Ford Ranger Complaints (1994)

438 consumer complaints on file.

#11242310August 7, 2019
STRUCTURE:BODY, SUSPENSION, UNKNOWN OR OTHER
THE FRAME AND SUSPENSION IS ROTTING HERE IS A RUST HOLE IN MY FRAME WHERE THE COIL SPRING GOES. THE TRUCK BODY HAS NO OTHER SIGNS OF RUST AND HAS NEVER BEEN ABUSED OR NEGLECTED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11093997May 15, 2018
TIRES, TIRES:TREAD/BELT
DROVE MY TRUCK ONE DAY ALL WAS FINE. DROVE IT THE NEXT DAY AND FELT A STRANGE VIBRATION. WHILE DRIVING I NOTICED THE TRUCK WANTED TO KEEP PULLING HARD TO THE RIGHT. INSPECTION OF TIRES REVEALED THE LEFT FRONT TIRE WAS WAS NOT TOUCHING THE COMPLETELY IN CONTACT WITH THE ROAD. TREAD IS GOOD. LOOKS LIKE BELT FAILURE. SCARRY. HAVE PICTURES. IT IS A CORNELL 1000. P215-70R14.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11033730October 25, 2017
STRUCTURE
1994 FORD RANGER. CONSUMER WRITES IN REGARDS TO RUSTED FRAME ON VEHICLE. *LD THE CONSUMER STATED THE FRAME RUSTED AND BROKE RELEASING THE GAS TANK FROM THE VEHICLE, WHILE DRIVING. THE CONSUMER REQUESTED TO BE REIMBURSED OR REPLACE THE FRAME. UPDATED 10/25/2017*JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10885083July 15, 2016
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1994 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 20 MPH, THERE WAS A STRONG FUEL ODOR COMING FROM THE VEHICLE. THE CONTACT OBSERVED FROM THE FRONT DRIVER MIRROR SIDE A TRAIL. IN ADDITION, THERE WAS FUEL LEAKING FROM THE VEHICLE. AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE, WHERE IT WAS DETERMINED THAT THERE WAS A CRACK IN THE FUEL LINE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 94V111001 (FUEL SYSTEM/GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10873566June 10, 2016
STRUCTURE:BODY
FRAME IS RUSTED COMPLETELY PARTS FALLING OFF AND MOTOR MOUNTS HAVE RUSTED APART. REAR BUMBER ALMOST RUSTED AWAY AND FALLING OFF.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10823331January 31, 2016
STRUCTURE:BODY
PASSENGER SIDE FRAME RUSTED JUST BEHIND THE FRONT WHEEL. THIS IS A POTENTIAL SAFETY ISSUE AND WILL CAUSE THE TRUCK TO FAIL THE STATE SAFETY INSPECTION RENDERING THE TRUCK USELESS. UNLESS IT BRAKES BEFORE THAT TIME. DRIVERS SIDE IN BETTER CONDITION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10749197August 17, 2015
SUSPENSION, STEERING, SERVICE BRAKES
NOTICED A CLUNKING NOISE IF THE RIGHT FRONT OF THE VEHICLE DURING TURNING, STOPPING AND GOING OVER SMALL BUMPS. FIGURED IT WOULD BE SOMETHING SIMPLE AND TOOK IT TO MY MECHANIC. HE SAID IT WAS A RUSTED FRAME MOUNT AND TO TAKE IT TO A BODY SHOP. SO I DID AND THE SECOND OPINION WAS THAT THE FRAME WAS RUSTED COMPLETELY IN TWO JUST IF FRONT OF THE RIGHT SHOCK MOUNT. I CLIMBED UNDER THE VEHICLE AND IT TRULY IS RUSTED COMPLETELY INTO TWO PIECES. I DON'T KNOW WHAT IS KEEP THE FRONT RIGHT WHEEL WHERE IT BELONGS. UNSAFE TO DRIVE. PARKED FOR NOW. WHERE DO I TURN NOW? NO PUN INTENDED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10676261January 17, 2015
