BMW 740Li Recalls (2021)

5 recalls on file.

• Recall25V644000September 25, 2025
  ELECTRICAL SYSTEM:STARTER ASSEMBLY

  BMW of North America, LLC (BMW) is recalling certain 2020 340I, X6, 2020-2025 840I, 2020-2022 740LI, 2019-2020 X7, and X5 vehicles. After repeated attempts, the starter motor may overheat from an electrical overload.

  Remedy

  Dealers will replace the engine starter, free of charge. This recall includes vehicles repaired under recall 24V576 and those owners will need to have their vehicle repaired again. Owner notification letters were mailed February 9, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 17, 2025.

• Recall21V062000February 10, 2021
  SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC

  BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.

  Remedy

  BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.

• Recall21V046000February 3, 2021
  POWER TRAIN:DRIVELINE:DRIVESHAFT

  BMW of North America, LLC (BMW) is recalling certain 2020-2021 530i xDrive, 540i xDrive and 2021 740Li xDrive vehicles. The output shafts (left/right) which transfer power from the driveshaft to the rear wheels may break due to a heat treatment error during supplier production.

  Remedy

  BMW will notify owners, and dealers will replace the output shaft(s), free of charge. The recall began March 24, 2021. Owners may contact BMW customer service at 1-800-525-7417.

• Recall20V761000December 9, 2020
  ELECTRICAL SYSTEM:12V/24V/48V BATTERY

  BMW of North America, LLC (BMW) is recalling certain 2021 M340i xDrive, M440i xDrive Coupe, 530i, 530i xDrive, 540i, 540i xDrive, 740Li, 740Li xDrive, 840i Gran Coupe, 840i xDrive Gran Coupe, X5 sDrive40i, X5 xDrive40i, X6 sDrive40i, X6 xDrive40i, and X7 xDrive40i vehicles. The connection between the 48-Volt battery and the starter-generator may not have been assembled properly, which can cause increased electrical resistance at the connections.

  Remedy

  BMW will notify owners, and dealers will inspect the connection between the 48-Volt battery and the starter-generator assembly, replacing it if necessary, free of charge. The recall is expected to begin April 12, 2021. Owners may contact BMW customer service at 1-800-525-7417.

• Recall20V379000June 30, 2020
  CHILD SEAT:TETHER: CONNECTOR/CLIP

  BMW of North America, LLC (BMW) is recalling certain 2020-2021 740Li, 740 Li xDrive, 750Li xDrive, M760Li xDrive, and Alpina B7 vehicles. The top child seat tether anchor on the rear middle seat may not be readily accessible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, Section 6.1(b) "Child Restraint Anchorage Systems."

  Remedy

  BMW will notify owners, and dealers will install a top tether anchor cover at the rear middle seating position. Until vehicles are remedied, owners will be instructed to utilize the outboard rear seating positions which are equipped with an accessible top tether anchor, or, the middle rear seating position and the vehicle's three-point safety belt. The recall began August 20, 2020. Owners may contact BMW customer service at 1-800-525-7417.