of a sudden felt it start fishtailing and pulled over and thank God I didn't crash
No injuries · No fire · No crash
Bought a set of duralast gold wrists a801116 asks since the day i put them in i had to replace parts whole charging a problem that turned out to be from the wires. Cause it was causing arcing in every one of the cylinders.
No injuries · No fire · No crash
The contact owns a 2003 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the passenger’s side front wheel detached without warning. The wheel bearing and hub were replaced by the owner. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The manufacturer was not contacted nor informed of the failure. The approximate failure mileage was 190,000.
No injuries · No fire · No crash
BROUGHT MY VEHICLE IN FOR A ALIGNMENT AND THEY DISCOVERED THE RUSTED AND CORRADIATED REAR LEFT TRAILING CONTROL ARM ON MY 2003 HYUNDAI SANTA FE, I BROUGHT TO DEALERSHIP AFTER THAT TO GET A RECALL AND THE TOLD ME THAT SINCE THE VEHICLE WAS BOUGHT IN ND AND THAT STATE IS NOT INCLUDED IN THE RECALL THEY WILL DECLINE THE WORK, EVEN THOU MINN. IS RIGHT NEXT DOOR LIKE I LIVE ABOUT 1 MILE TO MN THEY STILL WOULDN'T EXCEPT THE RECALL, IT IS OBVIOUS THE PART THAT IS ON RECALL FITS MY CAR, WHEN LOOKING ON THE RIGHT SIDE ARM THERE IS NO RUST OR CORROSION. THE DEALER STATES IT IS NOT SAFE TO DRIVE VEHICLE, BECAUSE THE ARM IS STARTING TO BEND ALSO. SO WHAT DO I DO NOW, IT WILL BE VERY COSTLY TO FIX,
No injuries · No fire · No crash