STRUCTURE, SUSPENSION
REAR LEFT SPRING SHACKLE AND MOUNT RUSTED OFF. BIG RUST HOLE IN THE FRAME BESIDE FUEL TANK ON LEFT SIDE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10651280October 30, 2014
FUEL/PROPULSION SYSTEM
SINCE APPROXIMATELY 2000 I HAVE BEEN UNABLE TO FILL THE TRUCK WITH GAS. I CAN NOT FILL THE TANK, IF I DO THE FUEL WILL JUST SPILL ON THE GROUND. HOSE FROM FUEL FILL TO TANK MUST BE CRACKED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10637724September 20, 2014
TIRES, TIRES:TREAD/BELT
FUZION TOURING TIRES P195/70R14 91T TREAD SEPARATING AT <14KMILES. I BOUGHT THIS SET OF TIRES AND RIMS USED FROM A FRIEND WHO HAD BOUGHT THE SET OF TIRES FROM ON ONLINE TIRE RETAILER, IN EARLY 2013 (TIRE DOT CODE JEFJ CAN 4412 MADE IN CHINA). THE RIMS AND TIRES WERE INSTALLED ON A 1996 FORD RANGER 2WD INITIALLY AND THEN ON MY 1994 FORD RANGER XLT 2WD. FRONT TWO TIRES BEGAN TO FEEL WOBBLY AND VIBRATE EXCESSIVELY. UPON INSPECTION, THE TIRES WERE DISFIGURED AND OUT OF ROUND. UPON CLOSER INSPECTION BOTH FRONT TIRES APPEARED AS IF THE INNER BELTS HAD PEAKED IN THE CENTER OF THE TIRE ON THE TREAD SURFACE (LIKE THE TREAD SURFACE HAD BEEN FOLDED AROUND THE PERIMETER OF THE TIRE), BUT NOT ALL THE WAY AROUND THE TIRES. THIS WAS THE OBVIOUS CAUSE OF THE VIBRATION. TIRES REPLACED AND EVERYTHING WAS FINE. THE REPLACEMENT TIRES WERE PUT ON THE REAR AND THE TWO REMAINING FUZION TIRES WERE MOVED TO THE FRONT. A COUPLE OF MONTHS LATER, ONE OF THE FUZION TIRES NOW ON THE FRONT REPEATED THE SAME PROBLEM I HAD WITH THE OTHER TWO. OBVIOUSLY THERE IS A DEFECT IN THE TIRES FOR 3 OF 4 TO GO BAD IN EXACTLY THE SAME WAY WITH IN SUCH A CLOSE TIME RANGE. THE 4TH TIRE APPEARS TO BE OK, HOWEVER DUE TO THE PROBLEM WITH THE OTHER THREE, I AM REPLACING IT TOO. IF YOU HAVE THESE TIRES AND EXPERIENCE VIBRATION, IMMEDIATELY INVESTIGATE THE SHAPE OF THE TIRE TREAD SURFACE FOR DISFIGUREMENT - IF YOU FIND ANY, IMMEDIATELY REPLACE THE TIRE. I CAN PROVIDE PHOTOS AS NEEDED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10575893March 31, 2014
POWER TRAIN, ENGINE AND ENGINE COOLING, SUSPENSION, STEERING
JM AUTO SALES AT 12248 N. 600 E. DEMOTTE, IN 46310, SOLD ME AN UNSAFE VEHICLE, HE ASSURED ME THAT HE SERVICES ALL HIS VEHICLES BEFORE HE SELLS THEM BECAUSE HE WANTS HIS CUSTOMERS HAPPY, WHEN I TOOK THE TRUCK TO MY MECHANIC HE TOLD ME THAT IT NEEDS A NEW TRANSMISSION, CENTER LINKS, WHEEL ALIGNMENT, AND EXHAUST FLANGE MANIFOLD, ITS UNFAIR FOR THIS BUSINESS TO SELL A VEHICLE THAT IS UNSAFE FOR THE ROAD, THIS SHOULD FALL UNDER THE UNSAFE AND DECEPTIVE ACTS AND PRACTICES ACT. IF HE SERVICES THE VEHICLE HE WOULD KNOW WHAT'S WRONG WITH THEM AND NOT PUT THEM FOR SALE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10556331December 17, 2013
FUEL SYSTEM, GASOLINE
I LEFT MY TRUCK FOR INSPECTION ON 12/9/13. IT WOULD NOT INSPECT BECAUSE OF A SMALL LEAK IN ONE OF THE FLEXIBLE FUEL LINE CABLES THAT LEAD FROM THE MAIN FUEL LINE TO THE ENGINE. THIS PART WAS SUPPOSEDLY ON RECALL AT SOME PAST DATE. THE NHTSA RECALL IS #94V111001. I NEVER RECEIVED ANY CORRESPONDENCE ON THIS RECALL. UNFORTUNATELY, FORD INFORMS ME THAT THE PART IS DISCONTINUED, AND MY MECHANIC IS UNABLE TO FIND A REPLACEMENT PART ANYWHERE. I AM CURRENTLY TRYING TO FIND A MACHINE SHOP THAT CAN MAKE THE PART. MY QUESTION IS "DO I HAVE ANY OPTIONS THAT I COULD PURSUE AGAINST FORD". *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10535816August 16, 2013
SUSPENSION, STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
PURCHASED A VERY NICE 1994 FORD RANGER XLT WITH APPROX. 63,709 ORIGINAL MILES THE FRAME PERCHES AND LEAF SPRING PURCHASES ARE LIKE SWISS CHEESE THE SCALE ON THE FRAME IS TERRIBLE THE MECHANIC COULD NOT SAFELY PUT THIS TRUCK ON A LIFT LOOKS LIKE TRUCK UNDERNEATH WAS DIPPED IN RUST ANY INFORMATION OR REPLY WOULD BE APPRECIATED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10474551September 10, 2012
SUSPENSION
PREMATURE SEVERE RUST ON UNDER BODY OF FRAME AND JUST ABOUT EVERY COMPONENT CONNECTED TO THE FRAME ITSELF, INCLUDING BODY MOUNTS, LEAF SPRING BRACKETS, STEERING COMPONENTS. WITHOUT PROPER KNOWLEDGE OF THIS ACTIVE AND AGGRESSIVE RUST CAN LEAD TO LOSS OF STEERING, CONTROL, AND SHIFTING LOADS AS REAR LEAF SPRING BRACKET HAS ALREADY FAILED AFTER HITTING A POTHOLE. BODY MOUNTS HAVE RUSTED LEAVING THE CAB WITH POTENTIAL TO FALL OFF, OR SHIFT DURING A SIMPLE DRIVING MANEUVER . FRAME HAS PANCAKES OF RUST FLAKING OFF AT THIS TIME IN IT'S AGE (NOW 18 YEARS). THIS IS A WELL KNOWN ISSUE TO INTERNET FORD TRUCK CLUB MEMBERS WITH SEVERE RUST THAT DIRECTLY AFFECTS THE SAFETY AND INTEGRITY OF THE FRAME AND IT'S COMPONENTS ATTACHED TO IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461993June 17, 2012
ELECTRICAL SYSTEM
COMPLAINT: HIGH RISK OF ACCIDENT DUE TO ENGINE SHUT DOWN. SUBJECT: IGNITION MODULE SAFETY COMPLAINT. 6 OUT OF 7 BAD COMMENTS: PROBLEM: 1994 FORD RANGER PICKUP DIES FREQUENTLY AND SPORADICALLY AFTER IGNITION MODULE REPLACEMENT BY AUTO MECHANIC. FIRST 2 OEM MODULES FROM ADVANCE AUTO TEST BAD AT PARTS DEALER. THIRD MODULE IS FORD MOTOR CRAFT AND IS ASSUMED GOOD. SEVERAL NEW PARTS INSTALLED INCLUDING CRANK SENSOR, FUEL FILTER, FUEL RELAY, TIMING BELT, EEC (COMPUTER), WATER PUMP, EEC RELAY. SPORADIC DYING CONTINUES. FORD MODULE TESTED AT AUTO ZONE AND FAILS, BUT NEW AUTO ZONE DURALAST MODULE IS TESTED FOR COMPARISON AND PASSES. MECHANIC RETURNS MODULE AND ORDERS NEW ONE FROM ADVANCE AUTO. IT FAILS TEST IN STORE. MECHANIC ORDERS ANOTHER THAT PASSES AT ADVANCE BUT FAILS AT AUTO ZONE ON DURALAST TEST. I INSTALL MODULE AND IT FAILS A QUARTER MILE FROM HOUSE. MECHANIC GETS ANOTHER MOTOR CRAFT MODULE FROM FORD THAT PASSES AT ADVANCE AND FAILS AT AUTO ZONE. I DON'T INSTALL IT. THAT MAKES 4 OEM MODULES THAT FAILED AND 2 MOTOR CRAFT. FINALLY, I INSTALL AUTO ZONE MODULE THAT PASSED TEST AT AUTO ZONE. NO FAILURE FOR 4 DAYS AND COUNTING. LOCAL FORD DEALER TRIED TWICE TO FIND THE PROBLEM AFTER THE FIRST MOTOR CRAFT MODULE WAS INSTALLED AND DID NOT LOCATE THE PROBLEM. THEY DID NOT HAVE AN OUT OF VEHICLE ANALYZER. MY CONCLUSION: THERE IS A STRONG POSSIBILITY THAT OTHER PEOPLE WILL ENCOUNTER THE SAME PROBLEM. MY VEHICLE DIED ON THE ORDER OF SEVERAL DOZEN TIMES OVER A SIX MONTH PERIOD (ALMOST DAILY). LUCKILY I LIVE IN A RURAL AREA AND AM QUICK AT HITTING THE EMERGENCY BLINKER. AFTER AWHILE,I BOUGHT A USED CAR AND ONLY DROVE THE TRUCK TO TEST IT. SAFETY HAZARD: UNEXPECTED DYING ON BUSY HIGHWAY OR AT INTERSECTION COULD RESULT IN SERIOUS INJURY OR DEATH. PLEASE LET ME KNOW THAT YOUR DOING SOMETHING. FORD WON'T. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10451521March 13, 2012
SERVICE BRAKES, HYDRAULIC
I APPLIED MY BRAKE PEDAL AND IT WAS FINE ONE SECOND AND THEN LOST PRESSURE AND WENT TO THE FLOOR WITH A POPPING FEELING ON THE RIGHT FRONT WHEEL AND THEN I TURN MY WHEEL INTO THE OTHER LANE TO AVOID HITTING THE CAR IN FRONT OF ME AND A CAR CAME FROM NO WHERE IN THE OTHER DIRECTION AND HIT MY 1994 RANGER ON THE RIGHT REAR WHEEL AND BEDSIDE . *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10433797November 1, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1994 FORD RANGER. THE CONTACT STATED THAT FUEL FUMES ENTERED THE VEHICLE. AFTER INSPECTING THE VEHICLE, HE NOTICED THAT FUEL WAS LEAKING FROM THE HARD FUEL LINE TO THE RADIATOR FAN, WHICH WAS BLOWING THE FUEL BACK UNDER THE ENGINE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 85,000. UPDATED 7/28/15*CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10422534August 30, 2011
STRUCTURE:FRAME AND MEMBERS
1994 FORD RANGER WITH FRAME ROT HIDDEN BY FRONT RIGHT COIL SPRING MOUNT , UNSAFE ! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10421560August 26, 2011
PARKING BRAKE
TL* THE CONTACT OWNS A 1994 FORD RANGER. THE CONTACT STATED HAT WHILE THE VEHICLE WAS PARKED ON A LEVEL ROAD SURFACE WITH THE EMERGENCY BRAKE ENGAGED, THE VEHICLE UNEXPECTEDLY ROLLED FOR A FEW SECONDS. THERE WAS A RECALL ASSOCIATED WITH THE NHTSA CAMPAIGN ID NUMBER 94V169001 (PARKING BRAKE: CONVENTIONAL); HOWEVER THE RECALL EXPIRED AND THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAULTY EMERGENCY BRAKE. THE CONTACT PLANNED TO REPAIR THE VEHICLE HIMSELF. THE APPROXIMATE FAILURE MILEAGE WAS 270,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10395726April 13, 2011
ELECTRICAL SYSTEM
OUR 1994 FORD RANGER STARTED ON FIRE WHILE SITTING IN ARE DRIVEWAY, FOR AND HOUR. IT BURNT ALL ELECTRICAL HARNESS. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0

← Back to Ford Ranger